text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:ASTRO GEM/LEAD FREE GLAZES,FIRED ANTIQUE,UNDERGLAZES,620-469
CAGE:EO367
CAGE:EO367
CAGE:26290
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
AND GASTROINTESTINAL TRACTS. ACUTE- EYE CONTACT MAY CAUSE
IRRITATION. PROLONGED SKIN CONTACT MAY CAUSE IRRITATION. INHALATION
OF DUSTS/MISTS MAY CAUSE LUNG INJURY . HARMFUL IF INGESTED.
CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:CONTAINS CRYSTALLINE SILICA.
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, TEARING, SHORTNES
OF BREATH
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:CALL PHYSICIAN IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH
WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. INHALED:MOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
ORAL:CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS, IF NEEDED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. VENTILATE AREA.
ABSORB ON SAND, VERMICULITE OR SIMILAR MATERIAL. SWEEP UP AND PLACE
IN AN APPROPRIATE CONTAINER FOR DISPOSAL.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DO NOT GET IN EYES, ON SKIN/ON CLOTHING. AVOID
INHALATION OF DUST/MIST. FOR INDUSTRIAL AND INSTITUTIONAL USE ONLY.
READ AND FOLLOW LABEL DIRECTIONS AND PRECAUTIONS. WASH AFTER
HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. IF AIRBORNE CONCENTRATION
IS HIGH, WEAR A NIOSH-APPROVED DUST OR FUME RESPIRATOR.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP MIST OR
DUST LEVELS AS LOW AS POSSIBLE, WHILE SPRAYING.
Other Protective Equipment:EYEBATH, WASHING FACILITY
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH BEFORE EATING OR DRINKING.
Supplemental Safety and Health
ASTRO GEM GLAZES, FIRED ANTIQUES, LEAD FREE GLAZES, ONE STROKE COLORS,
UNDERGLAZES, CERAMIC GLAZE(S), MISCELLANEOUS, STONEWARE GLASES,
LUSTER ASTRO GEMS, SERIES 2000 GLAZES, STROKE AND COAT SERIES
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:1000F,538C
Spec Gravity:1.4 - 1.6
Solubility in Water:INSOLUBLE
Appearance and Odor:COLOR VARIABLE, AQUEOUS SLURRY - PRACTICALLY
ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN TRASH. OBSERVE LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:STAMP PAD INKS, BLACK (PINT)
CAGE:EO365
CAGE:86874
CAGE:EO365
============= Composition/Information on Ingredients =============
Ingred Name:DYE
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:GLYCERIN
CAS:56-81-5
RTECS #:MA8050000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 (MIST) 9293
Ingred Name:GLYCOL ETHERS, DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Ingred Name:GLYCERIN
CAS:56-81-5
RTECS #:MA8050000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 (MIST) 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS NOT CONSIDERED TOXIC.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:PRODUCT IS CONSIDERED SAFE WHEN USED UNDER
NORMAL USE CONDITIONS.
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>390F
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP W/ABSORBENT MATERIAL & DISCARD AS
SOLID WASTE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CAP ON BOTTLE WHEN NOT IN USE.
THE PRODUCT IS CONSIDERED SAFE WHEN USED UNDER NORMAL USE
CONDITIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE UNDER NORMAL USE CONDITIONS.
Ventilation:NONE UNDER NORMAL USE CONDITIONS.
Other Protective Equipment:NONE UNDER NORMAL USE CONDITIONS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>550F
Vapor Pres:<0.1
Spec Gravity:1.2 - 1.3
Solubility in Water:COMPLETE
Appearance and Odor:WATER WHITE, CLEAR LIQUID W/BLAND ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD AS SOLID WASTE IN ACCORDANCE W/FEDERAL,
STATE, & LOCAL REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:MAGNAFLUX MAGNETIC PARTICLE 14A/20 LB
CAGE:59042
CAGE:37676
CAGE:59042
============= Composition/Information on Ingredients =============
Ingred Name:IRON (III) OXIDE; (IRON OXIDE). LD50:(ORAL,RAT) >5 G/KG.
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 60-100%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 FUME (FE)
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT:NONE. EYES:GRITTY
MATERIAL MAY SCRATCH EYEBALL. INHALATION:NOT SIGNIFICANT BECAUSE
14A IS USED ONLY WHEN MIXED INTO A LIQUID VEHICLE. INGESTION:NOT
SIGNIFICANT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:FLUSH W/COPIOUS
AMOUNTS OF WATER. CALL MD . EYES:RINSE CAREFULLY UNDER UPPER & L
OWER EYELIDS USING PLENTY OF WATER FOR AT LEAST 15 MINUTES. NOTE:IN
CAN FURNISH NUMBER OF REGIONAL POISON CONTROL CENTER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:IF HEATED TO FLAME TEMPERATURE, 14A CAN
SMOLDER & EMIT NOXIOUS FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING DUST. KEEP DRY.
Other Precautions:AS A DRY POWDER CONCENTRATE, 14A IS A NUISANCE DUST.
WHEN DILUTED & USED AS SPECIFIED (ONE OZ PER SIX GALLONS OF
VEHICLE) ANY HAZARDS ARE DUE TO THE VEHICLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR W/FILTER IF USED
IN ENCLOSED, UNVENTILATED SPACE.
Ventilation:14A IS DISPERSED IN A VEHICLE WHEN USED. CONTROLS SHOULD BE
THOSE RECOMMENDED FOR THE VEHICLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:0.5
pH:NEUT
Solubility in Water:0
Appearance and Odor:DUSTY BROWN POWDER; NO ODOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES, OXIDES OF CARBON & NITROGEN IF
HEATED TO COMBUSTION TEMPERATURE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISPOSE OF AN ORDINARY WASTE. RCRA:NOT A HAZARDOUS
WASTE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:P-83 SOF-T-SUDS
CAGE:HO510
CAGE:97257
CAGE:HO510
CAGE:NO690
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN/INHALATION: IRRITATION.
INGESTION: NAUSEA, VOMITING, & DIARRHEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN/INHALATION: IRRITATION. INGESTION:
NAUSEA, VOMITING, & DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: GIVE LARGE
QUANTITIES OF WATER, THEN SEVERAL GLASSES OF MILK. INDUCE VOMITING.
EYES: FLUSH W/LARGE QUANTITIES OF WATER FOR 15 MINS. SKIN: RINSE
W/WATER. OBT AIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED FULL-FACE BREATHING
APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP WATER AWAY FROM SPILL. SCOOP & SWEEP TO
RECOVER. FLUSH CONTAMINATED AREA W/PLENTY OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF REACH OF CHILDREN.
USE ADEQUATE VENTILATION.
Other Precautions:AVOID HANDLING WHICH WILL CREATE LARGE AMOUNTS OF
DUSTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED W/ADEQUATE VENTING.
Ventilation:USE ADEQUATE VENTILATION.
Work Hygienic Practices:RINSE HANDS AFTER USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:WHITE POWDER BLEND, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & OXIDIZERS
Stability Condition to Avoid:EXTREME TEMPERATURES
Hazardous Decomposition Products:CO & CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LOCQUIC PRIMER N
CAGE:05972
CAGE:05972
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 98%>
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:ORGANO-COPPER SALT
Fraction by Wt: <1%
Other REC Limits:N/K FP-N
OSHA PEL:N/K FP-N
ACGIH TLV:N/K FP-N
Ingred Name:TRIALKYLAMINE CARBOXYLATE
Fraction by Wt: <1%
Other REC Limits:TOXIC
OSHA PEL:
ACGIH TLV:
Ingred Name:ALIPHATIC CARBOXYLIC ACID
Fraction by Wt: <1%
Other REC Limits:IRRITANT
OSHA PEL:
ACGIH TLV:
===================== Hazards Identification =====================
LD50 LC50 Mixture:EST DERMAL LD 50 >2000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXICITY POSSIBLE EYE
IRRITANT.MODERATELY TOXIC BY INGESTION.TLV 350 PPM
Explanation of Carcinogenicity:N/A FPN
Effects of Overexposure:HEADACHE,NAUSEA,DIZZINESS NARCOSIS AT HIGH
CONCENTRATION.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMITING.KEEP INDIVIDUAL CALM.OBTAIN
MEDICAL ATTENTION.INHAL:REMOVE TO FRESH AIR IF SYMPTOMS
PERSIST.OBTAIN MEDICAL ATTENTION.SKIN:FLUSH W/ H*2O.EYE:FLUSH
THOROUGHLY W/ H*2O FOR A T LEAST 15 MIN OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, FOAM, DRY CHEM
Fire Fighting Procedures:WEAR PRESSURE DEMAND SCBA & FULL PROTECTIVE
EQUIPMENT
Unusual Fire/Explosion Hazard:NONE (MFR) THERMAL DECOMPOSITION PRODUCTS
MAY INCLUDE HCL & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:ALLOW TO EVAPORATE W/ GOOD VENTILATION SOAK UP
RESIDUE IN INERT ABSORBENT.
Neutralizing Agent:
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 110F AVOID PROLONGED
BREATHING OF VAPOR.KEEP AWAY FROM EYES.
Other Precautions:NO SMOKING IN AREA OF USE.DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING,OPEN FLAMES OR HOT SURFACES.HEAT &/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL &/OR PHOSGENE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN
Ventilation:PROVIDE ADEQUATE LOCAL VENTILATION TO MAINTAIN VAPOR
CONCENTRATION BELOW TLV.
Work Hygienic Practices:OBSERVE GOOD WORK HYGIENIC PRACTICES
Supplemental Safety and Health
1,1,1-TRICHLOROETHANE(METHYL CHLOROFORM) HAS BEEN SHOWN TO CAUSE
REPRODUCTIVE AFFECTS & KIDNEY & LIVER DAMAGE IN EXPERIMENTAL
ANIMALS ON PROLONGED INHALATION.IT IS OUR BEST TECHNICAL JUDGEMENT
THAT W/ PROPER PRECAUTIONS NORMAL USE OF THIS PRODUCT POSES ON
SUCH HAZARD (MFR).
================== Physical/Chemical Properties ==================
HCC:T4
NRC/State Lic Num:NA
Boiling Pt:B.P. Text:ABOUT 170 F
Vapor Density:4.5
Spec Gravity:1.320
Solubility in Water:NIL
Appearance and Odor:GREEN LIQUID SHARP ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT VIOLENT W/ ALUMINUM ON PROLONGED CONTACT.
Hazardous Decomposition Products:FIRE OR THERMAL DECOMP TOXIC
CHLORIDES,HCL PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW EPA & LOCAL REGULATIONS FOR DISPOSAL OF
CHLORINATED HYDROCARBONS.DO NOT INCINERATE PRESSURIZED CANS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MIL-P-53022B, TYPE I CATALYST, PART B
Kit Part:Y
Preparer's Name:JANE FREEMAN
CAGE:09225
CAGE:09225
============= Composition/Information on Ingredients =============
Ingred Name:1-METHOXY-2-PROPANOL SOLVENT
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 26.770%
Other REC Limits:NONE RECOMME
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
Ingred Name:TOLUENE SOLVENT (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2.608%
Other REC Limits:SKIN NOTATIO
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTYL ALCOHOL SOLVENT (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 15.542%
Other REC Limits:NONE RECOMME
OSHA PEL:50 PPM (CEILING)
ACGIH TLV:50 PPM (CEILING)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:EPOXY RESIN
Fraction by Wt: 20-30%
Other REC Limits:NONE RECOMME
Ingred Name:METHYL ISOBUTYL KETONE SOLVENT (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 6.153%
Other REC Limits:NONE RECOMME
OSHA PEL:50 PPM; STEL 75 PPM
ACGIH TLV:50 PPM; STEL 75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 18.407%
Other REC Limits:NONE RECOMME
OSHA PEL:200 PPM;STEL 300 PPM
ACGIH TLV:200 PPM;STEL 300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5.371%
Other REC Limits:NONE RECOMME
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOC: 5.681 LBS/GAL; 680.754 GRAMS/LITER
RTECS #:9999999VO
Other REC Limits:NONE RECOMME
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC. RESPIRATORY
TRACT IRRITATION, ACUTE NERVOUS SYSTEM DEPRESSION (HEADACHE,
DIZZINESS, STAGGERING, CONFUSION, COMA). SKIN OR EYE: IRRITATION.
CHRONIC OVEREXPOSURE: REPEATED OR PRO LONGED OVEREXPOSURE WITH
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE, LIVER, KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS; CHEMICAL SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. NOTIFY PHYSICIAN. EYES: FLUSH IMMEDIATELY WITH
LARGE AMOUNTS OF RUNNING WATER FOR AT LEAST 15 MINUTES. TAKE TO A
PHYSICIAN FOR MEDICAL TREATMENT. SKIN: WASH AFFECTEDAREAS WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. CONSULT A PHYSICIAN.
INGESTION: CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:21.0F,-6.1C
Autoignition Temp:Autoignition Temp Text:650 F
Lower Limits:1.1
Upper Limits:36.5
Extinguishing Media:FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:WEAR PROTECT EQUIP INCLUDING SCBA. WATER MAY
BE INEFFECTIVE, USE WATER (FOG NOZZLES PREFERRED) COOL CLOSED CNTNR
TO PREVENT PRESSURE BLDUP,AUTOIGNITN,EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CONTAINER TIGHTLY CLOSED. KEEP FROM
HEAT/IGNIT SOURCE. CLOSED CNTNR MAY EXPLODE W/HEAT. DON'T APPLY TO
HOT SRFCS. NEVER USE WELD/CUT TORCH ON/NEAR DRUM.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, ELECTRICAL, STATIC OR FRICTIONAL SPARKS). AVOID BREATHING
VAPORS. VENTILATE AREA. CONTAIN & REMOVE WITH INERT ABSORBENT AND
NONSPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED TO COMPLY WITH OSHA 1910.106. KEEP
AWAY FROM SPARKS & OPEN FLAME. DON'T INGEST.
Other Precautions:GROUND CONTAINERS WHEN POURING. AVOID LIQUID FREE
FALL >FEW INCHES. USE W/VENT & RESP EQUIP. AVOID PROLONGED VAPOR
BREATHING. AVOID PROLONGED/REPEATED SKIN CONTACT. EMPTIED CNTNR
RETAIN HZD RESIDUE/EX PLOSIVE VAPOR. OBEY ALL HZD PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAYED IN OUTDOOR OR DURING SAND/GRINDING:
NIOSH MECHAN FILTER RESPRTR (RMV SOLID PARTICLES). RESTRICTED AREA:
NIOSH CHEM/MECHAN FILTER. CONFINED AREA: NIOSH AIR SUPPLIED
RSPRTR/HOOD. USE NIOSH RSPRTR WHEN CUT/WELD HAZING TORCH.
Ventilation:GENRL DILUTN/LOCAL EXHAUST VENT TO KEEP BELOW PEL/TLV WHILE
MIXING,APPLICATION,CURING,REMOVE DECOMP FROM WELD/FLAME CUT.
Other Protective Equipment:USE PROTECTIVE SKIN CREAM WHERE CONTACT IS
LIKELY. PREVENT PROLONGED SKIN CONTACT WITH CONTAMINATED CLOTHING.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING OR SMOKING. SMOKE IN DESIGNATED AREAS ONLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:170 TO 290F
Decomp Temp:Decomp Text:400F,204C
Vapor Pres:74.00 @68F
Vapor Density:> AIR
Spec Gravity:0.90
Viscosity:*
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:80.19
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. MAY CONTAIN CARBON MONOXIDE
& CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE ABOVE
120F. STORE LARGE QUANTITIES IN BUILDINGS DESIGNED TO COMPLY WITH
OSHA 1910.106. KEEP AWAY FROM SPARKS AND OPEN FLAME. EPA HAZARDOUS
WASTE NUMBER/CODE:D001, IGNITABLE. DISPOSAL METHODS:
INCINERATION.
======================================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HYBON
CAGE:DO894
CAGE:93915
CAGE:DO894
============= Composition/Information on Ingredients =============
Ingred Name:FIBROUS GLASS
CAS:65997-17-3
Fraction by Wt: >97.5%
OSHA PEL:15 MG/CUM
ACGIH TLV:15 MG/CUM
Ingred Name:SURFACE SIZING
Fraction by Wt: <2.5%
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CALCIUM
CAS:7440-70-2
RTECS #:EV8040000
Ingred Name:BORON
CAS:7440-42-8
RTECS #:ED7350000
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: TRANSIENT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: TRANSIENT IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH MILD SOAP AND WATER. EYES: IF FIBERS SHOULD
GET INTO THE EYES, CLEANSE W/CLEAR WATER.
===================== Fire Fighting Measures =====================
Flash Point:NON-BURNING
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP.
======================Handling and Storage ======================
Handling and Storage Precautions:FOR MAXIMUM COMFORT, AVOID EXCESSIVE
CONTACT W/SKIN & USE GOOD PERSONAL HYGIENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:MECHANICAL: NORMAL
Other Protective Equipment:NONE REQUIRED
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NONE
Melt/Freeze Pt:M.P/F.P Text:838F
Vapor Pres:NONE
Vapor Density:NONE
Spec Gravity:2.55
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW WHITE AND NO ODOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:IN SUSTAINED FIRE THE ORGANIC BINDERS
WILL DECOMPOSE RELEASING MINUTE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS IN THE CASE OF ANY INNOCUOUS SOLID
MATERIAL.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:151939 CRONEX OR NDTMD-A NDT MANUAL DEVELOP
CAGE:DO962
CAGE:82348
CAGE:6K054
CAGE:18873
CAGE:DO962
============= Composition/Information on Ingredients =============
Ingred Name:HYDROQUINONE (SARA III)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 5-10%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 10-30%
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 1-5%
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 3-7%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-100%
Ingred Name:1-PHENYL-3-PYRAZOLIDONE
CAS:92-43-3
RTECS #:UQ8750000
Fraction by Wt: 0.5-1.5%
Other REC Limits:NONE SPECIFIED
Ingred Name:POTASSIUM BROMIDE
CAS:7758-02-3
RTECS #:TS7650000
Fraction by Wt: 0.5-1.5%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES, SKIN, RESPIRATORY AND
GASTROINTESTINAL IRRITATION. INGESTION OF HYDROQUINONE CAN AFFECT
THE CENTRAL NERVOUS SYSTEM, CAN CAUSE LIVER DISEASE, CAN DAMAGE
BLOOD AND BONE MARROW. CHRONIC: NON E SPECIFIED BY MANUFACTURER.
Effects of Overexposure:EYES/SKIN: IRRITATION, EYE AND SKIN
DISCOLORATION. INHALATION: RESPIRATORY IRRITATION, COUGHING,
SHORTNESS OF BREATH. INGESTION: NAUSEA, HEADACHE, DIZINESS,
ABDOMINAL PAIN, DIARRHEA.
Medical Cond Aggravated by Exposure:PERSONS WITH EXISTING LIVER OR BONE
MARROW DISEASE MAY BE AT INCREASED RISK OF TOXIC EFFECTS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. SEE DOCTOR. SKIN: IMMEDIATELY WASH SKIN WITH SOAP AND
WATER. INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RE SPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
SEE DOCTOR. INGESTION: GIVE LARGE AMOUNTS OF WATER. DO NOT INDUCE
VOMITING. NOTHING BY MOUTH IF UNCONSCIOUS. SEE DOCTOR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON-FLAMMABLE. USE EXTINGUISHING MEDIA APPROPIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:EVACUATE PERSONS TO SAFE AREA. KEEP PERSONNEL
REMOVED AND UPWIND OF FIRE. WEAR SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPIATE PERSONAL PROTECTIVE EQUIPMENT
DURING CLEANUP. ABSORB IN INERT MATERIAL, SUCH AS SAWDUST OR SAND.
NEUTRALIZE. WASH AREA WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL VENTILATED AREA. KEEP
CONTAINER TIGHTLY CLOSED. DO NOT STORE OR CONSUME FOOD, DRINK OR
TOBACCO IN AREA NEAR THIS PRODUCT.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. AVOID BREATHING
VAPORS OR MIST. AVOID CONTACT WITH EYES AND SKIN. AVOID CONTACT
WITH CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED WITH ADEQUATE
VENTILATION.
Ventilation:NO SPECIAL REQUIREMENTS. PROVIDE ADEQUATE VENTILATION.
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
KEY1:C2. THIS REPRESENTS NEW FORMULATION OF PART-A OF TWO PARTS
PRODUCTS; SEE P/N IND "A" FOR OLD PART. ALSO LATER CHANGED TRADE
NAME FROM CRONEX TO NDT.
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:B.P. Text:>212F/>100C
Spec Gravity:1.25
pH:11-12
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND ALUMINUM.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSES BY REACTION WITH STRONG
ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE NONUSABLE SOLID MATERIAL AND/OR
CONTAMINATED SOIL FOR DISPOSAL IN APPROVED AND PERMITTED LANDFILL.
DISCHARGE TO SEWER REQUIRES APPROVAL OF PERMITTING AUTHORITY AND
MAY REQUIRE PRETREATMENT. COM PLY WITH ALL APPLICABLE LAWS AND
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FOAM A COMPONENT
Kit Part:Y
Preparer's Name:ROBERT SHANKLIN
CAGE:1N060
CAGE:1N060
============= Composition/Information on Ingredients =============
Ingred Name:ISOCYANIC ACID, METHYLENEDI-P-PHENYLENE ESTER;
(DIPHENYLMETHANE DIISOCYANATE)
CAS:101-68-8
RTECS #:NQ8350000
Fraction by Wt: 45-50%
OSHA PEL:0.02 PPM
ACGIH TLV:0.02 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HIGHER MOLECULAR POLYMERS OF SAME STRUCTURE TO EACH OTHER;
(HIGHER POLYMERS OF SAME STRUCT)
Fraction by Wt: 45-50%
Ingred Name:ETHANE,1,1,2-TRICHLORO-1,2,2-TRIFLUORO-; (CFCL3 (FREON
118))
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 0-10%
OSHA PEL:1000 PPM, 1250 STEL
ACGIH TLV:1000 PPM, 1250 STEL
Ozone Depleting Chemical:1
Ingred Name:BENZENE, ISOCYANATO-; (PHENYL ISOCYANATE)
CAS:103-71-9
RTECS #:DA3675000
Fraction by Wt: TRACE
Ingred Name:TRICHLOROISOPROPYLPHOSPHATE
Fraction by Wt: 0-10%
ACGIH TLV:1000 PPM (MFR)
Ingred Name:SPILL PROC: VENT AREA TO REMOVE VAPORS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:RUPTURE. NO SMOKING IN AREA OF USE. DO NOT USE
IN GEN VICIN OF ARC WELD, OPEN FLAMES/HOT SURF. HEAT (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:&/OR UV RADIA MAY CAUSE FORM OF CHLORIDES, FLUORIDES
AND PHOSGENE .
RTECS #:9999999ZZ
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: MAY CAUSE
BREATHLESSNESS, SEV COUGH, CHEST DISCOMFORT, IRRIT OF MUC MEMB &
REDUCE PULM FUNC. (RXN MAY BE DELAYED 4-8 HRS) ALLERGIC SENSITIVITY
MAY DEVELOP IN SOME INDIVIDUALS. SKIN: MIN OR IRRIT MAY RSLT FROM
RXN W/SKIN MOISTURE & PROTEIN, MAY LEAD TO ALLERGIC SENSITIVITY &
TEMP STAINS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OF SKIN. EYES: MAY LEAD TO IRRIT
W/TEARS. INGEST:IRRIT & POSS CORR ACTION ON MOUTH, THROAT, & STOM
TISSUES. VOMIT MAY OCCUR. CHRONIC: RESP DISTRESS DURING SLEEP IS
SYMPTOMATIC OF CHRONIC EXP OS. CHLOROFLUOROCARBON MATLS HAVE
PRDCDSENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD
HAVE (SUPP DATA)
Medical Cond Aggravated by Exposure:INDIVIDUALS SUFFERING FROM
ASTHMA/OTHER CHRONIC RESP CNDTNS MAY EXHIBIT A HEIGHTENED
SENSITIVITY TO THIS PRODUCT. EMPLOYEES SHOULD BE SCREENED
PERIODICALLY FOR SUCH CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/CLEAN, WARM WATER @ LOW PRESS FOR @ LST 15 MIN,
OCCAS LIFT LIDS. CONSULT A PHYS IMMED. SKIN:WASH EXPOSED SKIN
W/WARM, SOAPY WATER THORO. SEE PHYS IF RED/SWELL APPEARS.
INHAL:REMOVE TO FRES H AIR IMMED. IF BRTHG IS
LABORED/DFCLT,ADMINISTER OXYGEN, CONSULT PHYS IMMED. RXN MAY BE
DELAYED 4-8 HRS. INGEST: INDUCE VOMIT W/WARM SALT WATER @ LST 3
TIMES/UNTIL VOMIT IS CLEAR. FOLLOW (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:415F,213C
Extinguishing Media:WATER FOG, ALCOHOL FOAM, FOAM, CARBON DIOXIDE, DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE. THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE CHLORIDES, FLUORIDES AND PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:ONLY PROPERLY PROTECTED PERS SHOULD REMAIN IN
AREA.CNTN SPILL, COVER LIQ W/ABSORB MATL SUCH AS SAWDUST. PLACE IN
OPEN TOP CONTR & TREAT W/DECONTAM SOLN (90% WATER, 6% AMMONIA, 4%
DETERGENT). REMOVE CO NTRS TO SAFE AREA & LET STAND 24-48 HRS. (ING
6)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY SEALED CONTR TO PVNT
MOISTURE CONTAM. DO NOT RE-SEAL IF CONTAM IS SUSPECTED. AVOID
CONTACT W/SKIN/EYES.
Other Precautions:ALWAYS OPEN CONTR SLOWLY TO VENT OFF ANY PRESS
BUILD-UP FROM HEAT/CONTAM. IF CNTR IS EXPOSED TO HIGH HEAT, >400F,
IT CAN BE PRESSURIZED & POSS RUPTURE. MDI REACTS SLOWLY W/WATER TO
FORM CARBON DIOXIDE . GAS CAN CAUSE SEALED CONTR TO (ING 7)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR SHORT TERM EXPOSURES USE AN NIOSH/MSHA
APPROVED ORGANIC FILTER RESPIRATOR MASK, SUPPLIED AIR OR SCBA IS
PREFERRED.
Ventilation:GENERAL MECHANICAL OR LOCAL EXHAUST TO MAINTAIN LEVELS
BELOW TLV.
Other Protective Equipment:COVER AS MUCH OF EXPOSED SKIN AS POSS
W/APPROP CLTHG. IF SKIN CREAMS ARE USED, KEEP AREA COVERED BY CREAM
TO A MINIMUM.
Work Hygienic Practices:REMOVE CLOTHING THAT IS SATURATED WITH
MATERIAL, WASH EXPOSED AREAS WITH SOAP AND WATER.
Supplemental Safety and Health
EFTS OF OVEREXP:SIMILAR EFT IN HUMANS. ADRENOMIMETICS (E.G.,
EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES
IN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO CFC'S .FIRST AID PROC
:W/A QUART OF MILK & A MILD CARTHARTIC (MILK OF MAGNESIA). CONSULT
A PHYS IMMED.NEVER INDUCE VOMIT FROM AN UNCON PERSON.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>400F,>204C
Vapor Pres:<1@25C
Vapor Density:8.6
Spec Gravity:1.24(H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, STRONG BASES, ALCOHOLS, METAL CMPDS & SURF ACTIVE AGENTS. WILL
CAUSE SOME CORROSION TO COPPER ALLOYS & ALUMINUM.
Stability Condition to Avoid:AVOID TEMPERATURES >120F.
Hazardous Decomposition Products:>400F, CARBON DIOXIDE, OXIDES OF
NITROGEN & TRACES OF HYDROGEN CHLORIDE. CHLORIDES, FLUORIDES AND
PHOSGENE .
Conditions to Avoid Polymerization:CONTAMINATION BY MOISTURE OR OTHER
MATERIALS THAT REACT W/ISOCYANATES SHOULD BE AVOIDED.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE, PREFERABLY AFTER MIXING W/ANOTHER
COMBUSTIBLE FUEL. MUST HAVE COMPLETE COMBUSTION TO PREVENT
FORMATION OF PHOSGENE, MAY ALSO REACT W/WASTE POLYOL. DISPOSE OF
ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:30752-16 OZ PRIMER-006 OATEY CLEAR PRIMER - NSF
Preparer's Name:GABRIELLA BITZ
CAGE:EO573
CAGE:53472
CAGE:EO573
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXANONE, KETOHEXAMETHYLENE
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 15-20%
Other REC Limits:100PPM (SKIN) STEL
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE; DIMETHYL KETONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: <1%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 70-75%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TETRAHYDROFURAN
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 10-15%
Other REC Limits:200 PPM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MUCOUS MEMBRANE, NOSE, &
THROAT IRRITATION, HEADACHE, DIZZINESS, NAUSEA, NUMBNESS OF THE
EXTREMITIES, & NARCOSIS. SKIN: IRRITATION, DERMATITIS, &
ABSORPTION. EYES: IRRITATION. INGESTION: L UNG ASPIRATION HAZARD,
CAUSE SYSTEMIC EFFECTS LIKE THOSE OF INHALATION, & LIVER TOXIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: MUCOUS MEMBRANE, NOSE,& THROAT
IRRITATION, HEADACHE, DIZZINESS, NAUSEA, NUMBNESS OF THE
EXTREMITIES, & NARCOSIS. SKIN: IRRITATION, DERMATITIS, &
ABSORPTION. EYES: IRRITATION. INGESTION: LU NG ASPIRATION HAZARD, &
CAUSE SYSTEMIC EFFECTS LIKE THOSE OF INHALATION, & LIVER TOXIN.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: WASH W/WATER FOR
15 MINS. INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. IF BREATHING STOPS, GIVE ARTIFICIAL
RESPIRATION. KEEP VIC TIM QUIET & WARM. INGESTION: DRINK WATER.
AVOID ALCOHOLIC BEVERAGES. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:0-5F
Lower Limits:1.8%
Upper Limits:10%
Extinguishing Media:DRY CHEMICAL, CO2, WATER, FOAM EXTINGUISHER
Fire Fighting Procedures:EVACUATE AREA.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. STOP LEAK IF IT CAN BE DONE
WITHOUT RISK. TAKE UP W/SAND, EARTH, OR OTHER NON-COMBUSTIBLE
ABSORBANT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE AWAY FROM
HEAT, SPARKS, OR FLAMES. CONTAINERS, EVEN EMPTIES WILL RETAIN
RESIDUE & VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED CANNISTER RESPIRATOR WHEN
>TLV.
Ventilation:GENERAL MECHANICAL: TO KEEP <PEL/TLV. LOCAL EXHAUST: OPEN
DOORS & WINDOWS. IF USED IN ENCLOSED AREA, USE EXHAUST FANS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:174F
Vapor Pres:70
Vapor Density:2.5
Spec Gravity:0.797-0.817
Evaporation Rate & Reference:(BU AC = 1): 5.5-8
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID W/SHARP, FRAGRANT, MINT/ETHER ODOR
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING MATERIALS, ALKALIS, CHLORINATED INORGANICS, POTASSIUM,
CALCIUM, SODIUM HYPOCHLORITE, COPPER/ALLOYS
Stability Condition to Avoid:HEAT, SPARKS, & OPEN FLAME
Hazardous Decomposition Products:CO, CO2, HYDROGEN CHLORIDE, & SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. FLAMMABLE LIQUID. UN1993. IGNITABLE
WASTE/TOXIC WASTE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MS-375L BASE COMPONENT
Preparer's Name:ERNEST CARTER
CAGE:88444
CAGE:88444
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
CAS:25068-38-6
Code:F
RTECS #:CE6880000
Minumum % Wt:10.
Maxumum % Wt:15.
Ingred Name:METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Minumum % Wt:3.
Maxumum % Wt:8.
OSHA PEL:465 MG/M3;100 PPM
ACGIH TLV:233 MG/M3;50 PPM
Ingred Name:1-METHOXY-2-PROPANOL
CAS:107-98-2
RTECS #:UB7700000
< Wt:5.
ACGIH TLV:369 MG/M3;100 PPM
ACGIH STEL:553 MG/M3;150 PPM
Ingred Name:AROMATIC NAPTHA
Minumum % Wt:3.
Maxumum % Wt:8.
Ingred Name:CALCIUM METASILICATE
CAS:13983-17-0
Code:F
RTECS #:ZC9750000
< Wt:4.
Ingred Name:ALUMINO SILICATE MINERAL
CAS:37244-96-5
Code:F
Minumum % Wt:20.
Maxumum % Wt:35.
Ingred Name:ALUMINUM
CAS:7429-90-5
RTECS #:BD0330000
Minumum % Wt:20.
Maxumum % Wt:35.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES: IRRITANT. AGGREGATE MAY CAUSE
INJURY. SKIN: MAY CAUSE MODERATE IRRITATION AND SENSITIZATION. MAY
CAUSE ALLERGIC SKIN REACTION WHICH CAN BE SEVERE IN CERTAIN
INDIVIDUALS. INHALATION: VAPORS MAY C AUSE HEADACHES, NASEA,
DIZZINESS AND ERSPIRATORY IRRTATION. INGESTION: NO SPECIFIC
INFORMATION AVAILABLE. CONTAINS MATERIALS THAT MAY BE SLIGHTLY
TOXIC.
Effects of Overexposure:IRRITATION, SENSITIZATION AND DERMATITIS.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA AND OTHER SKIN
CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE QUANTITIES OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH CONTACT AREA WITH MILD SOAP AND WATER FOR 15 MINUTES.
INHALATION: REM OVE TO FRESH AIR. IF BREATHING HAS STOPPED,
ADMINISTER ARTIFICIAL RESPIRATION AND SEEK MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING (CONTAINS SOLVENT). GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CALC
Flash Point:=38.C, 100.4F
Lower Limits:1.6
Upper Limits:11.8
Extinguishing Media:DRY CHEMICAL OR CHEMICAL FOAM.
Fire Fighting Procedures:REMOVE ALL IGNITION SOURCES. WEAR COMPLETE
PERSONAL PROTECTIVE EQUIPMENT INCLUDING SELF-CONTAINED BREATHING
APPARATUS WHERE POTENTIAL FOR EXPOSURE TO VAPORS OR PRODUCTS OF
COMBUSTION EXISTS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINS MAY RUPTURE (DUE TI BUILD
UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. DECOMPOSITION AND
COMBUSTION PRODUCTS MAY BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH INERT MATERIAL AND COLLECT FOR
DISPOSAL. FLUSH CONTAMINATED AREA WITH WATER. PREVENT WASHINGS FROM
ENTERING WATERWAYS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID ALL PERSONAL CONTACT. DO NOT
EXCEED 110%F/43%C IN STORAGE AREA. GROUND AND BOND METAL CONTAINERS
FOR LIQUID TRASFER TO AVOID STATIC SPARKS.
Other Precautions:A SAFETY SHOWER AND EYE WASH FACILITY SHOULD BE
AVAILABLE TO EMPLOYEES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC
VAPOR CARTRIDGE IF REQUIRED.
Ventilation:EXPLOSION PROOF MECHANICAL VENTILATION AND LOCAL EXHAUST
ARE RECOMMENDED. MECHANICAL EXHAUST IS NOT RECOMMENDED AS THE SOLE
MEANS OF CONTROLLING EMPLOYEE EXPOSU
Other Protective Equipment:IN OPERATIONS WHERE CONTACT MAY OCCUR,
COVERALLS, APRON AND IMPERVIOUS FOOT COVERING ARE RECOMMENDED. A
SAFETY SHOWER AND EYE WASH FACILITY SHOULD BE AVAILABLE TO
EMPLOYEES.
Work Hygienic Practices:AVOID ALL PERSONAL CONTACT. DO NOT EXCEED 110
DEG F IN STORAGE AREA. GROUND AND BOND METAL CONTAINERS FOR LIQUID
TRANSFER TO AVOID STATIC SPARKS.
Supplemental Safety and Health
CONTAMINATED CLOTHING SHOULD BE REMOVED IMMEDIATELY AND THOROUGHLY
LAUNDERED BEFORE REUSE.
================== Physical/Chemical Properties ==================
Boiling Pt:>116.C, 240.8F
Vapor Pres:8MMHG @ 68%F /20%C
Vapor Density:3.1 (AIR=1
Spec Gravity:1.75
Evaporation Rate & Reference:0.5 (BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:PIGMENTED VISCOUS PASTE, MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
ALDEHYDES
=================== Toxicological Information===================
Toxicological Information:TITANIUM DIOXIDE: LD50 10G/KG (DERMAL
RABBIT), LC50 6820PPM (INHALE, RAT) XYLENE: LD50 3.9G/KG
(DERMAL, RABBIT) LC50 6700PPM (INHALE, RAT) NAPTHA: LD50 3.1
G/KG (DERMAL,RABBIT) LC50 3670 PPM(I NHALE, RAT) EPOXY RESIN:
LD50 4G/KG (DERMAL, RABBIT) MANGANESE OXIDE: LD50 0.40 G/KG
(DERMAL, RABBIT)
===================== Ecological Information =====================
Ecological:EPA WASTE NO.: D001
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT, IF DISPOSED AS SHIPPED, MEETS EPA
CRITERIA OF A HAZARDOUS WASTE AS SPECIFIED IN 40 CFR 261 ON THE
BASIS OF ITS IGNITABILITY. DISPOSE OF IN A LICENSED HAZARDOUS WASTE
FACILITY IN ACCORDAN CE WITH APPLICABLE LAWS.
=================== MSDS Transport Information ===================
Transport Information:DOT: PAINT, DOT: FLAMMABLE UN# 1263
===================== Regulatory Information =====================
SARA Title III Information:ALL INGREDIENTS ARE ON TSCA INVENTORY OR ARE
EXEMPT. (SARA, CERCLA, HAPS) TOXIC CHEMICAL SUBJECT TO REPORTING
REQUIRMENTS OF SAARA AND CERCLA (40 CFR 302, 355, 372) OR HAPS (40
CFR 63).
State Regulatory Information:CALIFORNIA PROPOSITION 65: WARNING! THIS
PRODUCT CONTAINS A CHEMNICAL KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER. WARNING! THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO
THE STATE OF CALIFORNIA T O CAUSE BIRHT DEFECTS OR OTHER
REPRODUCTIVE HARM. 1) ALUMINO SILICATE 2) ANTISKID AGGREGATE 3)
XYLENE 4) HIGH FLASH NAPTHA 5) REACTIVE DILUENT
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CEILCOTE HARDENER 2, 58270
CAGE:FO873
CAGE:98898
CAGE:FO873
============= Composition/Information on Ingredients =============
Ingred Name:HYDROPEROXIDE, ALPHA, ALPHA-DIMETHYLBENZYL-; (CUMENE
HYDROPEROXIDE) (SARA 313) (CERCLA)
CAS:80-15-9
RTECS #:MX2450000
Fraction by Wt: 70-85%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:BENZYL ALCOHOL, ALPHA, ALPHA-DIMETHYL-;
(2-PHENYL-2-PROPANOL)
CAS:617-94-7
RTECS #:DO4562000
Fraction by Wt: 5-15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CUMENE (SARA 313) (CERCLA)
CAS:98-82-8
RTECS #:GR8575000
Fraction by Wt: <10%
OSHA PEL:50 PPM, S
ACGIH TLV:50 PPM, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETOPHENONE (SARA 313) (CERCLA)
CAS:98-86-2
RTECS #:AM5250000
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:10 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FIRST AID PROC: VOMIT; GIVE LG QTYS OF WATER; GET IMMED MED
ATTN. IF VOMIT OCCURS SPONTANEOUSLY, KEEP HEAD BELOW (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: HIPS TO PREVENT ASPIRATION OF LIQS INTO LUNGS. DO
NOT GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: IMPORTANT. REFERENCE OSHA REG CFR 29 1910.134
FOR RECOMMENDED RESPIRATORY PROTECTION.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) 800-1600 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: VAPS CAN BE IRRIT TO NOSE, MUC
MEMBS, THROAT & UPPER RESP TRACT. EYES: CONTACT IS EXTREMELY IRRIT
& CORR TO EYE. THIS MATL CAN CAUSE DMG OR BLINDNESS. SKIN CNTCT:
SHORT SINGLE EXPOS MAY CAUSE M OD IRRIT TO MILD BURN. PRLNGD/RPTD
EXPOS MAY CAUSE SEVERE BURN. CUMENE MAY BE ABSORBED THRU SKIN TO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: INCREASE OVERALL TOXICITY LEVEL.
INGEST: CAN RSLT IN BURNS OF MOUTH, ESOPHAGUS & STOMACH. CHRONIC:
PROD DOES NOT CNTN CARCIN MATLS AS DEFINED BY OSHA HAZ
COMMUNICATIONS ACT 1910.1200. CUMENE & CUMENE HYDROPEROXIDE: LAB
TEST DATA HAS BEEN REPORTED SHOWING THESE CHEMS TO BE MUTAGENIC IN
VITRO.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE VICTIM FROM EXPOS. IF DFCLTY W/BRTHG, ADMIN
OXYGEN. IF BRTHG HAS STOPPED ADMIN ARTF RESP, PREFERABLY
MOUTH-TO-MOUTH. SEEK MED ATTN. EYES: FLUSH EYES W/WATER, LIFTING
UPPER & LOWER LIDS O CCASNLY FOR AT LEAST 15 MIN. SEEK MED ATTN.
SKIN: REMOVE CONTAM CLTHG. WASH THOROUGHLY W/SOAP & WATER. IF IRRIT
PERSISTS SEEK MED ATTN. WASH CONTAM CLTHG BEFORE REUSE. INGEST: DO
NOT INDUCE (ING 5)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:162F,72C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL AND WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EVACUATE AREA, FIGHT FIRE FROM SAFE DIST.
AT HIGHER TEMP VAPS CAN CAUSE PRESS BUILD UP IN SEALED CNTNRS. USE
WATER TO COOL CNTNRS EXPOSED TO FIRE. (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA, ELIMINATE ALL SOURCES OF
IGNITION. WEAR APPROPRIATE PROTECTIVE GEAR, CONTAIN LEAK OR SPILL,
SALVAGE, CLEAN UP W/NON-COMBUSTIBLE, NON-ACIDIC ABSORBENT MATERIAL
LIKE SAND OR SODA ASH. WA SH DOWN AREA WITH DETERGENT AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE.
Other Precautions:DO NOT WEAR CONTACT LENSES WHEN WORKING WITH THIS
MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPRVD RESP PROT WHENEVER AIRBORNE
CONCS EXCEED TLV CEILINGS OR TWA. USE NIOSH APPRVD RESPS EQUIPPED
W/ORG VAP CARTRIDGE FOR LISTED HAZ. CONFINED SPACES, ROOMS OR TANKS
ARE AREAS WHERE CONC ERN FOR TLVS IS ESPECIALLY (ING 7)
Ventilation:VENT REC. AIR MOVEMENT MUST BE DESIGNED TO INSURE TURNOVER
AT ALL LOCATIONS IN WORK AREA TO AVOID BUILD UP OF HVY VAPS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
SELECTION OF SPECIFIC ITEMS SUCH AS BOOTS & APRON DEPEND ON
OPERATION.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: ELEC GROUNDING IS NOT RECOMMENDED. CNDTNS TO AVOID: POSSIBLY
LEADING TO PRESS BUILDUP & CNTNR FAILURE/EXPLO. EXCESS HEAT,FUMES &
SMOKE CAN OCCUR IF PROD IS NOT MIXED & USED ACCRD TO DIRECTI ONS.
NOT SENSITIVE TO MECH IMPACT. MATLTO AVOID: RXN. NEVER MIX CUMENE
HYDROPEROXIDE W/COBALT NAPHTHENATE DIRECTLY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:-40F,-40C
Vapor Pres:2.0 @ 20C
Vapor Density:> AIR
Spec Gravity:1.05
Solubility in Water:NONE
Appearance and Odor:CLEAR YELLOW LIQUID; SHARP AROMATIC ODOR.
Percent Volatiles by Volume:10
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING & REDUCING AGENTS, ACIDS, ISOCYANATES, ORG COBALTS, AMINES &
METAL SALTS MAY RSLT IN VIOLENT EXPLO (SUPDAT)
Stability Condition to Avoid:STABLE AT ROOM TEMPS; AVOID TEMPS >140F
&/OR CONTAM. HIGHER TEMPS &/OR CONTAM PROMOTES EXOTHERMIC DECOMP
(SUPDAT)
Hazardous Decomposition Products:CARBON MONOXIDE & DIOXIDE, KETONES,
ALCOHOLS, METHANE, ETHANE, PHENOLS & VARIOUS HYDROCARBONS FROM
INCOMPLETE COMBUST.
==================== Disposal Considerations ====================
Waste Disposal Methods:HANDLE DISP OF WASTE MATL IN MANNER WHICH
COMPLIES W/LOC, STATE, PROVINCE & FED REGS. INCIN AT AGENCY APPRVD
WASTE DISP FACILITIES. EMPTY CNTNRS SHOULD BE THOROUGHLY WASHED
BEFORE DISP. RQ: CASRN 80-1 5-9: 50 LBS; 98-82-8: 500 LBS;
98-86-2:5000 LBS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:199 7915, KODAK VERSAMAT 885 DEVELOPER STARTER
Kit Part:Y
Preparer's Name:NOT PROVIDED
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:60.
Maxumum % Wt:65.
Other REC Limits:NOT PROVIDED
Code:F
Code:F
Ingred Name:SODIUM BROMIDE
CAS:7647-15-6
RTECS #:VZ3150000
Minumum % Wt:30.
Maxumum % Wt:35.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:ACETIC ACID
CAS:64-19-7
RTECS #:AF1225000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:25 MG/M3;10 PPM
ACGIH TLV:25 MG/M3;10 PPM
ACGIH STEL:37 MG/M3;15 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF EXPOSURE: INGESTION OF
BROMIDE SALTS CAN CAUSE NAUSEA, VOMITING, HEADACHE, IRRITABILITY,
DELIRIUM, MEMORY LOSS, DECREASED APPETITE, JOINT PAIN,
HALLUCINATIONS, STUPOR, COMA, AND ACNELIKE RA SH ON FACE, LEGS, AND
TRUNK. INHALATION: LOW HAZARD FOR USUAL INDUSTRIAL HANDLING BY
TRAINED PERSONNEL. EYES: CAUSES IRRITATION. HOWEVER, IMMEDIATE
FLUSHING OF THE EYES WITH WATER WILL MINIMIZE ANY IR RITATIVE
EFFECT. SKIN: LOW HAZARD FOR USUAL INDUSTRIAL HANDLING BY TRAINED
PERSONNEL. INGESTION: HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:CARCINOGENICITY CLASSIFICATION
(COMPONENTS PRESENT AT 0.1% OR MORE): - INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER (IARC): NONE - AMERICAN CONFERENCE OF
GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH): NON E - NATIONAL
TOXICOLOGY PROGRAM (NTP): NONE - OCCUPATIONAL SAFETY AND HEALTH
ADMINISTRATION (OSHA): NONE
Effects of Overexposure:INGESTION OF BROMIDE SALTS CAN CAUSE NAUSEA,
VOMITING, HEADACHE, IRRITABILITY, DELIRIUM, MEMORY LOSS, DECREASED
APPETITE, JOINT PAIN, HALLUCINATIONS, STUPOR, COMA, AND ACNELIKE
RASH ON FACE, LEGS, AND TRUNK. EYES: CAUSES IRRITATION.
Medical Cond Aggravated by Exposure:NOT PROVIDED
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:
IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTEN TION IF SYMPTOMS OCCUR. SKIN: WASH WITH SOAP AND
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. INGESTION: ONLY
INDUCE VOMITING AT THE INSTRUCTION OF MEDICAL PERSONNEL. CALL A
PHYSICIAN OR POISON CON TROL CENTER IMMEDIATELY. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NOT PROVIDED
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES (SEE INCOMPATIBILITY SECTION).
Other Precautions:AVOID BREATHING VAPOR AT CONCENTRATIONS GREATER THAN
THE EXPOSURE LIMITS. AVOID CONTACT WITH EYES AND PROLONGED OR
REPEATED CONTACT WITH SKIN. USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HAND LING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: FULL-FACE ORGANIC VAPOR
CARTRIDGE. IF RESPIRATO RS ARE USED, A PROGRAM SHOULD BE INSTITUTED
TO ASSURE COMPLIANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER
HOUR) SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO
CONDITIONS.
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:IT IS A GOOD INDUSTRIAL HYGIENE PRACTICE TO
MINIMIZE SKIN CONTACT.
Supplemental Safety and Health
SUPPLEMENTARY LOCAL EXHAUST VENTILATION, CLOSED SYSTEMS, OR RESPIRATORY
PROTECTION MAY BE NEEDED IN SPECIAL CIRCUMSTANCES SUCH AS POORLY
VENTILATED SPACES, EVAPORATION FROM LARGE SURFACES, SPRAYING, H
EATING, ETC.
================== Physical/Chemical Properties ==================
HCC:C2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:68F: 24 MBAR (18 MM HG)
Vapor Density:0.6
Spec Gravity:1.34
pH:<2.0
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID. SLIGHT ODOR.
Percent Volatiles by Volume:65-70 WT
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES.
Stability Condition to Avoid:NOT PROVIDED
Hazardous Decomposition Products:HYDROGEN BROMIDE.
=================== Toxicological Information===================
Toxicological Information:EFFECTS OF EXPOSURE: INGESTION OF BROMIDE
SALTS CAN CAUSE NAUSEA, VOMITING, HEADACHE, IRRITABILITY, DELIRIUM,
MEMORY LOSS, DECREASED APPETITE, JOINT PAIN, HALLUCINATIONS,
STUPOR, COMA, AND ACNELIKE RA SH ON FACE, LEGS, AND TRUNK.
INHALATION: LOW HAZARD FOR USUAL INDUSTRIAL HANDLING BY TRAINED
PERSONNEL. EYES: CAUSES IRRITATION. HOWEVER, IMMEDIATE FLUSHING OF
THE EYES WITH WATER WILL MINIMIZE ANY IR RITATIVE EFFECT. SKIN: LOW
HAZARD FOR USUAL INDUSTRIAL HANDLING BY TRAINED PERSONNEL.
INGESTION: HARMFUL IF SWALLOWED.
===================== Ecological Information =====================
Ecological:THE FOLLOWING PROPERTIES ARE ESTIMATED FROM THE COMPONENTS
OF THE PREPARATIONS. POTENTIAL TOXICITY: FISH LC50 MG/L: >100.
DAPHNID EC50 MG/L: >100.ALGAL IC50 MG/L: >100. ORGANICS
READILY DEGRAD ABLE (>70%): YES (7 DAYS). POTENTIAL
BIOACCUMULATION: LOG POW <1. COD (APPROXIMATE G/L): 60. BOD5
(APPROXIMATE G/L): 45. POTENTIAL TOXICITY: WASTE TREATMENT
MICROORGANISMS EC50 (MG/L): >100.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL IS SUBJECT TO
NATIONAL, STATE, OR LOCAL LAWS. CONTRACT WITH A LICENSED CHEMICAL
DISPOSAL AGENCY.
=================== MSDS Transport Information ===================
Transport Information:FOR TRANSPORTATION INFORMATION REGARDING THIS
PRODUCT CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE:
(716) 722-2400 BETWEEN 8 A.M. AND 5 P.M. (EASTERN STANDARD
TIME), MONDAY THROUGH FR IDAY.
===================== Regulatory Information =====================
SARA Title III Information:CHEMICAL(S) SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OR TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986 AND 40 CFR
PART 372: NONE
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: NONE - MATERIAL(S) KNOWN TO THE STATE
OF CALIFORNIA TO CAUSE ADVERSE REPRODUCTIVE EFFECTS: NONE
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DOXEPIN HYDROCHLORIDE
Preparer's Name:JEROME A HALPERIN
CAGE:14128
CAGE:14128
============= Composition/Information on Ingredients =============
Ingred Name:DOXEPIN HYDROCHLORIDE *94-3*
CAS:1229-29-4
RTECS #:HQ4375000
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 147 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and
Chronic:ARRHYTHMIA/TACHYCARDIA/DYSPENA/PARESTHESIA/RESPRIATORY
DEPRESSION/CYANOSIS. POSSIBLE ALLERGIC REACTION TO DUST IF
INHALED/INGESTED/CONTACT W/SKIN. EYE/SKIN/RESPIRATORY TRACT
IRRITATION. POSSIBLE HYPER SENSITIZATION. IRRITATING TO MUCOUS
MEMBRANES/RESPIRATORY TRACT. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of
Overexposure:IRRITATION/DROWSINESS/DIZZINESS/HEADACHE/EUPHORIA/STUP
OR/RESTLESSNESS/AGITATION/INSOMNIA/SLEEP/SOMNOLENCE/CONVULSIONS/MUS
CLE CONTRACTIONS/SPASTICITY/COMA/BLOOD PRESSURE
DECREASE/SHOCK/VOMITING/DILATED PUPILS/BLURRED VISION/DRY
MOUTH/CONSTIPATION/KIDNEY CHANGES/URINARY RETENTION/DISTURBED
CONCENTRATION/(SEE SUPP)
Medical Cond Aggravated by Exposure:HYPERSENSITIVITY TO MATERIAL,
PRE-EXISTING HEART DISEASE, NARROW ANGLE GLAUCOMA, LIVER/KIDNEY
IMPAIRMENT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES/SKIN: FLUSH W/WATER.
INGESTION: FLUSH OUT MOUTH W/WATER. MAINTAIN RESPIRATORY FUNCTION.
TREATMENT OF OVERDOSE IS SYMPTOMATIC/SUPPORTIVE. EMPTY STOMACH BY
GASTRIC LAVAGE. ADMINISTER ACTIVATE CHARCOAL SLURRY REPEATEDLY
FOLLOWED BY STIMULANT CATHARTIC. MAINTAIN BODY TEMP. MONITOR
CARDIOVASCULAR FUNCTION FOR 5 DAYS. CONTROL CARDIAC ARRHYTHMIAS
W/LIDOCAINE. (SUPP)
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2, FOAM AS APPROPRIATE
FOR SURROUNDING FIRE/MATERIALS.
Fire Fighting Procedures:EVACUATE AREA. WEAR SELF CONTAINED BREATHING
APPARATUS & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MATERIAL IS ASSUMED TO BE COMBUSTIBLE. AS
W/ALL DRY POWDERS IT'S ADVISABLE TO GROUND MECHANICAL EQUIPMENT IN
CONTACT W/DRY MATERIAL TO DISSIPATE STATIC.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROVED RESPIRATOR & CHEMICALLY
APPROPRIATE CONTAINER FOR WASTE DISPOSAL. VENTILATE AREA & WASH
SITE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHT CONTAINER. SHOULD BE
HANDLED/STORED PER LABEL/OTHER INSTRUCTIONS TO ENSURE PRODUCT
INTEGRITY. USE W/ADEQUATE VENTILATION.
Other Precautions:AVOID CONTACT W/EYES, SKIN/CLOTHING. AVOID BREATHING
DUST/MIST/FUMES/VAPORS. USE W/ADEAUATE DUST CONROL. DON'T PERMIT
EATING/DRINKING/SMOKING NEAR MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATOR.
Ventilation:ADEQUATE. LOCAL EXHAUST/MECHANICAL (GENERAL): RECOMMENDED.
Other Protective Equipment:APPROPRIATE LABORATORY APPAREL
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SYMPTOMS CONT'D: DISORIENTATION/EXCITEMENT/TINGLING OF
EXTREMITIES/PHOTOSENSITIZATION/EDEMA OF
FACE/TONGUE/FEVER/HALLUCINATION. FIRST AID CONT'D: ADMINISTER 1-3MG
PHYSOSTIGMINE SALICYLATE FOR ADULTS B Y FLOW INTRAVENOUS INFUSION
OVER 2-3 MINS. ADMINISTER ANTICONVULSANTS. STANDARD MEASURES FOR
SHOCK/METABOLIC ACIDOSIS.
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALLINE POWDER W/SLIGHT AMINE LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:TOXIC FUMES, NITROGEN OXIDES, HYDROGEN
CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TX-2000
CAGE:62522
CAGE:62522
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL-2-CYANOACRYLATE
CAS:7085-85-0
Other REC Limits:2-5 PPM
Ingred Name:POLYMETHYLMETHACRYLATE, METHYL METHACRYLATE POLYMER
CAS:9011-14-7
RTECS #:TR0400000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RATS LD50 = 12.2 CC/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MUCOUS MEMBRANES W/SOME
COUGHING. EYES: IRRITATION, TEARING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: MUCOUS MEMBRANES W/SOME COUGHING.
EYES: IRRITATION, TEARING.
Medical Cond Aggravated by Exposure:SKIN, EYE & RESPIRATORY DISORDERS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: FLUSH AREAS OF CONTACT
W/WATER. WIPE AWAY LIQUID ADHESIVE WHERE POSSIBLE W/RESIDUALS BEING
REJECTED BY SOAKING IN WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:176F
Extinguishing Media:FLUSH W/LARGE AMOUNTS OF WATER OR DRY CHEMICAL
EXTINGUISHER.
Fire Fighting Procedures:FUMES MAY BE IRRITATING IF NOT BURNING &
WATER OR DRY CHEMICAL.
Unusual Fire/Explosion Hazard:NONE, COMBUSTIBLE REQUIRING THE ABOVE
PROCEDURES.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/PAPER TOWELS OR CLOTH; SWEEP INTO
TRAY FOR LIQUID TO BE REACTED W/WATER FOR SOLID WASTE TREATMENT.
AVOID OVER EXPOSURE TO FUMES W/LARGE SPILLS & POOR VENTILATION.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID MOISTURE, DIRECT UV-SUNLIGHT &
DON'T STORE >77F. KEEP CONTAINERS CLOSED TIGHTLY WHEN NOT IN USE.
IDEAL STORAGE IS AT 41-50F.
Other Precautions:AVOID BREATHING VAPOR, CONTACT W/EYES & SKIN. DON'T
STORE AT -5C WHICH FREEZES PRODUCT TO USELESS STATE. PRODUCT NOT
DAMAGED BY FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NECESSARY, A NIOSH APPROVED ORGANIC
VAPOR CANISTER MAY BE USED.
Ventilation:MECHANICAL/LOCAL EXHAUST: LARGE QUANTITIES USED TO 2 PPM.
Other Protective Equipment:APRON PROTECTS CLOTHING FROM HARDENED GLUE,
SOAP & WATER HELPS REMOVE ADHESIVE FROM SKIN.
Supplemental Safety and Health
POLYMETHYLMETHACRYLATE IMPLANTED UNDER THE SKIN OF EXPERIMENTAL ANIMALS
CAUSED TUMORS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:149F
Vapor Pres:1
Spec Gravity:1.05
Solubility in Water:INSOLUBLE
Appearance and Odor:TRANSPARENT WATER-WHITE TO STRAW COLORED LIQUID
W/STIMULATIVE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOL, AMINES, ALKALINE MATERIALS & DIOXIDE.
Stability Condition to Avoid:HEAT >176, MOISTURE, ALKALINES,
UV-SUNLIGHT.
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE SOLID COMBUSTIBLE WASTE OR DUMP AS
CHEMICAL WASTE ACCORDING TO LOCAL, STATE & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CUTTER OUTDOORSMAN INSECT REPELLENT STICK
Preparer's Name:H.L. PAULS
CAGE:CHEMX
CAGE:CHEMX
CAGE:0WMK8
Contract Num:SP0450-00-M-D265
CAGE:042Y4
CAGE:0WRF5
============= Composition/Information on Ingredients =============
Ingred Name:N,N-DIETHYL-META-TOLUAMIDE (DEET)
CAS:134-62-3
RTECS #:XS3675000
= Wt:30.
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
= Wt:9.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL;9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL IF SWALLOWED..
EYE/SKIN: AVOID CONTACT WITH EYES, LIPS, OPEN CUTS OR IRRITATED
SKIN. IF SKIN REACTION OCCURS WASH WITH SOAP AND WATER. GET MEDICAL
ATTENTION IF IRRITATION PERSISTS. PERSISTS. SPECIAL NOTES: APPLY
ONLY TO SKIN OR CLOTHING. DO NOT INGEST. KEEP OUT OF EYES.
Explanation of Carcinogenicity:PER MSDS:INGREDS LISTED BY NTP/OSHA/IARC
AS CARCINOGENS OR POTENTIAL CARCINOGENS: NONE.
Effects of Overexposure:INGESTION HARMFUL. SKIN IRRITATION. SKIN
REACTION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGESTION-CONSULT A PHYSICIAN OR POISON CONTROL. IF
CONSCIOUS, GIVE 1 OR 2 GLASSES OF WATER & INDUCE VOMITING. DO NOT
INDUCE VOMITING OR GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
EYE-FLUSH EYES WITH PLENTY OF WATER. IF IRRITATION PERSISTS, GET
MEDICAL ATTENTION. SKIN-IF SKIN REACTION OCCURS, WASH WITH SOAP &
WATER. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NONE.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP BULK QUANTITIES AND WASH ANY RESIDUAL
TO DRAIN.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ/FOLLOW LABEL DIRECTIONS.THEY ARE
YOUR BEST GUIDE TO USING THIS PRODUCT EFFECTIVELY & GIVE NECESSARY
SAFETY PRECAUTIONS TO PROTECT YOUR HEALTH.
Other Precautions:EPA REG #:121-59.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
READ AND FOLLOW LABEL DIRECTIONS. THEY ARE YOUR BEST GUIDE TO USING
THIS PRODUCT EFFECTIVELY, AND GIVE NECESSARY SAFETY PRECAUTIONS TO
PROTECT YOUR HEALTH.
================== Physical/Chemical Properties ==================
HCC:T5
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:1.06 G/ML
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:INSOLUBLE.
Appearance and Odor:YELLOW TRANSPARENT SOLID GEL WITH JASMINE
FRAGRANCE.
Percent Volatiles by Volume:9.0
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY SOFTEN OR DAMAGE SOME SYNTHETICS SUCH AS RAYON. MAY DAMAGE LEATHER.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
===================== Ecological Information =====================
Ecological:EPA REGISTRATION NUMBER: 121-59.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL MAY BE DISPOSED OF AS NORMAL SOLID
NON-HAZARDOUS WASTE. DO NOT REUSE CONTAINER.
=================== MSDS Transport Information ===================
Transport Information:DOT SHIPPING NAME: CONSUMER COMMODITY. DOT HAZARD
CLASS: ORM-D.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:233 HAI-NI 233, NICKEL ALLOYS
CAGE:49076
CAGE:49076
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (SARA III). SPEC GRAV:8.9. MP:1450C.
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: >99%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:UNDER NORMAL HNDLG & USE, EXPOS TO
SOLID, MASSIVE FORMS OF ALLOY PRESENTS FEW HLTH HAZS. THEY MAY INCL
SKIN IRRIT/ OTHER ALLERGIC RXNS IN SENSITIVE INDIVIDUALS.
ACUTE:EXPOS TO DUST, WELDING FUME & GAS ES MAY CAUSE NAUS,
TIGHTNESS OF CHEST, FEVER, IRRIT OF EYES, NOSE, THROAT & SKIN; LOSS
OF CONSCIOUSNESS (EFTS OF OVEREXP
Explanation of Carcinogenicity:NICKEL:IARC (GROUP 2B), NTP (ANTICIPATED
TO BE A CARCINOGEN).
Effects of Overexposure:HLTH HAZ:DUE TO WELDING GASES/LACK OF O2.
CHRONIC:ADVERSE EFTS MAY INCL SKIN SENSITIZATION, NEUROLOGICAL DMG
& RESP DISEASES (BRONCH ASTHMA, LUNG FIBROSIS/PNEUMOCONIOSIS).
ACCORDING TO OSHA 20 CFR 191 0.1200 NICKEL IS CONSIDERED POSS
CARCIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE & GET PROMPT MED ATTN. ADMIN O2 IF
VICTIM IS UNCONSCIOUS. IF NOT BRTHG, RESUSCITATE IMMEDIATELY.
EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR MINIMUM OF 15 MINUTES,
SEEK ASSIS TANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER.
CALL MD . INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL IS NONFLAMMABLE; HOWEVER,
WELDING ARCS & SPARKS CAN IGNITE FLAMMABLE LIQUIDS, VAPORS &
COMBUSTIBLE SOLIDS.
================== Accidental Release Measures ==================
Spill Release Procedures:UNDER NORMAL HNDLG & USE, MATL IS NOT VOLAT/
DUSTY & DOES NOT PRESENT SPILLAGE & LEAKAGE PROBS. NO PROT REQD,
EXCEPT AVOID PRLNG/RPTD DIRECT SKIN CONT IF SENSITIVE TO METALS.
GRINDING/(SUPDAT
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:MATL IN SOLID FORM DOES NOT REQ SPECIAL PRECS IN
HNDLG & STORING. HOWEVER, USE INDUS HYGIENE AIR MONITORING TO
ENSURE USE OF MATL DOES NOT CREATE EXPOSURES WHICH EXCEED LEVELS
SPECIFIED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF SOLID METAL ALLOYS ARE CONVERTED IN MFG (INCL
GRINDING, HIGH TEMP CUTTING & WELDING) PROCESSES TO DUSTS, FUMES,
GASES/ MISTS & VENT IS NOT ADEQ TO MAINTAIN EXPOS BELOW LIMS
SPECIFIED, THEN RESP PRO T SHLD BE USED. USE ONLY NIOSH/ (SUPDAT)
Ventilation:IF SOLID METAL ALLOYS ARE CONVERTED TO DUSTS, FUMES/MISTS,
MAINTAIN WORKING ENVIRON BELOW EXPOS LIMS SPECIFIED (SUPDAT)
FACE PROT & FLAME RETARDANT CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV:8.8 +/- 0.1 (H2O=1). HAZ DECOMP PROD:OZONE & NOX. SPILL
PROC:WELDING OPERATIONS, VACUUM RESIDUE INTO SUITABLE CNTNRS. RESP
PROT:MSHA APPRVD RESPS I/A/W OSHA 29CFR1910.134. VENT:IN INGREDIENT
S BY USE OF ADEQ EXHST VENT. EYE PROT:SHADED LENS . SELECT WELDING
LENSE SHADE FROM AWS PUBLICATION F2.2.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:4982F,2750C
Melt/Freeze Pt:M.P/F.P Text:SEE ING
Spec Gravity:SUPP DATA
Solubility in Water:0
Appearance and Odor:GREY METALLIC METALS SHAPED AS WIRE, ROD/STRIP;
ODORLESS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID ACIDS. CONTACT W/MINERAL ACIDS WILL RELEASE HYDROGEN - A READILY
COMBUSTIBLE GAS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES & GASES FROM WELDING & HIGH TEMP
MAY INCL OXIDES OF METALS, CHROMATES, FLUORIDES, COMPLEX METALLICS,
CO, (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W EPA OR LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: 98-0400-0879-3 00-51115-03340-7, FIRE (SUPDAT)
Cage: 1BY21
=======================================================
Contractor Summary
=======================================================
Cage: 76381
Cage: 1BY21
=======================================================
Ingredients
=======================================================
Cas: 21645-51-2
RTECS #: BD0940000
% Wt: 30-40
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
#04499600-5226P
% Wt: 18-36
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 9010-98-4
RTECS #: EI9640000
% Wt: 10-15
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 8009-03-8
RTECS #: SE6780000
% Wt: 5-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 112945-52-5
RTECS #: VV7310000
% Wt: 1-5
OSHA PEL: 6 MG/M3
ACGIH TLV: 10 MG/M3
------------------------------
Cas: 64742-53-6
RTECS #: PY8036001
NAPHTHENIC; (HYDROTREATED LIGHT NAPHTHENIC
% Wt: 1-5
OSHA PEL: 5 MG/M3 (OIL MIST)
ACGIH TLV: 5 MG/M3 (OIL MIST)
------------------------------
-----------------------------
Cas: 25155-81-1
% Wt: 1-4
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 137-26-8
RTECS #: JO1400000
DIAMIDE) (SARA 313) (CERCLA)
% Wt: <3.4
OSHA PEL: 5 MG/M3
ACGIH TLV: 1 MG/M3
EPA Rpt Qty: 10 LBS
DOT Rpt Qty: 10 LBS
------------------------------
Cas: 1305-62-0
RTECS #: EW2800000
% Wt: 1-3
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 5 MG/M3
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 1-3
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:EYE:MECH EYE IRRIT:SIGNS/SYMPS CAN INCL IRRIT,
REDNESS, SCRATCHING OF CORNEA & TEARING. SKIN:MECH SKIN IRRIT:SIGNS/SYMPS
CAN INCL ITCHING & REDNESS. PRLNGD/RPTD EXPOS MAY CAUSE:ALLERGIC SKIN RXN
:SIGNS/SYMPS CAN INCL REDNESS, SWELL, BLISTERING, & ITCHING. INGEST:GI
EFTS:SIGNS/SYMPS GENERALLY (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:WILL INCL ABDOM PAIN.
REPROD/DEVELOPMENTAL TOXINS:TETRAMETHYL THIOPEROXYDICARBONIC DIAMIDE:REPROD
EFTS-HENS FED MAIZE TREATED W/THIRAM CAUSED PRODUCTION OF ABNORMAL
(SOFT-SHELLED) EGGS. BIRTH DEFECTS-WHEN PREGNANT NMRI MICE WERE GIVEN ORAL
DOSES OF 10-30 MG/ANIMAL FROM DAY 5-15 OF PREGNANCY, INCR(SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE:IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET IMMEDIATE MEDICAL ATTENTION. SKIN:WASH AFFECTED AREA WITH SOAP
AND WATER. INHAL:IF SIGNS/SYMPTOMS OCCUR, REMOVE PERSON TO FRESH AIR. IF
SIGNS/SYMPTOMS CONTINUE,CALL PHYSICIAN. INGEST:DRINK TWO GLASSES OF WATER.
CALL PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE PRECAUTIONS FROM OTHER SECTIONS. COLLECT
SPILLED MATERIAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE IN AN INDUSTRIAL/COMMERCIAL FACILITY IN
PRESENCE OF COMBUSTIBLE MATERIAL. COMBUSTION PRODUCTS WILL INCLUDE HCL.
DISPOSE OF WASTE PROD IN SANITARY LANDFILL. RECLAIM IF FEASIBLE. DISPOSAL MUS
T BE I/A/W FEDERAL, STATE & LOCAL REGS (FP N).
Handling And Storage Precautions: AVOID EYE CONTACT. AVOID PROLONGED OR
REPEATED SKIN CONTACT. DO NOT INGEST. KEEP OUT OF THE REACH OF CHILDREN.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). MFR TRADE NAME/PART NO:BARRIER MOLDABLE PUTTY
PADS, STRIPS & STIX. EFTS OF OVEREXP:RESORPTION OCCURRED DURING
INTERMEDIA TE & LATE STAGES OF FETOGENESIS. MALFORMATIONS, CHARACT BY
CLEFT PALATES, MICROGNATHIA, WAVY RIBS & DISTORTED
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.620 WATER=1
Solubility in Water: NIL
Appearance and Odor: STRIPS, BROWN, SLIGHT LATEX ODOR.
Percent Volatiles by Volume: 1-3
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE KNOWN.
Hazardous Decomposition Products: CARBON MONOXIDE AND CARBON DIOXIDE, HYDROGEN
CHLORIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 98-0400-0879-3 00-51115-03340-7, FIRE (SUPDAT)
Cage: 1BY21
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 11/13/1996
Status Code: C
Label Date: 11/13/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:EYE:MECHANICAL EYE IRRITATION:IRRITATION,
REDNESS, SCRATCHING OF CORNEA & TEARING. SKIN:MECHANICAL SKIN
IRRITATION:ITCHING & REDNESS. PROLONGED/REPEATED EXPOSURE MAY
CAUSE:ALLERGIC SKIN REACTION :REDNESS, SWELLING, BLISTERING, & ITCHING.
INGESTION:GASTROINTESTINAL EFFECTS:GENERALLY WILL INCLUDE ABDOMINAL PAIN.
CHRONIC:REPRODUCTIVE/DEVELOPMENTAL TOXINS:TETRAMETHYL THIOPEROXYDICARBONIC
DIAMIDE: REPROD EFTS - HENS FED MAIZE TREATED W/THIRAM CAUSED PRODUCTION OF
ABNORMAL (SOFT-SHELLED) EGGS. BIRTH DEFECTS.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TT-P-61,BLACK # 17038
CAGE:00468
CAGE:33151
CAGE:00468
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENTS
Fraction by Wt: 31.2%
ACGIH TLV:200PPM
===================== Hazards Identification =====================
Effects of
Overexposure:ANESTHESIA,HEADACHE,NAUSEA,DIZZINESS,ETC.LIQUID-MILDLY
TO MODERATELY EYE IRRITATING
======================= First Aid Measures =======================
First Aid:REMOVE VICTIM AND RESTORE BREATHING IF NECESSARY.WASH SKIN
WITH SOAP AND WATER.FLUSH EYE WITH COLD WATER
===================== Fire Fighting Measures =====================
Flash Point:105F,41 C TCC
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:DRY CHEMICAL,FOAM,CO*2,STEAM,WATER FOG,
Fire Fighting Procedures:DO NOT USE WATER.EXCLUDE AIR. CONSULT FIRE
MARSHALL
Unusual Fire/Explosion Hazard:VAPOR FORMS EXPLOSIVE MIXTURE BETWEEN
UPPER AND LOWER EXPLOSIVE UNITS.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID FLAME AND SPARK SOURCES.PROVIDE ADEQUATE
VENTILATION.USE OIL SEWER IF AVAILABLE,OR REMOVE TO A CONTAINER
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID OPEN FLAME AND SPARK
SOURCES.AVOID SPLASH FILLING.PROVIDE ADEQUATE VENTILATION.AVOID
EXCESSIVE HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC CANNISTER MASK OR AIR PACK
Ventilation:APPROVED CLASS D EXPLOSION PROOF MOTOR AND SWITHCES.
Other Protective Equipment:NA
Supplemental Safety and Health
BOILING RANGE 157-194C
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:315-382 F
Vapor Density:5.0
Spec Gravity:0.78
Evaporation Rate & Reference:BUTYL ACETATE 0.13
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK PAINT,HYDROCARBON ODOR
Percent Volatiles by Volume:42.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO*2 WHEN COMBUSTED
==================== Disposal Considerations ====================
Waste Disposal Methods:EVAPORATE OR FLUSH W/WATER IN A WELL VENTILATED
AREA.USE OIL SEWER IF AVAILABLE,OR REMOVE TO A CONTAINER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:INHIBITED RED FUMING NITRIC ACID IRFNA
Preparer's Name:W. W. SHEPHERD
CAGE:FO294
CAGE:FO294
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID (SARA III)
CAS:7697-37-2
RTECS #:QU5775000
OSHA PEL:2 PPM/4 STEL
ACGIH TLV:2 PPM/4 STEL; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NITROGEN DIOXIDE (SARA III)
CAS:10102-44-0
RTECS #:QW9800000
OSHA PEL:C,5 PPM
ACGIH TLV:3 PPM/5 STEL; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NITROGEN DIOXIDE (SARA III)
CAS:10544-72-6
RTECS #:QX1575000
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:HYDROGEN FLUORIDE (SARA III)
CAS:7664-39-3
RTECS #:MW7875000
OSHA PEL:3 PPM/6 STEL (F)
ACGIH TLV:C 3 PPM (F); 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: TOXIC. VERY DANGEROUS/POOR
WARNING PROPERTIES/MAY CAUSE COUGHING/DIFFICULT BREATHING/PULMONARY
EDEMA/DEATH. SKIN: DESTROYS TISSUE BY DIRECT ACTION. CAUSES BURNS.
STAINS SKIN/TISSUE YELLOW OR YELLOWISH BROWN. EYES: CAUSES
BURNS/PERMANENT LOSS OF VISION. INGESTION: BURNING/CORROSION OF
MOUTH & DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EFECTS OF EXPOSURE MAY BE DELAYED. KEEP PATIENT
AT REST & UNDER SURVEILLANCE A MINIMUM OF 72 HOURS. ADMINISTER
OXYGEN IF BREATHING IS DIFFICULT. ORAL: DON'T USE CARBONATED
ALKALIES AS ANTIDOTE. SYSTE MIC: TREATMENT BASED ON SOUND
JUDGEMENTOF PHYS & INDIVIDUAL REACTIONS OF THE PATIENT. NO SPECIFIC
ANTIDOTE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 30 MINS. SEE PHYSICIAN. SKIN:
FLUSH W/WATER FOR 30 MIN WHILE REMOVING CONTAMINATED CLOTHING. SEE
PHYSICIAN. DESTROY CONTAMINATED CLOTHES & SHOES. INHALATION: REMOVE
TO FRESH AIR. TRANSPORT TO HOSPITAL. KEEP PATIENT AT REST EVEN IF
NO SYMPTOMS ARE EVIDENT. START ARTIFICIAL RESPIRATION IF BREATHING
HAS STOPPED. INGESTION: DRINK LARGE MTS OF WATER. SEE PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER. AFTER DILUTION WITH WATER OTHER
EXTINGUISHING AGENTS MAY BE USED.
Fire Fighting Procedures:SCBA & SPECIAL RESISTANT SUIT MUST BE WORN.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN, RECOVER, PREVENT CONTACT W/OXIDIZABLE
MATERIALS. CAREFULLY DILUTE UNRECOVERABLE MATERIAL W/EXCESS WATER.
PLACE IN SUITABLE CONTAINER. IF LARGE AMOUNT OF FUMES ARE
GENERATED, PERSONNEL EVACUAT ION MAY BE REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL WELL VENTILATED AREA
AWAY FROM REDUCING AGENTS & COMBUSTIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR RESISTANT SCBA.
Ventilation:LOCAL & GENERAL VENTILATION IS REQUIRED
Other Protective Equipment:WEAR SPECIAL RESISTANT FULL BODY COVERING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:140F
Melt/Freeze Pt:M.P/F.P Text:-61F
Vapor Pres:5
Vapor Density:>1
Spec Gravity:1.5
Solubility in Water:100%
Appearance and Odor:RED LIQUID WHICH EMITS YELLOWISH RED TOXIC FUMES OF
NOX; IRRITATING ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT EXPLOSIVELY W/REDUCING AGENTS. REACTS VIGOROUSLY W/MANY
ORGANIC MATERIALS INCLUDING CYCLOHEXANE, FORMALDEHYDE.
Hazardous Decomposition Products:TOXIC FUMES OF NOX AND HF.
Conditions to Avoid Polymerization:REACTS WITH MANY METALS & ALCOHOLS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. THIS IS A RCRA HAZARDOUS WASTE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:698 NEUTRAL SRS
CAGE:59500
CAGE:59500
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <1%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 5-10%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:25 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:POTASSIUM ROSIN SOAP
CAS:61790-50-9
Fraction by Wt: 1-5%
Ingred Name:CARVENE; CYCLOHEXENE, 1-METHYL-4-(1-METHYLETHENYL), CITRUS
TERPENE, D-LIMONENE, P-MENTHADIENE
CAS:5989-27-5
RTECS #:GW6360000
Fraction by Wt: 1-10%
Ingred Name:5(6)-CARBOXY-4-HEXYL-2-CYCLOHEXENE-1-OCTANOIC ACID, SODIUM
SALT
CAS:68127-35-5
Fraction by Wt: 5-15%
Ingred Name:NONYLPHENOL POLYOXYETHYLENE ETHER; POLYOXYETHYLENE
NONYLPHENOL; TERGITOL NPX; TRITON N-100; NONIONIC SURFACTANT
CAS:9016-45-9
RTECS #:MD0900000
Fraction by Wt: 1-5%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:DIETHANOLAMINE OLEATE
CAS:13961-86-9
RTECS #:RK0880000
Fraction by Wt: 1-5%
Ingred Name:ALCOHOLS, C8-18, ETHOXYLATED PROPOXYLATED*94-4*
CAS:69013-18-9
Fraction by Wt: 1-5%
Ingred Name:LINEAR ALCOHOL (CAS #68131-40-8)
Ingred Name:ETHYLENE OXIDE (SUSPECTED HUMAN CARCINOGEN BY ACGIH, IARC,
& OSHA; IARC GROUP 2A; SUSP CARCINOGEN BY NTP) *94-4*
CAS:75-21-8
RTECS #:KX2450000
ACGIH TLV:1.8 MG/CUM (A2)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RABBIT): 300 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:SKIN: ALKALINE MATERIALS CAUSE BURNS.
EYES: SEVERE IRRITATION/INJURY. INGESTION: BURNING SENSATION.
INHALATION: BURNING OF NASAL PASSAGES.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, BURNS, GASTRIC UPSET, DIARRHEA,
SEVERE INFLAMMATION OF MUCOUS MEMBRANES/EYES, SLIGHT HEADACHE.
Medical Cond Aggravated by Exposure:PRE-EXISSTING BLOOD DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH IMMEDIATELY W/MILD SOAP & WATER. RINSE THOROUGHLY
W/COOL WATER. PAT DRY, DON'T RUB. EYES: FLUSH IMMEDIATELY W/WATER
FOR 15 MINS. INGESTION: DON'T ATTEMPT TO INDUCE VOMITING. GIVE 2
GLASSES OF WATER & HAVE MSDS AVAILABLE. INHALATION: REMOVE TO
FRESH AIR.OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/INERT MATERIAL/SAND/VERMICULITE.
SWEEP/SCOOP UP & PUT IN DISPOSAL CONTAINER. FLUSH AREA W/WATER.
PREVENT WASHINGS FROM ENTERING WATERWAYS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE SEPARATE
FROM OXIDIZERS. KEEP FROM FREEZING. USE W/ADEQUATE VENTILATION.
Other Precautions:DON'T TAKE INTERNALLY. AVOID CONTAMINATION OF
SKIN/FREE FALL OF LIQUID IN EXCESS OF A FEW INCHES. DON'T WEAR
CONTACT LENSES WHEN WORKING W/THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE W/ADEQUATE VENTILATION.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:EYE FOUNTAIN
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
ORAL LD50 INFORMATION IS FOR 2-BUTOXYETHANOL.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:32F
Vapor Density:>1
pH:9-9.5
Evaporation Rate & Reference:FASTER THAN N-BU AC
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, DARK, AMBER LIQUID W/CITRUS ODOR.
Percent Volatiles by Volume:82/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDIC MATERIALS/OXIDIZERS.
Stability Condition to Avoid:FREEZING.
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 01-398-0947
Product ID: GLASS CLEANER
Cage: NO602
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: NO602
Assigned Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: NO602
Cage: 0UHH5
=======================================================
Item Description Information
=======================================================
Specification Number: A-A-40
Type/Grade/Class: TYPE 1 CL 1
=======================================================
Ingredients
=======================================================
Cas: 111-76-2
RTECS #: KJ8575000
% Wt: 5.5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 25 PPM
------------------------------
Cas: 67-63-0
RTECS #: NT8050000
% Wt: 4.5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 400 PPM
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: IRRIT, CORNEAL INJURY, MUCOUS MEMBRANE IRRIT. SKIN:
IRRIT, DERMATITIS. PROLONGED SKIN ABSORPTION: HEADACHE, DIZZY, NAUSEA, VOMIT,
DIARRHEA. INHAL: HEADACHE, DIZZY, NAUSEA, VOMIT, DIARRHEA. INGEST : HEADACHE,
DIZZY, NAUSEA, VOMIT, DIARRHEA.
Medical Cond Aggravated By Exposure: PRE-EXISTING SKIN CONDITIONS.
First Aid: EYE: REMOVE CONTACTS. FLUSH W/WATER FOR 15 MINUTES. SKIN: CALL DR.
INGEST: DRINK 2 GLASSES OF WATER & INDUCE VOMIT. GET IMMED MED AID IN ALL
CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: LG: STOP SPILL. CONTAIN SPILL BY DIKE OR OTHER MEANS.
PUMP INTO SALVAGE TANK. WASH FLOOR W/WATER.
Waste Disposal Methods: IN ACCORDANCE W/LOCAL, STATE, FEDERAL REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINERS CLOSED. STORE IN COOL DRY
WELL VENTILATED AREA.
Other Precautions: KEEP FROM FREEZING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 125F,52C
Extinguishing Media: WATER FOG, CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE SCBA & TURN-OUT GEAR.
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED UNDER NORMAL USE. NIOSH CARTRIDGE
RESPIRATOR IF VAPORS EXCEED TLV.
Ventilation: USE IN WELL-VENTILATED AREA.
Other Protective Equipment: IMPERVIOUS APRON/BOOTS TO MAINTAIN BELOW TLV.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 180F,82C
M.P/F.P Text: 25.0F,-3.9C
Decomp Text: 25.0F,-3.9C
Vapor Pres: <1
Vapor Density: >AIR
Spec Gravity: <1 WATER=1
PH: 9-11
Viscosity: <1 (WATER=1)
Evaporation Rate & Reference: 1 CC/60 HRS @ 77F
Solubility in Water: COMPLETE
Appearance and Odor: WATER CLEAR MILD ALCOHOL ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: OXIDIZING AGENTS
Hazardous Decomposition Products: OXIDES OF CARBON, OTHER HYDROCARBONS.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 134245
Product ID: GLASS CLEANER
Review Date: 04/19/1998
Multiple KIT Number: 0
Review IND: Y
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: GJL
Symbols: G
DOT Proper Shipping Name: FLAMMABLE LIQUIDS, N.O.S.
Hazard Class: 3
UN ID Num: UN1993
DOT Packaging Group: III
Label: FLAMMABLE LIQUID
Special Provision: B1,B52,T7,T30
Packaging Exception: 150
Non Bulk Pack: 203
Bulk Pack: 242
Max Qty Pass: 60 L
Max Qty Cargo: 220 L
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: HIA
IMO Proper Shipping Name: FLAMMABLE LIQUID, N.O.S. o
IMDG Page Number: 3345
UN Number: 1993
UN Hazard Class: 3.3
IMO Packaging Group: III
Subsidiary Risk Label: -
EMS Number: 3-07
MED First Aid Guide NUM: T
=======================================================
Detail IATA Information
=======================================================
IATA PSN CA
IATA UN ID Num: 1993
IATA Proper Shipping Name: FLAMMABLE LIQUID, N.O.S. *
IATA UN Class: 3
IATA Label: FLAMMABLE LIQUID
UN Packing Group: III
Packing Note Passenger: 309
Max Quant Pass: 60L
Max Quant Cargo: 220L
Packaging Note Cargo: 310
=======================================================
Detail AFI Information
=======================================================
AFI PSN CA
AFI Symbols: *
AFI Proper Shipping Name: FLAMMABLE LIQUIDS, N.O.S.
AFI Hazard Class: 3
AFI UN ID NUM: UN1993
AFI Packing Group: III
Special Provisions: P5
Back Pack Reference: A7.3
=======================================================
HAZCOM Label
=======================================================
Product ID: GLASS CLEANER
Cage: NO602
Assigned IND: Y
Company Name: LHB OF HOUSTON
Street: 3530 W. DALLAS
Zipcode: 77019
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: EYE: IRRIT, CORNEAL INJURY, MUCOUS MEMBRANE IRRIT.
SKIN: IRRIT, DERMATITIS. PROLONGED SKIN ABSORPTION: HEADACHE, DIZZY, NAUSEA,
VOMIT, DIARRHEA. INHAL: HEADACHE, DIZZY, NAUSEA, VOMIT, DIARRHEA. INGEST :
HEADACHE, DIZZY, NAUSEA, VOMIT, DIARRHEA.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ISO-QUIN (SEE SUPPL)
Kit Part:Y
Preparer's Name:NOT PROVIDED
CAGE:24719
CAGE:24719
Contract Num:MDA414-99-T-5105
CAGE:0FBL1
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL
CAS:67-63-0
RTECS #:NT8050000
= Wt:45.
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:CONTACT WITH EYES CAUSES IRRITATION
AND WILL INJURE EYE TISSUE IF NOT REMOVED PROMPTLY. PROLONGED OR
REPEATED CONTACT WITH SKIN MAY CAUSE IRRITATION DERMATITIS. HIGH
VAPOR CONCENTRATIONS ARE IRRITATIN G TO EYES AND RESPIRATORY TRACT,
MAY CAUSE HEADACHES AND DIZZINESS, ARE ANESTHETIC AND MAY HAVE
OTHER CNS EFFECTS.
======================= First Aid Measures =======================
First Aid:INHALATION: USING PROPER RESPIRATORY PROTECTION, IMMEDIATELY
REMOVE THE VICTIM FROM EXPOSURE. ADMINISTER ARTIFICIAL RESPIRATION
IF BREATHING IS STOPPED. SEEK MEDICAL ATTENTION IMMEDIATELY. SKIN:
REMOV E ANY CONTAMINATED CLOTHING. WASH SKIN THOROUGHLY. SEEK
MEDICAL ATTENTION IF IRRITATION PERSISTS. EYES: FLUSH EYES
IMMEDIATELY WITH LARGE AMOUNTS OF RUNNING WATER FOR AT LEAST 15
MINUTES. SEEK MEDICAL ATTENTION IMMEDIATELY. INGESTION: NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. IF SWALLOWED. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS SPONTANEOUSLY, KEEP AIRWAY
CLEAR. SEEK MEDICAL ATTENT ION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=21.1C, 70.F
Lower Limits:2.0
Upper Limits:12.7
Extinguishing Media:ALCOHOL TYPE FOAM AND DRY CHEMICAL.
Fire Fighting Procedures:USE WATER SPRAY TO COOL EXPOSED SURFACES.
ALLOW FIRE TO BURN UNDER CONTROLLED CONDITIONS OR EXTINGUISH. IF
LEAK OR SPILL HAS NOT IGNITED, USE WATER SPRAY TO DISPERSE VAPOR.
TRY TO COVER LIQUID SPILLSWITH FOAM.
================== Accidental Release Measures ==================
Spill Release Procedures:SPILLS SHOULD BE CONTAINED, COLLECTED INTO
ABSORBENT MATERIAL AND DISPOSED OF IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT MODERATE TEMPERATURES (50-110
F) TO AVOID FREEZING OR OVERHEATING. READ LABEL CAREFULLY AND
FOLLOW DIRECTIONS. STORE AWAY FROM SOURCES OF EXCESSIVE HEAT OR
IGNITION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WITH NORMAL USE.
Ventilation:NO SPECIAL REQUIREMENTS.
Other Protective Equipment:NOT REQUIRED.
Supplemental Safety and Health
CONTRACTOR'S NAME: DAKOTA SPORTS. CONTRACTOR'S PART NUMBER/TRADE NAME:
TRS 6392/VARSITY KIT. THIS KIT CONTAINS 5 PARTS, SEE MSDS SERIAL #
CLFHD, CLFHG, CLFHJ, AND CLFHL. P/N 093024 IS WRITTEN ON THE M SDS.
================== Physical/Chemical Properties ==================
Boiling Pt:=80.C, 176.F
Melt/Freeze Pt:M.P/F.P Text:LIQUID AT ROOM TEMP
Vapor Density:>AIR
Spec Gravity:0.915
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, YELLOW LIQUID.
Percent Volatiles by Volume:45
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAUSTICS, AMINES, ALKANOLAMINES, STRONG OXIDIZERS AND CHLORINATED
COMPOUNDS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSED OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS.
======================= Other Information =======================
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:TW-25B HIGH-TECH LUBRICANT
CAGE:0BAN7
CAGE:0BAN7
============= Composition/Information on Ingredients =============
Ingred Name:SYNTHETIC OILS, ESTERS AND OTHER INGREDIENTS; (SYNTHETIC
OILS (ORGANIC ESTERS)) (MIXTURE W/ING 2)
Other REC Limits:5 MG/M3 (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL; (HIGHLY REFINED MINERAL OILS)
CAS:8012-95-1
RTECS #:PY8030000
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3 (MIST)
Ingred Name:CALCIUM SULFATE; (CALCIUM SUFLULIATE/CARBOXYCATE COMPLEX IN
HIGHLY REFINED MINERAL OIL MIXTURE)
CAS:7778-18-9
RTECS #:WS6920000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:PHOSPHORIC ACID, TRITOLYL ESTER; (TRICRESYL PHOSPHATE)
CAS:1330-78-5
RTECS #:TD0175000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE KNOWN.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15
MINUTES, SEEK ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUN TS OF
WATER. CALL MD . INGEST:CONTACT MD. DO NOT INDUCE VOMITING, DRINK
PLENTY OF WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:475F,246C
Extinguishing Media:CO*2, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE AIR PACK.
Unusual Fire/Explosion Hazard:INHALATION OF THERMAL DECOMPOSITION
PRODUCTS OF FLUOROCARBONS MUST BE AVOIDED FOR SAME REASONS THAT
APPLY TO ALL COMBUSTIBLE MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SALVAGE UNCONTAMINATED MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AREA CLEAN. AVOID INGESTION.
Other Precautions:PROTECT FROM SPATTERING INTO EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NO SPECIAL REQUIREMENT.
Ventilation:VENT IF SPRAYING.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH SKIN OR CLOTHING W/DETERGENT AFTER
EXPOSURE. WSAH HANDS BEFORE EATING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.48 (H*2O=1)
Solubility in Water:LONG TERM-NEGLIGIBLE
Appearance and Odor:OFF WHITE; SWEET ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, BASES & OXIDIZING AGENTS.
Stability Condition to Avoid:SUSTAINED TEMPERATURES >600F.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE HF
&/OR PHOSPHORUS OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . REMOVE TO APPROVED LUBRICANT RECOVERY PROCEDURE.
OTHERWISE DISPOSE OF AS WASTE OIL. DO NOT INCINERATE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:JOHNSON ARTIC WHITE, OM-0017-2745
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 6.35%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE) (SARA 313)
(CERCLA) LEL: 13.00%
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 17.44%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM, A2
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA) LEL: 1.27%
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 16.85%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA) LEL: 2.60%
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 11.49%
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MINERAL SPIRITS LEL: 0.70%
CAS:64642-88-7
Fraction by Wt: 0.31%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LIGROINE; (VARNISH MAKERS & PAINTER NAPHTHA) LEL: 1.10%
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 1.48%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYL ALCOHOL (ETHANOL); (DENATURED ETHYL ALCOHOL) LEL:
3.30%
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 3.17%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:XYLENE (SARA 313) (CERCLA) LEL: 1.00%
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1.34%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHANOL, 2-BUTOXY-; (ETHYLENE GLYCOL MONO BUTYL ETHER) LEL:
1.10%
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 1.11%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
Ingred Name:PROPANE LEL: 2.30%
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 18.0%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:ISOBUTANE LEL: 1.90%
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 12.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: HAZ LIST INFO & SAFE HNDLG & EXPOS INFO . ANIMAL
STUDIES CLEARLY DEMONSTRATED DOSE-RELATED (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: ADVERSE EFTS ON THE CNS, HEMATOPOIETIC TISS, BLOOD,
KIDNEYS & LIVER, ASSOC W/ADMIN OF ETHYLENE GLYCOL (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: MONOBUTYL ETHER (EGBE) (EXTRACTED FROM DHHS (NIOSH)
PUBLICATION #90-118) . FOR MORE COMPLETE (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: EXPLANATION OF HEALTH HAZARDS OF SPECIFIC
INGREDIENTS, CONTACT NEHC .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: MAY BE HARMFUL. CAN
IRRITATE UPPER RESP SYS & CAUSE HDCH, DIZZ, NAUS & VOMIT. INGEST:
MAY BE HARMFUL. CAN CAUSE GI IRRIT, NAUS, VOMIT, DIARR. ASPIR
HAZ-CAN CAUSE CHEM PNEUMIT & PULM EDEM A/HEMORR. EYE: CAN CAUSE SEV
IRRIT, REDNESS, TEARING & BLURRED VISION. SKIN: CAN CAUSE IRRIT,
DEFAT, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: IARC MONO, SUPP, VOL
7, PG 194, 1987: GROUP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:
(SUP DAT)
Effects of Overexposure:HLTH HAZ: & DERM. CHRONIC: LIVER & KIDNEY DMG.
CNS DEPRESS. DERM. CHLOROCARBON MATLS HAVE PRDCED SENSIT OF THE
MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE SIMILAR EFT
IN HUMANS. ADRENOMIMETI CS (E.G., EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS
ACUTELY/CHRONICALLY (SUP DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH POTABLE WATER FOR AT LEAST 15 MINUTES. SEE
MD . SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE MD .
INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE OXYGEN OR
ARTI FICIAL RESPIRATION) . INGESTION: CALL MD IMMEDIATELY . FOR
MORE INFORMATION CONCERNING MANUFACTURER'S FIRST AID PROCEDURES FOR
INDIVIDUAL INGREDIENTS, CONTACT NEHC .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-10F,-23C
Lower Limits:SEE INGS
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, OR FOAM.
Fire Fighting Procedures:WEAR NIOSH APPRVD PRESS DEMAND SCBA & FULL
PROT EQUIP . WATER SPRAY MAY BE INEFFECTIVE, BUT MAY BE USED TO
COOL CONTRS TO PVNT BURSTING. IF WATER(SUP DAT)
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT MAY CAUSE BURSTING OF
AEROSOL CAN. THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE HCL AND
PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. WIPE UP WITH INERT MATERIALS AND
PLACE IN APPROPRIATE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. EXPOSURE TO
HEAT OR PROLONGED EXPOSURE TO SUN MAY CAUSE BURSTING. USE ONLY AS
DIRECTED.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONC VAPS &
INHALING CONTENTS CAN BE HARMFUL/FATAL. NO SMKNG IN AREA OF USE. DO
NOT USE IN GEN VICIN OF ARC WELDING, OPEN FLAMES/HOT SURFS. HEAT
&/UV RADIATION MAY C AUSE FORMATION OF HCL &/PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID CONTINUOUS BREATHING OF VAPORS AND SPRAY
MIST. A NIOSH APPROVED SCBA REQUIRED FOR CONCENTRATIONS ABOVE TLV
LIMITS.
Ventilation:USE WITH ADEQUATE VENTILATION, SUFFICIENT TO PREVENT
INHALATION OF SOLVENT VAPORS.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN: ANTIC TO BE CARCIN. ANIMAL: LUNG. FIRE FIGHT PROC: IS
USED, FOG NOZZ ARE PREF. HAZ DECOMP PROD: & TRACES OF PHOSGENE .
EFTS OF OVEREXP: EXPOSED TO CHOLOROCARBONS . TOLUEN E APPEARS ON
THE NAVY OCCUP CHEM REPRO HAZ LIST. SEEK CONSULT FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST (ING 12)
================== Physical/Chemical Properties ==================
Vapor Pres:40 PSI
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F. KEEP FROM SPARKS,
PILOT LIGHTS OR OPEN FLAME.
Hazardous Decomposition Products:MAY PRDCE HAZ FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON DIOXIDE &/MONOXIDE, HYDROGEN
CHLORIDE VAP (SUP DAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE AEROSOL. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT PLACE
AEROSOL CANS IN HOME COMPACTOR. DO NOT PUNCTURE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SUNDANCE-Q DISINFECTANT CLEANER
Preparer's Name:BONITA C PATTERSON
CAGE:59923
CAGE:59923
============= Composition/Information on Ingredients =============
Ingred Name:QUATERNARY AMMONIUM COMPOUNDS, BENZYL-C12-18-ALKYLDIMETHYL,
CHLORIDES *96-2*
CAS:68391-01-5
Fraction by Wt: 2.5%
Ingred Name:QUATERNARY AMMONIUM COMPOUNDS, C12-18-ALKYL
((ETHYLPHENYL)METHYL)DIMETHYL, CHLORIDES *96-1*
CAS:68956-79-6
Fraction by Wt: 2.5%
Ingred Name:TETRASODIUM SALT OF ETHYLENEDIAMINETETRAACETIC ACID, SODIUM
EDTA, SODIUM (DI) ETHYLENEDIAMINE TETRAACETATE *96-2*
CAS:64-02-8
RTECS #:AH5075000
Fraction by Wt: 5-7%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: CORROSIVE. IRRITATION.
INGESTION: HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/WATER FOR 15
MINS. SKIN: FLUSH W/WATER. INGESTION: DRINK LARGE QUANTITIES OF
WATER. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F
Unusual Fire/Explosion Hazard:PRODUCT ISN'T FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE MOP/WET VACCUM TO COLLECT MATERIAL FOR
PROPER DISPOSAL. RINSE AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE GOOD PERSONAL HYGIENE PRACTICE.
WASH CONTAMINATED CLOTHING & EQUIPMENT BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
Other Protective Equipment:FACE SHIELD
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.03
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR YELLOW LIQUID W/NO ODOR.
Percent Volatiles by Volume:88
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LEAD ACID STORAGE BATTERY
Preparer's Name:ALAN L. CSORITAS
CAGE:63432
CAGE:0YUR5
CAGE:63432
CAGE:3X778
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 60%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.05MG/M3, A3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY (SARA 313) (CERCLA)
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG (SB)/M3; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC (SARA 313) (CERCLA)
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1018
ACGIH TLV:0.01 MG/M3, A1; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SULFURIC ACID (SARA 302/313) (CERCLA)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-38%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CALCIUM, METAL
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: <0.15%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR SULFURIC ACID IS 1 MG/M3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CONTENTS OF BATTERY ARE CORROSIVE
EYES: MAY CAUSE IRRITATION.SKIN:MAY CAUSE IRRITATION AND
BURNS.INGEST:MAY CAUSE GI TRACT IRRITATION.INHAL:MAY CAUSE
RESPIRATORY IRRITATION.CHRONIC:DRYING OF THE SKIN,
BRONCHITIS,EROSION OF TOOTH ENAMEL.
Explanation of Carcinogenicity:SULFURIC ACID MISTS-IARC 2B.LEAD-IARC
2B.
Effects of Overexposure:SKIN:DERMATITIS.
Medical Cond Aggravated by Exposure:SULFURIC ACID MISTS MAY BRONCHIAL
SYSTEM, SKIN AND EYES.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH WATER.GET MEDICAL
ATTENTION.EYES:FLUSH WITH WATER FOR 15 MINUTES.GET MEDICAL
ATTENTION.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR ARTIFICIAL
RESPIRATION IF NE EDED.INGEST:DO NOT INDUCE VOMITING.GET PROMPT
QUALIFIED MEDICAL ATTENTION.IF CONSCIOUS,RINSE MOUTH WITH WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:675F
Lower Limits:4.1(H2)
Upper Limits:74.2(H2)
Extinguishing Media:HALON,DRY CHEMICAL.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.ACID MISTS ARE CORROSIVE.
Unusual Fire/Explosion Hazard:HYDROGEN GAS AND SULFURIC ACID MISTS MAY
BE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION.USE PROPER
RESPIRATORY AND PROTECTIVE EQUIPMENT.NEUTRALIZE.SOAK UP WITH A NON-
COMBUSTIBLE INERT ABSORBANT(CLAY,SAND);PLACE IN PROPER CONTAINER
FOR DISPOSAL.AVOID SHORTIN G BATTERY TERMINALS.
Neutralizing Agent:SODA BICARBONATE,SODA ASH,SAND,LIME SHOULD BE KEPT
ON SITE FOR SPILL REMEDIATION
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE. KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
HEAT,SPARKS,FLAMES AND INCOMPATIBLE MATERIALS.
Other Precautions:AVOID SHORTING BATTERY TERMINALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE EITHER A SELF-CONTAINED BREATHING APPARATUS OR
A NIOSH/ MSHA APPROVED RESPIRATOR FOR ACID GAS,DEPENDING ON THE
AIRBORN CONCENTRATION.
Ventilation:USE GENERAL DILUTION VENTILATION(4 AIR CHANGES PER HOUR).
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:275F,135C
Melt/Freeze Pt:M.P/F.P Text:>320F,>160C
Vapor Density:3.4
Spec Gravity:1.08-1.4
pH:ACID
Solubility in Water:ELECTROLYTE-COMPLETE
Appearance and Odor:BATTERY WITH POLYPROPYLENE OR HARD RUBBER CASE.
ELECTROLYTE IS COLORLESS ACID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:OVERCHARGING,SOURCES OF IGNITION.
Hazardous Decomposition Products:EXPLOSIVE HYDROGEN/OXYGEN FORMED
BATTERY DURING CHARGING.SULFURIC ACID
MISTS,SO2,SO3,STILBENE,ARSINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE WHOLE SCRAP BATTERIES TO LEAD SMELTER.
PLACE NEUTRALIZED SPILLS IN CONTAINER WITH SORBENT
MATERIALS.DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PAPI 901
CAGE:GO857
CAGE:93703
CAGE:GO857
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE BISPHENYL ISOCYANATE
RTECS #:NQ8805000
Fraction by Wt: 50.0%
ACGIH TLV:C, 0.02PPM
===================== Hazards Identification =====================
Effects of Overexposure:BREATHLESSNESS, CHEST DISCOMFORT, REDUCED
PULMONARY FUNCTION
======================= First Aid Measures =======================
First Aid:INH: TREAT SYMPTOMATICALLY; VASO-DILATORS; OXYGEN. CALL MD.
SKIN: WASH W/SOAP & WATER. ALCOHOL HELPFUL. EYE: FLUSH W/WATER FOR
AT LEAST 15 MIN. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:415F CC
Extinguishing Media:FOG, FOAM, DRY CHEM, CARBON DIOXIDE
Fire Fighting Procedures:USE SELF-CNTND BRTHNG APPARATUS
Unusual Fire/Explosion Hazard:AVOID WATER CONTAM IN CLOSED CNTNR OR
CONFINED AREA: CO*2 EVOLVED.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER LIQ W/ABSORBENT MATL. PLACE IN OPEN-TOP
CNTNR. REMOVE TO WELL-VENT AREA, TREAT W/DILUTE AMMONIA SOLUTION:
EXOTHERMIC, WATER; 90% / CONC NH*4, OH; 8% / LIQ DETERGENT; 2%, MFR
REC.
======================Handling and Storage ======================
Handling and Storage Precautions:HARMFUL IF INH. CAUSES SKIN/EYE IRRIT.
MAY CAUSE ALLERGIC RESP REACTION. AVOID CNTCT W/SKIN/EYES/CLOTHING.
Other Precautions:SEE UPJOHN TECH INFORMATION SHEET & TECH BULLETIN
107.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPRVD MASK OR RESP
Ventilation:TO MAINTAIN CONC BELOW TLV
Other Protective Equipment:WATERPROOF PROTECTIVE CLOTHING, COVERALLS,
RUBBER BOOTS, ETC
Supplemental Safety and Health
BP: 625F. DECOMPOSES AT 5MMHG 390F. VAP PRESS: 0.0003 AT 25C.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:390F
Spec Gravity:1.20
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK BROWN LIQ
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, STRONG BASES
Stability Condition to Avoid:MOISTURE CONTAM
Hazardous Decomposition Products:>500F: CO,BENZENE,TOLUENE,OXIDES OF
NITROGEN,HCH,ACETONE
Conditions to Avoid Polymerization:MOISTURE CONTAM
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY OR LANDFILL NEUTRALIZED MATL IAW LOCAL,
STATE, FED REG.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SHER-WOOD DYE STAIN DARK RED, S61R5
CAGE:54626
CAGE:54626
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL; (METHYL ALCOHOL) (SARA III) VP: 92
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 91%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, ISOBUTYL ESTER; (ISOBUTYL ACETATE) (MFR CAS #
110-96-6) VP: 12.5
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 9%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 6.56 LBS/GAL
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:INTERNALLY.KEEP OUT OF THE REACH OF CHILDREN.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:FROM PROD, UNDERLYING PAINT, OR THE ABRASIVE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ALCOHOLS & ACETATES CAN BE ABSORBED
THRU SKIN. TO MINIMIZE EXPOS, FOLLOW RECOM FOR PROPER USE, VENT &
PERSONAL PROT EQUIP. ACUTE:IRRIT OF EYES, SKIN & RESP SYS. MAY
CAUSE NERVOUS SYS DEPRESS. EXTREMEOVEREXPOS MAY RSLT IN UNCON &
POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORDINATION ARE INDICATIONS
OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EXCESSIVE EXPOS TO VAP/SPRAY MISTS.
REDNESS & ITCHING/BURNING SENSATION MAY INDICATE EYE/EXCESSIVE SKIN
EXPOS. CHRONIC:PRLNG OVEREXP TO SOLVS MAY CAUSE ADVERSE EFTS TO
LIVER, URINARY & REPRO SYS. REPORTS HAVE ASSOC RPTD/PRLNG
OVEREXPOS TO SOLVENTS W/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOS. RESTORE BRTHG. KEEP WARM & QUIET.
SKIN:WASH AREA THORO W/SOAP & WATER. REMOVE CONTAMD CLTHG & LAUNDER
BEFORE REUSE. EYES:FLUSH W/LG AMT WATER FOR @ LEAST 15 MIN. GET MED
ATTN. INGEST:NEVER GIVE ANYTHING BY MOUTH TOUNCON PERSON. GIVE
SEVERAL GLASSES WATER. IF VOMIT IS NOT SPONTANEOUS, INDUCE BY
GENTLY TOUCHING BACK OF THROAT W/FINGER. KEEP AIRWAY CLEAR. SEEK
MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:50.0F,10.0C
Lower Limits:1.2%
Upper Limits:36.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFTIVE. IF WATER USED, FOG NOZZ PREF. WATER
MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICATN TO HOT SURF (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE FLAM. KEEP AWAY FROM
HEAT, SPARKS & OPEN FLAME. CONSULT NFPA CODE. USE APPRVD BONDING &
GROUNDING PROC. KEEP CNTNR CLSD WHEN NOT (SUPDAT)
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS CAN BE HARMFUL. USE ONLY WITH ADEQUATE
VENTILATION. AVOID BREATHING VAPOR & SPRAY MIST. AVOID CONTACT WITH
SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED < APPLIC
LIM BY VENT, WEAR PROPERLY FITTED, NIOSH/MSHA APPRVD ORG
VAP/PARTICULATE RESP. WHEN SANDING/ABRADING DRIED FILM, WEAR
NIOSH/MSHA APPRVD DUST/MIST RESP F OR DUST WHICH MAY BE GENERATED
(ING 5)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATL IS <
APPLIC EXPOS LIM. REFER TO OSHA STDS 1910.94, 107, 1910.108.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOS
TO EXTREME HEAT. EXPLO HAZ:REQ SPECIAL PREC. DURING EMER CNDTNS
OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMMED
APPARENT. HNDLG/STOR PREC:IN USE. TRANSFER ONLY TO APPRVD CNTNRS
W/COMPLETE & APPROP LABELING. DO NOT TAKE (ING 4)
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:>148F,>64C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.79-0.82
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:98-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERM APPLIC
EPA HAZ WASTE NUMBER. INCIN IN APPRVD FACILITY. DO NOT INCIN CLSD
CNTNR. DISPOSE OF I/A/W FED, STATE & LOCAL REGS
REGARDINGPOLLUTION.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:IMX CA 19-9 CALIBRATOR B, 5B09B
Resp. Party Other MSDS Num.:L
CAGE:33110
CAGE:33110
============= Composition/Information on Ingredients =============
Ingred Name:TROMETHAMINE HYDROCHLORIDE. LD50 (ORAL, RAT): 1780-5900
MG/KG
CAS:1185-53-1
= Wt:1.3
Ingred Name:SODIUM AZIDE
CAS:26628-22-8
RTECS #:VY8050000
= Wt:.1
ACGIH STEL:C0.29 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:96.5
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS SECTION
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: FOR BLOODBORNE PATHOGENS:
NON-INTACT SKIN, MUCOUS MEMBRANES, PARENTERAL CONTACT. PRIMARY
IRRITANT EFFECT: SKIN: NO IRRITANT EFFECT. EYE: NO IRRITANT EFFECT.
SENSITIZATION: NO SENSITIZING E FFECTS KNOWN. TARGET ORGANS/SYSTEM:
NOT APPLICABLE. SPECIAL HAZARDS: THIS PRODUCT CONTAINS HUMAN
SOURCED AND/OR POTENTIALLY INFECTIOUS COMPONENTS.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE EXPECTED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM SOURCE OF EXPOSURE. IF SIGNS OF TOXICITY
OCCUR, SEEK MEDICAL ATTENTION. PROVIDE SYMPTOMATIC/SUPPORTIVE CARE
AS NEEDED. SKIN: REMOVE FROM SOURCE OF EXPOSURE. WASH AFFECTED AREA
WITH SOAP AND WATER. SEEK MEDICAL ATTENTION AND APPROPRIATE
FOLLOW-UP. EYE: FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. SEEK MEDICAL ATTENTION AND APPROPRIATE FOLLOW-UP.
INGESTION: RINSE M OUTH WITH WATER. SEEK MEDICAL ATTENTION AND
APPROPRIATE FOLLOW-UP. INFORMATION FOR DOCTOR: SEE SECTION 3:
SPECIAL HAZARDS. THE FOLLOWING SYMPTOMS MAY OCCUR: NONE EXPECTED.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, EXTINGUISHING POWDER OR WATER SPRAY. FIGHT
LARGER FIRES WITH WATER SPRAY OR ALCOHOL RESISTANT FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODUCT DOES NOT PRESENT AN EXPLOSION
HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:SAFE WORK PRACTICES: NIOSH APPRVD RESP PROT
SHOULD BE WORN IF EXPOS LIMITS CAN BE EXCEEDED. HANDLE AS
POTENTIALLY INFECTIOUS. MEASURES FOR ENVIRONMNETAL PROTECTION:
PREVENT LIQ & VAP FROM ENTERING INT O SEWAGE SYSTEM, WORKPITS &
CELLARS. CONTAIN SPILL W/APPROP ABSORB MATL. MEASURES FOR
CLEANING/COLLECTING: ABSORB W/LIQUID-BUILDING MATL (SAND,
DIATOMITE, ACID BINDERS, UNIVERSAL(SUPDAT)
======================Handling and Storage ======================
Handling and Storage Precautions:INFO FOR SAFE HANDLING: HANDLE AS
POTENTIALLY INFECTIOUS MATL. INFO ABOUT PROT AGAINST EXPLOSIONS &
FIRES: NO SPECIAL MEASURES REQUIRED. STORAGE REQUIREMENTS TO BE MET
BY STOREROOMS & RECEPTACLES: NO SPECIAL REQUIREMENTS.
Other Precautions:INFO ABOUT STORAGE IN ONE COMMON STORAGE FACILITY: DO
NOT STORE TOGETHER W/ACIDS. FURTHER INFOMATION ABOUT STORAGE
CONDITIONS: PROTECT FROM HEAT & DIRECT SUNLIGHT: STORAGE CLASS: NOT
APPLICABLE. CLASS ACCORDING TO REGULATION ON FLAMMABLE LIQUIDS:
NOT APPLICABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE APPROPRIATE NIOSH APPROVED RESPIRATORY
PROTECTION SHOULD BE USED IF AIRBORNE CHEMICAL CONCENTRATION
EXCEEDS THE EXPOSURE LIMITS (IF ANY) LISTED IN SECTION 8.
Ventilation:NOT NECESSARY IF ROOM IS WELL-VENTILATED.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR LABORATORY COAT OR PROTECTIVE GARB WHEN
WORKING WITH MATERIAL.
Work Hygienic Practices:KEEP AWAY FROM FOODSTUFFS, BEVERAGES AND FEED.
WASH HANDS BEFORE BREAKS AND AT THE END OF WORK.
Supplemental Safety and Health
SPILL PROC: BINDERS, SAWDUST). WEAR PROTECTIVE EQUIPMENT. CLEAN AREA
WITH A DETERGENT. APPLY A SUITABLE DISINFECTANT. ADDITIONAL
INFORMATION: NO DANGEROUS SUBSTANCES ARE RELEASED.
================== Physical/Chemical Properties ==================
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:NOT DETERMINED
Vapor Pres:23.0 @ 20C
Vapor Density:1G/CM3@20C
pH:7.0 @ 20C
Solubility in Water:FULLY MISCIBLE
Appearance and Odor:COLORLESS LIQUID; ODORLESS.
================= Stability and Reactivity Data =================
REACTIONS WITH HEAVY METALS MAY FORM EXPLOSIVE SUBSTANCES. CONTACT WITH
ACIDS MAY RELEASE TOXIC GAS (I.E. HYDROGEN AZIDE HN*3).
Hazardous Decomposition Products:NO DANGEROUS DECOMPOSITION PRODUCTS
KNOWN.
=================== Toxicological Information===================
Toxicological Information:ACUTE TOXICITY: LD/LC50 VALUES FOR HAZARDOUS
INGREDIENTS PER OSHA CRITERIA: COMPONENTS (100% PURE SUBSTANCE/S)
1185-53-1 TROMETHAMINE HYDROCHLORIDE: ORAL: LD50: <1000 MG/KG
(RABBIT). APPROXIMATE LETHA L DOSE (LDL0). LD50: 1780-5900 MG/KG
(RAT).
===================== Ecological Information =====================
Ecological:GENERAL NOTES: DO NOT ALLOW UNDILUTED PRODUCT OR LARGE
QUANTITIES OF IT TO REACH GROUND WATER, WATER COURSE OR SEWAGE
SYSTEM.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT RECOMMENDATION: & UNCLEANED PACKAGINGS:
RECOMMENDATION: DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS. RECOMMENDED CLEANSING AGENT: WATER, IF NECESSARY WITH
CLEANSING AGENTS.
=================== MSDS Transport Information ===================
Transport Information:DOT REGULATIONS: HAZARD CLASS: REMARKS: NOT
REGULATED FOR TRANSPORTATION. LAND TRANSPORT ADR/RID (CROSS-BORDER)
ADR/RID CLASS: REMARKS: NOT REGULATED FOR TRANSPORTATION. IMDG
CLASS: MARINE POLLUTANT: NO. REMARKS: NOT REGULATED FOR
TRANSPORTATION. AIR TRANSPORT ICAO-TI AND IATA-DGR: ICAO/IATA
CLASS: REMARKS: NOT REGULATED FOR TRANSPORTATION.
===================== Regulatory Information =====================
SARA Title III Information:NATIONAL AND INTERNATIONAL REGULATIONS. SARA
(SUPERFUND AMENDMENTS & REAUTHORIZATION ACT OF 1986 - USA): SECTION
302/304 (40CRF355.30/40CFR355.40): 26628-22-8 SODIUM AZIDE. SECTION
313 (40CFR372.65):26628-22-8 SODIUM AZIDE.
Federal Regulatory Information:MARKINGS ACCORDING TO EUROPEAN
GUIDELINES: THE PRODUCT HAS BEEN CLASSIFIED & LABELLED I/A/
W/APPLICABLE EUROPEAN COMMUNITY (EC) DIRECTIVES. CODE LETTER &
HAZARD DESIGNATION OF PRODUCT: XN. HAZARD-DETE RMINING SUBSTANCE/S
OF LABELLING: SODIUM AZIDE. RISK PHRASES: 22 HARMFUL IF INGESTED.
32 CONTACT W/ACIDS LIBERATES VERY TOXIC GAS. SAFETY PHRASES: 2 KEEP
OUT OF REACH OF CHILDREN. 13 KEEP AWAY FROM FO OD, DRINK, & ANIMAL
FEEDINGSTUFFS. 36 WEAR SUITABLE PROTECTIVE CLOTHING. 46 IF
INGESTED. SEEK MEDICA L ADVICE IMMEDIATELY & SHOW THIS
CONTAINER/LABEL. CLASSIFICATION/WARNING ACCORDING TO WORKSAFE
AUSTRALIA: HAZARDOUS.
State Regulatory Information:CALIFORNIA PROPOSITION 65 (USA): CHEMICALS
KNOWN TO CAUSE CANCER: THE PRODUCT DOES NOT CONTAIN LISTED
SUBSTANCES. CHEMICALS KNOWN TO CAUSE REPRODUCTIVE TOXICITY: THE
PRODUCT DOES NOT CONTAIN LISTED SU BSTANCES.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HEPTANE, 03008 4
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXANE, METHYL-; (METHYLCYCLOHEXANE)
CAS:108-87-2
RTECS #:GV6125000
Fraction by Wt: 0.2%
OSHA PEL:500 PPM
ACGIH TLV:400 PPM
Ingred Name:HEPTANE; (HEPTANE (N-))
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 99.4%
OSHA PEL:500 PPM
ACGIH TLV:400 PPM/500STEL
Ingred Name:ISOOCTANE (VAN)
CAS:26635-64-3
RTECS #:NS7240000
Fraction by Wt: 0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIMETHYLCYCLOPENTANES
CAS:28729-52-4
Fraction by Wt: 0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE MILD IRRIT.
SKIN: MAY CAUSE MOD IRRIT. PRLNG &/RPTD CONT MAY CAUSE DEFAT OF
SKIN & DERM. INGEST: ASPIR HAZ. CAUSES GI IRRIT W/NAUS, VOMIT &
DIARR. ASPIR OF MATL INTO LUNGS MAY C AUSE CHEM PNEUMIT, WHICH CAN
BE FATAL. INHAL: INHAL OF HIGH CONCS MAY CAUSE CNS DEPRESS
CHARACTERIZED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: BY HDCH, DIZZ, UNCON & COMA. MAY
CAUSE RESP TRACT IRRIT. CHRONIC: PROLONGED OR REPEATED SKIN CONTACT
MAY CAUSE DERMATITIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID. SKIN:FLUSH W/PLENTY OF
SOAP & WATER FOR AT LEAST 15 MIN WHILE REMOVING CONTAM CLTHG &
SHOES. GET MED AI D IF IRRIT DEVELOPS/PERSISTS. WASH CLTHG BEFORE
REUSE. INGEST:DO NOT INDUCE VOMIT. IF VICTIM IS CONSCIOUS & ALERT,
GIVE 2-4 CUPFULS OF MILK/WATER. POSS ASPIR HAZ. GET MED AID IMMED.
INHAL: (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:20.0F,-6.7C
Lower Limits:1.1%
Extinguishing Media:DO NOT USE WATER DIRECTLY ON FIRE. USE FOAM, DRY
CHEMICAL, OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:VAPORS CAN TRAVEL TO A SOURCE OF IGNITION
AND FLASH BACK. EXTREMELY FLAMMABLE. MATERIAL WILL READILY IGNITE
AT ROOM TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL W/INERT MATL (E.G., DRY
SAND/EARTH), THEN PLACE INTO CHEM WASTE CONTR. WEAR NIOSH APPRVD
SCBA & APPROP PERS PROT. SCOOP UP W/NON-SPK TOOL, THEN PLACE INTO
SUITABLE CONTR FOR DISP. REMOVE ALL SOURCES OF IGNITION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL VENTILATED AREA. USE
SPARK-PROOF TOOLS AND EXPLOSION PROOF EQUIPMENT. AVOID CONTACT WITH
EYES, SKIN, AND CLOTHING.
Other Precautions:EMPTY CONTRS RETAIN PROD RESIDUE (LIQ &/VAP), & CAN
BE DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE SUCH CONTRS TO HEAT, SPKS/OPEN FLAMES. AVOID INGEST &
INHAL. KEEP AWA Y FROM SOURCES OF IGNIT. STORE (SUP DAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL/LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . WEAR APRON & PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:GET MED AID IMMED. REMOVE FROM EXPOS TO FRESH AIR IMMED.
IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. NOTES
TO MD:TREAT SYMPTOMATICALLY & SUPPORTIVELY. NO SPECIFIC ANTI DOTE
EXISTS. OTHER PREC:IN TIGHTLY CLSDCONTR. STORE IN COOL, DRY,
WELL-VENTD AREA AWAY FROM INCOMPATIBLE SUBSTANCES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:200F,93C
Melt/Freeze Pt:M.P/F.P Text:-131F,-91C
Vapor Pres:40.0
Vapor Density:3.5
Spec Gravity:0.696 (H*2O=1)
Evaporation Rate & Reference:2.8 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID, MILD GASOLINE-LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:INCOMPATIBLE MATERIALS, IGNITION SOURCES.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:OX-GARD
CAGE:GO193
CAGE:62933
CAGE:GO193
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOSURE TO LIQUIDS, VAPORS, & FUME
SHOULD BE MINIMIZED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: CAUSES REDNESS & IRRITATION W/PROLONGED
USE.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR AT LEAST 15 MINS. SKIN: WASH
THOROUGHLY W/SOAP & WATER FOR 10 MINS. INGESTION: DON'T INDUCE
VOMITING. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:165
Extinguishing Media:DRY CHEMICAL OR CO2. DON'T USE WATER
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:MATERIAL GENERATES HYDROGEN GAS WHEN
EXPOSED TO MOISTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SMALL SPILL W/CLAY, DIATOMECEOUS EARTH
OR OTHER INERT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS SEALED & STORED IN
COOL PLACE. DON'T STORE NEAR HEAT OR OPEN FLAMES, OXIDIZING AGENTS
OR MOISTURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IN NORMAL USE.
Ventilation:LOCAL EXHAUST: NORMAL ROOM VENTILATION. MECHANICAL
(GENERAL): ADEQUATE VENTILATION NEEDED AT ALL TIMES
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHES BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:480-490F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:GRAY GREASE W/SWEET ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ZINC OXIDE, SULFUR OXIDE, LIQUID CHLORINE, CONCENTRATED OXYGEN CALCIUM
Stability Condition to Avoid:HEAT, OPEN FLAME
Hazardous Decomposition Products:MAY GIVE OFF ACROLEING, VARIOUS
ALDEHYDES, KETONES, CO2, SMOKE, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LOV-500 HIGH GLOSS VINYL COLOR
CAGE:29431
CAGE:29431
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC C8-C10 (AROMATIC
100) *91-4*
CAS:64742-95-6
Fraction by Wt: 8.6-9%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:CYCLOHEXANONE, KETOHEXAMETHYLENE
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 12.5-13%
Other REC Limits:100PPM (SKIN) STEL
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYRIC ACID LACTONE, TETRAHYDRO-2-FURANONE, BLO
BUTYRYLACTONE
CAS:96-48-0
RTECS #:LU3500000
Fraction by Wt: 8-8.5%
ACGIH TLV:10 PPM
Ingred Name:LEAD CHROMATE, CR, CHROME GREEN, CHROME YELLOW (SUSPECTED
HUMAN CARCINOGEN BY ACGIH, IARC & NTP)
CAS:7758-97-6
RTECS #:GB2975000
Fraction by Wt: 9-14.7%
OSHA PEL:0.5 MG/CUM PB
ACGIH TLV:0.05 MG/CUM CR (A2)
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 2.5-6.4%
OSHA PEL:1 MG/CUM
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYES: IRRITATION & DAMAGE. SKIN:
IRRITATION, DAMAGE, DRYNESS & REDNESS. INHALATION: RESPIRATORY
TRACT IRRITATION, DIZZINESS, HEADACHE, NAUSEA, VOMITING, DAMAGE TO
KIDNEYS/LIVER/CENTRAL NERVOUS SYSTEM & LOSS OF CONSCIOUSNESS.
Explanation of Carcinogenicity:LEAD & CHROMATES ARE SUSPECTED HUMAN
CARCINOGENS BY ACGIH.
Effects of Overexposure:EYES: IRRITATION & DAMGE. SKIN: IRRITATION,
DAMAGE, DRYNESS & REDNESS. INHALATION: RESPIRATORY TRACT
IRRITATION, DIZZINESS, HEADACHE, NAUSEA, VOMITING, DAMAGE TO
KIDNEYS/LIVER/CENTRAL NERVOUS SYSTEM & LOSS OF CONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. IF UNCONSCIOUS, APPLY CPR IF
NEEDED. INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION
IN ALL CASE S.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:111F
Lower Limits:1%
Upper Limits:6.9%
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO2 & DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. USE
WATER FOG TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPOSIVE MIXTURES W/AIR.
EMPTY CONTAINERS COULD IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. ABSORB W/SAND.
WEAR PROTECTIVE CLOTHING. PUMP INTO SALVAGE TANK. KEEP MATERIAL OUT
OF SEWERS, STREAMS ETC.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. OVERHEATING MAY
CAUSE CONTAINER TO RUPTURE. AVOID CONTACT W/EYES/SKIN & INHALATION.
DON'T TAKE INTERNALLY.
Other Precautions:CHECK ALL CONTAINERS FOR LEAKS. KEEP CONTAINERS COOL,
DRY & AWAY FROM IGNITION SOURCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE MSHA/NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:LOCAL & MECHANICAL EXHAUST TO KEEP <TLV.
Other Protective Equipment:EYEWASH STATION, IMPERVIOUS CLOTHING & BOOTS
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING. WASH THOROUGHLY
AFTER HANDLING.
Supplemental Safety and Health
BOILING RANGE: 308-415F.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE SUPP.
Vapor Pres:1.28-1.31
Vapor Density:3.76-3.79
Spec Gravity:1.222-1.312
Evaporation Rate & Reference:(BU AC = 1): SLOWER
Solubility in Water:<0.1%
Appearance and Odor:COLORED PASTE W/MILD ODOR
Percent Volatiles by Volume: 58-60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALIES & MINERAL ACIDS
Stability Condition to Avoid:EXTREME COLD/HEAT, ELEVATED TEMPERATURES,
OTHER IGNITION SOURCES & FREEZING
Hazardous Decomposition Products:ACRID SMOKE, CO, CO2, VARIOUS
HYDROCARBONS & NOXIOUS GASES
Conditions to Avoid Polymerization:DROPPING OR PUNCTURE OF CONTAINERS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:COMPOSITION B, TYPE 1, GRADE A
CAGE:1D893
CAGE:1D893
============= Composition/Information on Ingredients =============
Ingred Name:ING 12: AVOID SAND, GLASS, GRIT, & METAL FRAGMENTS WHICH
MAY SENSITIZE MATL TO IMPACT &/OR FRICTION. WET WITH (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: WATER TO DESENSITIZE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:UP ON CONTINUING BASIS. CAUTION: EXPLO MUST BE
TESTED FOR COMPATIBILITY W/ANY MATLS WHICH THEY CONT. (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:KEEP CNTNR CLSD.EXTREME CARE SHOULD BE EXERCISED
DURING MAINTENANCE OF EXPLO CONTAMD EQUIP. DECONTAM PROC(ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: INCL WASHING/STEAMING. CHEM DECONTAM,& THERM
DECONTAM. DECONTAM SHOULD BE PERFORMED PRIOR TO WELDING, (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: CUTTING/GRINDING METAL PARTS. PENETRATING OIL
SHOULD BE USED LIBERALLY ON NUTS, BOLTS, & ALL THREADED (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: CONNECTIONS TO AID IN DESENSITIZING HIDDEN EXPLO
PRIOR TO DISASSEMBLY. MILITARY HIGH EXPLO. HAS BEEN (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:ASSIGNED THE UNITED NATIONS ORGANIZATION
CLASSIFICATION OF 1, DIVISION 1 (MASS DETONATING) BASED ON DEPT
(ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: OF DEFENSE EXPLOSIVE HAZARD CLASSIFICATION
PROCEDURES, ARMY TECHNICAL BULLETIN 700-2.
RTECS #:9999999ZZ
Ingred Name:S-TRIAZINE, HEXAHYDRO-1,3,5-TRINITRO-;
(CYCLOTRIMETHYLENETRINITRAMINE)LD50 (ORAL,RAT): 100 MG/KG. MP:401F,
(ING 2)
CAS:121-82-4
RTECS #:XY9450000
Fraction by Wt: SEE ING
OSHA PEL:1.5 MG/M3, S
ACGIH TLV:1.5 MG/M3, S
Ingred Name:ING 1: 205C (DECOMPOSITION).
RTECS #:9999999ZZ
Ingred Name:TRINITROTOLUENE. PERCENTAGE (WT): 37.2-41.8. MP: 174F,79C.
CAS:118-96-7
RTECS #:XU0175000
Fraction by Wt: SEE ING
OSHA PEL:S, 1.5 MG/M3
ACGIH TLV:S, 0.5 MG/M3; 9293
Ingred Name:WAX; (SYNTHETIC WAX)
Fraction by Wt: .7-1.3%
Ingred Name:FIRE FIGHT PROC:SUFF INITIATION SOURCE. NO ATTEMPT TO FIGHT
FIRES SHOULD BE MADE EXCEPT FOR MANUAL ACTIVATION OF (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:INSTALLED FIRE EXTING EQUIP.PERS SHOULD LEAVE
BUILDING IMMED USING AS MUCH PROT COVER AS POSS & ACTIVATING (ING
7)
RTECS #:9999999ZZ
Ingred Name:ING 6: DELUGE SYSTEMS AND FIRE ALARM EQUIPMENT WHILE
ESCAPING.
RTECS #:9999999ZZ
Ingred Name:EXPLO HAZ: OF STRUCTURES, EQUIP,& CNTNRS WHICH HAVE BEEN
EXPOS TO EXPLO.PROPERTY WHICH MAY BE CONTAMD BY EXPLO (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: MUST NOT BE SUBJECTED TO HEAT, SPARKS/FLAME.
DETONATION CAN OCCUR.THERM DECONTAM UNDER CNTRLD CNDTNS IS (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:RECOM METH FOR COMPLETE DECONTAM.THERM DECONTAM MUST
BE PRECEDED BY WASHING/STEAMING & CHEM NEUTRALIZATION(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: OF DISOLUTION. CONTAMINATED PROPERTY MUST NOT BE
BURIED.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: METAL-TO-METAL CONT, IMPACT W/SHARP OBJECTS,
FRICTION/OTHER SITUATIONS WHICH MAY INITIATE EXPLO. (ING 13)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: CAN CAUSE ALLERGIC SKIN
REACTION. CAN CAUSE EYE IRRITATION. TNT CAN DISCOLOR SKIN AND HAIR
ON CONTACT. INHALATION & INGESTION: CHRONIC EXPOSURE TO RDX DUST
HAS BEEN REPORTED TO CAUSE CONVUL SIONS OR UNCONSCIOUSNESS. CHRONIC
LOCALAND SYSTEMIC EFFECTS ARE NOT FULLY KNOWN. INHALATION AND (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: INGESTION CAN RESULT IN SYSTEMIC
POISONING, USUALLY AFFECTING BONE MARROW (BLOOD-CELL-PRODUCING
SYSTEM) AND LIVER. INGESTING TNT CAUSES NAUSEA, VOMITING, ANOREXIA
AND CAN CAUSE LIVER AND BLO OD DAMAGE, AND APLASTIC ANEMIA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LRG AMTS OF WATER FOR AT LST 15 MINS. REMOVE
CONT LENSES. GET MED ATTN. SKIN:WASH W/SOAP & WARM RUNNING WATER.
CLEAN CLTHG THORO & DISP OF CONTAMD SHOES. GET MED ATTN FOR
RASH/IRRIT. INHA L: REMOVE TO FRESH AIR, TREAT ANY IRRITSYMP.IF
BRTHG IS DFCLT, GIVE OXYGEN. GET MED ATTN. INGEST: IF CONSCIOUS
INDUCE VOMIT IMMED BY GIVING 1-2 GLASSES OF WATER & TOUCHING BACK
OF THROAT/BY (SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRINKLER/DELUGE SYSTEM RECOMMENDED.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT
EQUIP.BURNING EXPLO MAY ACCELERATE TO DETONATION AT ANY TIME WHEN
SUBJECTED TO CONFINEMENT, SHOCK/OTHER (ING 5)
Unusual Fire/Explosion Hazard:MUST NOT BE CONFINED IF BURNING.CAN CAUSE
DEFLAGRATION/TRANSITION TO DETONATION W/EXTREMELY VIOLENT RSLTS.MAY
BE RETAINED IN FISSURES, CRACKS,& CREVICES (ING 8)
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP SPILLS IMMED USING SOFT BRISTLE BRUSH
& CONDUCTIVE RUB PAN/RUB SHOVEL.USE CONDUCTIVE CNTNRS & GROUND ALL
CNTNRS BEFORE TRANSFERRING EXPLO BETWEEN CNTNRS. TREAT LIKE FLAM
SOLV W/REGARD TO ELEC TROSTATIC DISCHARGE. AVOID PINCHING MATL,
(ING 12)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN APPROVED EXPLOSIVES MAGAZINES
IN ACCORDANCE WITH AMCR 385-100.
Other Precautions:STOR & HNDLG MUST BE CARRIED OUT I/A/W APPROP SAFETY
AGENCY REGS CONCERNING QUANTITY DISTANCE, BARRICADING,PERS EXPOS &
MATL HNDLG EQUIP. RECYCLE/DISP OF USED CNTNRS I/A/W APPROP SAFETY
AGENCY REGS.DU ST GEN BY HNDLG MUST BE CLEANED (ING 15)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR DUSTS AND
PARTICULATES IF EXPOSED TO DUSTING.
Ventilation:LOCAL EXHAUST: HOODS FOR DUSTY OPERATIONS ARE REQUIRED.
MECHANICAL: GENERAL. SPECIAL: DUST COLLECTION EQUIP REQUIRED.
Other Protective Equipment:CAPS & COVERALLS FOR FULL BODY PROT. COTTON
UNDERWEAR, SOCKS,& CONDUCTIVE SHOES TO AVOID HUMAN STATIC
DISCHARGE.(SUPDAT)
Work Hygienic Practices:AS PREC,HNDL ONLY IN WELL-VENT AREAS, CHANGE
CLTHS DAILY, BATHE AT END OF WORK PERIOD,& WASH HANDS THORO AFTER
HANDLING.
Supplemental Safety and Health
MATLS TO AVOID: SENSIT SUCH AS GLASS, SAND,& METAL FRAGMENTS. FIRST AID
PROC: GIVING SYRUP OF IPECAC.NEVER GIVE ANYTHING BY MOUTH TO AN
UNCON PERSON.GET MED ATTN.WASTE DISP METH: RESISTANT CLTHG.DISP
SHOULD COMPLY W/ALL APPLIC FED, ST,& LOC REGS. OTHER PROT EQUIP:
SAFETY SHOWER, EYE BATH, AND WASHING FACILITIES.
================== Physical/Chemical Properties ==================
HCC:E1
Melt/Freeze Pt:M.P/F.P Text:SEE INGS
Vapor Pres:.1 @ 100C
Spec Gravity:1.7 (H*2O=1)
Solubility in Water:INSOLUBLE @ 20C
Appearance and Odor:LIGHT BROWN FLAKED SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES, ALKOXIDES, AMMONIA, POTASSIUM HYDROXIDE, SODIUM CARBONATE,
SODIUM SULFIDE, POTASSIUM METHYLATE, PHYS (SUPDAT)
Stability Condition to Avoid:SHOCK, HEAT, ELECTROSTATIC DISCHARGE,
IMPACT, IMPINGEMENT AND FRICTION.
Hazardous Decomposition Products:TOXIC OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DESTROY BY OPEN BURNING,BY BURNING IN AN APPRVD
INCIN/BY CHEM TREATMENT W/CAUSTICS. SITE SHOULD BE LOCATED TO
PROVIDE ADEQ QUANTITY-DISTANCE PROT. EXPLO SHOULD NOT BE BURNED IN
CNTNRS, SHOULD BE IGNIT ED REMOTELY. PERS SHOULD WEAR FLAME (SUPP
DATA)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DR POWDERED RESIN
CAGE:LO083
CAGE:LO083
CAGE:85063
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENT.
===================== Hazards Identification =====================
Effects of Overexposure:SOME PEOPLE DEVELOP DERMATITIS UPON PRLNG
CONTCT.F/INGEST-INDUCE VOMIT & DRINK MILK.EYES-FLUSH W/WTR
===================== Fire Fighting Measures =====================
Flash Point:UNK
Extinguishing Media:WATER
Fire Fighting Procedures:AVOID FUMES
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPEC PRECAUTIONS BUT ADVISABLE BUT
TO AVOID EXCESSIVE SKIN CONTACT-MAY CAUSE DERMATITIS.
Other Precautions:DO NOT INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USUAL VENTILATION
Ventilation:USUAL LOC EXHAUST-SATISFACTORY
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Density:UNK
Spec Gravity:0.650
Appearance and Odor:POWDER-SLIGHT FORMALDEHYDE ODOR
Percent Volatiles by Volume:3-5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE IN REGULAR USE-IN FIRE,AVOID ACRID FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN GENERAL WASTE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:195A200, SEVEN STAR RUST PREVENTATIVE QUICK (SUPDAT)
CAGE:0D4B9
CAGE:0D4B9
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 27.7%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:NEPHELINE SYENITE
CAS:37244-96-5
Fraction by Wt: 45.3%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 22%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 16.4%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 30.1%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1.9%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:COPPER, (PHTHALOCYANINATO(2-))-; (PHTHALO BLUE). ACGIH
TLV:10 MG/M3; 5 MG/M3 (MFR).
CAS:147-14-8
Fraction by Wt: 1.3%
OSHA PEL:N/K
ACGIH TLV:SEE INGREDIENT
Ingred Name:PERM-YELLOW; (AZO YELLOW)
CAS:6358-31-2
Fraction by Wt: 4.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-NAPHTHOL, 1-((2,4-DINITROPHENYL)AZO)-; (DINITRANILINE
ORANGE)
CAS:3468-63-1
RTECS #:QL3854000
Fraction by Wt: 2.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:C.I. PIGMENT GREEN 7; (PHTHALO GREEN)
CAS:1328-53-6
RTECS #:GE4300000
Fraction by Wt: 2.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-NAPHTHALENOL, 1-((4-METHYL-2-NITROPHENYL)AZO)-; (AZO RED)
CAS:2425-85-6
RTECS #:QK4247000
Fraction by Wt: 5.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYL ALCOHOL; (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 0.5%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM MAY OCCUR ON OVEREXPOSURE. MAY ALSO CAUSE
NERVOUS SYSTEM DEPRESSION. HEADACHE, DIZZINESS, NAUSEA AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCES SIVE EXPOSURE TO VAPORS OR
SPRAY MISTS.CHRONIC:REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OCCUP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CARBON BLACK:IARC MONOGRAPHS, VOL 65, PG
24-27, 1995:GROUP 2B.
Effects of Overexposure:HLTH HAZ:OVEREXPOSURE TO SOLVENTS W/PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
INHALING CONTENTS CAN BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE.
RESTORE BREATHING. KEEP WARM & QUIET. SKIN:WASH AFFECTED AREA
THOROUGHLY W/SOAP & WATER. EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:0.9%
Extinguishing Media:FOR DRY SOLIDS, USE WATER, FOAM, CO*2, DRY
CHEMICALS.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILD-UP & POSS
AUTO-IGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAME. HEAT MAY CAUSE
PRESS BUILD-UP IN CLSD CNTNRS. WATER MAY BE USED TO COOL.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE & REMOVE
W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT & OPEN FLAME. USE APPRVD BONDING & GROUNDING PROCS.
TRANSFER ONLY TO APPRVD, PROPERLY MARKED CNTNRS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROPERLY FITTED NIOSH APPROVED ORGANIC
VAPOR/PARTICULATE RESPIRATOR.
Ventilation:LOCAL EXHAUST: PREFERABLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:DRYING INDUSTRIAL ENAMEL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:308F,153C
Vapor Density:HVR/AIR
Spec Gravity:1.32 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:COLORED PIGMENT LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE - CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF I/A/W FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:OCTACOSANE, 261C-9
CAGE:IO526
CAGE:IO526
CAGE:58378
============= Composition/Information on Ingredients =============
Ingred Name:OCTACOSANE
CAS:630-02-4
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. MAY CAUSE EYE AND SKIN IRRITATION.
TO THE BEST OF MFR KNOWLEDGE, THE CHEMICAL, PHYSICAL, AND
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. SKIN: FLUSH W/WATER. WASH CONTAMINATED CLOTHING BEFORE
REUSE. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE ARTF RESP.
IF B REATHING IS DFCLT, GIVE OXYGEN. INGEST:WASH OUT MOUTH W/WATER
PROVIDED PERSON IS CONSCIOUS. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE
FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS
WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND WASH SPILL
SITE AFTER MATERIAL PICKUPIS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALATION. DO NOT GET IN EYES,
ON SKIN/CLTHG. KEEP TIGHTLY CLOSED. STORE IN A COOL DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:532F,278C
Melt/Freeze Pt:M.P/F.P Text:142F,61C
Vapor Pres:<1@20C
Vapor Density:13.6
Appearance and Odor:WHITE POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX MATERIAL WITH A COMBUSTIBLE SOLVENT
AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN AFTERBURNER AND
SCRUBBER. OBSERVE ALL FEDERAL, STATE, AND LOCAL LAWS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DIMETHYL PHOSPHITE, 99% D17845-4
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHONIC ACID, DIMETHYL ESTER (DIMETHYL PHOSPHITE, 99%)
CAS:868-85-9
RTECS #:SZ7710000
Fraction by Wt: 99%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORL,RAT)3050 MG/KG (SEE SUPP DATA)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY BE HARMFUL BY INHALATION OR
INGESTION. VAPOR OR MIST IS IRRITATING TO EYES, MUCOUS MEMBRANES
AND UPPER RESPIRATORY TRACT. CAUSES SKIN IRRITATION.
Effects of Overexposure:NAUSEA, HEADACHE AND VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/COPIOUS AMTS OF WATER FOR AT LEAST
15 MINUTES. SKIN:IMMEDIATELY WASH W/SOAP & COPIOUS AMTS OF WATER.
WASH CONTAMINATED CLOTHING BEFORE REUSE. INHAL:REMOVE TO FRESH AIR.
SUPPOR T BREATHING (GIVE O*2/ARTF RESP), CALL MD. INGEST:CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:85.0F,29.4C
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER,
ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
FLAMMABLE LIQUID.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO SOURCE OF IGNITION AND
FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. SHUT OFF ALL SOURCES OF IGNIT.
COVER W/DRY LIME OR SODA ASH, PICK UP, KEEP IN CLOSED CNTNR & HOLD
FOR WASTE DISPOSAL. VENT AREA & WASH SPILL SITE AFTER MATL PICKUP
IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP AWAY
FROM HEAT, SPARKS AND OPEN FLAME. KEEP TIGHTLY CLOSED. AVOID
INHALATION. DO NOT GET IN EYES, ON SKIN OR CLOTHING.
Other Precautions:CARCINOGEN. IRRITANT. STENCH. MOISTURE-SENSITIVE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
LD50-LC50 MIX:LD50:(SKN,RBT)2400 MG/KG.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:338F,170C
Spec Gravity:1.2
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES, STRONG ACIDS, ACID CHLORIDES.
Stability Condition to Avoid:MAY DECOMPOSE ON EXPOSURE TO MOIST AIR OR
WATER.
Hazardous Decomposition Products:TOXIC FUMES OF:CO, CO*2. THERMAL
DECOMPOSITION MAY PRODUCE TOXIC FUMES OF PHOSPHORUS OXIDES AND/OR
PHOSPHINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN CHEMICAL INCINERATOR EQUIPPED
W/AFTERBURNER & SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS
MATERIAL IS HIGHLY FLAMMABLE. DISPOSE OF I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ABSORBED ELECTROLYTE BATTERY/DYNASTY
Resp. Party Other MSDS Num.:L 84
CAGE:25244
CAGE:25244
============= Composition/Information on Ingredients =============
Ingred Name:LEAD
CAS:7439-92-1
RTECS #:OF7525000
= Wt:50.
ACGIH TLV:0.15 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD DIOXIDE
CAS:1309-60-0
RTECS #:OG0700000
= Wt:21.
Ingred Name:LEAD SULFATE
CAS:7446-14-2
RTECS #:OG4375000
< Wt:1.
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SULFURIC ACID (ELECTROLYTE)
CAS:7664-93-9
RTECS #:WS5600000
= Wt:22.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
ACGIH STEL:3 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:INHALATION: ACID MIST GENERATED DURING
BATTERY FORMATION MAY CAUSE RESPIRATORY IRRITATION. SKIN: BATTERY
ELECTROLYTE (ACID) MAY CAUSE IRRITATIVE CONTACT DERMATITIS. SKIN
ABSORPTION: SKIN ABSORPTION IS NOT A SIGNIFICANT ROUTE OF ENTRY.
EYE:BATTERY ELECTROLYTE (ACID) WILL IRRITATE THE EYES UPON CONTACT.
INGESTION: HANDS CONTAMINATED BY CONTACT WITH INTERNAL COMPONENTS
OF A BATTERY CAN CAUSE INGESTIO N OF LEAD/LEAD COMPOUNDS. HANDS
SHOULD BE WASHED PRIOR TO EATING, DRINKING OR SMOKING.
Explanation of Carcinogenicity:THE INTERNATIONAL AGENCY FOR RESEARCH ON
CANCER (IARC) HAS CLASSIFIED "STRONG INORGANIC ACID MIST CONTAINING
SULFURIC ACID" AS A CATEGORY 1 CARCINOGEN, A SUBSTANCE THAT IS
CARCINOOGENIC TO HUMANS. THI S CLASSIFICATION DOES NOT APPLY TO
LIQUID FORMS OF SULFURIC ACID OR SULFURIC ACID SOLUTIONS WITHIN A
BATTERY.
Effects of Overexposure:ACUTE EFFECTS OF OVEREXPOSURE TO LEAD ARE GI
(GASTROINTESTINAL) UPSET WHICH MAY BE LOSS OF APPETITE, DIARRHEA
&/OR COMSTIPATION WITH CRAMPING, DIFFICULTY IN SLEEPING, & FATIGUE.
EXPOSURE &/OR CONTACT WITH BATTEY ELECTROLYTE (ACID) MAY LEADTO
IRRITATION OF THE SKIN, CORNEAL DAMAGE TO THE EYES IF NOT WASHED
IMMEDIATELY, & IRRITATION OF THE MUCUOUS MEMBRANES OF THE EYES &
UPPER RESPIRATORY SYSTEM INC LUDING LUNGS. CHRONIC EFFECTS: LEAD &
ITS COMPOUNDS MAY CAUSE CHRONIC ANEMIA, DAMAGE TO THE KIDNEYS &
NERVOUS STSTEM. LEAD MAY ALSO CAUSE REPRODUCTIVE SYSTEM DAMAGE &
CAN AFFECT DEVELOPING
Medical Cond Aggravated by Exposure:INORGANIC LEAD & ITS COMPOUNDS CAN
AGGRAVATE CHRONIC FORMS OF KIDNEY, LIVER, & NEUROLOGIC DISEASES.
CONTACT OF BATTERY ELECTROLYTE (ACID) WITH THE SKIN MAY AGGRAVATE
SKIN DISEASES SUCH AS ECZEMA.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE & CONSULT A PHYSICIAN IF ANY
OF THE ACUTE EFFECTS LISTED DEVELOP. SKIN: WASH THOROUGHLY WITH
SOAP & WATER. IF ELECTROLYTE COMES INTO CONTACT WITH CLOTHING,
REMOVE & DI SCARD. EYE: IMMEDIATELY RINSE WITH COOL RUNNING WATER
FOR AT LEAST 15 MINS. SEEK MEDICAL ATTENTION AFTER RINSING.
INGESTION: LEAD/LEAD COMPOUNDS, CONSULT A PHYSICIAN. ELECTROLYTE:
DO NOT INDUCE VOMITI NG. REFER TO A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:=259.C, 498.2F
HYDROGEN
Autoignition Temp:=580.C, 1076.F
Autoignition Temp Text:H2
Lower Limits:4.1
Upper Limits:74.2
Extinguishing Media:DRY CHEMICAL, FOAM, OR CARBON DIOXIDE (CO2).
Fire Fighting Procedures:USE POSITIVE PRESSURE SELF CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:HYDROGEN & OXYGEN GASES ARE PRODUCTED IN
THE CELLS DURING NORMAL BATTERY OPERATION (HYDROGEN IS FLAMMABLE &
OXYGEN SUPPORTS COMBUSTION). THESE GASES ENTER THE AIR THROUGH THE
VENT CAPS. TO AVOID THE C HANCE OF A FIRE OR EXPLOSION, KEEP SPARKS
& OTHER SOURCES OF IGNITION AWAY FROM THE BATTERY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE COMBUSTIBLE MATERIALS & ALL SOURCES OF
IGNITION. COVER SPILL WITH SODA ASH (SODIUM CARBONATE) OR QUICKLIME
(CALCIUM OXIDE). MIX WELL. MAKE CERTAIN MIXTURE IS NEUTRAL THEN
COLLECT RESIDUE & PLAC E IN A DRUM OR OTHER SUITABLE CONTAINER.
DISPOSE OF AS A HAZARDOUS WASTE. WEAR ACID-RESISTANT BOOTS,
RELEASE UNNEUTRALIZED ACID!
Neutralizing Agent:SODA ASH (SODIUM CARBONATE) OR QUICKLIME (CALCIUM
OXIDE)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE LEAD/ACID BATTERIES WITH
ADEQUATE VENTILATION. ROOM VENTILATION IS REQUIRED FOR BATTERIES
UTILIZED FOR STANDBY POWER GENERATION. NEVER RE-CHARGE BATTERIES IN
AN UNVENTILATED, ENCLOSED SPACE. DO NOT REMOVE VENT CAPS.
Other Precautions:FOLLOW SHIPPING & HANDLING INSTRUCTIONS WHICH ARE
APPLICABLE TO THE BATTERY TYPE. TO AVOID DAMAGE TO TERMINALS AND
SEALS, DO NOT DOUBLE-STACK INDUSTRIAL BATTERIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL HANDLING CONDITIONS.
DURING BATTERY FORMATION (HIGH-RATE CHARGE CONDITION), ACID MIST
CAN BE GENERATED WHICH MAY CAUSE RESPIRATORY IRRITATION. IF
IRRITATION OCCURS, WEAR A R ESPIRATOR SUTIABLE FOR PROTECTION
AGAINST ACID MIST.
Ventilation:NO DATA PROVIDED BY RESPONSIBLE PARTY.
FINISH ARE PREFERRED
SHIELD OVER SAFETY GLASSES
Other Protective Equipment:SAFETY SHOES ARE RECOMMENDED WHEN HANDLING
BATTERIES. ALL FOOTWEAR MUST MEET REQUIREMENTS OF ANSI Z41.1 - REV
1972. WEAR ACID-RESISTANT BOOTS.
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE EATING, DRINKING
OR SMOKING. DISCARD COMTAMINATED CLOTHING.
Supplemental Safety and Health
NO DATA PROVIDED BY RESPONSIBLE PARTY.
================== Physical/Chemical Properties ==================
HCC:Z4
Boiling Pt:B.P. Text:110 C-112 C (ACID)
Melt/Freeze Pt:=327.C, 620.6F
M.P/F.P Text:(LEAD)
Vapor Pres:11.7 (ELECTROLYTE)
Vapor Density:3.4 (ACID)
Spec Gravity:1.3 (ACID)
Evaporation Rate & Reference:NOT DETERMINED
Solubility in Water:COMPLETE (ACID)
Appearance and Odor:ELECTROLYTE-CLEAR TO CLOUDY LIQUID ABSORBED BY
INTERNAL BATTERY COMPONENTS.
Percent Volatiles by Volume:N/D
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
LEAD/LEAD COMPOUNDS: POTASSIUM, CARBIDES, SULFIDES, PEROXIDES,
PHOSPHORUS, SULFUR. BATTERY ELECTROLYTE (ACID): COMBUSTIBLE
MATERIALS, STRONG REDUCING AGENTS, MOST METALS, CARBIDES, ORGANIC
MATERIALS, CHLORATES, NITRATES, PI
Stability Condition to Avoid:SPARKS AND OTHER SOURCES OF IGNITION. HIGH
TEMPERATURES. BATTERY ELECTROLYTE (ACID) WILL REACT WITH WATER TO
PRODUCE HEAT. CAN REACT WITH OXIDIZING OR REDUCING AGENTS.
Hazardous Decomposition Products:LEAD/LEAD COMPOUNDS: OXIDES OF LEAD &
SULFUR. BATTERY ELECTROLYTE (ACID): HYDROGEN, SULFUR DIOXIDE,
SULFUR TRIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY RESPONSIBLE PARTY.
==================== Disposal Considerations ====================
Waste Disposal Methods:ELECTROLYTE:NEUTRALIZE AS FOR A SPILL,COLLECT
RESIDUE & PLACE IN A DRUM OR SUTIABLE CONTAINER.DISPOSE OF AS A
HAZARDOUS WASTE.DO NOT FLUSH LEAD CONTAMINATED ACID TO SEWER.
BATTERIES:SEND TO LEAD SMELT ER FOR RECLAIMATION FOLLOWING
APPLICABLE FEDERAL, STATE & LOCAL REGULATIONS. PRODUCT CAN BE
RECYCLED ALONG WITH AUTOMOTIVE (SLI) LEAD-ACID BATTERIES.
=================== MSDS Transport Information ===================
Transport Information:DOT-BATTERY, WET NON-SPILLABLE, NOT SUBJECT TO
REGULATIONS. IATA-NOT RESTRICTED FOR AIR TRANSPORT-COMPLIES WITH
IATA/ICAO SPECIAL PROVISION A67. IMO-BATTERY, WET NON-SPILLABLE,
NOT SUBJECT TO REGULATI ONS.
===================== Regulatory Information =====================
SARA Title III Information:THE CONTENTS OF THIS PRODUCT ARE TOXIC
CHEMICALS THAT ARE SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION
302 AND 313 OF THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW
ACT OF 1986 (40 CFR 355 AND 372).
Federal Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BARCO BOND MB-100B (PART B)
Kit Part:Y
CAGE:28473
CAGE:28473
============= Composition/Information on Ingredients =============
Ingred Name:SILICA,AMORPHOUS HYDRATED (CAS# 7631-86-9)
RTECS #:VV7322000
Fraction by Wt: 60%
ACGIH TLV:20 MPPCF
Ingred Name:POLYAMINE ADDUCT
Fraction by Wt: 26%
Ingred Name:DIETHYLENE TRIAMINE
CAS:111-40-0
RTECS #:IE1225000
Fraction by Wt: 14%
OSHA PEL:1 PPM
ACGIH TLV:S, 1 PPM; 9192
===================== Hazards Identification =====================
Effects of Overexposure:EYES:BURNS,IRRIT,POSS
ABRASION.SKIN:BURNS,IRRIT,SENSIT.INHAL:SEVERE IRRIT,DIFFICULT (SEE
SUPP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/COPIOUS AMTS OF H*2O FOR @ LEAST 15 MIN,HOLD
EYELIDS OPEN.CALL DR.SKIN:WASH IMMED W/SOAP,H*2O.WASH CONTAM CLTHG
BEFORE REUSE.DESTROY CONTAM SHOES.INHAL:RMV TO FRESH AIR,GIVE O*2
IF BRTHG DIFFICULT.GIVE ARTF RESP IF NOT (SEE OTHR PRECAUT)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:H*2O FOG,ALCOHOL FOAM,DRY CHEMICAL/CO*2.
Fire Fighting Procedures:MATL WILL NOT BURN UNLESS PREHEATED. DO NOT
ENTER CONFINED FIRE AREA WITHOUT NIOSH/MSHA APPRVD SCBA & FULL PROT
EQUIP . COOL FIRE EXPOSED CNTNRS W/WATER.
Unusual Fire/Explosion Hazard:DETA AND PHENOL VAPORS MAY BE RELEASED
UNDER FIRE CONDITIONS AND NITROGEN OXIDES AND NITROGEN CONTAINING
ORGANIC COMPOUNDS MAY BE PRODUCED UPON COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE UP EXCESS MATERIAL + WASH CONTAMINATED
AREA W/SOAP + H*2O.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN VENTILATED AREA AT LESS THAN
100F.WASH HANDS AFTER HANDLING,BEFORE EATING/USING TOILET
FACILITIES.
Other Precautions:EMER,FIRST AID PROC:BRTHG.GET MED ATTN.INGEST:DONT
INDUCE VOMIT.GIVE LARGE QUANT OF H*2O TO PERSON IF CONSCIOUS + NOT
CONVULSING.IF VOMIT OCCURS,REPEAT LIQ INTAKE.GET IMMED MED HELP.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ATMOSPHERE-SUPPLYING/AIR
PURIFYING RESPIRATORS.
Ventilation:LOCAL EXHAUST ROOM VENTILATION ADEQUATE FOR MOST
OPERATIONS.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
OVEREXP EFTS BREATHING,PULMONARY SENSITATION INGEST POSS
GASTROINTESTINAL IRRIT/ULCERATION MOUTH AND THROAT BURNS SPECIAL
FIRE PROTEC AREA COOL FIRE EXP CNTRNS W/H20 U/K UNKNOW DOP 10/25/85
KEY1:N1
================== Physical/Chemical Properties ==================
HCC:B3
Vapor Pres:< 1
Vapor Density:> 1
Spec Gravity:2.08
Solubility in Water:PARTLY SOLUBLE
Appearance and Odor:TAN PASTE W/AMONICAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS/LEWIS + MIINERAL ACIDS.
Stability Condition to Avoid:STRONG OXIDIZERS,ACIDS + BASES.
Hazardous Decomposition Products:NITROGEN OXIDES,CO,NITROGEN CONTAINING
ORGANIC COMPOUNDS
Conditions to Avoid Polymerization:STRONG OXIDIZERS,ACIDS + BASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN DISPOSAL FACILITY IAW FEDERAL,STATE +
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MIL-C-372C;PQ 4800 RUST PREVENTATIVE
Preparer's Name:N.R.NETZEL
CAGE:VELSI
CAGE:0Z6C4
CAGE:VELSI
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBON SOLVENT
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALIPHATIC PETROLEUM SOLVENT (KEROSENE)
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 59%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR OIL KEROSENE IS 200PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:VAPORS MAY CAUSE
IRRITATION.SKIN:MAY CAUSE IRRITATION.INGEST:HARMFUL IF
SWALLOWED.MAY CAUSE LUNG DAMAGE IF VOMITED AFTER
SWALLOWING.INHAL:VAPORS MAY CAUSE RESPIRATORY IRRITATION AND CNS
EFFECTS.C HRONIC:2-BUTOXYETHANOL MAY HEMOLYZE REDBLOOD CELLS AND
DAMAGE KIDNEYS AND LIVER.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of
Overexposure:INHAL:HEADACHE,VOMITING,NAUSEA,DIZZINESS,INCOORDINATIO
N.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.CALL PHYSICIAN IF
IRRITATION DEVELOPS.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR
ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT INDUCE VOMITING.GET
PROMPT QUALIFIED MEDICAL ATTENTION.NOTE TO PHYSICIAN:TREAT
SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:120F,49C
Extinguishing Media:WATER FOG,DRY CHEMICAL,CARBON DIOXIDE,FOAM.AVOID
SPREADING BURNING LIQUID WITH WATER STREAM.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.HEAT OF FIRE MAY CAUSE
CONTAINERS TO BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION.USE PROPER
RESPIRATORY AND PROTECTIVE EQUIPMENT.VENTILATE AREA.SOAK UP WITH A
NON-COMBUSTIBLE INERT ABSORBANT(CLAY,SAND);PLACE IN PROPER
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
HEAT,SPARKS,FLAMES AND INCOMPATIBLE MATERIALS.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
RESPIRATOR OR SCBA AS APPROPIATE FOR EXPOSURE OF CONCERN.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:PROVIDE A LOCAL EYE WASH STATION AND SAFETY
SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>250F,>121C
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID,SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH HEAT,SOURCES OF IGNITION.
Hazardous Decomposition Products:UNIDENTIFIED TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: SCOTCHCAL BRAND SCREEN PRINTING INK 6605I
Cage: 1BY21
=======================================================
Contractor Summary
=======================================================
Cage: 76381
Cage: 1BY21
=======================================================
Ingredients
=======================================================
INCOORDINATION, SLOWED RXN TIME, FATG, BLURRED
-----------------------------
(BENZENE SOLV EXTRACTS) IS POTNTL CANCER
-----------------------------
LAB ANIMAL STUDIES. ETHYL ACRYLATE IS POTNTL
-----------------------------
ANIMAL STUDIES.
-----------------------------
DOT-APPRVD CNTNR & SEAL.
-----------------------------
RESPIRATORY PROTECTION.
-----------------------------
Cas: 763-69-9
RTECS #: UF3325000
% Wt: 15-40
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 108-65-6
RTECS #: AI8295000
% Wt: 15-40
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 9010-88-2
ACRYLATE-METHYL METHACRYLATE POLYMER
% Wt: 15-30
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 9011-14-7
RTECS #: TR0400000
% Wt: 10-30
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 1333-86-4
RTECS #: FF5800000
% Wt: 1-5
OSHA PEL: 3.5 MG/M3
ACGIH TLV: 3.5 MG/M3
------------------------------
Cas: 80-62-6
RTECS #: OZ5075000
% Wt: 0.1-0.5
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
% Wt: 0.1-0.5
OSHA PEL: 200 PPM
ACGIH TLV: 50 PPM, S
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 140-88-5
RTECS #: AT0700000
% Wt: <0.1
OSHA PEL: 25 PPM, S
ACGIH TLV: 5 PPM; 15 STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
BY OSHA, THEY ARE NOT EXPECTED EFTS
-----------------------------
REDUCED URINE VOL, BLOOD IN URINE &
-----------------------------
(JAUNDICE) & TENDERNESS OF UPPER ABDOM. CNS
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES:MOD IRRIT: SIGNS/SYMPS CAN INCL REDNESS, SWELL, PAIN,
TEARING & HAZY VISION. SKIN: MILD IRRIT: SIGNS/SYMPS CAN INCL REDNESS,
SWELL & ITCH. INHAL: CNS DEPRESS: SIGNS/SYMPS CAN INCL HDCH, DIZZ, DRO W,
INCOORDINATION, SLOWED RXN TIME, SLURRED SPEECH, GIDD & UNCON. IRRIT
(UPPER RESP): SIGNS/SYMPS CAN (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:INCL SORENESS OF NOSE &
THROAT, COUGH & SNEEZING. INGEST:MAY CAUSE IRRIT OF GI TISS: SIGNS/SYMPS
CAN INCL PAIN, VOMIT, ABDOM TENDERNESS, NAUS, BLOOD IN VOMITUS & IN
FECES. CHRONIC:TOLUENE APP EARS ON NAVY LIST OF OCCUP CHEM REPRO HAZS. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MIN. GET MEDICAL ATTENTION. SKIN: FLUSH SKIN WITH LARGE AMOUNTS OF
WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. INHAL:REMOVE TO FRESH
AIR. IF NOT BREATHING,GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT,
GET IMMEDIATE MEDICAL ATTENTION. INGEST: DO NOT INDUCE VOMITING. DRINK TWO
GLASSES OF WATER. CALL MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REFER TO OTHER SECTIONS OF MSDS FOR INFO REGARDING
PHYSICAL & HLTH HAZS, RESP PROT, VENT & PERSONAL PROT EQUIP. CALL
612-733-1110 OR 612-733-6100 FOR 24-HR SPILL ASSISTANCE. VENT AREA. EXTING
ALL IGNI T SOURCES. COLLECT USING NON-SPARKING
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). INCINERATE IN A PERMITTED HAZ WASTE INCINERATOR. DISPOSE
OF WASTE PROD IN FACILITY PERMITTED TO ACCEPT CHEMICAL WASTE. RECLAIM IF FEAS
IBLE. U.S. EPA HAZ WASTE NO = D001 (IGNITABLE).
Handling And Storage Precautions: KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP
CONTAINER IN WELL VENTILATED AREA.
Other Precautions: KEEP CNTNR TIGHTLY CLSD. KEEP AWAY FROM HEAT, SPK, OPEN
FLAME & OTHER IGNIT SOURCES. PVNT ALL SOURCES OF IGNIT. GROUND CNTNRS
SECURELY WHEN TRANSFERRING CONTENTS. WEAR LOW STATIC/PROPERLY GROUNDED SHO
ES. COMBUST LIQ & VAP. NO SMOKING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 110F,43C
Lower Limits: 1%
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NOT DETERMINED.
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID PRLNG BREATHING OF VAPORS. SELECT ONE OF
FOLLOWING NIOSH/MSHA APPROVED RESPIRATORS BASED ON AIRBORNE CONCENTRATION OF
CONTAMINANTS & I/A/W/ OSHA REGS: HALF-MASK ORGANIC VAP RESPIRATOR,
FULL-FACE ORGANIC VAPOR RESPIRATOR.
Ventilation: USE W/APPROP LOC EXHST VENT. PROVIDE SUFFICIENT VENT TO MAINTAIN
EMISSIONS BELOW RECOM EXPOS LIMS. IF EXHST
Other Protective Equipment: AVOID PROLONGED OR REPEATED SKIN CONTACT. WEAR
APRON, COVERALLS AS NECESSARY TO PREVENT SKIN CONTACT.
Work Hygienic Practices: DO NOT EAT/DRINK/SMOKE WHEN USING PROD. WASH EXPOS
AREAS THORO W/SOAP & WATER. WASH HANDS AFTER HNDLG & BEFORE EATING.
Supplemental Safety and Health: EFTS OF OVEREXP: HAZ LIST INFO & SAFE HNDLG
& EXPOS INFO (FP N). PRLNG/RPTD OVEREXP ABOVE RECOM GUIDELINES MAY CAUSE:
KIDNEY EFTS: SIGNS/SYMPS CAN INCL REDUCED URINE VOL, BLOOD IN URINE &
BACK PAIN. L IVER EFTS: SIGNS/SYMPS CAN INCL YELLOW SKIN (JAUNDICE) &
TENDERNESS OF ABDOMEN. WHILE FOLLOWING EFTS ARE ASSOC
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >295F,>146C
Vapor Pres: <4
Vapor Density: >1
Spec Gravity: 1.1-1.4(H*2O=1)
Solubility in Water: MODERATE
Appearance and Odor: LIQUID, BLACK; SWEET SOLVENT ODOR.
Percent Volatiles by Volume: 45-65
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE AND CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: SCOTCHCAL BRAND SCREEN PRINTING INK 6605I
Cage: 1BY21
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 03/24/1993
Status Code: C
Label Date: 03/24/1993
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. KEEP AWAY FROM HEAT & OPEN FLAME.
ACUTE:EYE:CAUSES SEVERE IRRITATION. SKIN:MAY CAUSE IRRITATION UPON PROLONGED
OR REPEATED CONTACT. MAY BE ABSORBED THROUGH SKIN IN HARMFUL AMOUNTS. INHAL:
MAY CAUSE RESPIRATORY SYSTEM IRRITATION& NERVOUS SYSTEM IMPAIRMENT.
MODERATELY TOXIC BY INGESTION. MAY CAUSE NAUSEA, VOMITING, DIARRHEA &
NARCOSIS. CHRONIC:TOLUENE APPEARS ON THE NAVY LISTING OF OCCUP ATIONAL
CHEMICAL REPRODUCTIVE HAZARDS (FP N). MAY CAUSE KIDNEY OR LIVER DAMAGE.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LAST N LAST GLOSS POLYURETHANE
CAGE:87827
CAGE:87827
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS; (ALIPHATIC HYDROCARBON)
CAS:64741-41-9
Fraction by Wt: 49.3%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEVERE EYE IRRITATION, DRYING OF SKIN.
EXCESSIVE INHALATION CAUSES HEADACHE, DIZZINESS, AND NAUSEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER FOR AT LEAST 15 MIN. SKIN: WASH WITH
MILD SOAP AND WATER. INHAL: REMOVE TO FRESH AIR AND CALL PHYS.
INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:108F,42C
Lower Limits:0.77%
Upper Limits:6%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, SAND.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . AVOID SPREADING BURNING LIQUID WITH WATER
USED FOR COOLING PURPOSES.
Unusual Fire/Explosion Hazard:KEEP WORK AREAS FREE OF HOT METAL
SURFACES AND OTHER SOURCES OF IGNITION. COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID EXPOSURE TO SPARKS, FIRE OR HOT METAL
SURFACES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS/OPEN FLAME.
USE W/ADEQ VENT. AVOID PROLONGED OR REPEATED CONTACT.
Other Precautions:FACE AND HAND PROTECTION RECOMMENDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SCBA FOR CONCENTRATIONS
ABOVE TLV.
Ventilation:LOCAL EXHAUST/MECH(GEN).
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:AVOID INGESTING THIS PRODUCT.
Supplemental Safety and Health
VP: 3.9 PSIA @ 163 F
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:312F,156C
Vapor Pres:SUPP DATA
Vapor Density:5.0
Spec Gravity:0.9076(H2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR AND CHARACTERISTIC
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, AND FIRE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS OR DISPOSE OF
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:63XX INT/EXT QUICK DRYING SEMI-GLOSS ENAMEL, 6300D
CAGE:FO133
CAGE:97903
CAGE:FO133
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:ALKYD RESIN
Fraction by Wt: 45%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL
SPIRITS). VP:2 @ 68F. LEL:1%.
CAS:64742-88-7
Fraction by Wt: 35%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:SILICON DIOXIDE (AMORPHOUS); (AMORPHOUS SILICA)
CAS:67762-90-7
Fraction by Wt: <5%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ORGANOPHILIC CLAY
Fraction by Wt: <5%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 393 G/L (LESS WATER).
RTECS #:9999999VO
Ingred Name:FIRST AID PROC:ASPIRATION OF VOMITUS CAN CAUSE CHEMICAL
PNEUMONITUS WHICH CAN BE FATAL.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:STORE IN CLOSED CONTAINERS UNTIL PROPERLY
DISPOSED OF.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:TRANSFER CONTENTS TO BOTTLES OR OTHER UNLABELLED
CONTAINERS. DO NOT REUSE EMPTY CONTAINERS. KEEP OUT (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:OF REACH OF CHILDREN.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:WEAR NIOSH/MSHA APPRVD CHEM/MECH FILTERS DESIGNED
TO REMOVE COMBINATION OF PARTICULATES & VAP. WHEN (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:USED IN CONFINED AREAS, WEAR NIOSH/MSHA APPRVD AIR
SUPPLY RESPS/HOODS. USE NIOSH/MSHA APPRVD RESPS WHEN (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:FLAME CUTTING, WELDING, BRAZING & SANDING MATL
COATED W/THIS PROD. FOLLOW RESP MFR'S DIRECTIONS FOR RESP USE.
RTECS #:9999999ZZ
Ingred Name:VENT:STDS IN MIXING, APPLICATION & CURING AREAS & TO REMOVE
SANDING DUSTS OF DRIED COATING & DECOMP PROD DURING (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:WELDING & FLAME CUTTING ON SURFS COATED W/THIS PROD.
HEAVY SOLV VAPS SHOULD BE REMOVED FROM LOWER LEVELS (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:OF THE WORK AREA & ALL IGNITION SOURCES SHOULD BE
ELIMINATED.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:PREVENT CONTACT ARE RECOMMENDED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF RESP TRACT; MAY
AFFECT BRAIN/NERV SYS CAUSING DIZZ, HDCH, NAUS, WEAK & FATG.
EXTREME EXPOS CAN RSLT IN UNCON & EVEN RESP ARREST. EYE/SKIN
CONT:CAUSES IRRIT. INGEST:CAN CAUSE STOM &/OR INTEST IRRIT, NAUS,
VOMIT & DIARR.ASPIR OF VOMITUS CAN CAUSE CHEM PNEUM, WHICH CAN BE
FATAL. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHRONIC:RPTS HAVE ASSOC RPTD & PRLNG
OCCUP OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG. PRLNG & RPTD
BRTHG OF SPRAY MIST &/OR SANDING DUST OVER PERIOD OF YRS MAY CAUSE
DUST DISEASE OF LUNGS. WARNING:INTENTIONAL MISUSE BY DELIB
CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE WHEN USED I/A/W SAFE HANDLING
& USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL:LEAVE AREA TO OBTAIN FRESH AIR. IF CONTINUED DFCLTY IS
EXPER, SUMMON MED ASSISTANCE IMMED. IF BRTHG CEASES, RESTORE USING
APPRVD CPR TECHNIQUES & SUMMON MED ASSISTANCE IMMED. EYES:FLUSH
W/LG AMT S OF WATER FOR AT LST 15 MINS. GET MED ASSISTANCE.
SKIN:WASH AREA THORO W/SOAP & WATER. REMOVE SOILED CLTHG. GET MED
ASSISTANCE IF IRRIT PERSISTS. INGEST:DO NOT INDUCE VOMIT. CONSULT
MD IMMED. (ING 8)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102F,39C
Lower Limits:SEE INGS
Extinguishing Media:IN CASE OF FIRE, USE CO*2, DRY CHEMICAL, FOAM OR
OTHER NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
SUMMON PROFESSIONAL FIREFIGHTERS. WATER SPRAY MAY BE INEFT. IF
WATER IS USED, FOG NOZZS ARE PREF. (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT & FLAME. DUE TO PRESS BUILD-UP, CLSD CNTNRS EXPOS TO EXTREME
HEAT MAY EXPLODE. NEVER USE WELDING/CUTTING (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (HEAT, FLAME). DO
NOT SMOKE. AVOID BRTHG VAPS. BEFORE ATTEMPTING CLEAN-UP REFER TO
HAZ CAUT INFO IN OTHER SECTIONS OF THIS MSDS. VENTILATE AREA.
CONTAIN SPILLED MATL & REMO VE W/INERT ABSORB & NON-SPARKING
TOOLS.(ING 9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPORS, SPRAY MIST OR
SANDING DUST. USE ONLY W/ADEQUATE VENTILATION. DO NOT GET ON SKIN
OR IN EYES. KEEP AWAY FROM HEAT & FLAME.
Other Precautions:DO NOT SMOKE. PREVENT BUILD-UP OF VAPORS BY
MAINTAINING CONTINUOUS FLOW OF FRESH AIR. DO NOT STORE >120F OR
NEAR FIRE/OPEN FLAME. STORE LG QTYS IN BLDGS DESIGNED TO COMPLY
W/OSHA 1910.106. KEEP CNTNR CLSD WHEN NOT IN USE. DO NOT (ING 10)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAY APPLIED IN OUTDOOR/OPEN AREAS
W/UNRESTRICTED VENT & DURING SANDING/GRINDING OPERATIONS, USE
NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE SOLID AIRBORNE
PARTICLES OF OVERSPRAY & SANDING DUST . WHEN USED IN RESTRICTED
AREAS,(ING 12)
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO
KEEP AIR CONTAM CONC BELOW CURRENT APPLIC SAFETY & HLTH (ING 15)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . SOLV IMPERMEABLE CLTHG & BOOTS TO (ING 18)
Work Hygienic Practices:REMOVE & WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING, SMOKING OR USING THE WASHROOM.
Supplemental Safety and Health
FIRE FIGHT PROC:IF EXPOS TO FIRE/EXTREME HEAT, WATER SHOULD BE USED TO
COOL CLSD CNTNRS & PVNT PRESS BUILD-UP/POSS AUTO-IGNIT. EXPLO
HAZ:TORCH ON/NEAR CNTNR (EVEN EMPTY) AS PROD/ITS RESIDUE MAY IGNITE
. DURING EMER CNDTNS, OVEREXP TO DECOMPPRODS MAY CAUSE HLTH HAZ.
SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>310F,>154C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:51.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE HAZ FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE & OXIDES
OF INGS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:155 9582 KODALITH SUPER RT DEVELOPER,PART B
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CARBONATE
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 94 - 98%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM BROMIDE
CAS:7758-02-3
RTECS #:TS7650000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:METAPHOSPHORIC ACID, HEXASODIUM SALT (CERCLA)/SODIUM
HEXAMETAPHOSPHATE
CAS:10124-56-8
RTECS #:OY3675000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- CAUSES EYE & SKIN IRRITATION. AIRBORNE DUST
IRRITATING. MAY CAUSE UPPER RESPIRATORY TRACT IRRITATION. HARMFUL
IF INGESTED. MAY CAUSE GASTROINTE STINAL IRRITATION. CHRONIC -
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, TEARING, COUGHING, NAUSEA
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN.
SKIN:FLUSH WITH PLENTY OF WATER. ORAL: DO NOT INDUCE VOMITING. IF
CONSCIO US, DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNT OF WATER IF
PERMITTED OR SWEEP UP AND PLACE IN A CONTAINER FOR CHEMICAL WASTE.
CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION. AVOID
RAISING DUST.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM STRONG ACIDS. KEEP
CONTAINER TIGHTLY CLOSED.
Other Precautions:DO NOT GENERATE DUST. AVOID BREATHING DUST. DO NOT
GET IN EYE, ON SKIN OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING
AND BEFORE EATING OR DRINKING. USE WITH ADEQUATE VENTILATION. KEEP
OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS TO AN ACCEPTABLE LEVEL, A NIOSH-APPROVED DUST
RESPIRATOR MUST BE WORN. A PROGRAM SHOULD BE INSTITUTED TO ASSURE
COMPLIANCE WITH OSHA STA NDARD 29 CFR 1910.134.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY1:N1. SEE PNI A FOR PART A AND PNI W FOR WORKING SOLUTION.
ECOLOGICAL INFORMATION: NO BIOCHEMICAL OXYGEN DEMAND, A LOW
POTENTIAL TO AFFECT SOME AQUATIC ORGANISMS. WHEN DILUTED WITH LARGE
AMOUNT OF WATER, IT IS NOT EXPECTED TO CAUSE ADVERSE ENVIRONMENTAL
EFFECTS.
================== Physical/Chemical Properties ==================
HCC:T4
NRC/State Lic Num:NOT RELEVANT
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE POWDER - ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL REGULATIONS. FLUSH TO SEWER WITH LARGE
AMOUNT OF WATER, IF PERMITTED.
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 01-035-5391
Product ID: EMGARD 2984-D EP 75W-90 SYNTHETIC GEAR LUBRICANTS
Cage: TO539
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: LUBRICATING OIL,GEAR
Specification Number: MIL-L-2105
Type/Grade/Class: 75W GRADE
Unit of Issue: CN
Quantitative Expression: 00000000005GL
UI Container Qty: 6
Type of Container: PPP-P-704
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL (RAT) IS NOT KNOWN.
Skin: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: OVERVIEW: NON HAZARDOUS UNDER NORMAL CONDITIONS OF USE.
SKIN CONTACT: SIMILAR MATERIALS ARE NOT CLASSIFIED AS SKIN IRRITANTS. THE
SKIN IRRITATION SCORE FOR THIS SUBSTANCE HAS NOT BEEN DETERMINED. EYE
CONTACT: SIMILAR MATERIALS AE NOT CLASSIFIED AS EYE IRRITANTS. THE EYE
IRRITATION SCORE FOR THIS SUBSTANCE HAS NOT BEEN DETERMINED.INHALATION:
INHALATION OF MIST MAY CAUSE IRRITATION OF THE RESP IRATORY SYSTEM.
INGESTION: MAY BE HARMFUL IF SWALLOWED IN LARGE QUANTITIES.CHRONIC
EFFECTS: NONE KNOWN. NO EFFECTS OF CHRONIC EXPOSURE OR TARGET ORGAN EFFECTS
ARE KNOWN. NO EXPOSURE LIMITS HAVE B EEN ESTABLISHED FOR THIS PRODUCT.
Explanation Of Carcinogenicity: NO CARCINOGENICITY, MUTAGENICITY, OR
TERATOGENICITY ARE KNOWN.
Signs And Symptions Of Overexposure: SKIN/EYE:IRRITATION. INHALATION:
IRRITATION OF THE RESPIRATORY SYSTEM.
First Aid: SKIN CONTACT: WASH AFFECTED AREA WITH SOAP AND WATER. EYE CONTACT:
FLUSH WITH PLENTY OF COOL WATER FOR 15 MINUTES. DO NOT LET VICTIM RUB EYES.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION: REMOVE VICTIM TO
FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION, PREFERABLY, MOUTH TO
MOUTH. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. IF VICTIM IS
CONSCIOUS AND ABLE TO SWAL LOW, PROMPTLY DRINK WATER TO DILUTE. DO NOT GIVE
SODIUM BICARBONATE, FRUIT JUICE, VINEGAR. NEVER GIVE ANYTHING BY MOUTH IF
VICTIM IS UNCONSCIOUS OR HAVING CONVULSION. CALL PHYSICIAN/POISON CONTROL IM
MEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ADD DRY MATERIAL TO ABSORB SPILL (IF LARGE SPILL,
DIKE TO CONTAIN). USING RECOMMENDED PROTECTIVE EQUIPMENT, PICK UP BULK OF
SPILL AND CONTAINERIZE FOR RECOVERY OR DISPOSAL. FLUSH AREA WITH WATER TO
REMOVE RESIDUES.
Waste Disposal Methods: ALL RECOVERED MATERIAL SHOULD BE PACKAGED, LABELED,
TRANSPORTED, AND DISPOSED OR RECLAIMED IN CONFORMANCE WITH APPLICABLE LAWS
AND REGULATIONS AND IN CONFORMANCE WITH GOOD ENGINEERING PRACTICES. AVOI D
LANDFILLING OF LIQUIDS. RECLAIM WHERE POSSIBLE.
Handling And Storage Precautions: WEAR SAFETY GLASSES WITH SIDE SHIELDS,
23C RESPIRATOR, EXCLUDING SINGLE USE OR DISPOSABLE RESPIRATORS IN ACCORDANCE
WITH 30 CFR 11(1). PROVIDE LOCAL EXHAUST VENTILATION.
Other Precautions: THE RESPIRATOR SHALL BE EQUIPPED WITH COMBINATION CARTRIDGES
APPROVED FOR PAINTS, ENAMELS AND LACQUERS UNLESS AIR-SUPPLIED RESPIRATOR IS
SELECTED. USE OF RESPIRATOR SHALL BE ACCORDING TO 29 CFR 1910. 134 AND 30
CFR 11.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point: =170.C, 338.F
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER SPRAY.
Fire Fighting Procedures: USE WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON
DIOXIDE. WATER MAY BE INEFFECTIVE BUT SHOULD BE USED TO KEEP FIRE EXPOSED
CONTAINERS COOL. IF A SPILL OR LEAK HAS NOT IGNITED, USE WATER SPRAY TO
DISPER SE THE VAPORS. WATER SPRAY MAY BE USED TO FLUSH SPILLS AWAY FROM
FIRES.
Unusual Fire/Explosion Hazard: PERFORM ONLY THOSE FIRE FIGHTING PROCEDURES FOR
WHICH YOU HAVE BEEN TRAINED.FIREFIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS IN THE POSITIVE PRESSURE MODE WITH A FULL FACEPIECE WHEN
THERE IS A POSSIBILITY OF EXPOSURE TO SMOKE, FUMES OR HAZARDOUS
DECOMPOSITION PRODUCTS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF EXPOSED TO AEROSOL/MIST, WEAR NIOSH APPROVE CATEGORY
23C RESPIRATOR, EXCLUDING SINGLE USE OR DISPOSABLE RESPIRATORS IN ACCORDANCE
WITH 30CFR11(I). RESPIRATOR SHALL BE EQUIPPED WITH COMBINATION CAR TRIDGES
APPROVED FOR PAINTS, ENAMELS, AND LACQUERS UNLESS AIR-SUPPLIED RESPIRATOR IS
SELECTED. USE OF RESPIRATOR SHALL BE ACCORDING TO 29CFR 1910.134/30CFR11.
Ventilation: LOCAL EXHAUST.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V5
B.P. Text: N/D
M.P/F.P Text: N/D
Vapor Pres: N/D
Vapor Density: N/D
Spec Gravity: 0.885
PH: N/D
Evaporation Rate & Reference: N/D
Solubility in Water: INSOLUBLE
Appearance and Odor: DARK COLORED LIQUID; PUNGENT ODOR.
Percent Volatiles by Volume: N/D @ 70F
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID CONTACT WITH HEAT, SPARKS, FLAMES AND ALL
SOURCES OF IGNITION.
Materials To Avoid: STRONG ACIDS, BASES, AND OXIDIZING AGENTS.
Hazardous Decomposition Products: MAY PRODDUCE OXIDES OF CARBON, NITROGEN,
SULFUR AND PHOSPHORUS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: NO TOXICITY INFORMATION AVAILABLE OR TESTING
CONDUCTED ON THIS PRODUCT. ANY HEALTH OR TOXICOLOGICAL INFORMATION INCLUDED
UNDER "HEALTH HAZARDS" WAS BASED ON DATA ASSOCIATED WITH THE COMPONENTS OR AN
A NALOGOUS PRODUCT.
=======================================================
Ecological Information
=======================================================
Ecological: ECOLOGICAL TOXICITY: NOT DETERMINED. ENVIRONMENTAL FATE: NOT
DETERMINED.
=======================================================
=======================================================
Transport Information: PROPER SHIPPING NAME: NOT REGULATED FOR NONBULK
HIGHWAY/TRANSPORTATION. DOT HAZARD CLASS: NOT DETERMINED. DOT HAZARDOUS
MATERIALS: NOT DETERMINED. EMERGENCY RESPONSE GUIDE NUMBER: NOT DETERMINED.
PACK AGING GROUP: NOT DETERMINED.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA 311/312 HAZARD CATEGORIES: NONE. SARA 313
TOXIC CHEMICALS: NONE. SARA 302 EXTREMELY HAZARDOUS SUBSTANCES: NONE. CERCLA
HAZARDOUS SUBSTANCES: BETA NAPHTHYLAMINE (91598), <0.0001 %.
Federal Regulatory Information: TSCA INVENTORY STATUS: THIS PRODUCT AND/OR ALL
OF ITS COMPONENTS ARE INCLUDED ON THE TSCA INVENTORY OF CHEMICAL SUBSTANCES.
TSCA 12(B) COMPONENTS: NONE.
State Regulatory Information: CALIFORNIA PROPOSITION 65 COMPONENTS: WARNING:
THIS PRODUCT CONTAINS A CHEMICAL (OR CHEMICALS) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS AND/OR OTHER REPRODUCTIVE HARME.
BETA NAP HTHYLAMINE (91598), <0.0001%.
=======================================================
Other Information
=======================================================
Other Information: RATINGS: HEALTH = 1; FLAMMABILITY = 1; REACTIVITY = 0. NFPA
RATINGS: HEALTH = 1; FLAMMABILITY = 1; REACTIVITY = 0; OTHER = NONE.
=======================================================
Transportation Information
=======================================================
Trans ID NO: 154769
Product ID: EMGARD 2984-D EP 75W-90 SYNTHETIC GEAR LUBRICANTS
Review Date: 09/26/2000
Net Unit Weight: 36.9 LBS
Multiple KIT Number: 0
Unit Of Issue: CN
Container QTY: 6
Type Of Container: PPP-P-704
Additional Data: TRANSPORTATION DATA PER MANUFACTURER'S MSDS.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: EMGARD 2984-D EP 75W-90 SYNTHETIC GEAR LUBRICANTS
Cage: TO539
Assigned IND: Y
Company Name: COGNIC CORPORATION
Street: 5051 ESTECREEK DRIVE
Zipcode: 45232
Label Required IND: Y
Date Of Label Review: 09/26/2000
Status Code: A
Label Date: 09/26/2000
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: NON HAZARDOUS UNDER NORMAL CONDITIONS OF USE. FIRST
AID: INHALATION: MOVE TO FRESH AIR, IF NOT BREATHING GIVE ARTIFICIAL
RESPIRATION, PREFERABLY, MOUTH TO MOUTH. GET MEDICAL ATTENTION. SKIN CONTACT:
W ASH AREA WITH SOAP AND WATER. EYE CONTACT: FLUSH WITH COOL WATER FOR 15
MINUTES. DO NOT LET VICTIM RUB EYES. GET MEDICAL ATTENTION IF IRRITATION
DEVELOPS. INGESTION: DO NOT INDUCE VOMITING. IF CONSCI OUS AND ABLE TO
SWALLOW, HAVE VICTIM DRINK WATER TO DILUTE. DO NOT GIVE SODIUMBICARBONATE,
FRUIT JUICES, OR VINEGAR. NEVER GIVE ANYTHING BY MOUTH TO UNCONSIOUS PERSON.
CALL PHYSICIAN OR POISON CONTRO L CENTER.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FP-95(M) PENETRANT
Kit Part:Y
CAGE:98733
CAGE:98733
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED MIDDLE PETROLEUM DISTILLATE
CAS:64742-46-7
RTECS #:JN9379645
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: < 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA 313)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: < 4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:800 PPM
ACGIH TLV:800 PPM; 9596
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9596
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:NONE RECOMMENDED
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: < 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT-PRESUMED NON-IRRIT.SKIN
CONTACT-SLIGHTLY IRRIT.INHAL-VAPORS/OIL MIST MAY CAUSE MILD IRRIT
OF UPPER RESP TRACT.INGEST-MAY RESULT IN VOMITING.ASPIRATION MUST
BE AVOIDED.
Explanation of Carcinogenicity:PER
MSDS:CARCINOGENICITY/NTP/IARC:NA;OSHA:NO.
Effects of Overexposure:SKIN CONTACT-IRRIT.INGESTION-POSSIBLE VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPRIATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER.SKIN:FLUSH W/WATER,WASH
W/SOAP/WATER.INHAL:REMOVE TO FRESH AIR.PROVIDE OXYGEN IF BREATHING
IS DIFFICULT.INGEST:DO NOT INDUCE VOMITING.GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:210F,99C
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2.DO NOT USE
DIRECT STREAM OF WATER.
Fire Fighting Procedures:MATL WONT BURN UNLESS PREHEATED.DONT ENTER
CONFINED FIRE-SPACE W/O FULL BUNKER GEAR INCLUDE +PRESSURE NIOSH
APPROV SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE. NOTE:WHEN PKG IN AEROSOL CAN THE
PROPELLANT IS MIXTURE OF BUTANE,PROPANE AND ISOBUTANE, FLASH POINT
APPROX -100F.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAKUP W/ABSORBENT SUCH AS CLAY,SAND,OTHER
SUITABLE MATL.DISPOSE OF IN ACCORDANCE WITH FEDERAL/STATE REGS FOR
ALL RESIDUE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT/OPEN
FLAMES/OXIDIZING MATLS.
Other Precautions:NONE.READ/FOLLOW LABEL DIRECTIONS/INFO GIVEN ON
MSDS.USE CARE WHEN HNDLG/USING ALL NON-DESTRUCTIVE TEST CHEM
PRODUCT.ADDN INFO CALL MET-L-CHEK CO.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPO EXCEEDS TLV USE NIOSH APPROVED
RESPIRATOR TO PREVENT OVEREXPOSURE.
Ventilation:LOC EXHAUST/MECHANICAL(GEN):TO MAINTAIN TLV.
SPECIAL/OTHER:NONE.
Other Protective Equipment:AS REQUIRED TO MINIMIZED SKIN CONTACT.
Work Hygienic Practices:MINIMIZE SKIN CONTACT.WASH W/SOAP/WATER BEFORE
EATING/DRINKING/SMOKING/USING TOILET.
Supplemental Safety and Health
3-PART KIT,SEE PNIND:B,C.KEY1=HCC=N1.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:>400F,>204C
Melt/Freeze Pt:M.P/F.P Text:-75F,-59C
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:0.91
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW-GREEN LIQUID, SLIGHT HYDROCARBON ODOR
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT, OPEN FLAMES, AND OXIDIZING MATLS.
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND OTHER
UNIDENTIFIED ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:HEAT, OPEN FLAMES, AND OXIDIZING
MATLS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAINS NO TOXIC CHEMS SUBJ TO REPORT REQMTS OF
SEC 313 EMPCRA/40CFR372.PLACE IN APPROPRIATE DISPOSAL FACILITY IN
COMPLIANCE W/LOCAL REGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:XE 9862 A SAND TYPE II
Kit Part:Y
Preparer's Name:MIKE LICHATOWICH
CAGE:02388
CAGE:02388
============= Composition/Information on Ingredients =============
Ingred Name:P M ACETATE (VAPOR PRESSURE 3.7 MM HG @20C)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 16%
Ingred Name:PHENOLIC RESIN
Fraction by Wt: 14%
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 11%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 8%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:GREEN PIGMENT (AS CR)
CAS:1308-38-9
RTECS #:GB6475000
Fraction by Wt: 3%
OSHA PEL:1.0 MG/M3
ACGIH TLV:.05 MG/M3
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOC. ORGANIC CMPD 4.46 LB/GAL LESS WATER & NPRS* (NK) G/L
LESS WATER VOC. (NK) LB/GAL SOLIDS (NK) G/L SOLIDS CALCU
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HISTOLOGIC FIBROSIS OF LUNGS,
INCOHERENCE, CORNEAL VACUOLIZATION, ANOREXIA. TAR-GET ORGANS: CNS,
LUNGS, EYES, SKIN, RESPIRATORY SYSTEM, GI TRACT, BLOOD, LIVER,
KIDNEYS.ALSO SEE BELOW
Explanation of Carcinogenicity:NOT LISTED
Effects of Overexposure:EYE:SEVERE
IRRITATION,LACRIMATION,REDNESS,BLURRED
VISION.SKIN:REDNESS,IRRITATIONDEFATTING LEADING TO
DERMATITIS.BREATH:NASAL/RESPIRATORY IRRITATION,CNS
DEPRESS,(DIZZY,DROWSY,WEAK,FATIGUE,CONFUSION) NA
USEA,HEADACHE,VERTIGO,POSS UNCONSCIOUS,POSS ASPHYXIATION.SWALLOW:GI
IRRITATION,ABDOMINAL PAIN,NAUSEA,VOMITING,DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR AT ONCE. IF BREATH STOPPED, CPR,
GET MED ATTN IMMD.SKIN: IMMED FLUSH W/PLENTY OF WTR. REMOVE
CONTAM CLOTHES & FLUSH SKIN W/WTR. GETMED ATTN. LAUNDER CLOTHES &
SHOES BEFORE REUSE. EYE: IMMED FLUSH LG AMTS OF WTR15 MIN, LIFTING
LIDS. GET MED ATTN IMMED.CONTACT LENS SHOULD NOT BE
WORN.INGEST:DRINK 1/2 GLASSES WATER. DO NOT INDUCE VOMIT. GET MED
ATTN/POISON CC IMMEDIATELY
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:20 F/-6 C
Lower Limits:1.0
Upper Limits:10
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:SELF CONTAINED BREATHING APPARATUS W/FULL
FACEPIECE OPERATED POSITIVE PRESSURE & FULL PROT CLOTHES. WTR TO
COOL CLOSED CONTAIN PREVENT PRESSURE BUILDUP/EXPLOS
Unusual Fire/Explosion Hazard:KEEP CONT TIGHTLY CLOSED. VAPORS HEAVIER
THAN AIR,MAY TRAVEL ALONG GROUND TO IG-NITE SOURCE. ISOLATE FROM
HEAT, ETC. OVEREXP TO DECOMP MAY CAUSE HEALTH HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL IGNITION SOURCES. MIN BREATHING OF
VAPORSAVOID SKIN CONTACT. ABSORB W/INERT MATERIAL; CLAY,SOIL, OR
COMMERCIALLY AVAIL ABSORBENT. SHOVEL RECLAIMED LIQ/ABSORBENT INTO
RECOVERY OR SALVAGE DRUMS FOR DISPOSAL. LG: DIKE, RECLAIM IN
DRUM,TANK,TRUCK
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMP AREAS OR
NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT IN
USEAVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME ORCUT ON EMPTY DRUMS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROPRIATE PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA) DURING & AFTER APPLICATION UNLESS AIR MONITOR DEMO
VAPOR/MIST LEVELS ARE BELOW APPLICABLE LIMITS. FOLLOW RESPIRATOR
MANUFACTURER'S DIRECTIONS FOR USE
Ventilation:SUFFICIENT VENT IN VOL/PATTERN TO KEEP AIR CONCERN BELOW
CURRENT APPL OSHA PERMISSIBLE LIMIT. REMOVE DECOMP PRODUCTS
Other Protective Equipment:WEAR CHEMICAL RESISTANT CLOTHING AS NEEDED
TO PREVENT SKIN CONTACT. REMOVE CLOTHES THAT BECOME WET (FLAMMABLE
HAZARD)
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
RESTROOM. WASH PROMPTLY WHEN SKIN BECOMES CONTAMINATED.
Supplemental Safety and Health
CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION
TO HOT SURFACES REQUIRES SPECIAL PRECAUTIONS. DURING EMERGENCY
CONDITIONS, OVEREXP TO DECOMP PRODUCTS MAY CAUSE A HEALTH HAZAR D.
SYMPTOMS MAY NOT BE IMMEDIATELTY APPARENT OBTAIN MEDICAL ATTENTION.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175-302 F
Decomp Temp:Decomp Text:NE
Vapor Density:> AIR
Viscosity:75-85 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:59.64
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, NITRATES, ALKALIES, ACIDS.
Stability Condition to Avoid:UNDER REASONABLE CONDITIONS OF STORAGE AND
USE
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE
Conditions to Avoid Polymerization:HIGH TEMPERATURES, SHOCK FROM
DROPPING
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MOTOR LAMINATION
Preparer's Name:W R KOENIG
CAGE:INLA2
CAGE:93516
CAGE:INLA2
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: <1%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM (DUST)
Ingred Name:ALUMINUM (POWDER)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: <0.3%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <0.1%
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: <0.2%
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: <0.1%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
Ingred Name:SULFUR
CAS:7704-34-9
RTECS #:WS4250000
Fraction by Wt: <0.1%
OSHA PEL:5 MG/CUM
ACGIH TLV:5.2 MG/CUM
Ingred Name:ANTIMONY
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: <0.1%
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: >95%
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NONE UNLESS BURNING/CUTTING/ETC.
IRRITANT. MANGANESE/ZINC/COPPER- METAL FUME FEVER. IRON-SIDEROSIS.
MANGANESE-NERVOUS DYSFUNCTION.
ALUMINUM-PNEUMOCONIOSIS/DYSPNEA/FIBROSIS LUNG TISSUE.
CHROMIUM-DECREA SED PULMONARY FUNCTION/CORROSIVE. COPPER-NASAL
ULCER/DERMATITIS. NICKEL-INFLAMMATION.
ANTIMONY-PNEUMOCONIOSIS/ANEMIA.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:METALLIC TASTE/CHILLS/FEVER/ACHING
MUSCLES/DRYNESS OF MOUTH & THROAT/HEADACHE.
MANGANESE-HEADACHE/RESTLESS SLEEP PATTERN/RESTLESSNESS/PERSONALITY
CHANGES/MUSCULAR WEAKNESS. ALUMINUM-COUGH/WEAK. COPPER -METALLIC
TASTE. NICKEL-FEVER. ANTIMONY-HEADACHE/TIGHT CHEST/SHORT
BREATHE/METALLIC TASTE/NAUSEA/GINGIVITIS/ITCHING.
Medical Cond Aggravated by Exposure:WILSON'S DISEASE, RESPIRATORY
DISORDERS (ASTHMA, EMPHYSEMA, ETC.)
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR OR OXYGEN IF
NECESSARY. TREAT SYMPTOMATICALLY BY BED REST. SKIN: WASH
ABRASIONS/CUTS & CLOSE BY CLEAN COMPRESS. TREAT BURNS. WASH
AFFECTED AREA W/SOAP/WATER. EYE: FLUSH W/WATER. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Fire Fighting Procedures:USE FIRE FIGHTING TECHNIQUES OR AGENTS
APPLICABLE TO SURROUNDING MATERIALS.
Unusual Fire/Explosion Hazard:STEEL SHEET & PLATE PRODUCTS DON'T
PRESENT AN EXPLOSION HAZARD & DON'T CONTRIBUTE TO COMBUSTION OF
OTHER MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:PRODUCTS CAN EASILY DESTROY OBJECTS IN THEIR
PATH. CONTROL SITUATION. DETERMINE IF ANY
UTILITIES/PERSONS/VEHICLES ARE INVOLVED. ASSIST INJURED/CONTROL
TRAFFIC/CONTROL SOURCES. NOTIFY NEAREST FIRE FIGH TING FACILITY.
======================Handling and Storage ======================
Handling and Storage Precautions:BE ALERT TO SHARP EDGES, SLIPPERY
SURFACES WHEN HANDLING & FOR UNSECURED LOADS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN CONTROLS ARE NOT SUFFICIENT TO REDUCE
EXPOSURE BELOW LIMITS, USE MSHA/NIOSH APPROVED RESPIRATORY
PROTECTION W/IN THE USE LIMITIONS OF THE RESPIRATOR.
Ventilation:LOCAL EXHAUST OR VENTILATION SYSTEMS SUFFICIENT TO MAINTAIN
EXPOSURE LEVELS TO CONTAMINANTS BELOW LIMITS
Other Protective Equipment:HELMET, APPROPRIATE HEAT SHIELDING GARMENTS
GARMENTS.
Supplemental Safety and Health
MELTING POINT: BASE METAL- >2700F. APPEARANCE/ODOR: SHEET/STRIP, OR
PLATE THAT CAN VARY FROM GRAYISH TO SILVER. A FILM OF RUST
PREVENTATIVE OIL MAY BE PRESENT. ODORLESS BUT PRESENCE OF
PROTECTIVE FILM MAY IMPART A REFINED OIL AROMA.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:SEE SUPP
Spec Gravity: 7.8
Solubility in Water:INSOLUBLE
Appearance and Odor:SEE SUPP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DAMAGED PRODUCTS ARE NOT CONSIDERED HAZARDOUS
WASTE UNDER RCRA. THIS MATERIAL MAY BE CLAIMED FOR REUSE OR
DISPOSAL IN ACCORDANCE W/STATE, LOCAL, & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HYDROFLUORIC ACID, A463-500
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:HYDROFLUORIC ACID (SARA 302/313) (CERCLA)
CAS:7664-39-3
RTECS #:MW7875000
Fraction by Wt: 48-50%
OSHA PEL:3 PPM (F)
ACGIH TLV:3 PPM (F), C
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:WATER. LD50:(ORAL,RAT) >90 ML/KG.
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 50-52%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:TOX INFO:HYDROFLUORIC ACID:SUSPECTED OCCUP HUMAN
CARCIN (GRP 3). TERATOGENICITY:EMBRYO/FETUS:DEATH. REPRO (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:EFTS:FERTILITY:POST-IMPLANTATION MORTALITY &
PRE-IMPLANTATION MORTALITY. MUTAGENICITY:DNA DMG. SEX (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:CHROMOSOME LOSS/NON-DISJUNCTION.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:DFCLT, GIVE OXYG. GET MED AID. NOTE TO
MD:DUE TO DELAYED & PERSISTENT SYMPS, OBSERVE PATIENT (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:CLOSELY FOR 48 HRS. PROMPT ACTION IS ESSNTL IN ALL
CASES OF CONT. TREATMENT IS AIMED AT COUNTERACTING EFTS (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:OF THE ACID & PRECIPITATING THE TOXIC FLUORIDE IONS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:PERIOD NOT SPECIFIED). CLEAR AIR ACT/CLEAN WATER
ACT:HYDROFLUORIC ACID IS LISTED AS A HAZARDOUS AIR (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:AIR POLLUTANT (HAP) & A HAZARDOUS SUBSTANCE UNDER THE
CWA.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:CONT W/LIQ OR VAP CAUSES SEV
BURNS & POSS IRREVERSIBLE DMG. SKIN:CAUSES SEV IRRIT. MAY BE FATAL
IF ABSORBED. CAUSES SEV BURNS W/DELAYED TISS DESTRUCT. SUBSTANCE IS
RAPIDLY ABSORBED. INITIAL CONT MAY BE PAINLESS BUT WILL
PENETRATETISS CAUSING SEV NECROSIS & BONE DESTRUCT. INGEST:CAUSES
SEV (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DIGEST TRACT BURNS W/ABDOM PAIN,
VOMIT, POSS TISS DESTRUCT & POSS DEATH. MAY CAUSE SYSTEMIC TOX EFTS
ON HEART, LIVER & KIDNEYS. DEPLETES CALCIUM LEVELS IN BODY WHICH IF
LEFT UNTREATED CAN LEA D TO HYPOCALCEMIA & DEATH. INHAL:MAY CAUSE
SEV IRRIT OF UPPER RESP TRACT W/PAIN, BURNS & INFLAMM. MAY CAUSE
PULM(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:GET MED AID IMMED. GENTLY LIFT EYELIDS & FLUSH
CONTINUOUSLY W/WATER FOR AT LST 15 MINS. SKIN:GET MED AID IMMED.
RINSE AREA W/LG AMTS OF WATER FOR AT LST 15 MINS. REMOVE CONTAM
CLTHG & SHOES. INGE ST:DO NOT INDUCE VOMIT. IF VICTIM IS CONSCIOUS
& ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. GET MED AID IMMED.
INHAL:REMOVE FROM EXPOS TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF
RESP. IF BRTHG IS (ING 6)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER SPRAY TO COOL FIRE-EXPOSED CNTNRS.
SUBSTANCE IS NON-FLAMM; USE AGENT MOST APPROP TO EXTING SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER REACTIVE MATL WILL REACT W/WATER &
MAY RELS FLAMM &/OR TOX GAS. REACTS W/MOST METALS TO FORM HIGHLY
FLAMM HYDROGEN GAS WHICH CAN FORM EXPLOS MIXTS W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID RUNOFF INTO STORM SEWERS & DITCHES WHICH
LEAD TO WATERWAYS. WEAR NIOSH APPRVD SCBA & APPROP PERSONAL PROT
(SEE EXPOS CONTROLS, PERSONAL PROT SECTION). NEUT SPILL W/SODIUM
BICARBONATE. ECOTOXICIT Y:FISH (FRESH WATER) 60 PPM LETHAL (TIME
(ING 7)
Neutralizing Agent:SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET ON SKIN OR IN EYES. DO NOT
INGEST OR INHALE. STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY
FROM INCOMPATIBLE SUBSTANCES.
Other Precautions:DANGER:CORROSIVE. HARMFUL IF INHALED. POISON. DO NOT
STORE IN METAL OR GLASS CONTAINERS. USE W/ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE PROCESS ENCLOSURE, LOC EXHST VENT/OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW REC EXPOS LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR APPROP PROT CLTHG TO PREVENT SKIN CONT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
MATLS TO AVOID:SPECIFICS. EFTS OF OVEREXP:EDEMA & SEV RESP DISTURBS.
DEPLETES CALCIUM LEVELS IN BODY WHICH IF LEFT UNTREATED CAN LEAD TO
HYPOCALCEMIA & DEATH. CHRONIC:RPTD INHAL MAY CAUSE CHRONIC BRON CH.
PRLNG/RPTD EXPOS MAY CAUSE PERM BONE STRUCTURE ABNORMS. TARGET
ORGANS:KIDNEYS, RESP SYS, SKELETAL STRUCTURES.(ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:151F,66C
Melt/Freeze Pt:M.P/F.P Text:-96F,-71C
Vapor Density:2.21
Spec Gravity:1.2 (H*2O=1)
pH:<2
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; STRONG, IRRITATING ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPAT MATLS, METALS. SUBSTANCE IS INCOMPAT W/OVER 35 SPECIFIC CHEMS.
PLEASE REFER TO NPFA FIRE PROT GUIDE FOR(SUPDAT)
Stability Condition to Avoid:STABLE AT ROOM TEMPERATURE IN CLOSED
CONTAINERS UNDER NORMAL STORAGE & HANDLING CONDITIONS.
Hazardous Decomposition Products:FLUORIDE FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT W/FEDERAL,
STATE & LOCAL REGULATIONS. NOT LISTED AS A MATERIAL BANNED FROM
LAND DISPOSAL ACCORDING TO RCRA.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ARGOSHIELD GAS #90, G-109
CAGE:AIRCO
CAGE:AIRCO
CAGE:00741
============= Composition/Information on Ingredients =============
Ingred Name:ING 4:CYLS ARE STORED TO EXCEED 130F (54C). CYLS SHOULD BE
STORED UPRIGHT & FIRMLY SECURED TO PVNT FALLING/BEING (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:KNOCKED OVER. FULL & EMPTY CYLS SHOULD BE SEGREGATED.
USE "FIRST IN-FIRST OUT" INVENTORY SYS TO PVNT FULL (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:CYLS BEING STORED FOR EXCESSIVE PERIODS OF TIME. FOR
ADDNL STOR RECS, CONSULT COMPRESSED GAS ASSOC'S (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:PAMPHLETS P-1 & SFTY BULLETINS SB-7. NEVER CARRY
COMPRESSED GAS CYL/CNTNR OF GAS IN CRYOGENIC LIQ FORM IN (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:ENCLSD SPACE SUCH AS CAR TRUNK, VAN/STATION WAGON.
LEAK CAN RSLT IN FIRE, EXPLO, ASPHY/TOX EXPOS. THESE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:MIXTS ARE NONCORR & MAY BE USED W/ANY COMMON
STRUCTURAL MATL. COMPRESSED GAS CYLS SHOULD NOT BE REFILLED (ING
11)
RTECS #:9999999ZZ
Ingred Name:ING 10:EXCEPT BY QUALIFIED PRODUCERS OF COMPRESSED GASES.
SHIPMENT OF COMPRESSED GAS CYL WHICH HAS NOT BEEN (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:FILLED BY OWNER/WITH HIS (WRITTEN) CONSENT IS
VIOLATION OF FEDERAL LAW (49CFR).
RTECS #:9999999ZZ
Ingred Name:ARGON
CAS:7440-37-1
RTECS #:CF2300000
Fraction by Wt: 6-75%
OSHA PEL:N/K
ACGIH TLV:ASPHYXIANT
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 2-5%
OSHA PEL:5000 PPM
ACGIH TLV:5000 PPM;30000 STEL
Ingred Name:HELIUM
CAS:7440-59-7
RTECS #:MH6520000
Fraction by Wt: 30-90%
OSHA PEL:N/K
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:SUPDAT:COOL, DRY, WELL-VENTILATED AREA AWAY FROM HEAVILY
TRAFFICKED AREAS & EMER EXITS. DO NOT ALLOW TEMP WHERE (ING 5)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE EFFECTS OF EXPOSURE TO HIGH
CONCENTRATIONS SO AS TO DISPLACE THE OXYGEN IN THE AIR NECESSARY
FOR LIFE ARE HEADACHES, DIZZINESS, LABORED BREATHING & EVENTUAL
UNCONSCIOUSNESS. THE MAJOR HAZARD IS FR OM ASPHYXIATION DUE TO
OXYGEN DISPLACEMENT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:PROMPT MED ATTN IS MANDATORY IN ALL CASES OF OVEREXP. RESUCE
PERS SHOULD BE EQUIPPED W/NIOSH/MSHA APPRVD SCBA. INGEST:CALL MD
IMMED . EYES:IMMED FLUSH W/POTABLE WATER FOR MIN OF 15 MINS, SEEK
AS SISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMTS OF WATER. CALL MD .
INHAL:VICTIMS SHOULD BE ASSISTED TO UNCONTAM AREA & INHALE FRESH
AIR. QUICK REMOVAL FROM CONTAM AREA IS MOST (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR COMBUSTIBLE
MATERIALS INVOLVED IN FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:ELECTRICAL CLASSIFICATION: NONHAZARDOUS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL PERSONNEL FROM AFFECTED AREA. USE
APROPRIATE PROTECTIVE EQUIPMENT. IF LEAK IS IN CONTAINER OR
CONTAINER VALVE, CONTACT CHEMTREC FOR EMERGENCY ASSISTANCE OR YOUR
CLOSEST AIRCO LOCATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL-VENTILATED AREAS.
VALVE PROT CAPS MUST REMAIN IN PLACE UNLESS CNTNR IS SECURED
W/VALVE OUTLET PIPED TO USE POINT.
Other Precautions:DO NOT DRAG, SLIDE/ROLL CYLS. USE SUITABLE HAND TRUCK
FOR CYL MOVEMENT. USE PRESS REDUCING REGULATOR WHEN CONNECTING CYL
TO LOWER PRESS (<3000 PSIG) PIPING/SYS. DO NOT HEAT CYL BY ANY
MEANS TO INCR DI SCHARGE RATE OF PROD FROM CYL. (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED AIRLINE RESPIRATOR W/FULL
FACE PIECE EQUIPPED W/ESCAPE BOTTLE OR NIOSH/MSHA APPROVED SCBA
SHOULD BE AVAILABLE FOR EMERGENCY USE. OPERATE THIS EQUIPMENT IN
THE POSITIVE PRESSURE DEM AND MODE, PPD!
Ventilation:USE LOCAL EXHAUST TO PREVENT ACCUMULATION OF HIGH CONCS SO
AS TO REDUCE OXYGEN LEVEL IN AIR TO <18 MOLAR PERCENT.
Other Protective Equipment:SAFETY SHOES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:IMPORTANT. UNCON PERS SHOULD BE MOVED TO UNCONTAM AREA &
IF BRTHG HAS STOPPED, ADMIN ARTF RESUSCITATION & SUPP OXYGEN.
FURTHER TREATMENT SHOULD BE SYMPTOMATIC & SUPPORTIVE. OTHER PREC:U
SE CHECK VALVE/TRAP IN DISCHARGE LINE TO PVNT HAZ BACK FLOW INTO
SYS. PROT CYLS FROM PHYSICAL DMG. STORE IN (ING 4)
================== Physical/Chemical Properties ==================
Spec Gravity:0.25 @ STP
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS . DO
NOT ATTEMPT TO DISP OF WASTE/UNUSED QTYS. RETURN IN SHIPPING CNTNR
PROPERLY LABELED, W/ANY VALVE OUTLET PLUGS/CAPS SECURE & VALVE PROT
CAP IN PLACE TO AIRCO FOR PROPER DISPOSAL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:F63 W 56, POLANE HS POLYURETHANE COATING (S
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE. VP: 22
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA III). VP: 5.9
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0-5%
OSHA PEL:100 PPM;150 STEL
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE). VP: 70
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5-10%
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE (SARA III). VP: 2
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 0-10%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, ISOPROPYL ESTER; (ISOPROPYL ACETATE). VP: 47.5
CAS:108-21-4
RTECS #:AI4930000
Fraction by Wt: 5-15%
OSHA PEL:250 PPM;310 PPM STEL
ACGIH TLV:250 PPM;310 PPM STEL
Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (SARA III).
VP: 10
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 0-20%
OSHA PEL:150 PPM;200 STEL
ACGIH TLV:150 PPM;200 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-45%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:EFTS OF OVEREXP:THE WORK PLACE. REPORTS HAVE ASSOC RPTD &
PRLNGD OVEREXP TO SOLV W/PERMANENT BRAIN & NERVOUS SYS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:(TOLUENE CAS # 108-88-3) APPEARS ON NAVY LIST OF
OCCUP REPROD HAZ. SEEK CONSULTATION FROM APPROP HLTH (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: FROM APPROP HEALTH PROFESSIONALS CONCERNING LATEST
HAZARD LIST INFORMATION & SAFE HANDLING AND EXPOSURE (ING 11)
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: LOCAL REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: & UNTIL ALL VAPORS ARE GONE: KEEP AREA VENT. DO
NOT SMOKE. EXTING ALL FLAMES, PILOT LIGHTS (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:CLASSIFIED AS NUISANCE PARTICULATES, FOR EXAMPLE
TITANIUM DIOXIDE, CALCIUM CARBONATE, ETC, WHICH MAY BE (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: NFPA CODE. USE APPRVD BONDING & GROUNDING PROC.
KEEP CNTNR CLSD WHEN NOT IN USE. TRANSFER ONLY TO APPRVD(ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:USE. BEFORE OPENING PKG, READ & FOLLOW WARNING LBLS
ON ALL COMPONENTS. INTENTIONAL MISUSE BY DELIB CONC &(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: CONTAINS MATLS CLASSIFIED AS NUISANCE PARTICULATES,
FOR EXAMPLE TITANIUM DIOXIDE, CALCIUM CARBONATE, ETC(ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:THEY HAVE CHRONIC LUNG/BRTHG PROBLEMS/IF THEY EVER
HAD RXN TO ISOCYANATE. USE ONLY W/ADEQ VENT. AVOID (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:W/OTHER COMPONENTS BEFORE USE. BEFORE OPENING
PACKAGES, READ & FOLLOW WARNING LABELS ON ALL COMPONENTS.
RTECS #:9999999ZZ
Ingred Name:ING 18:GENERATED BY SANDING OR ABRADING.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: RESP FOR WHOLE TIME OF SPRAYING & UNTIL ALL VAP
& MIST ARE GONE. NO PERSONS SHOULD BE ALLOWED IN AREA(ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:WHERE PROD IS BEING USED UNLESS EQUIPPED W/SAME
RESPIRATORY PROTECTION RECOMMENDED FOR PAINTERS.
RTECS #:9999999ZZ
Ingred Name:VENT: TO OSHA STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:OVEREXP CAUSES EYE/SKIN & RESP
IRRIT.MAY CAUSE NERV SYS DEPRESS ACCOMPANIED BY
HDCH/DIZZ/NAUS/CONFUSION & STAGG GAIT.EXTREME OVEREXP MAY RSLT IN
UNCON & POSS DEATH.MAY CAUSE ALLERGIC RESP RXN IN SUSCEPTIBLE
PERSONS &/OR SKIN & RESP SENSIT. THIS EFT MAY BE DELAYED SEVERAL
HRS AFTER EXPOS.CHRONIC: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVENT
Effects of Overexposure:HLTH HAZ:PRLNGD OVEREXP TO INGS MAY CAUSE
ADVERSE EFTS TO LIVER, URINARY, BLOOD FORMING, & CARDIO-VASCULAR
SYS. PERSONS SENSIT TO ISOCYANATES WILL EXPERIENCE INCR ALLERGIC
RXN ON RPTD EXPOS. RATS EXPO S TO TITANIUM DIOXIDE DUST @ 250 MG/M3
DEVELOPED LUNG CANCER, HOWEVER SUCH EXPOS LEVELS ARE NOT ATTAINABLE
IN (ING 9)
Medical Cond Aggravated by Exposure:NO PERSON SHOULD USE THIS PROD/BE
IN AREA WHERE USED IF THEY HAVE CHRONIC LUNG/BRTHG PROBLEMS OR IF
THEY EVER HAD RXN TO ISOCYANATE.
======================= First Aid Measures =======================
First Aid:INHAL: IF ANY BREATHING PROBLEMS OCCUR DURING USE, LEAVE THE
AREA & GET FRESH AIR. IF PROBLEMS REMAIN OR OCCUR LATER,
IMMEDIATELY GET MEDICAL ATTENTION. SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP A ND WATER. EYES: FLUSH EYES WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MIN. GET MEDICAL ATTENTION.
INGEST: GET MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>25.0F,>-3.9C
Lower Limits:1%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPROVD SCBA & FULL PROT EQUIP.
H*2O SPRAY MAY BE INEFTIVE. IF H*2O IS USED, FOG NOZZ ARE PREF.
H*2O MAY BE USED TO COOL CLSD CONTR (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS, & OPEN FLAME. CLSD CONTR MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICATN TO HOT SURF(SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:USE ONLY W/ADEQ VENT. AVOID BRTH VAPOR & SPRAY MIST.
AVOID CONTACT W/SKIN & EYES. PROTECT AGAINST DUST WHICH MAY
GENERATED BY SANDING/ABRADING DRIED FILM. CONTENTS ARE FLAMMABLE.
KEEP AWAY FROM HEAT/S PARKS/OPEN FLAME. DURING USE (ING 12)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE OVERSPRAY IS PRESENT, NIOSH/MSHA APPRVD
POSITIVE AIR SUPPLIED RESP (TC19C) IS RECOMMENDED. IF UNAVAIL, WEAR
NIOSH/MSHA APPRVD VAP/PARTICULATE RESP WHICH RESP MFR RECOMMENDS AS
EFTIVE FOR ISOCYAN ATE VAP/MIST.
Ventilation:LOC EXHST PREFERABLE. GEN EXHST ACCEPTABLE IF THE EXPOSURE
TO MATLS IN INGRED SEC IS MAINTAINED BELOW APPLICABLE(ING 19)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:NON-LEAD COLORS HI-GLOSS WHITE. FIRE FIGHT PROC:
CLOSED CNTNRS TO PREVENT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN
EXPOSED TO EXTREME HEAT. EXPLO HAZ:REQUIRES SPECIAL PREC. DU RING
EMERGENCY CNDTNS OVEREXP TO DECOMPPROD MAY CAUSE HLTH HAZ. SYMP MAY
NOT BE IMMED APPARENT. GET MEDICAL ATTENTION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>174F,>79C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.96-1.56
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:35-40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CO*2, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 261. WASTE MUST BE TESTED FOR IGNIT TO DETERMINE APPLIC EPA
HAZ WASTE NO. INCINERATE IN APPRVD FACILITY. DO NOT INCINERATE CLSD
CNTNR. DISP OF I /A/W FED, STATE & LOC REGS REGARDING POLLUTION.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:F-152 WHITE EPOXY POLYAMIDE COATING
Kit Part:Y
CAGE:9D157
CAGE:9D157
============= Composition/Information on Ingredients =============
Ingred Name:HARDNER-AMIDO AMIDE, CONTAINING (TETRAETHYLENE PENTAMINE
<%5) (POLYAMINE AMID 95%)
Fraction by Wt: 0.35%
Other REC Limits:NONE RECOMMENDED
Ingred Name:RHEOLOGICAL ADDITIVES
Fraction by Wt: 0.31%
Other REC Limits:NONE RECOMMENDED
Ingred Name:RHEOLOGICAL ADDITIVES
Fraction by Wt: 0.22%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MAGNESIUM SILICATE
CAS:1480-96-6
Fraction by Wt: 4.47%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 11.15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9394
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NAUSEA, DIZZINESS, HEADACHE AND
CONVULSIONS. CHRONIC: POSSIBLE SKIN SENSITIZATION.
Explanation of Carcinogenicity:THIS PRODUCTS INGREDIENTS ARE NOT FOUND
IN NTP, IARC OR OSHA'S LIST.
Effects of Overexposure:INHALED-COUGHING, SHORTNESS OF BREATH, MAY
CAUSE DIZZINESS. CONTACT WITH SKIN OR EYES-BURNING SENSATION, RASH
BREAKOUT WITH SKIN TURNING PINK AND REDNESS OF EYES. ABSORBED
THROUGH SKIN-SKIN RASH MAY C AUSE BURNING OF SKIN INFLAMMATION.
SWALLOWED-VOMITING DUE TO UNPLESANT TASTE. MAY CAUSE DIARRHEA OR
STOMACH CRAMPS.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA AND OTHER
RESPIRATORY DISEASE.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH IMMEDIATELY WITH FRESH WATER BY AN EYE WASH
APPARATUS OR BY HAND. SEEK MEDICAL ATTENTION. SKIN-WASH IMMEDIATELY
WITH WATER. THEN WASH WITH SOAP & WATER, RINSE IMMEDIATELY. SEEK
MEDICAL ATTEN TION.INHALED-MOVE PERSON TO FRESH AIR; ARTIFICIAL
RESPIRATION IF NECESSARY. SEEK MEDICAL ATTENTION. SWALLOWED-SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:101F,38C
Autoignition Temp:Autoignition Temp Text:UNKNON
Lower Limits:1.4
Upper Limits:11.2
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:BLANKET FLAME WITH ONE OF THE ABOVE. DO NOT
ENTER FIRE AREA WITHOUT PROPER PROTECTION & EQUIPMENT INCLUDING
NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:KEEP MATERIAL AWAY FROM HEAT, SPARKS &
OPEN FLAMES. EXPLOSIVE WHEN HEATED. STAY A SAFE DISTANCE FROM FIRE
WHEN EXTINGUISHING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL TYPES OF IGNITION. PROVIDE
SUFFICIENT VENTILATION. PROTECT CLEANUP MAN WITH 8540 3M CORP NIOSH
PROTECTION SECTION).
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN DRY AREA AT ROOM TEMPERATURE,
77F PLUS OR MINUS 5 DEGREES. PREVENT CANS FROM CORROSION &
COSEQUENTLY, SPILLAGE.
Other Precautions:WASH CONTAMINATED EQUIPMENT WITH FRESH WATER.
***RECOMMENDATIONS TO PHYSICIANS: CONSULT WITH THE POISON CONTROL
CENTER. FOR WORKERS WHO ARE EXPOSED REGULARLY, PROVIDE DETAILED
PERIODIC EXAMINATIONS.** *
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ORGANIC VAPOR CARTRIDGE, &/OR ACID GASES
E.G. 8540 3M CORP RESPIRATOR, (NIOSH APPROVED). WHEN USING IN
CONFINED AREA, USE AIR-FED HOOD.
Ventilation:USE LOCAL EXHAUST WHEN APPLYING MATERIAL IN CONFINED AREAS.
KEEP VAPOR BELOW TLV.
Other Protective Equipment:USE PROTECTIVE CLOTHING AND CHANGE
CONTAMINATED CLOTHING IMMEDIATELY. PROVIDE EMERGENCY SHOWERS &
EYEWASH FOUNTAINS.
Work Hygienic Practices:TRAIN EMPLOYEES ON ALL SPECIAL HANDLING
PROCEDURES IN THIS SECTION BEFORE THEY WORK WITH THIS PRODUCT.
Supplemental Safety and Health
REPORTS HAVE SHOWN THAT ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS CAN CAUSE PERMANENT BRAIN AND NERVOUS
SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS MAY BE HARMFUL ORFATAL. USE ONLY WITH
ADEQUATE VENTILATION.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:244F,118C
Melt/Freeze Pt:M.P/F.P Text:128F,53C
Vapor Pres:4.8
Vapor Density:2.1
Spec Gravity:1.3
Evaporation Rate & Reference:0.43 (N-BUTYL ACETATE=1)
Solubility in Water:POOR
Appearance and Odor:TYPICAL PAINT APPERANCE WITH STRONG SOLVENT ODOR
TYPICAL OF BUTANOL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WHEN "A" AND "B" ARE MIXED, KEEP AWAY FROM HEAT. HEAT WILL CREATE A
RAPID CHEMICAL REACTION. EMITS HEAT.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAMES. DO NOT ALLOW
VAPOR TO ACCUMULATE.
Hazardous Decomposition Products:COMBUSTIBLE FUMES MAY ACCUMULATE IN
CONFINED AREA & SPARKS OR OPEN FLAMES MAY IGNITE IT
Conditions to Avoid Polymerization:HEAT, SPARKS AND OPEN FLAMES WHEN A
& B ARE MIXED.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE ANY KIND OF ABSORBENT TO ABSORB SPILLED
MATERIAL AND PUT IN A METAL CONTAINER MARKED "DO NOT USE THIS
MATERIAL". DISPOSE OF LEGALLY. DISPOSE OF ALL WASTE IN ACCORDANCE
WITH FEDERAL, STATE AND LOCA L REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:S374-300L SODIUM PHOSPHATE DIBASIC ANHYDROUS 08330
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PHOSPHATE, DIBASIC, ANHYDROUS, DISODIUM PHOSPHATE
CAS:7558-79-4
RTECS #:WC4500000
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 17 GM/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION: GI
IRRITATION. INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: FLUSH
W/PLENTY OF SOAP & WATER FOR 15 MINS. INGESTION: IF CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. INHALATION: REMOVE TO FRESH
AIR. GIVE CPR/ OXYGEN IF NEEDED. NOTES TO PHYSICIAN: TREAT
SYMPTOMATICALLY & SUPPORTIVELY. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:SMALL: DRY CHEMICAL, CO2, WATER
SPRAY/ALCOHOL-RESISTANT FOAM. USE EXTINGUISHING MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR APPROPRIATE PROTECTIVE CLOTHING & SCBA.
Unusual Fire/Explosion Hazard:MATERIAL WILL NOT BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT.
VACUUM/SWEEP UP MATERIAL & PLACE INTO A SUITABLE DISPOSAL
CONTAINER. AVOID GENERATING DUSTY CONDITIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A TIGHTLY CLOSED CONTAINER.
STORE IN A COOL DRY WELL VENTILATED AREA AWAY FROM INCOMPATIBLE
SUBSTANCES. USE W/ADEQUATE VENTILATION.
Other Precautions:AVOID INGESTION & INHALATION. AVOID CONTACT W/EYES &
SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:ADEQUATE TO KEEP AIRBORNE CONCENTRATIONS LOW.
Other Protective Equipment:PROTECTIVE CLOTHING.
Supplemental Safety and Health
PH: 8.7-9.3.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:118F
Spec Gravity:1.67
pH:(SUPP)
Solubility in Water:104%
Appearance and Odor:WHITE CRYSTALLINE SOLID; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/STRONG OXIDIZERS, ALKALOIDS, LEAD ACETATE, ANTIPYRINE,
CHLORAL HYDRATE, RESORCINOL & PYROGALLOL.
Stability Condition to Avoid:AIR
Hazardous Decomposition Products:OXIDES OF PHOSPHORUS, SODIUM OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:OXO-SOLV
CAGE:06645
CAGE:06645
============= Composition/Information on Ingredients =============
Ingred Name:N-AMYL ACETATE (SARA III)
CAS:628-63-7
RTECS #:AJ1925000
Fraction by Wt: <5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: <5%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AROMATIC PETROLEUM DISTILLATES (BENZENE FREE)
Fraction by Wt: 80%
ACGIH TLV:200PPM (MFR)
===================== Hazards Identification =====================
Effects of Overexposure:SKIN & EYE:IRRITATION. INH OF VAPORS:NAUSEA,
DIZZINESS
======================= First Aid Measures =======================
First Aid:SKIN: WASH WELL W/WATER. EYES;FLUSH W/ WATER FOR 15 MINUTES.
INH:REMOV TO WELL VENTILATED AREA.
===================== Fire Fighting Measures =====================
Flash Point:170F; 77C COC
Extinguishing Media:CO*2
Fire Fighting Procedures:SCBA
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WASH AREA WELL W/ DETERGENT & WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AREA AWAY FROM HEAT
W/ CONTAINER TIGHTLY CLOSED. OPEN CONTAINERS SLOWLY TO PREVENT
PRODUCT EXPULSION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL EXHAUST RECOMMENDED TO KEEP BELOW TLV
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:320F;160C
Spec Gravity:0.900
Solubility in Water:EMULSIFIES
Appearance and Odor:CLEAR AMBER LIQUID W/ ETHYL ACETATE ODOR.
Percent Volatiles by Volume:9.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECOMMENDS FLUSHING DOWN DRAIN & BURYING
CONTAINER. DISPOSAL METHOD MUST BE IAW FEDERAL, STATE & LOCAL
CODES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:VINAC BEADS SM-3
CAGE:00742
CAGE:00742
============= Composition/Information on Ingredients =============
Ingred Name:VINYL ACETATE-CROTONIC ACID COPOLYMER BEADS (LIMITS GIVEN
BY MFR FOR VINYL ACETATE, CAS 108-05-4)
CAS:25609-89-6
OSHA PEL:10 PPM; 20 PPM STEL
ACGIH TLV:10 PPM; 20 PPM STEL
Ingred Name:RESIDUAL MONOMER
Fraction by Wt: <0.5%
Ingred Name:DISPERSANTS
Fraction by Wt: <0.1%
Ingred Name:NUISANCE DUST (PARTICULATES NOT OTHERWISE CLASSIFIED)
Other REC Limits:PEL:5 MG/M3 RDUST
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL)>5000 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO ADVERSE EFFECTS OF ACUTE OR CHRONIC
EXPOSURE HAVE BEEN REPORTED. THIS PRODUCT MAY CONTAIN SMALL AMTS
(<0.5%) OF VINYL ACETATE MONOMER, VAPORS OF WHICH HAVE BEEN SHOWN
TO CAUSE TUMORS OF RESPIRATORY TRACT OF LAB ANIMALS. NO EVIDENCE
THATVINYL ACETATE HAS CAUSED CANCER IN HUMANS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:OVEREXPOSURE IS UNLIKELY TO
AGGRAVATE EXISTING MEDICAL CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYE:IRRIGATE W/WATER FOR AT LEAST 15 MINUTES. INGEST:GIVE
COPIOUS QTYS OF WATER & INDUCE VOMITING. INGESTION OF SMALL AMTS (1
TO 2 TEASPOONS) REQUIRES NO TREATMENT. SKIN:WASH W/WATER .
INHAL:REM OVE TO FRESH AIR. SUPPORT BREATHING (GIVE O2/ARTIFICIAL
RESPIRATION) . CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY OR MULTI-PURPOSE DRY CHEMICAL.
Fire Fighting Procedures:PROD WILL BURN & SUPPORT COMBUSTION WHEN
IGNITED. WHEN BEADS BURN, WATER, CO2, CO, ACETIC ACID & SMOKE ARE
PRODUCED. NIOSH/MSHA APPROVED SCBA (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:NO EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:PROD IS SHIPPED IN FIBER DRUMS/POLYOLEFIN
BAGS. BROKEN BAGS WILL RELEASE BEAD POLYMER WHICH ON HARD SURFACES
CREATES SEVERE FALLING HAZARD. CARE MUST BE TAKEN TO PREVENT SUCH
SPILLAGE & TO INSTITUTE C LEANUP PROCEDURES IN EVENT SPILL OCCURS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL CLEANLINESS SHOULD BE OBSERVED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:VENT ADEQ TO MAINTAIN DUST LEVELS BELOW 10MG/M3 UNDER MOST
ADVERSE COND (OPEN HNDLG SYS/LEAKY CONVEYORS) IS RECOMMENDED.
Other Protective Equipment:NONE.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
FIRE FIGHT PROC:SHOULD BE USED WHEN FIGHTING FIRES, ESPECIALLY IN
ENCLOSED SPACES SUCH AS WAREHOUSES.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:<1
Spec Gravity:1.2 @ 25C
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS TO PALE YELLOW, SMALL RIGID BEADS OR
SPHERES, NON-VOLATILE.
Percent Volatiles by Volume:0.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
IT WILL UNDERGO HYDROLYSIS IN PRESENCE OF ALKALI TO POLYVINYL ALCOHOL,
A WATER SOLUBLE POLYMER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PYROLYSIS AT TEMPS ABOVE 150C WILL
PRDCE ACETIC ACID, CARBON MONOXIDE, CARBON DIOXIDE & HYDROCARBON
FRAGMENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION OR LANDFILL I/A/W FEDERAL, STATE
AND LOCAL REGULATIONS IS RECOMMENDED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:2937 PRIMER CUSTOM SPRAY ENAMEL 3OZ AEROSOL
CAGE:FO415
CAGE:87890
CAGE:FO415
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBON PROPELLANT
CAS:68476-86-8
Fraction by Wt: 20-25%
OSHA PEL:1000 PPM (MFR)
ACGIH TLV:936 PPM (MFR)
Ingred Name:VM&P NAPHTHA
CAS:64742-89-8
Fraction by Wt: 15-20%
OSHA PEL:300 PPM (MFR)
ACGIH TLV:300 PPM (MFR)
Ingred Name:LACQUER DILUENT
CAS:64742-89-8
Fraction by Wt: 5-10%
OSHA PEL:400 PPM (MFR)
ACGIH TLV:400 PPM (MFR)
Ingred Name:MINERAL SPIRITS
CAS:64742-88-7
Fraction by Wt: 5-10%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 5-10%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 1-5%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:ZINC STEARATE
CAS:557-05-1
RTECS #:ZH5200000
Fraction by Wt: 1-5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 20-25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CONTACT W/LIQ GAS/GAS UNDER PRESS
MAY CAUSE BURNING DUE TO FREEZING EFT.RESULT MAY BE SLIGHT EYE
IRRIT.SKIN: CONTACT W/LIQ GAS/GAS UNDER PRESS MAY CAUSE BURNING DUE
TO FREEZING EFT.MAY RESULT IN DRYING OF SKIN/DERMATITIS.INGEST:MAY
RESULT IN VOM.ASPIR OF VOM INTO LUNGS MUST BE AVOIDED AS EVEN(EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HTH HAZ:SMALL QTYS IN LUNGS MAY RESULT IN CHEM
PNEUMONITIS AND PULM EDEMA.INHAL:EXPOS TO HIGH VAP CONC MAY PDCE
ANESTH EFT.INITIAL SYMPS AT HIGH CONC ARE DISORIENTATION, LACK OF
COORD, HDCH, & NAUS.CO NTINUED EXPOS MAY RESULT IN UNCON/DEATHDUE
TO O2 DEFICIENCY. CHRONIC: CAN LEAD TO CNS DEPRESSION (SEE SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:WASH IMMED W/PLENTY OF WATER FOR AT LEAST 15 MIN WHILE
HOLDING EYELIDS OPEN.CALL MD.SKIN: WASH IMMED W/MILD SOAP & WATER.
TREAT BURNED/FROSTBITTEN SKIN BY IMMERSING IN LUKEWARM WATER. IF
SKIN IS NOT BURNED,KEEP WARM & STIMULATE W/MASSAGE.CALL
MD.INHAL:REMOVE TO FRESH AIR.IF UNCON APPLY ARTF RESP/OXYGEN.CALL
MD.INGEST:DO NOT INDUCE VOM.CALL MD.IF VOM OCCURS,KEEP HEAD BELOW
HIPS TO PVNT ASPIR
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:<-40F,<-40C
Lower Limits:1.0
Upper Limits:12.0
Extinguishing Media:ALCOHOL RESISTANT FOAM, CO2 OR DRY CHEMICAL.
Fire Fighting Procedures:STREAM OF WATER COULD SPREAD FIRE.AVOID
BREATHING VAPORS.COOL FIRE EXPOSED CONTAINERS WITH WATER. WEAR
NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIP.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND MAY TRAVEL
A LONG DISTANCE TO IGNITION SOURCE AND FLASH BACK. HEAT MAY CAUSE
BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL POSSIBLE IGNITION SOURCES.
PROVIDE ADEQUATE VENTILATION.TAKE UP W/AN ABSORBENT MATERIAL &
PLACE IN NON-LEAKING CONTAINER.SEAL FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ ALL LABEL CAUTIONS.STORE AWAY
FROM IGNITION SOURCES IN A COOL WELL VENTILATED AREA.HANDLE AS
EXTREMELY FLAMMABLE LIQUID & GAS.DO NOT DROP CNTNR.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF PRODUCT/ANY COMPONENT OF IT IS
EXCEEDED, A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGULATIONS ALSO
PERMIT OTHER NIOSH/MSHA RESPIRATOR S UNDER SPECIFIC CONDITIONS.
Ventilation:PROVIDE SUFFICENT MECH(GEN/LOCAL EXHST)VENT TO MAINTAIN
EXPOS BELOW TLV(S).EXPLOSION PROOF EQUIPMENT IS ADVISED.
Other Protective Equipment:AS REQUIRED TO AVOID SKIN CONTACT/BREATHING
VAPORS. EMERGENCY EYE WASH & DELUGE SHOWER
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: PRODUCING SUCH EFFECTS AS HEADACHE, DIZZINESS, NAUSEA
AND LOSS OF CONSCIOUSNESS. EYE PROT: ADD FULL LENGTH FACESHIELD TO
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:-44F,-42C
Vapor Pres:50 PSIG
Vapor Density:2.7
Spec Gravity:0.839
Evaporation Rate & Reference:>1 (ETHER =1)
Solubility in Water:7%
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:84.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, SPARKS, FLAME AND 0THER
IGNITION SOURCES.
Hazardous Decomposition Products:CO IF BURNED W/INSUFFICIENT AIR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE CLOSED CONTAINERS.DISPOSE OF
IN ACCORDANCE W/LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ENAMEL ALKYD SG BLACK 27038 ID 745752
Preparer's Name:W.A. ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
Other REC Limits:10 MIN.
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 10%
OSHA PEL:100 PPM
Ingred Name:ISOBUTYL ALCOHOL (SARA III)
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 5%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 15%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:SILICA, CRYSTALLINE-CRISTOBALITE
CAS:14464-46-1
Fraction by Wt: 5%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 5%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FORMALDEHYDE (SARA III)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 1%
Other REC Limits:15 MIN
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM; A2; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOBUTYL ACETATE (SARA III)
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 5%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:LACTOL SPIRITS
CAS:64742-89-8
Fraction by Wt: 10%
ACGIH TLV:400
Ingred Name:VOC. ORGANIC CMPD 3.77 LB/GAL LESS WATER & NPRS* 452 G/L
LESS WATER VOC. 8.82 LB/GAL SOLIDS 1058 G/L SOLIDS CALCU
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ASPIRATION OF MATERIAL INTO LUNG MAY
CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. LIQUID MATERIAL MAY
ABSORBED THROUGH THE SKIN IN HARMFUL AMOUNTS.
Explanation of Carcinogenicity:TOLUENE HAS BEEN FOUND TO CAUSE KIDNEY,
LUNG AND SPLEEN DAMAGE IN LABORATORY ANIMALS.
Effects of Overexposure:OVEREXPOSURE MAY CAUSE INJURY TO THE LIVER,
KIDNEYS, AND BLOOD.REPEATED EXPOSURETOCRYSTALLINE SILICA MAY CAUSE
PNEUMOCONIOSIS, A PROGRESSIVELY DISABLING LUNG DISEASE.
======================= First Aid Measures =======================
First Aid:IF SWALLOWED DO NOT INDUCE VOMITING. CALL P.C.C, HOSPITAL ER
OR DR. IMMEDIATELY.INALATION: REMOVE TO FRESH AIR IMMEDIATELY. IF
BREATHING HAS STOP DO CPR. CALL DR. EYE: FLUSH WITH LARGE AMOUNTS
OF WATE R, LIFTING EYE LIDS OCCASIONALLY. CONTINUE FOR 15 MIN. CALL
DR. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AREA WITH SOAP AND
WATER. TREATMENT FOR EXPOSURE SHOULD BE DIRECTED AT THE CONTROL OF
SYMTOMS.
===================== Fire Fighting Measures =====================
Flash Point:1F/-17.22 C
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGUISHERS. USE POLYMER
FOAM FOR THE LARGER FIRES.
Fire Fighting Procedures:SCBA. WATER MAY BE INEFFECTIVE IF WATER IS
USED FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:SYMTOMS MAY NOT BE IMMEDIATELY APPARENT.
VAPORS MAY CAUSE FLASH FLOODS DANGER, DANGER,
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES, DIKE AND
CONTAIN SPILL WITH INERT MATERIAL. PLACE ABSORBENT DIKING MATERIALS
IN COVERD METAL CONTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 95 DEGREES F. STORE
IN LARGE QUANITIES IN COMPLIANCE WITH OSHA 29CFR1910
Other Precautions:DO NOT TAKE INTERNALLY. CLOSED CONTAINER AFTER EACH
USE. DO NOT BREATH SANDING DUST. EMPTY CONTAINERS MUST NOT BE
WASHED AND RE-USED FOR ANY PURPOSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESTRICTED AREAS A NIOSH APPROVED CHEMICAL
CARTRIDGE RESPIRATER MAY BE REQUIRED.SPRAYING, A MECHANICAL
PREFILTER MAYALSO BE REQUIRED. IN CONFINED ARES USE A NIOSH/MSHA
APPROVED AIR SUPPLIED RESPIRATER
Ventilation:GENERAL DILUTION AND LOCAL EXHAUST
Other Protective Equipment:NOT LIKELY TO BE NEEDED
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:182-302F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THEN ETHER
Percent Volatiles by Volume:57%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING,INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE AND CARBON
DIOXIDE.
Conditions to Avoid Polymerization:IT WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL LAWS. INCINERATE ONLY IN EPA PERMITTED FACILITY.DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:33-310 CITGO TRACTOR HYDRAULIC FLUID
CAGE:7X110
CAGE:7X110
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM OIL (TOTAL PERCENTAGE OF INGREDIENTS 1 THROUGH 4
: 75 - 92)
CAS:64741-89-5
RTECS #:PY8041500
Fraction by Wt: SEE ING
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:ANTI-WEAR AND VI IMPROVER(CONTAINS ZN DITHIOSPHATE)
Fraction by Wt: 8-12%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES,HYDROTREATED
(MILD),HEAVY PARAFFINIC
CAS:64742-54-7
RTECS #:PY8035500
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:ANTI-FOAM
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ANTI-WEAR
Fraction by Wt: 8 - 12%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DISPENSING AGENT
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ANTI-FOAM
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:GENERAL TOXICITY LOW.INHAL:LOW RISK OF
INHAL @AMB TEMP.MIST/FUMES MAY CAUSE DRWS,DIZZ,HEAD,NAU,LUNG
IRRIT,CHEM PNEUMONITIS.DERMAL:TRANSIENT,SLIGHT IRRIT.EYE:MAY BE
MILDLY IRRIT.INGEST:LOW TOXICITY.@SA YBOLT VISC 300SUS(100F) RISK
OF ASPIRATAION INTO LUNGS MINIMAL.<1OZ INGEST MAY PASS THRU SYS W/O
HARM.LG QUANT (SUPPLE)
Explanation of Carcinogenicity:PER MSDS:CARCINOGEN/ANIMAL
CARCINOGEN/SUSPECTED CARCINOGEN:NO.LISTED BY
NTP/IARC/OSHA/OTHER:NO.
Effects of Overexposure:DROWSINESS, DIZZINESS, HEADAHCES, NAUSEA, LUNG
IRRITATION. CHEMICAL PNEUMONITIS. SKIN:TANSIENT, SLIGHT IRRIT. MILD
EYE IRRIT. ASPIRATION HAZ, INGEST LG AMTS SLIGHT GI DISCOMFORT,
DIARRHEA, HEADAHCES. SUBCUTANEOUS/INTRAMUSCULAR INJECTION MAY
CAUSE IRRIT,ERYTHEMA,EDEMA. DRYING,CRACKING (DERM) OR FOLLICULITIS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.RESP SUPPORT IF NECESSARY.SEEK MED
AID. DERMAL:WASH W/SOAP/WATER. EYE:FLUSH W/LG VOL OF WATER.SEEK
PHYSICIAN IF ANY COMPLIACATIONS ARISE. INGEST:DO NOT INDUCE
VOMIT.SEEK MED AID. INJECT:SUBCUTANCOUS INJECTION IS MED
EMERG.SEEK MED AID IMMED. NOTE TO DR:ON INGEST AN OIL SAYBOLT VISC
300SUS(100F) ASPIRATION POTENTIAL INTO LUNGS MIN.LG QUANT SHOULD
STILL BE REMOVED BY LAVAGE
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:399F,204C
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF HEAT/IGN,PROVIDE ADEQUATE
VENTILATION,CONTAIN LEAK.SM:ABSORB W/SUITABLE MATL
(RAGS,STRAW,SAND).PLACE INTO CNTNR FOR LATER REMOVAL.LG:CONTAIN
SPILL IN EARTHEN DIKES FOR LATER RECOVERY .REPORT SPILLS AS
REQUIRED TO APPROP AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BEL 150F.DO NOT APPLY HIGH
HEAT/FLAME TO CNTNR.KEEP SEPARATE FROM STRONG OXIDIZING
AGENTS.EMPTY CNTNR MAY CONTAIN PROD RESIDUE-FLAMM/EXPLO VAP.
Other Precautions:DO NOT INHAL MIST/FUMES.PREVENT DIRECT DERMAL CONTACT
W/OIL.PRODUCT MAY CONTAIN SMALL QUANTITIES OF ZINC
DITHIOPHOSPHATE.REPAIR/MAINTAINCE:SEE PPE INFO;AVOID PROL COTNACT
W/USED OIL;WASH EXPO SKIN WEL L W/SOAP/WATER;REMOVE SOILED
CLOTH;(SUP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NONE REQUIRED.IF HIGH VAP/MIST CONC
EXPECTED USE RESP APPROVED FOR ORGANIC VAPORS/MISTS.
Ventilation:USE IN WELL VENTI AREA.CONFINED SPACE MECH VENTI MAY BE
REQUIRED TO KEEP LEVELS OF CERTAIN COMPO BEL MANDATED STDS
Other Protective Equipment:WEAR BODY-COVERING WORK CLOTHES TO AVOID
PROLONGED/REPEATED EXPOSURE.
Work Hygienic Practices:DO NOT WEAR HEAVILY CONTAMIN CLOTH BEF
LAUNDERING.
Supplemental Safety and Health
HEALTH HAZ:SLIGHT GI DISCOMFORT,DIARR,HEAD MAY
OCCUR.INGEST:SUBCUTANEOUS;INTRAMUSCULAR INJECTION MAY CUASE
IRIRT,ERYTHEMA,EDEMA.CHRONIC:PROL/FREQ CONTACT MAY CAUSE
DRHING,CRACKING(DERM),FOLLICULITIS. OTHER PRECAUT:USE OIL IMPERV
DISPO:RECOND/RECLAIM/RECYC/DISPO EMTPY CNTNR/RESIDUE
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:649F,343C
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:N/DETERMIN
Vapor Density:>1
Spec Gravity:0.88
pH:NA
Evaporation Rate & Reference:<1, (N-BUTYL ACETATE=1)
Solubility in Water:NEGIGLIBLE.
Appearance and Odor:AMBER LIQUID, MILD ODOR.
Percent Volatiles by Volume:NEGLIG
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CO2, (CO UNDER INCOMPLETE COMBUSTION).
==================== Disposal Considerations ====================
Waste Disposal Methods:IT'S RESPONSIBILITY OF USER TO DETERMINE IF MATL
HAZ WASTE @TIME OF DISPO.CHECK BEF DISPO TO BE SURE YOU'RE IN
COMPLIANCE W/ALL APPLICABLE LAWS/REGS.CHEMTREC/RCRA EMERG
HOTLINE#:800-424-9346.CONSULT A PPROP FED/STAET/LOC AUTHORITIES BEF
(SUPPLEMEN)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SILVER-ZINC BATTERY BA-586/D WITH SQUIB
Preparer's Name:HMIS
CAGE:82577
CAGE:0B3X4
CAGE:81855
CAGE:82577
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 48%
Other REC Limits:NONE SPECIFIED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILVER (SARA III)
CAS:7440-22-4
RTECS #:VW3500000
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:ELECTROLYTE: INHALATION: COUGHING, WHEEZING,
SHORTNESS OF BREATH. EYES: REDNESS, TEARING, BURNS, PAIN. SKIN:
REDNESS, RASH, BURNS. INGESTION: SEVERE STOMACH PAIN, NAUSEA,
VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN AND RESPIRATORY
CONDITIONS MAY BE AGGAVATED BY EXPOSURE TO ELECTROLYTE LIQUID OR
VAPOR.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH WITH PLENTY OF
WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL HELP. SKIN: FLUSH WITH
WATER; THEN WASH WITH SOAP AND WATER. INGESTION: DO NOT INDUCE
VOMITING. GIVE SEVERAL GLASSES OF WATER TO CONSCIOUS VICTIM. GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:HEAT OF FIRE WILL ACTUATE THE IGNITER,
BATTERY MIGHT EXPLODE, ACRID SMOKE FROM BURNING BATTERY.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. WEAR PROPER PROTECTIVE
CLOTHING. VENTILATE THE AREA. NEUTRALIZE. ABSORB WITH INERT
MATERIAL AND PLACE IN CONTAINER FOR DISPOSAL.
Neutralizing Agent:5% ACETIC ACID SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID SHORT CICUITING OR OVERCHARGING.
STORE IN A DRY, COOL AREA.
Other Precautions:NONE KNOWN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:CLOTHING TO PREVENT REPEATED OR PROLONGED
CONTACT WITH ELECTROLYTE. EYE WASH STATION & SAFETY SHOWER
AVAILABLE.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
BATTERY CONTAINING A SINGLE SQUIB, WHEN ACTUATED PUSHES THE ELECTROLYTE
INTO THE BATTERY CELLS. THE SQUIB IS BURRIED INSIDE THE BATTERY AND
IS VERY TINY, EVEN IF IT EXPLODES ONE WOULD NOT NOTICE IT. T HE
ONLY HAZARDOUS PART IN THIS ITEM ISELECTROLYTE. THIS INFO PROVIDED
BY KAREN DAVIS AT IMSD HEAD QTR,INDIAN HEAD, MD.
================== Physical/Chemical Properties ==================
HCC:B1
Spec Gravity:1.45 KOH
pH:UNKNON
Solubility in Water:COMPLETE FOR KOH
Appearance and Odor:BATTERY, NO ODOR. 28/100 V DC
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS AND SOLVENTS
Stability Condition to Avoid:SHORT CIRCUITING, OVERCHARGING.
Hazardous Decomposition Products:METAL OXIDES, FLAMMABLE HYDROGEN GAS,
ALKALI FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. RECYCLE METALS. CONTAINS SILVER (EPA WASTE
(#D011) AND ZINC. ALSO MAY EXHIBIT CHARACTERISTICS OF EPA WASTE
DOO2 (CORROSIVE).
======================================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CONFIDENCE 10 04880
Preparer's Name:STEVEN W. MIEFERT
CAGE:DUBOI
CAGE:73042
CAGE:DUBOI
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <2%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: <5%
Other REC Limits:2 MG/CUM (CEILING)
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: CORROSIVE/SENSITIVE. EYES:
CORROSIVE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: CORROSIVE/SENSITIVE. EYES: CORROSIVE.
Medical Cond Aggravated by Exposure:SENSITIZATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/FRESH WATER, GET MED ATT. SKIN:
FLUSH W/FRESH WATER. REMOVE CONTAMINATED CLOTHES/SHOES. INGESTION:
GIVE MILK, WATER OR EGG WHITES. DON'T INDUCE VOMITING, GET MED ATT.
===================== Fire Fighting Measures =====================
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:CO2, DRY CHEMICAL, WATER
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SMALL AMOUNTS TO DRAIN; COLLECT LARGE
AMOUNTS & RETURN TO CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T PRESSURE CONTAINER TO EMPTY.
KEEP CONTAINER CLOSED. IF FROZEN, THAW/MIX TO MAKE USABLE.
Other Precautions:DOT CORROSIVE UN-1760.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:MECHANCIAL
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:215F
Vapor Pres:17.5
Spec Gravity:1.185
Evaporation Rate & Reference:(N-BU AC = 1): >1
Solubility in Water:100%
Appearance and Odor:AMBER LIQUID; MILD ODOR.
Percent Volatiles by Volume:70%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:IF FROZEN, THAW/MIX TO MAKE USABLE
Hazardous Decomposition Products:OXIDES OF CARBON, HYDROGEN, SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:USE UNTIL <1 INCH REMAINS IN CONTAINER, EMPTY
CONTAINER. TRIPLE RINSE CONTAINER W/WATER, ADD TO OPERATION. REMOVE
OR DEFACE CONTAINER LABEL BEFORE SELLING OR DISPOSAL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:191 5834,PT A,KODAK SPEEDCHECK RA BLEACH-FIX AND REPLENISHER
Kit Part:Y
Preparer's Name:NOT PROVIDED
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:50.
Maxumum % Wt:55.
Other REC Limits:NOT PROVIDED
Code:F
Code:F
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Minumum % Wt:35.
Maxumum % Wt:40.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:SODIUM BISULFITE
CAS:7631-90-5
RTECS #:VZ2000000
Minumum % Wt:5.
Maxumum % Wt:10.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:5 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM BISULFITE
CAS:10192-30-0
RTECS #:WT3595000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM SULFITE
CAS:10196-04-0
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF EXPOSURE: INHALATION:
EXPECTED TO BE A LOW HAZARD FOR RECOMMENDED HANDLING. IN CONTACT
WITH STRONG ACIDS OR IF HEATED, SULFITES MAY LIBERATE SULFUR
DIOXIDE GAS. SULFUR DIOXIDE GAS IS IRRITA TING TO THE RESPIRATORY
TRACT. SOME ASTHMATICS OR HYPERSENSITIVE INDIVIDUALS MAY EXPERIENCE
DIFFICULT BREATHING. EYES: CAUSES IRRITATION. SKIN: THIS MATERIAL
HAS A LOW POTENTIAL TO CAUSE ALLERGIC SKINREACTIONS; HOWEVER,
CASES OF HUMAN SKIN SENSITIZATION HAVE BEEN REPORTED. INGESTION:
MAY BE HARMFUL IF SWALLOWED. MAY CAUSE IRRITATION OF THE
GASTROINTESTINAL TRACT IF SWALLOWED.
Explanation of Carcinogenicity:CARCINOGENICITY CLASSIFICATION
(COMPONENTS PRESENT AT 0.1% OR MORE): - INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER (IARC): NONE - AMERICAN CONFERENCE OF
GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH): NON E - NATIONAL
TOXICOLOGY PROGRAM (NTP): NONE - OCCUPATIONAL SAFETY AND HEALTH
ADMINISTRATION (OSHA): NONE
Effects of Overexposure:INHALATION: IN CONTACT WITH STRONG ACIDS OR IF
HEATED, SULFITES MAY LIBERATE SULFUR DIOXIDE GAS. SULFUR DIOXIDE
GAS IS IRRITATING TO THE RESPIRATORY TRACT. SOME ASTHMATICS OR
HYPERSENSITIVE INDIVIDUAL S MAY EXPERIENCE DIFFICULT BREATHING.
EYES: CAUSES IRRITATION. INGESTION: MAY CAUSE IRRITATION OF THE
GASTROINTESTINAL TRACT IF SWALLOWED.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS, HYPERSENSITIVE OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING,
WHEEZING, CHEST TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS,
WEAKNESS AND DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:
IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTEN TION IF SYMPTOMS OCCUR. SKIN: WASH WITH SOAP AND
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. INGESTION: DRINK
1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION. NEVER GIVE ANYTHING
BY MOUTH TO AN UNCO NSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:FLOOD WITH WATER.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:SOLUTION CONTAINS A STRONG REDUCING
AGENT. DRIED PRODUCT RESIDUE CAN ACT AS A REDUCING AGENT
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
CLEAN SURFACE THOROUGHLY TO REMOVERESIDUAL CONTAMINATION.
Neutralizing Agent:NOT PROVIDED
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED TO
PREVENT THE LOSS OF WATER. KEEP AWAY FROM INCOMPATIBLE SUBSTANCES
KEEP AWAY FROM COMBUSTIBLE MATERIAL. KEEP FROM CONTACT WITH
OXIDIZING MATERIALS, HIGHLY OXYGENATED OR HALOGENATED SOLVENTS,
ORGANIC COMPOUNDS CONTAINING REDUCIBLE FUNCTIONAL GROUPS.
Other Precautions:AVOID BREATHING MIST OR VAPOR. AVOID CONTACT WITH
EYES AND PROLONGED OR REPEATED CONTACT WITH SKIN. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING. REMOVE AND WASH
CONTAMINATED CLOTHING PROMPTLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. A RESPIRATOR SHOULD BE
WORN IF HAZARDOUS DECOMPOSITION PRODUCTS ARE LIKELY TO BE OR HAVE
BEEN RELEASED. RESPIRATOR TYPE: ACID GAS. SEE STABILITY AND
REACTIVITY SECTION. IF RESP IRATORS ARE USED, A PROGRAM SHOULD BE
INSTITUTED TO ASSURE COMPLIANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER
HOUR) SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO
CONDITIONS.
APPROPRIATE FOR RISK OF EXPOSURE
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:IT IS A GOOD INDUSTRIAL HYGIENE PRACTICE TO
MINIMIZE SKIN CONTACT.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:(68F):24 MBAR(18MM HG)
Vapor Density:0.6
Spec Gravity:1.3
pH:5.5
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID ODOR: AMMONIA
Percent Volatiles by Volume:50-55 BY WT
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS, STRONG
ACIDS, COMBUSTIBLE MATERIAL, HALOGENATED MATERIALS. CONTACT WITH
BASE LIBERATES FLAMMABLE MATERIAL.
Stability Condition to Avoid:NOT PROVIDED
Hazardous Decomposition Products:AMMONIA, CHLORAMINE, SULFUR DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:EFFECTS OF EXPOSURE: INHALATION: EXPECTED TO
BE A LOW HAZARD FOR RECOMMENDED HANDLING. IN CONTACT WITH STRONG
ACIDS OR IF HEATED, SULFITES MAY LIBERATE SULFUR DIOXIDE GAS.
SULFUR DIOXIDE GAS IS IRRITA TING TO THE RESPIRATORY TRACT. SOME
ASTHMATICS OR HYPERSENSITIVE INDIVIDUALS MAY EXPERIENCE DIFFICULT
BREATHING. EYES: CAUSES IRRITATION. SKIN: THIS MATERIAL HAS A LOW
POTENTIAL TO CAUSE ALLERGIC SKIN REACTIONS; HOWEVER, CASES OF
HUMAN SKIN SENSITIZATION HAVE BEEN REPORTED. INGESTION: MAY BE
HARMFUL IF SWALLOWED. MAY CAUSE IRRITATION OF THE GASTROINTESTINAL
TRACT IF SWALLOWED.
===================== Ecological Information =====================
Ecological:THE FOLLOWING PROPERTIES ARE ESTIMATED FROM THE COMPONENTS
OF THE PREPARATIONS. POTENTIAL TOXICITY: FISH LC50 MG/L: >100.
DAPHNID EC50 MG/L: >100.ALGAL IC50 MG/L: >100. ORGANICS
READILY DEGRAD ABLE (>70%): YES (7 DAYS). POTENTIAL
BIOACCUMULATION: LOG POW <1. COD (APPROXIMATE G/L): 257. BOD5
(APPROXIMATE G/L): 212. POTENTIAL TOXICITY: WASTE TREATMENT
MICROORGANISMS EC50 (MG/L): NOT AVA ILABLE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
=================== MSDS Transport Information ===================
Transport Information:FOR TRANSPORTATION INFORMATION REGARDING THIS
PRODUCT CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE:
(716) 722-2400 BETWEEN 8 A.M. AND 5 P.M. (EASTERN STANDARD TIME),
MONDAY THROUGH FRIDAY .
===================== Regulatory Information =====================
SARA Title III Information:CHEMICAL(S) SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OR TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986 AND 40 CFR
PART 372: AMMONIUM THIOSULFATE, AMMONI UM BISULFITE, AMMONIUM
ACETATE (AS SOURCES OF AQUEOUS AMMONIA.)
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: NONE - MATERIAL(S) KNOWN TO THE STATE
OF CALIFORNIA TO CAUSE ADVERSE REPRODUCTIVE EFFECTS: NONE
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:WHA 204 URINARY SEDIMENT STAIN
CAGE:34795
CAGE:34795
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM OXALATE
CAS:5972-73-6
Fraction by Wt: <1%
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL, SYNASOL *96-4*
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: <9.5%
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:SAFRANIN, SAFRANINE O *96-4*
CAS:477-73-6
RTECS #:SG1623000
Fraction by Wt: <1%
Ingred Name:HEXAMETHYLPARAROSANILINE CHLORIDE; CRYSTAL VIOLET
CAS:548-62-9
RTECS #:BO9000000
Fraction by Wt: <1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ETHANOL MAY BE HARMFUL IF
INHALED/CAUSE BLINDNESS IF SWALLOWED. SKIN/EYES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BLINDNESS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
INGESTION: INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:55.6F
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING AREAS.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:ETHANOL-FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: TAKE UP W/LAB ABSORBANT MATERIAL &
PLACE INTO CONTAINERS FOR LATER DISPOSAL. VENTILATE AREA & WASH
SITE W/MILD DETERGENT & WATER AFTER MATERIAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL VENTILATED AREA.
BOTTLE SHOULD REMAIN CAPPED & SEALED UNTIL USE. AVOID STORAGE AREA
IN EXTREME TEMP & DIRECT LIGHT.
Other Precautions:AVOID CONTACT W/EYES. KEEP AWAY FROM HEAT & OTHER
IGNITION SOURCES, POWERFUL OXIDIZERS & DIRECT SUNLIGHT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE FOR NORMAL USE.
Ventilation:LOCAL EXHAUST VENTILATION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175F
Vapor Pres:40
Spec Gravity:0.79
Evaporation Rate & Reference:(WATER =1): >1
Appearance and Odor:PURPLE LIQUID W/MILD ALCOHOLIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, CHROMIC ANHYDRIDE, LEAD PERCHLORATE, PERCHLORIC ACIDS.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, DIRECT SUNLIGHT,
EXTREME TEMP, DIRECT LIGHT
Hazardous Decomposition Products:CO, CO2, HYDROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH TO CHEMICAL SEWER/INCINERATE. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ZINC NITRATE,4344,8808,8812
CAGE:EO303
CAGE:0X801
CAGE:70829
CAGE:EO303
============= Composition/Information on Ingredients =============
Ingred Name:ZINC NITRATE (SARA 313) (CERCLA)
CAS:7779-88-6
RTECS #:ZH4772000
Fraction by Wt: 99- 100%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) 1400 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
AND GASTROINTESTINAL TRACTS. ACUTE- EYE OR SKIN CONTACT MAY CAUSE
IRRITATION AND PAIN. INHALATION CAUSES RESPIRATORY TRACT
IRRITATION. INGESTION CAUSES GASTROINTE STINAL IRRITATION. CHRONIC-
ZINC SALTS ARE ELIMINATED FAIRLY PROMPTLY, MAKING CHRONIC EFFECTS
LESS THAN ACUTE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DISCOMFORT, PAIN, TEARING, BLURRING
OF VISION, NAUSEA, VOMITING, COUGHING, SHORTNESS OF BREATH,
METHEMOGLOBINEMIA, FAINTNESS, BLUISH LIPS AND SKIN, ITCHING
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. CALL PHYSICIAN AT ONCE.
SKIN:FLUSH W ITH PLENTY OF WATER IMMEDIATELY. ORAL:DO NOT INDUCE
VOMITING. IF CONSCIOUS, DRINK PLENTY OF WATER. SEEK IMMEDIATE
MEDICAL ATTENTION. DO NOT GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY OR WATER, FOAM OR DRY CHEMICAL. USE
WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:STRONG OXIDIZER. INCREASES FLAMMABILITY
OF COMBUSTIBLE SUBSTANCES. IN CONTACT WITH EASILY OXIDIZABLE
SUBSTANCES, IT MAY REACT RAPIDLY ENOUGH TO IGNITE/EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING AND RESPIRATORY
EQUIPMENT. SWEEP, SCOOP OR PICK UP SPILLED MATERIAL. AVOID DUST
DISPERSAL. PACKAGE FOR DISPOSAL. WASH SPILL AREA TO REMOVE RESIUAL
CONTAMINATION. REPORT SPILL TO AUTHORITIES IF REQUIRED
(800-424-8802).
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED PLACE
AWAY FROM INCOMPATIBLE MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
PROTECT AGAINST PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID BREATHING DUSTS. AVOID
CONTACT WITH EYES, SKIN AND CLOTHING. LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE. KEEP OUT OF REACH OF CHILDREN. AVOID DUST
ACCUMULATION. OBSERVE A LL WARNINGS LISTED FOR THE PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED. IF AIRBORNE CONCENTRATIONS ARE
HIGH, WEAR NIOSH-APPROVED RESPIRATOR FOR DUST OR DUST MASK. IN
EMERGENCIES OR INSTANCES WHERE THE EXPOSURE LEVELS ARE NOT KNOWN,
USE A FULL-FACE POSITIVE PR ESSURE AIR-SUPPLIED RESPIRATOR.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP FUME OR
DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:EYEBATH, WASHING FACILITY, SAFETY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING OR
DRINKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:D1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:221F,105C
Melt/Freeze Pt:M.P/F.P Text:97.0F,36.1C
Spec Gravity:2.07
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:200 G/100 G
Appearance and Odor:COLORLESS OR WHITE CRYSTALS OR FLAKES - SLIGHT
NITRIC ACID ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METAL POWDERS, CYANIDES, SODIUM HYPOPHOSPHITE, STANNOUS CHLORIDE, P,
THIOCYANATES, C, METALLIC SULFIDES, S, ORGANICS
Stability Condition to Avoid:HEAT, FLAMES, IGNITION SOURCES
Hazardous Decomposition Products:TOXIC FUMES OF NITROGEN OXIDES, ZINC
OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH APPLICABLE FEDERAL,
STATE & LOCAL ENVIRONMENTAL REGULATIONS. REUSING OR RECYCLING IS
RECOMMENDED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FIRST BASE
CAGE:89044
CAGE:89044
============= Composition/Information on Ingredients =============
Ingred Name:CONTAINS NO COMPONENTS CONSIDERED HAZARDOUS (29 CFR
1910.1200). HOWEVER, CONTAINS 6% GLYCOL ETHERS (SARA 313)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION TO SKIN/EYES,
STOMACH DISTRESS, NAUSEA, VOMITING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/LOTS OF COOL RUNNING WATER 15
MINUTES. SKIN: FLUSH W/PLENTY OF COOL RUNNING WATER. WASH
THOROUGHLY W/SOAP & WATER. INGESTION: RINSE MOUTH. DRINK 1-2 LARGE
GLASSES WATER. DO N OT INDUCE VOMITING. NEVER GIVE ANYTHINGBY MOUTH
TO UNCONSCIOUS PERSON. IF IRRIT/DISCOMFORT PERSIST, CALL DR.
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:NO SPECIAL FIRE HAZARDS. PRODUCT DOES NOT
SUPPORT COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE/DAM LARGE SPILLS. PUMP TO CONTAINERS &
SOAK UP ON INERT ABSORBENT. FLUSH TO SANITARY SEWER.
======================Handling and Storage ======================
Other Precautions:NOT DOT REGULATED. KEEP FROM FREEZING. KEEP AWAY FROM
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED BEYOND STANDARD INDUSTRIAL HYGIENE
PRACTICES.
Ventilation:NONE REQUIRED BEYOND STANDARD INDUSTRIAL HYGIENE PRACTICES.
Work Hygienic Practices:NONE REQUIRED BEYOND STANDARD INDUSTRIAL
HYGIENE PRACTICES.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.0
pH:7.6
Solubility in Water:EMULSION
Appearance and Odor:LIGHT TAN, OPAQUE LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NK
Stability Condition to Avoid:DON'T MIX W/ANYTHING BUT WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT STATE/LOCAL AUTHOROTIES FOR RESTRICTIONS
ON DISPOSAL OF CHEMICAL WASTE.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:PETROBOND
CAGE:HO821
CAGE:HO821
CAGE:20064
============= Composition/Information on Ingredients =============
Ingred Name:SILICA
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 2-6%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:LOW CONCENTRATIONS OF INGS 3-5 MAY BE PRESENT
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
OSHA PEL:N/K
ACGIH TLV:0.05 MG/M3 RDUST
Ingred Name:SILICA, CRYSTALLINE - TRIDYMITE
CAS:15468-32-3
RTECS #:VV7335000
OSHA PEL:N/K
ACGIH TLV:0.05 MG/M3 RDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: POTENTIAL IRRITANT. PROLONGED
CONTACT MAY CAUSE BURNS. EYES: MAY CAUSE IRRITATION. INHALATION:
IRRITATION TO LUNGS, NOSE AND THROAT; PROLONGED INHALATION MAY
RESULT IN SILICOSIS, A NONCANCEROUS LUNG DISEASE.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE- (QUARTZ,
CRISTOBALITE, TRIDYMITE): IARC MONOGRAPHS, SUPPLEMENT, VOL 7, PG
341, 1987: (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. IF IRRITATION
CONTINUES, GET MEDICAL ATTENTION. EYES: WASH EYES W/WATER FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION. INGEST: DO NOT INDUCE
VOMITING. DRINK 2 GL ASSES OF WATER & GET MEDICAL ATTENTION.INHAL:
REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN. IF
BREATHING HAS STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY GIVE OFF TOXIC VAPORS WHEN BURNED.
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL HOUSEKEEPING; SWEEP UP AND PLACE IN
DISPOSAL CONTAINER. CAUTION. SPILLED MATERIAL MAY RETAIN HAZARDS OF
ORIGINAL PRODUCT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SHELTERED AREA OR COVER TO
PROTECT FROM MOISTURE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN DUSTY CONDITIONS USE A NIOSH/MSHA APPROVED
MECHANICAL RESPIRATOR FOR NONTOXIC DUSTS.
Ventilation:MECHANICAL, GENERAL ROOM VENTILATION. USE LOCAL VENTILATION
TO MAINTAIN TLV.
Other Protective Equipment:APRON, COVERALLS. EYE WASH FOUNTAI & DELUGE
SHOWER MEETING ANS DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN: GROUP 2A. NTP 7TH ANNUAL REPORT ON CARCINOGENS, 1994:
ANTICIPATED TO BE CARCINOGEN.
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:2.0 (H2O=1)
Appearance and Odor:RED POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BURNING MAY RELEASE CARBON DIOXIDE,
CARBON MONOXIDE, OXIDES OF NITROGEN, CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:KX-P450 (RS-138-25 TONER)
CAGE:KYUSH
CAGE:KYUSH
============= Composition/Information on Ingredients =============
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 6%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:METHACRYLIC ACID METHYL ESTER, POLYMER W/BUTYL ACRYLATE &
STYRENE *93-4*
CAS:27136-15-8
Fraction by Wt: 86%
Ingred Name:POLYPROPYLENE *93-4*
CAS:25085-53-4
Fraction by Wt: 4.5%
Ingred Name:CHROMATE
(1-),BIS(1-((5-CHLORO-2-HYDROPHENYL)AZO)-2-NAPHTHALENOLATO(2-))-,HY
DROGEN, COMPD. W/1-TETRADECANAMINE*93-4*
CAS:88377-66-6
Fraction by Wt: 2.5%
Ingred Name:IRON OXIDE, MAGNETITE
*93-4*
CAS:1317-61-9
Fraction by Wt: 1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINIMAL IRRITATION TO THE RESPIRATORY
TRACT MAY OCCUR AS W/EXPOSURE TO ANY NON-TOXIC DUST.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR AT LEAST
5 MINUTES. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, FOAM, CO2, DRY CHEMICALS
Fire Fighting Procedures:WEAR FULL EMERGENCY EQUIPMENT W/SCBA & FULL
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NOT A FIRE HAZARD BUT CAN BURN IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR CLEAN UP W/A VACUUM CLEANER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:KEEP AWAY FROM HEAT, SPARKS, & OPEN FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE.
Ventilation:NONE
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:INHALATION SHOULD BE AVOIDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.19
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK FINE POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/DUMP IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:FREON TF CLEANING AGENT
Preparer's Name:K.P. BROWN
CAGE:18873
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE (FREON 113) (SARA
III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD 50 ORAL RAT 43000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARDS- ACUTE: MILD EYE AND
SKIN IRRITANT. ANAESTHETIC AND CARDIAC EFFECTS. CHRONIC:NONE
SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:FREON 113 IS NOT LISTED AS A CARCINOGEN
BY IARC, NTP OR OSHA.
Effects of Overexposure:EYE:IRRITATION,TEARING,BLURRED VISION.
SKIN:IRRITATION,RASH. INHALATION:TEMPORARY NERVOUS SYSTEM
DEPRESSION WITH ANESTHETIC EFFECTS SUCH AS
DIZZINESS,HEADACHE,CONFUSION,INCOORDINATION,AND LOSS OF CONS
CIOUSNESS. HIGHER INHALATION MAY CAUSE HEART IRREGULARITIES. GROSS
OVEREXPOSURE MAY CAUSE ABNORMAL LIVER FUNCTION/DEATH.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PREEXISTING
DISEASES OF THE CARDIOVASCULAR SYSTEM MAY HAVE INCREASED
SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR, CALL A PHYSICIAN. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION.IF BREATHING IS DIFFICULT,
GIVE OXYGEN. EYE: FLUSH WITH WATER. SKIN: FLUSH WITH WATER. IF
IRRITATION PE RSISTS, GET MEDICAL ATTENTION. ORAL: GET MEDICAL
ATTENTION IMMEDIATELY. DO NOT INDUCE VOMITING AS THE HAZARD OF
ASPIRATING INTO THE LUNGS IS TOO GREAT.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON-FLAMMABLE. USE EXTINGUISHING MEDIA APPROPIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:CONTAINERS MAY RUPTURE UNDER FIRE
CONDITIONS. COMBUSTION OR HEAT OF FIRE MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. DO NOT FLUSH INTO SEWERS. DIKE
SPILL. COLLECT ON ABSORBENT MATERIAL AND TRANSFER TO STEEL DRUMS
FOR RECOVERY OR DISPOSAL. COMPLY WITH FEDERAL, STATE AND LOCAL
REGULATIONS ON REPORTING RELEASES.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A CLEAN, COOL, DRY AND
WELL-VENTILATED AREA OF LOW FIRE RISK. PROTECT CONTAINERS FROM
PHYSICAL DAMAGE AND KEEP CLOSED. DO NOT HEAT ABOVE 125F
Other Precautions:AVOID BREATHING VAPOR, LIQUID CONTACT WITH EYES, SKIN
OR CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR ADEQUATELY VENTED WORK
SITUATIONS. IF A LARGE SPILL OCCURSS, USE A SELF-CONTAINED
BREATHING APPARATUS OR SUPPLIED-AIR RESPIRATOR, APPROVED BY NIOSH.
Ventilation:NORMAL VENTILATION FOR STANDARD USE IS GENERALLY ADEQUATE.
USE MECHANICAL VENTILATION IN LOW PLACES.
Other Protective Equipment:USE IMPERVIOUS CLOTHING IF THERE IS REPEATED
OR PROLONGED CONTACT WITH LIQUID.
Work Hygienic Practices:REMOVE AND WASH CLOTHING PROMPTLY UPON
CONTAMINATION.
Supplemental Safety and Health
NOTE TO PHYSICIAN: BECAUSE OF CARDIAC RHYTHM, CATECHOLAMINE DRUGS, SUCH
AS EPINEPHRINE, SHOULD BE USED WITH SPECIAL CAUTION IN SITUATIONS
OF EMERGENCY LIFE SUPPORT.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:118F,48C
Vapor Pres:334 @ 77F
Vapor Density:2.9 @ 77F
Spec Gravity:1.57 @ 77F
Evaporation Rate & Reference:>1 (CCL4 = 1)
Solubility in Water:0.02%
Appearance and Odor:CLEAR COLORLESS LIQUID, SLIGHT ETHEREAL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS-POWDERED AL,ZN,BE,ETC.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAMES.
Hazardous Decomposition Products:DECOMPOSED BY HIGH TEMPERATURES (OPEN
FLAMES, GLOWING METAL SURFACES, ETC.) FORMING HYDROCHLORIC AND
HYDROFLUORIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE AND LOCAL
REGULATIONS. REMOVE TO A PERMITTED WASTE DISPOSAL FACILITY. EPA
HAZARDOUS WASTE NUMBERS F001 AND F002 MAY APPLY TO WASTE MATERIALS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ISOOCTANE (ASTM GRADE)
CAGE:46935
Contract Num:SP0450-00-M-D444
CAGE:82956
CAGE:2H215
CAGE:6Y142
CAGE:46935
CAGE:86511
============= Composition/Information on Ingredients =============
Ingred Name:ISOOCTANE (2,2,4-TRIMETHYLPENTANE)
CAS:540-84-1
RTECS #:SA3320000
= Wt:99.95
Other REC Limits:N/E
OSHA PEL:N/E
OSHA STEL:N/E
ACGIH TLV:N/E
ACGIH STEL:N/E
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
= Wt:.01
OSHA PEL:2000 MG/M3;500 PPM
ACGIH TLV:1640 MG/M3;400 PPM
ACGIH STEL:2050 MG/M3;500 PPM
Ingred Name:OCTANE ISOMERS (MSDS HAD CAS 26635-64-3)
= Wt:.04
Other REC Limits:N/E
OSHA PEL:N/E
OSHA STEL:N/E
ACGIH TLV:N/E
ACGIH STEL:N/E
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE/SKIN: MAY PRODUCE MILD
IRRITATION. INHALATION: MAY CAUSE SLIGHT MUCOUS MEMBRANE
IRRITATION, RAPID BREATHING, FATIGUE, HEADACHE, LIGHT HEADEDNESS,
DIZZINESS & OTHER CNS EFFECTS. EXTREME EXPO SURES MAY CAUSE
RESPIRATORY ARREST, CONVULSIONS OR UNCONSCIOUSNESS. INGESTION: MAY
CAUSE DIARRHEA, SLIGHT CNS DEPRESSION, DIFFICULTY IN BREATHING AND
FATIGUE. IF SWALLOWED, MAY BE ASPIRATED RESULTING IN INFLAMMATION
& POSSIBLE FLUID ACCUMULATION IN THE LUNGS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:SEE HEALTH EFFECTS SECTION FOR ACUTE EFFECTS.
SUBCHRONIC & CHRONIC EFFECTS: IN A SUBCHRONIC ORAL LAB STUDY
ISOOCTANE HAS PRODUCED KIDNEY DAMAGE IN MALE RATS ONLY. NO
COMPARABLE HEALTH HAZARD FOR KIDNE Y DISEASE IS KNOWN TO OCCUR IN
HUMANS.
Medical Cond Aggravated by Exposure:ISOOCTANE HAS PRODUCED KIDNEY
DAMAGE IN MALE RATS ONLY IN A SUBCHRONIC ORAL LABORATORY STUDY. NO
COMPARABLE HEALTH HAZARD FOR KIDNEY DISEASE IS KNOWN TO OCCUR IN
HUMANS.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYE : IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: GET IMMEDIATE
MEDICAL ATTENTION. DO NOT INDUCE VOMITING. NOTHING BY MOUTH IF
UNCONSCIOUS. NO TE TO PHYSICIAN: GASTRIC LAVAGE USING CUFFED
ENDOTRACHEAL TUBE MAY BE PERFORMED AT YOUR DISCRETION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=-7.6C, 18.F
Lower Limits:1.0
Upper Limits:NOT ESTABL
Extinguishing Media:DRY CHEMICAL, FOAM OR CARBON DIOXIDE
Fire Fighting Procedures:EVACUATE AREA, SHUT OFF SOURCE. WEAR SCBA &
OTHER PROTECTIVE EQUIPMENT. WATER SPRAY MAY BE USED TO COOL FIRE
EXPOSED CONTAINERS. DO NOT SPRAY WATER ON FIRE AS PRODUCT WILL
FLOAT AND COULD BE REIGMITED ON SURFACE OF WATER.
Unusual Fire/Explosion Hazard:CARBON OXIDES FORMED WHEN BURNED. HIGHLY
FLAMMABLE VAPORS WHICH ARE HEAVIER THAN AIR MAY ACCUMULATE IN LOW
AREAS AND/OR SPREAD ALONG GROUND AWAY FROM HANDLING SITE. PRODUCT
WILL FLOAT ON WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR PROTECTIVE EQUIPMENT AND
SCBA. SHUT OFF SOURCE, IF POSSIBLE AND CONTAIN SPILL. PROTECT FROM
IGNITION. KEEP OUT OF WATER SOURCES AND SEWERS. ABSORB IN A DRY,
INERT MATERIAL. TRANSFE R TO DISPOSAL DRUMS USING NON-SPARKING
EQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM SOURCES OF IGNITION. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. EMPTY CONTAINERS MAY BE HAZARDOUS.
Other Precautions:AVOID CONTACT WITH EYES, SKIN, OR CLOTHING. AVOID
BREATHING VAPORS. WEAR PROTECTIVE EQUIPMENT AND/OR GARMENTS. WASH
THOROUGHLY AFTER HANDLING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. PROVIDE MEANS OF CONTROLLING LEAKS AND SPILLS. USE WITH
ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CONCENTRATIONS EXCEEDING THE RECOMMENDED
EXPOSURE LIMIT, USE NIOSH APPROVED AIR PURIFYING RESPIRATOR.
Ventilation:USE ADEQUATE VENTILATION TO CONTROL CONCENTRATION BELOW
RECOMMENDED EXPOSURE LIMITS
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
PPE BASED ON NORMAL USES & CONDITIONS. FOR SPECIAL/UNUSUAL CONDITIONS,
USE EXPERT ADVISE OF INDUSTRIAL HYGIENIST OR OTHER QUALIFIED
PERSONNEL.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:211F,99C
Melt/Freeze Pt:M.P/F.P Text:-161F,-107C
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:1.7PSIA @ 100F
Vapor Density:>1
Spec Gravity:0.696
Viscosity:0.503 CST @ 68F
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID - MILD GASOLINE ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXYGEN AND STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREAM HEAT OR SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER HYDROCARBON COMPOUNDS DURING COMBUSTION.
=================== Toxicological Information===================
Toxicological Information:THE COMPANY RECOMMENDS A PERMISSIBLE EXPOSURE
LEVEL (8-HR TWA) OF 300 PPM FOR ISOOCTANE (2,2,4-TRIMETHYLPENTANE).
DERMAL LD50 (RABBIT) FOR ISOOCTANE IS >2000 MG/KG. INHALATION LC50
(RAT) FOR ISOOCTANE IS > 3078.44 PPM AFTRE A 4 HR EXPOSURE AND A
14 DAY POSTEXPOSURE OBSERVATION PERIOD. ORAL LD50 (RAT) FOR
ISOOCTANE IS > 5000 MG/KG. A TOXICITY STUDY SUMMARY FOR ISOOCTANE
IS AVAILABLE FROM PHILLIPS U PON REQUEST.
===================== Ecological Information =====================
Ecological:NOT PROVIDED
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS. INCINERATE OR PLACE IN PERMITTED WASTE
MANAGEMENT FACILITY.
=================== MSDS Transport Information ===================
Transport Information:SEE TRANSPORTATION DATA.
===================== Regulatory Information =====================
SARA Title III Information:DOES NOT CONTAIN CHEMICALS SUBJECT TO
REPORTING REQUIREMENTS OF SARA 313
Federal Regulatory Information:ISOOCTANE CERCLA RQ = 1000 LB
State Regulatory Information:NOT PROVIDED
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CARBOPACK B 60/80
CAGE:FO442
CAGE:54968
CAGE:FO442
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:CARBOWAX 20M
CAS:37225-26-6
Fraction by Wt: 5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: PULMONARY FIBROSIS & EMPHYSEMA.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/WATER FOR 15 MINUTES. INHALATION: MOVE TO
FRESH AIR. GIVE OXYGEN IF BREATHING IS LABORED.
===================== Fire Fighting Measures =====================
Flash Point:4200C
Extinguishing Media:WATER, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING A CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:MAY FORM FLAMMABLE DUST-AIR MIXTURES
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEALED CONTAINER IN COOL, DRY
LOCATION. KEEP AWAY FROM OXIDIZERS. AVOID GENERATING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR DUST MASK.
Ventilation:USE ONLY IN WELL VENTILATED AREA.
Supplemental Safety and Health
THIS IS A SPECIAL PACKING MATERIAL USED IN GS CHROMATOGRAPH COLUMNS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:4200 C
Spec Gravity:0.600
Appearance and Odor:BLACK GRANULES
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORINE, FLUORINE (FE, FE), POTASSIUM, POTASSIUM OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY W/ALL APPLICABLE FEDERAL, STATE, OR LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:837 2674 RA 2000 DEVELOPER AND REPLENISHER, MX 1651
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 9%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-65%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY LIBERATE SULFUR DIOXIDE GAS WHICH IS
IRRITATING TO RESPIRATORY TRACT. EYE CONTACT CAUSES IRRITATION.
SKIN CONTACT CAUSES IRRITATION . MAY CAUSE ALLERGIC SKIN REACTION.
HARMFUL IF SWALLOWED. CAN CAUSE KIDNEY DAMAGE. MAY CAUSE IRRITATION
OF GI TRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:RESPIRATORY TRACT IRRITATION, EYE IRRITATION,
SKIN IRRITATION, ALLERGIC SKIN REACTION, KIDNEY DAMAGE, GI TRACT
IRRITATION, WHEEZING, CHEST TIGHTNESS, STOMACH UPSET, HIVES,
FAINTNESS, WEAKNESS, DIARRHE A.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE WHEEZING, CHEST
TIGHTNESS, SSTOMACH UPSET, HIVES, FAINTNESS, WEAKNESS, DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: INDUCE VOMITING AS DIRECTED BY MEDICAL PERSONNAL. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL PHYSICIAN OR
POISON CONTROL ASAP.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. USE WITH ADEQUATE VENTILATION. KEEP FROM CONTACT WITH
OXIDIZING MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:THE ROUTINE USE OF A NONALKALINE (ACID) TYPE OF HAND
CLEANER AND REGULAR CLEANING OF WORKING SURFACES WILL HELP MINIMIZE
THE POSSIBILITY OF A SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.26
pH:10.8
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID, NO ODOR
Percent Volatiles by Volume:69%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:6801 MULTI-USE LACQUER THINNER
CAGE:30530
CAGE:30530
============= Composition/Information on Ingredients =============
Ingred Name:VOL ORGANIC CMPD: 800-844 G/L
RTECS #:9999999VO
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 11-43%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3-4%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 3%
Other REC Limits:50 PPM
OSHA PEL:410 MG/CUM
ACGIH TLV:205 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE; DIMETHYL KETONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 20-30%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5-15%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 0.5-32%
Other REC Limits:STEL 400 PPM
OSHA PEL:100 PPM
ACGIH TLV:300 PPM
Ingred Name:ISOBUTYL ACETATE
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 0.1-15%
Other REC Limits:150 PPM
OSHA PEL:150 PPM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION, DERMATITIS,
ABSORPTION. EYES: IRRITATION, TEMPORARY CORNEAL DAMAGE,
CONJUNCTIVITIS. INHALATION: RESPIRATORY SYSTEM IRRITATION/CNS
EFFECTS. PERMANENT BRAIN/CNS DAMAGE. OVEREXPOSURE TO SOLVENTS
DAMAGE LIVER/KIDNEY/SPLEEN/LUNGS/NERVOUS SYSTEM. INGESTION: CNS
DEPRESSION/ASPIRATION HAZARD.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: DRYNESS/CRACKING/OIL REMOVAL. EYES:
REDNESS/TEARING/PAIN. INHALATION:
HEADACHE/DIZZINESS/CONFUSION/NAUSEA/VOMITING/UNCONSCIOUSNESS.
INGESTION: BURNING OF MOUTH, THROAT, & ABDOMEN/NAUSEA/VOMITING
/DIARRHEA/WEAKNESS/DIZZINESS/SLOW & SHALLOW
RESPIRATION/UNCONSCIOUSNESS/CONVULSIONS.
Medical Cond Aggravated by Exposure:LIVER, KIDNEY, SPLEEN, LUNGS, SKIN,
OR NERVOUS SYSTEM DYSFUNCTION, DERMATITIS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: REMOVE CONTAMINATED
CLOTHING. WASH TWICE W/SOAP & WATER. INGESTION: DON'T INDUCE
VOMITING. ASPIRATION HAZARD. IF CONSCIOUS, DILUTE W/4 TO 8 OUNCES
OF WATER. INHA LATION: REMOVE TO FRESH AIR IMMEDIATELY. USE
OXYGEN/CPR IF NECESSARY. DON'T LEAVE VICTIM UNATTENDED. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<20F
Lower Limits:1%
Upper Limits:13.2%
Extinguishing Media:CO2, FOAM, DRY CHEMICAL, WATER (MIST ONLY)
Fire Fighting Procedures:WATER MAY BE USED TO COOL CONTAINERS & FIRE
FIGHTERS. HOWEVER, WATER COULD CAUSE FREE SOLVENT TO FLOAT & SPREAD
FIRE.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. ISOLATE AREA/DENY
ENTRY. CONTAIN AS LIQUID FOR POSSIBLE RECYCLING. ABSORB ONTO
SAND/OTHER ABSORBENT MATERIAL. SHOVEL INTO CLOSABLE CONTAINER FOR
DISPOSAL. WEAR PROTECTIVE EQUIPMENT. CONTAIN AWAY FROM SURFACE
WATER/SEWER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T GET INTO EYES/SKIN/CLOTHING.
AVOID BREATHING VAPORS. DON'T SMOKE WHEN HANDLING THIS PRODUCT.
DON'T WEAR CONTACT LENSES.
Other Precautions:EMPTY PRODUCT CONTAINERS CONTAIN PRODUCT RESIDUE.
DON'T PRESSURIZE/CUT/HEAT/WELD/GRIND/EXPOSE TO IGNITION SOURCES.
KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE. INTENTIONAL MISUSE
BY DELIBERATELY CON CENTRATING/INHALING IS HARMFUL/FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH-APPROVED RESPIRATORY EQUIPMENT WHEN
CONCENTRATION OF VAPORS EXCEEDS LIMIT. DEPENDING ON AIRBORNE
CONCENTRATION, USE RESPIRATOR/GAS MASK W/APPROPRIATE
CARTRIDGES/CANISTERS (FOR ORGANIC VAPORS ). SCBA FOR LARGE
SPILLS/EMERGENCIES.
Ventilation:LOCAL EXHAUST/GENERAL DILUTION. WHERE EXPLOSIVE MIXTURES
MAY BE PRESENT, SYSTEMS SAFE FOR SUCH LOCATION SHOULD BE USED.
Other Protective Equipment:SOURCE OF CLEAN WATER, RUBBER APRON OR OTHER
PROTECTIVE CLOTHING
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE. WASH THOROUGHLY
AFTER HANDLING/BEFORE EATING, DRINKING, OR USING TOBACCO PRODUCTS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 131-347F
Vapor Pres:78.6
Vapor Density:3.02
Spec Gravity: 0.8-0.8438
Evaporation Rate & Reference:(N-BU = 1): 3.3
Solubility in Water:APPRECIABLE
Appearance and Odor:LIQUID, COLORLESS, CLEAR W/CHARACTERISTIC SOLVENT
ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. FLAMMABLE LIQUID. NA1263.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FORAY DRY CHEMICAL EXTINGUISHING AGENT
Preparer's Name:SAFETY & HEALTH DEPT
CAGE:03670
CAGE:03670
============= Composition/Information on Ingredients =============
Ingred Name:PROPRIETARY MIXTURE OF FOLLOWING MATERIALS (INGRED #2-6).
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM PHOSPHATE MONOBASIC
CAS:7722-76-1
Fraction by Wt: 65-82%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM SULFATE
CAS:7783-20-2
RTECS #:BS4500000
Fraction by Wt: 12-22%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:METHYL HYDROGEN POLYSILOXANE
CAS:63148-57-2
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:YELLOW PIGMENT (C.I. PIGMENT YELLOW 4 (C.I.21095))
CAS:5468-75-7
RTECS #:EJ3512500
Fraction by Wt: <0.05%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON DIOXIDE CONTAINS 8-8.5 OUNCES OF CARBON DIOXIDE PER
CYLINDER
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: SEEING
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;96
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV:OSHA NUISANCE DUST 15MG/M3.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT:MILDLY IRRITATING FOR A
SHORT PERIOD OF TIME. SKIN CONTACT:MAY BE MILDLY IRRITATING.
INHAL:TREAT AS A MINERAL DUST. IRRITANT TO THE RESPIRATORY TRACT.
INGEST:NOT AN EXPECTED ROUTE OF ENTRY .
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:ACUTE OVEREXPOSURE:TRANSIENT COUGH, SHORTNESS
OF BREATH. CHRONIC OVEREXPOSURE:CHRONIC FIBROSIS OF THE LUNG,
PNEUMOCONIOSIS.
Medical Cond Aggravated by Exposure:REACTIVE AIRWAY.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION PERSISTS
SEEK MEDICAL ATTENTION. SKIN:WASH WITH SOAP & WATER. IF IRRITATION
PERSISTS SEEK MEDICAL ATTENTION. INHALATION:REMOVE VICTIM TO FRESH
AIR. SEEK MEDICAL ATTENTION IF DISCOMFORT CONTINUES. INGESTION:IF
PATIENT IS CONSCIOUS GIVE LARGE AMOUNTS OF WATER & INDUCE VOMITING.
SEEK MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:NONE---THIS IS AN EXTINGUISHING AGENT.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:SHOULD BE STORED IN ORIGINAL CONTAINER
OR ANSUL FIRE EXTINGUISHER.
Other Precautions:DO NOT MIX AGENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST MASK WHERE DUSTINESS IS PREVALENT OR TLV
EXCEEDED. MECHANICAL FILTER RESPIRATOR IF EXPOSURE IS PROLONGED.
Ventilation:LOCAL EXHAUST:DISCRETIONARY. MECHANICAL
(GENERAL):RECOMMENDED.
Other Protective Equipment:IF IRRITATION OCCURS LONG SLEEVES &
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
MATERIAL IS AN EXTINGUISHING AGENT. PER TIR: CARTRIDGE AS EXTINGUISHING
AGENT CHARGE METHOD.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:SLIGHT
Appearance and Odor:YELLOW COLORED POWDER, NO CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS, MG, OXIDIZERS THAT CAN RELEASE CHLORINE PER NFPA 43A.
Hazardous Decomposition Products:NHX AND/OR POX MAY BE EVOLVED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN COMPLIANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
Product ID:AEROSOL SPRAY PAINT, AP200 GRAY METAL
CAGE:25461
CAGE:25461
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS POLYMER (TYPE NOT SPECIFIED)
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:COBALT OCTOATE %6
OSHA PEL:0.05 MG/M3 (CO)
ACGIH TLV:0.05 MG/M3 (CO)
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:2-PENTANONE, 4-HYDROXY-4-METHYL-; (DIACETONE ALCOHOL). VP:
1.1 @ 20C.
CAS:123-42-2
RTECS #:SA9100000
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:HYDROTREATED HEAVY NAPHTHA (PETROLEUM); (HEAVY NAPHTHA)
CAS:64742-48-9
Other REC Limits:100 PPM (MFR)
Ingred Name:TALC (CONTAINING NO ASBESTOS); (HYDROUS MAGNESIUM SILICATE)
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
Ingred Name:OTHER PREC: APPROVED RESPIRATOR OR APPROPRIATE VENTILATION.
DO NOT SPRAY NEAR FIRE OR OPEN FLAME.
RTECS #:9999999ZZ
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE). VP: 71 @ 20C.
CAS:78-93-3
RTECS #:EL6475000
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYL ALCOHOL; (N-BUTYL ALCOHOL). VP: 5.5 @ 20C.
CAS:71-36-3
RTECS #:EO1400000
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE. VP: 25 @ 20C.
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MINERAL SPIRITS; (MEDIUM MINERAL SPIRITS). VP: 2 @ 20C.
CAS:64742-88-7
Other REC Limits:100 PPM (MFR)
Ingred Name:VM&P NAPHTHA. VP: 26 @ 100F.
CAS:64742-89-8
OSHA PEL:300 PPM; 400 STEL
ACGIH TLV:300 PPM
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE). VP: 400 @ 20C.
CAS:75-09-2
RTECS #:PA8050000
OSHA PEL:500 PPM;1000, C
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: GI DISTRESS. INHAL: OVEREXP
MAY CAUSE NOSE & THROAT IRRIT. MAY CAUSE CNS EFTS SUCH AS DIZZ,
HDCH, NAUS, STAGGERING GAIT, CONFUSION & UNCON. REPORTS HAVE ASSOC
RPTD & PRLNGD OVEREXP TO SOLVS W/ PERM BRAIN & NERVS SYS DAM. EYE
WATERING, HDCHS, NAUS, DIZZ & LOSS OF COORDINATION ARE SIGNS THAT
(EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: GROUP 2B (IARC),
GROUP 2 (NTP).
Effects of Overexposure:HLTH HAZ: SOLV LVLS ARE TOO HIGH. EYE: MAY
CAUSE IRRIT/BURNING. SKIN: RPTD/PRLNGD LIQ CONT MAY CAUSE IRRIT
W/DISCOMFORT & DERM. CHLOROCARBON/CHLOROFLUOROCARBON (CFC) MATLS
HAVE PRDCED SENSIT OF THE MY OCARDIUM TO EPINEPHRINE IN LAB ANIMALS
& COULD HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS (E.G.,
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY AND HAVE NAMES OF INGREDIENTS
AVAILABLE. DO NOT INDUCE VOMITING. INHAL: REMOVE TO FRESH AIR. IF
NOT BRTHG, GIVE ARTIFICIAL RESPIRATION, PREF MOUTH TO MOUTH. IF
BRTHG DIFFICU LTY PERSISTS/OCCURS LATER, CONSULT MD. SKIN:WASH WITH
SOAP & WATER. IF IRRIT OCCURS CONTACT MD. EYES: IMMEDIATLEY FLUSH
WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES; CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:<20F/<-7C
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT AND BREATHING OF VAPOR. CONFINE AND REMOVE
WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PRECS. KEEP AWAY FROM
HEAT, SPKS & FLAME. DO NOT STORE >120F. DO NOT EXPOSE TO DIRECT
SUNLIGHT TO AVOID BURSTING. DO NOT PUNCTURE.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICINITY
OF ARC WELDING, OPEN FLAMES/HOT SURFS. HEAT &/UV RADIATION MAY
CAUSE FORMATION OF HCL &/PHOSGENE . DO NOT SAND, FLAME CUT,
BRAZE/WELD DRY CO ATING W/OUT NISOH/MSHA (ING 16)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPS/MISTS. WEAR APPROP, PROPERLY
FITTED NIOSH/MSHA APPRVD RESPIRATOR DURING & AFTER APPLICATION
UNLESS AIR MONITORING DEMONSTRATES VAP/MIST LVLS ARE < APPLIC LIMS.
FOLLOW RESPIRATOR MF R'S DIRECTIONS FOR RESPIRATOR USE.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THORO AFTER HANDLING & BEFORE EATING &
SMOKING. PROT CREAMS MAY BE USED FOR EASE OF CLEAN-UP, NOT FOR
PROTECTION.
Supplemental Safety and Health
BP:<0F,<-18C (PROPELLANT).SOL IN H*2O:MOD - APPRECIABLE, DEPENDING ON
COLOR.EXPLO HAZ:PROPELLING CONTENTS ACROSS AREA. HLTH
HAZ:EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING
USES IN H UMANS ACUTELY/CHRONICALLY EXPOS TO CHLOROCARBON/CFC'S. .
FOR HLTH HAZ ASSOC W/INDIVIDUAL INGS CONTACT NEHC .
================= Stability and Reactivity Data =================
Hazardous Decomposition Products:HCL, PHOSGENE . CO, CO*2, SMOKE,
OXIDES OF HEAVY METALS REPORTED IN INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL I/A/W FEDERAL, STATE
AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:OGG-H, 03136
CAGE:0XZ81
CAGE:0XZ81
CAGE:59327
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, HYDROTREATED (SEVERE), HEAVY NAPHTHENIC
DISTILLATE, PETROLEUM
CAS:64742-52-5
RTECS #:PY8035001
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ASPHALT (PETROLEUM)
CAS:8052-42-4
RTECS #:CI9900000
OSHA PEL:N/K
ACGIH TLV:5 MG/M3; (FUME)
Ingred Name:SOLVENT DEASPHALTED RESIDUAL PETOLEUM OIL
CAS:64741-95-3
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LITHIUM TALLOWATE
CAS:64755-02-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:GRAPHITE, NATURAL
CAS:7782-42-5
RTECS #:MD9659600
OSHA PEL:15 MPPCF; Z-3
ACGIH TLV:2 MG/M3 RDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC:DEFATS SKIN; MAY
IRRITATE EYES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SENSITIVE SKIN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. EYES:FLUSH THORO W/FRESH WATER FOR
@ LEAST 15 MINUTES. GET MED ATTN. SKIN:FLUSH W/FRESH WATER, WASH
WITH SOAP AND WATER. REMOVE CONTAMD CLOTHES & SHOES. INGEST:GIVE
MILK/WAT ER, INDUCE VOMIT. GET MED ATTN. NEVER GIVE ANYTHING BY
MOUTH TO UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:425F,218C
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:CO*2, FOAM, DRY CHEMICALS.
Fire Fighting Procedures:NONE. USE NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP AND COLLECT BULK GREASE. PLACE INTO
METAL CNTNR FOR SOLID WASTE DISP. CLEAN SPILL AREA WITH DETERGENT
OR SOLVENTIZED CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS CLOSED IN A CLEAN,
DRY AREA. KEEP AWAY FROM HEAT, OPEN FLAME, AND OXIDIZING AGENTS.
Other Precautions:DO NOT PRESSURIZE CONTAINER TO EMPTY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:PRODUCING NORMAL AIR DILUTION.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.0
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE =1)
Solubility in Water:0%
Appearance and Odor:BLACK; MILD ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, SO*2, WITH INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE TO SOLID WASTE. DISPOSAL MUST BE I/A/W
FEDERAL, STATE & LOCAL REGULATIONS .
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:GERMICIDAL SOLUTION PINK GERMICIDE, 0255
CAGE:EO366
CAGE:EO366
CAGE:6P489
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM, ALKYLDIMETHYLBENZYL-, CHLORIDE; (BENZALKONIUM
CHLORIDE)
CAS:8001-54-5
RTECS #:BO3150000
Fraction by Wt: 0.13%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,FROGS) 30 MG/KG.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE OR MUCOUS MEMBRANE CONTACT MAY
RESULT IN IRRITATION. PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
SKIN IRRITATION. INGESTION MAY CAUSE NAUSEA AND VOMITING.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES:FLUSH W/LARGE QUANTITIES OF WATER FOR AT LEAST 15
MINUTES. IF REDNESS OR IRRITATION PERSISTS, CONTACT MD. SKIN:FLUSH
W/LA RGE QUANTITIES OF WATER. IF REDNESS OR IRRITATION PERSISTS,
CONTACT MD. INGEST:GET MEDICAL ASSISTANCE IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:TOXIC DECOMPOSITION PRODUCTS MAY BE
PRODUCED DURING FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER W/ABSORBENT MATERIAL, COLLECT IN
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED UNDER NORMAL CONDITIONS.
Ventilation:GENERAL MECHANICAL.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . PROT CLTHG AS NEC TO PREVENT EXCESSIVE CONT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.011
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC DECOMPOSITION PRODUCTS MAY BE
GENERATED DURING FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BUFFER PH-7, DRY PHOSHATE BUFFER
Preparer's Name:PETER WOLPERT
CAGE:86980
CAGE:86980
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:IRRITATION OF SKIN, EYES, AND
RESPIRATORY TRACTS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH PLENTY OF WATER. SKIN: WASH WITH SOAP AND
WATER. INHALATION: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES
================== Accidental Release Measures ==================
Spill Release Procedures:BRUSH UP AND DISSOLVE IN BEAKER OF WATER.
FLUSH DOWN DRAIN WITH ADDITIONAL WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED IN A COOL DRY
PLACE.
Other Precautions:AVOID PROLONGED CONTACT WITH SKIN. AVOID CONTACT WITH
EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED DUST AND MIST RESPIRATOR
Ventilation:GENERAL MECHANICAL EXHAUST TO KEEP FUMES AND DUST LEVELS
LOW
Other Protective Equipment:PROTECTIVE CLOTHING, EYEWASH BATH
Work Hygienic Practices:WASH AFTER HANDLING, DO NOT BREATH DUST.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.42 (WATER=1)
pH:6.86
Solubility in Water:READILY
Appearance and Odor:WHITE POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:CONTACT WITH MOISTURE, FLAMES, AND VERY
HIGH TEMPERATURES
Hazardous Decomposition Products:TOXIC FUMES OF PO, WHEN HEATED TO
DECOMPOSITION
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/LOCAL, STATE AND FEDERAL
ENVIRONMENTAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LAMINAR X500 HARDENER, 10C45
Preparer's Name:K. BUNTON
CAGE:0KZ46
CAGE:98795
CAGE:0KZ46
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL, 2-ETHOXY-, ACETATE; (CELLOSOLVE ACETATE) (2EEA).
VP:2 @ 20C.
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 10-50%
OSHA PEL:100 PPM, S
ACGIH TLV:5 PPM, S
Ingred Name:ACETIC ACID, ETHYL ESTER; (ETHYL ACETATE POLYURETHANE GRA)
(SARA III). VP:3 @ 20C.
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 30-40%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SARA III). VP:21 @ 20C.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <10%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE, 2,4-DIISOCYANATO-1-METHYL-; (TOLUENE DIISOCYANATE)
(SARA III). VP:0.05 @ 20C.
CAS:584-84-9
RTECS #:CZ6300000
Fraction by Wt: <10%
OSHA PEL:C,0.02 PPM/0.02 STEL
ACGIH TLV:0.005PPM/0.02STEL;93
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS. %: 6.105 LBS/GAL LESS WATER.
RTECS #:9999999VO
Fraction by Wt: SEE ING
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NIOSH RECS THAT 2-ETHOXYETHYL ACETATE,
(2EEA) BE REGARDED IN WORKPLACE AS HAVING POTNTL TO CAUSE ADVERSE
REPRO EFTS IN MALE & FEMALE WORKERS . ACUTE:OVEREXP BY INHAL MAY
CAUSE IRRIT OF RESP TRAC T, HDCH, DIZZ/DROW. SKIN/EYE CONT:IRRITTO
EYES & SKIN & SKIN SENSITIVITY. CHRONIC:THOSE HAZ MATLS (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:TOLUENE DIISOCYANATE:IARC GRP 2B, VOL 7,
P.56, 1987; ANTIC TO BE CARCIN, NTP 6TH ANNUAL RPT ON CARCINOGENS,
1991.
Effects of Overexposure:HLTH HAZ:LISTED IN INGS SECTION MAY AFFECT
FOLLOWING ORGANS: RESP TRACT, LIVER, REPRO SYSTEM, BLOOD. ALLERGIC
RESP & SKIN REACTION.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. EYE:FLUSH IMMEDIATELY W/LARGE
AMOUNTS OF RUNNING WATER FOR AT LEAST 15 MINUTES. SKIN:REMOVE
CONTAMINATED CLOTHING & WASH W/SOAP & WATER. INGEST:DRINK WATER. IF
NECESSARY, C ONSULT MD FOR ANY OF THESE CONDITIONS.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:40.0F,4.4C
Lower Limits:0.9%
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID - CLASS IB.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION,AVOID BREATHING
VAPORS,VENTILATE AREA. REMOVE W/INERT ABSORBANT & NON-SPARKING
TOOLS. BEFORE ATTEMPTING TO CLEAN UP SEE HAZARDOUS INGREDIENTS
SECTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DONT INGEST.GROUND CNTNR WHEN
POUR.AVOID LIQUID FREE FALL.DRUM SHOULD BE COMPLETELY EMPTY BEFORE
WELD/BRAZE.CLEAN DRUM INDUSTRIALLY BEFORE USE.
Other Precautions:DO NOT FLAME CUT, BRAZE OR WELD W/OUT NIOSH/MSHA
APPROVED RESPIRATOR OR APPROPRIATE VENTILATION. KEEP CONTAINER
CLOSED WHEN NOT IN USE. DO NOT BREATHE VAPOR OR SPRAY MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE GEN DILUTION/LOC EXHST FAILS TO ADEQ
DILUTE TWA/PEL OF MATL, THEN NIOSH/MSHA APPRVD RESP PROT SHLD BE
USED AS FOLLOWS:WEAR APPROP, PROPERLY FITTED RESP WHEN EXPOSED.
AIRLINE RESP (TC19C) IS REC. VAP/PARTICULATE RESP (TC23C) (SUPDAT)
Ventilation:PROVIDE GENERAL DILUTION OR LOCAL EXHAUST VENT TO KEEP TWA
& LEL BELOW ACCEPT LIMITS & TO REMOVE DECOMP PRODUCTS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
RESP PROT:MAY BE APPROP WHEN AIR-BORNE MONITORING SHOWS ISOCYANATES TO
BE 10 TIMES LESS THAN APPLICABLE EXPOSURE LIMITS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>167F,>75C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOCYANATE REACT W/WATER .
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES MAY CONTAIN CARBON MONOXIDE &
OXIDES OF NITROGEN. MAY PRODUCE HAZARDOUS FUMES WHEN HEATED TO
DECOMP AS IN WELDING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE &
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HYDROGEN PEROXIDE 3 %
Preparer's Name:MARCY COLLAS
CAGE:65422
CAGE:65422
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN PEROXIDE (SARA III)
CAS:7722-84-1
RTECS #:MX0900000
Fraction by Wt: 3.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 PPM
ACGIH TLV:1 PPM; 9192
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF
EYES,SKIN,RESPIRATORY OR G,I.TRACT;REDNESS OR BURNS OF EYES ARE
POSSIBLE.VOMITING AND DIRRHEA.
Explanation of Carcinogenicity:DATA PER MGF MSDS.
Effects of Overexposure:EYE BURNS. SKIN IRRITATION. EFFECTS MAY BE
DELAYED.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
WORSEN.
======================= First Aid Measures =======================
First Aid:EYES AND SKIN:FLUSH WITH LARGE AMOUNT OF WATER FOR ABOUT
15-20 MINUTES;SEEK MEDICAL ATTENTION IMMEDIATELY.INHALATION:REMOVE
TO FRESH AIR;CALL A PHYSICIAN.INGESTION:SEEK MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:DECOMPOSITION RELEASES OXYGEN WHICH MAY
INTENSIFY FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO AN APPROVED CHEMICAL SEWER BY
FLOODING WITH LARGE AMOUNTS OF WATER APPLIED QUICKLY TO ENTIRE
SPILL AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA, NON-COMBUSTIBLE AREA, AWAY FROM HEAT AND IGNITION SOURCES.
KEEP CONTAINERS CLOSED.
Other Precautions:AVOID CONTACT WITH EYES, SKIN, CLOTHING, AND
COMBUSTIBLE MATERIALS. AVOID CONTAMINATION FROM ANY SOURCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:PROTECTIVE CLOTHINGS.EYE-WASH
FACILITIES,SAFETY SHOWER.
Work Hygienic Practices:WASH THROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH SLIGHT PUNGENT ODOR.
Percent Volatiles by Volume:99.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HEAVY METALS, ORGANIC MATERIALS, DIRT.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAMES
Hazardous Decomposition Products:CONTAMINATION MAY CAUSE RAPID
DECOMPOSITION WITH RELEASE OF LARGE QUANTITIES OF OXYGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:SUDAFED BRAND TABLETS.
CAGE:09979
CAGE:09979
============= Composition/Information on Ingredients =============
Ingred Name:PSEUDOEPHEDRINE HYDROCHLORIDE
CAS:345-78-8
RTECS #:UL5950000
Fraction by Wt: 100.0%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT)=2,206+/-273MG/KG
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL BY INHALATION OF DUST OR IF
SWALLOWED IN EXCESS OF THERAPEUTIC DOSES.INGESTION MAY CAUSE RAPID
PULSE,RAISED BLOOD PRESSURE,PAIN IN CHEST,ANXIETY AND
RESTLESSNESS;THERE MAY BE DILATION OR PUPIL S OF THE EYES.SERIOUS
ADVERSE EFFECTS OF OVERDOSAGE INCLUDE
IRRITABILITY,CONVULSIONS,PALPATATIONS,AND HYPERTENSION.
Explanation of Carcinogenicity:DATA PER MGF MSDS.
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
WORSEN.
======================= First Aid Measures =======================
First Aid:EYES AND SKIN:FLUSH WITH LARGE AMOUNT OF WATER FOR ABOUT
15-20 MINUTES;SEEK MEDICAL ATTENTION IMMEDIATELY.INHALATION:REMOVE
TO FRESH AIR;CALL A PHYSICIAN.INGESTION:SEEK MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:COMBUSTIBLE.DUST CLOUDS MAY BE A POSSIBLE
EXPLOSION HAZARD.HEATING WILL GIVE RISE TO TOXIC FUMES(HCL)
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;SWEEP UP OR
VACUUM AND COLLECT FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA.KEEP CONTAINER CLOSED WHEN NOT IN USE.TEMPERATURE NOT
EXCEEDING 30C;PROTECT FROM LIGHT.
Other Precautions:WASH THOROUGHLY AFTER EACH USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR
DUST/MIST(3M 8710) IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:PROTECTIVE CLOTHINGS.EYE-WASH
FACILITIES,SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST/DUST.WASH THOROUGHLY AFTER EACH USE.
Supplemental Safety and Health
PROTECT FROM LIGHT.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:361F,183C
Solubility in Water:NEGLIBIBLE
Appearance and Odor:WHITE,CRYSTALLINE POWDER;ALMOST ODORLESS;BITTER
TASTE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE NOTED
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:NOT SPECIFIED
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES;DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BISMARCK BROWN Y, C548
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:BISMARCK BROWN Y
CAS:10114-58-6
Fraction by Wt: 90-100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL/SKIN/EYE/SKIN
ABSORP/INGEST: NONE IDENTIFIED. CHRONIC: NONE IDENTIFIED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST: CALL A PHYS. IF SWALLOWED, IF CONSCIOUS, IMMED INDUCE
VOMIT. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYGEN. SKIN: FLUSH W/WATER. EYE: IMMED FLUSH
WIT H PLENTY OF WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE IDENTIFIED.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE CLOTHING. W/CLEAN SHOVEL, CAREFULLY PLACE MATERIAL INTO
CLEAN, DRY CONTAINER AND COVER; REMOVE FROM AREA. FLUSH SPILL AREA
W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP COTNAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE. AVOID CONTACT W/EYES,
SKIN, CLTHG. CAUSES IRRITATION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:IMPERVIOUS CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SINCE SOME OF THE HAZ OF PROD ARE UNKNOWN, AN INDUST HYGIENIST SHOULD
BE CONSULTED ON VENTILATION AND PERSONAL PROTECTIVE EQUIPMENT.
COVER BODY AS MUCH AS POSSIBLE TO AVOID CONTACT WITH CHEMICAL.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:APPRECIABLE(>10%)
Appearance and Odor:PURPLE TO REDDISH-BROWN CRYSTALS
Percent Volatiles by Volume:0@21C
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE DOCUMENTED.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, OXIDES OF NITROGEN,
CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL APPLICABLE FEDERAL, STATE, AND
LOCAL ENVIRONMENTAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:0176099 THROMBOSCREEN THROMBOPLASTIN,DRIED 200 DET
CAGE:FO220
CAGE:15481
CAGE:9T814
CAGE:FO220
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE, AZIDE *95-4*
CAS:26628-22-8
RTECS #:VY8050000
Fraction by Wt: 5%
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INHALATION:
NEUROLOGICAL EFFECTS AT EXTREMELY HIGH LEVELS. LOWERED BLOOD
PRESSURE, SLOW PULSE & RESPIRATORY TRACT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HEADACHE, DIZZINESS, BLURRED VISION,
IRRITATION.
======================= First Aid Measures =======================
First Aid:INGESTION: INDUCE VOMITING BY GIVING WATER & P-AMINO
PROPIOPHENONE. INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED.
SKIN/EYES: FLUSH W/WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL/SODA ASH.
Fire Fighting Procedures:DON'T USE WATER. SODIUM METAL CAN REACT
W/WATER TO FORM HYDROGEN. WEAR SCBA.
Unusual Fire/Explosion Hazard:EXPLOSION HAZARD BY HEAT/SHOCK. EXPLOSIVE
METAL AZIDES FORM W/COPPER/LEAD.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER MATERIAL/ABSORB ON AN INERT MATERIAL &
PLACE IN A NON-METAL CONTAINER. RINSE AREA W/WATER. WEAR PROTECTIVE
EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:SODIUM AZIDE CAN REACT W/COPPER & LEAD
PLUMBING. SODIUM HYDROXIDE CAN BE USED AS A CLEANING AGENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Work Hygienic Practices:NO SPECIAL REQUIREMENTS BEYOND NORMAL SAFE
LABORATORY PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Decomp Temp:Decomp Text:662F
Vapor Pres:NEGLIGIBLE
Vapor Density:2.2
Spec Gravity:1.85
Solubility in Water:42%
Appearance and Odor:WHITE GRANULAR POWDER W/NO ODOR.
Percent Volatiles by Volume:<0.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDRAZOIC ACID, LEAD, SILVER, MERCURY, COPPER, CARBON
DISULFIDE/BROMINE/NITRIC ACID/BENZYL CHLORIDE/POTASSIUM HYDROXIDE.
Stability Condition to Avoid:HEAT, SHOCK
Hazardous Decomposition Products:SODIUM AZIDE DECOMPOSES TO SODIUM
METAL & CAN EMIT HYDRAZOIC ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL QUANTITIES OF MATERIAL MAY BE POURED INTO
A DRAIN/SEWER & FLUSHED W/LARGE QUANTITIES OF WATER. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FORMREZ F17-80, 081 0918
Preparer's Name:CHARLES GREEN
CAGE:IO535
CAGE:4X549
CAGE:IO535
============= Composition/Information on Ingredients =============
Ingred Name:POLYESTER RESIN
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC:NO DATA AVAILABLE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES:IMMEDIATELY FLUSH W/LARGE QUANTITIES OF WATER FOR AT
LEAST 15 MINUTES & CALL MD. SKIN:FLUSH W/LARGE AMOUNTS OF WATER FOR
15 MINUTES. INGEST:CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:DRY CHEMICAL, CO*2 OR FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/INERT MATERIAL SUCH AS SAND, SOIL OR
VERMICULITE; SWEEP UP & DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 40 & 120F.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:MECHANICAL.
Other Protective Equipment:SYNTHETIC APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Vapor Pres:<1 @ 20C
Spec Gravity:1.248 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:VERY VISCOUS LIGHT YELLOW LIQUID; CHARACTERISTIC
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS HYDROGEN PEROXIDE, BROMINE & CHROMIC ACID.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AS W/ANY ORGANIC MATERIAL, COMBUSTION
WILL PRODUCE CARBON DIOXIDE (CO*2) & PROBABLY CARBON MONOXIDE (CO).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL APPLICABLE FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:5R324, 5750/5760/5765/5790 DOCUCOLOR 40 (SUPDAT)
CAGE:0E6G9
CAGE:0E6G9
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:KAOLIN; (CU-ZN FERRITE POWDER)
CAS:66402-68-4
Fraction by Wt: >90%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYESTER
CAS:128781-91-9
Fraction by Wt: >4.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER, (PHTHALOCYANINATO(2-))-; (BLUE PIGMENT)
CAS:147-14-8
Fraction by Wt: 0.2-0.4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SPILL PROC: USED TO REDUCE STATIC BUILDUP (SEE FIRE &
EXPLOSION DATA). RESIDUE CAN BE REMOVED W/SOAP & COLD (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: WATER. GARMENTS MAY BE WASHED OR DRY CLEANED AFTER
REMOVAL OF LOOSE TONER.
RTECS #:9999999ZZ
REQUIRED. FOR MORE INFORMATION, CONTACT XEROX.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) >5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINIMAL RESP TRACT IRRIT MAY OCCUR AS
W/EXPOS TO LARGE AMOUNTS OF ANY NON-TOXIC DUST. THE RSLTS OBTAINED
FROM XEROX SPONSORED, CHRONIC TONER INHAL STUDY, DEMONSTRATED NO
LUNG CHANGE IN RATS FOR LOWEST (1MG/M3) EXPOS LEVEL (IE, LEVEL
MOST RELEVANT TO POTNTL HUMAN EXPOS). VERY SLIGHT DEGREE OF
FIBROSIS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: WAS NOTED IN 25% OF ANIMALS AT MIDDLE
(4MG/M3) EXPOS LEVEL, WHILE SLIGHT DEGREE OF FIBROSIS WAS NOTED IN
ALL ANIMALS AT HIGHEST (16MG/M3) EXPOS LEVEL. THESE FINDINGS ARE
ATTRIBUTED TO "LUNG OVERLOADING," A GENERIC RESPONSE TO EXCESSIVE
AMOUNTS OF ANY DUST RETAINED IN LUNGS FOR PRLNGD PERIOD. THIS
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE. INGESTION:
DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, DRY CHEMICAL, CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. LIKE MOST
ORGANIC MATERIALS IN POWDER FORM, IT CAN FORM EXPLOSIVE MIXTURES
WHEN DISPERSED IN AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM SPILLED TONER & CAREFULLY
TRANSFER INTO SEALABLE WASTE CNTNR. SWEEP SLOWLY TO MINIMIZE
GENERATION OF DUST DURING CLEAN-UP. IF VACUUM IS USED, MOTOR MUST
BE RATED AS DUST TIGHT. COND UCTIVE HOSE BONDED TO MACHINE SHOULD
BE(ING 4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT. USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:FOR USE OTHER THAN NORM CUSTOMER-OPERATING
PROCEDURES (SUCH AS IN BULK TONER PROCESSING FACILITIES), ANSI
APPRVD (ING 6)
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: CYAN DEVELOPER. EFTS OF OVEREXP: STUDY WAS
CONDUCTED USING SPECIAL TEST TONER TO COMPLY W/EPA TESTING
PROTOCOL. TEST TONER WAS TEN TIMES MORE RESPIRABLE THAN
COMMERCIALLY AVA IL XEROX TONER & WOULD NOT BE FUNCTIONALLY
SUITABLE FOR XEROX EQUIP.
================== Physical/Chemical Properties ==================
Appearance and Odor:BLUE POWDER; FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
AVOID BREATHING SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL IS NOT HAZ WASTE ACCORDING TO
FEDERAL REG 40 CFR 261 WHEN DISPOSED. STATE & LOCAL WASTE DISP REQS
HOWEVER, MAY BE MORE RESTRICTIVE. PLEASE, CONSULT W/APPROP FEDERAL,
STATE & LOCAL WASTE DISP AUTHS. INCINERATE ONLY IN CLOSED
CONTAINER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SOFSCALE, A90050
CAGE:2J095
CAGE:2J095
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL; (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:SUCCINAMIC ACID, 3-AMINO-N-(ALPHA-CARBOXYPHENETHYL)-,
N-METHYL ESTER, STEREOISOMER; (ASPARTAME)
CAS:22839-47-0
RTECS #:WM3047000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO ACUTE OR CHRONIC EXPOSURE EFFECT
SEEN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES:FLUSH LIBERALLY W/WATER FOR AT LEAST 15 MINUTES &
CONTACT MD. SKIN:RINSE W/WATER. INGEST:TREAT AS A 10% ALCOHOL
SOLUTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:162F,72C
Extinguishing Media:WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL STEPS REQUIRED BEYOND FLUSHING
W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:PREFERRED STORAGE IN COOL, DRY
LOCATION.
Other Precautions:FLAMMABLE LIQUID. FOR DENTAL PROFESSIONAL USE ONLY.
KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED DURING NORMAL USE OF THIS
PRODUCT.
Ventilation:NONE REQUIRED DURING NORMAL USE OF THIS PRODUCT.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:187F,86C
Spec Gravity:0.96 (H*2O=1)
pH:6.4
Evaporation Rate & Reference:1 (H*2O=1)
Solubility in Water:100%
Appearance and Odor:CLEAR, BLUE-GREEN GEL W/PLEASANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL APPLICABLE FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CWF-UV CLEAR/CEDAR/REDWOOD
CAGE:IO086
CAGE:IO086
CAGE:16668
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (SOLVENT NAPHTHA MEDIUM
ALIPHATIC) (OR ING 2). VP:<3 @ 100F.
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: <24%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (SOLVENT
NAPHTHA MEDIUM ALIPHATIC). VP:<5 @ 100F.
CAS:64742-88-7
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA). VP:<0.05 @ 74F.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <2.5%
OSHA PEL:N/K
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:RESP PROT:SUPPLIER). ENGINEERING OR ADMINISTRATIVE CONTROLS
SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:LIQUID CONTACT IS LIKELY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED SKIN CONTACT MAY
CAUSE SKIN IRRITATION. SKIN:DRYNESS, IRRITATION, DERMATITIS FROM
EXCESSIVE, PROLONGED OR REPEATED CONTACT. EYES:CAN CAUSE SEVERE
IRRITATION, REDNESS, TEARING AND BLURRED VISION.
INHALATION:PROLONGED OR REPEATED CONTACT CAN CAUSE NASAL AND
RESPIRATORY IRRITATION, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE, POSSIBLE UNCONSCIOUSNESS & EVEN ASPHYXIATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP)
. SKIN:WASH PROMPTLY W/SOAP & WATER. DO NOT CONTINUE TO WEAR
OIL-SOAKED CLTHG. DISCARD OIL-SOAKED LEATHER GOODS. EYES:FLUSH
IMMED W/ COPIOUS AMTS OF CLEAN COOL WATER FOR ATLST 15 MINS & CALL
MD. INGEST:DO NOT INDUCE VOMIT DUE TO DANGER OF ASPIRATING OIL INTO
LUNGS. AFTER SPONT VOMIT, MONITOR FOR BRTHG DFCLTY. THIS EFT MAY
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:175F,79C
Extinguishing Media:FOAM, DRY CHEMICAL, WATER FOG, CO*2.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY CAUSE FROTHING. EXPOSED MATERIAL MAY BE
COOLED WITH WATER. AVOID BREATHING FUMES.
Unusual Fire/Explosion Hazard:COMBUST LIQ. DENSE SMOKE. VAPS ARE
HVR/AIR & MAY TRAVEL ALONG GROUND/BE MOVED BY VENT & IGNITED BY
HEAT, PILOT LIGHTS, OTHER FLAMES & IGNIT SOURCES AT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF VAPOR IGNITIONS.
VENTILATE AREA. REMOVE LIQUID WASTE WITH OIL-ABSORBING COMPOUNDS
AND NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTIBLE. PREVENT CONTACT W/FLAMES
OR HOT SURFACES. DO NOT STORE NEAR HEAT. KEEP CONTAINERS CLOSED
WHEN NOT IN USE.
Other Precautions:AVOID PROLONGED CONTACT W/SKIN. AVOID BREATHING
CONCENTRATED VAPORS. STORE ONLY IN WELL-VENTILATED AREAS. STORE OUT
OF SUN & AWAY FROM HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED, A
NIOSH/OSHA JOINTLY APPRVD, AIR SUPPLIED RESP IS ADVISED IN ABSENCE
OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH/OSHA
RESPS UNDER SPECIFIED C NDTNS (SEE YOUR SAFETY EQUIP (ING 4)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . OIL REPELLANT, PROT CLTHG IF PRLNG (ING 5)
Work Hygienic Practices:WASH HANDS W/SOAP & WATER BEFORE EATING,
DRINKING, SMOKING/USING TOILET FACILITIES. LAUNDER CONTAM CLTHG
BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ:LOCATIONS DIST FROM MATL HNDLG POINT. DO NOT FLUSH INTO
PUBLIC SEWER SYSTEM. FIRST AID PROC:BE DELAYED. IF SYMPS APPEAR,
PERSIST/IF EXPOS IS SEV, SEEK PROMPT MED HELP. REMOVE TO FRESH AIR.
N OTES TO MD:ASPIR OF LIQ PETRO PRODS INTO LUNGS MAY CAUSE SEV
PNEUM (OIL PNEUM). VOMIT SHOULD NOT BE INDUCED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.95
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:59
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AOVID CONTACT W/STRONG OXIDIZERS.
Stability Condition to Avoid:STORAGE OF COMBUSTIBLE MATERIALS WETTED
W/LIQUID CAN PRODUCE HEAT & SPONTANEOUS COMBUSTION.
Hazardous Decomposition Products:COMBUSTION IN RESTRICTED ENVIRONMENTS
CAN PRODUCE CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE CLOSED CONTAINERS. DO NOT
DISPOSE OF WASTE MATERIAL IN SEWERS OR WATERWAYS. DISPOSE I/A/W ALL
LOCAL, STATE & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DIMETHYL PHTHALATE, 99%, D17898-5
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:DIMETHYLPHTHALATE (SARA III)
CAS:131-11-3
RTECS #:TI1575000
Fraction by Wt: 99%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORL,RAT)6800 MG/KG;(SEE SUPP DATA)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:HARMFUL IF INGESTED, INHALED OR
ABSORBED THROUGH SKIN. VAPOR OR MIST IS IRRITATING TO EYES, MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT. CAUSES EYE AND SKIN
IRRITATION. CHRONIC:MAY CAUSE REPROD UCTIVE DISORDERS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EXPOSURE CAN CAUSE:NAUSEA, DIZZINESS AND
HEADACHE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/COPIOUS AMTS OF WATER FOR AT LEAST
15 MINUTES. SKIN:IMMEDIATELY FLUSH W/COPIOUS AMTS OF WATER FOR 15
MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. WASH
CONTAMINATED CLOTHING BEFORE REUSE. INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP), CALL MD. INGEST:CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:295F,146C
Lower Limits:0.94% @ 181C
Upper Limits:8.03% @ 229C
Extinguishing Media:WATER SPRAY, CO*2, DRY CHEMICAL POWDER, ALCOHOL OR
POLYMER FOAM. FOAM/WATER SPRAY ARE EFFECTIVE BUT MAY CAUSE
FROTHING.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES. USE
WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH/MSHA APPROVED SCBA,
PLACE IN CLOSED CONTAINERS FOR DISPOSAL. VENTILATE AREA & WASH
SPILL SITE AFTER MATERI AL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP TIGHTLY
CLOSED. AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT BREATHE VAPOR.
DO NOT GET IN EYES, ON SKIN OR CLOTHING.
Other Precautions:IRRITANT. HARMFUL VAPOR. POSSIBLE TERATOGEN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN CHEMICAL FUME HOOD.
Other Protective Equipment:PROTECTIVE CLOTHING. SAFETY SHOWER AND EYE
BATH.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
LD50-LC50 MIX:LD50:(IPR,RAT)3375 MG/KG; LD50:(ORL,MUS)6800 MG/KG;
LD50:(IPR,MUS)1580 MG/KG; LD50:(ORL,RBT)4400 MG/KG;
LD50:(ORL,GPG)2400 MG/KG; LD50:(ORL,CKN)8500 MG/KG.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:540F,282C
Melt/Freeze Pt:M.P/F.P Text:35.6F,2.0C
Vapor Pres:1.0 @ 100C
Vapor Density:6.69
Spec Gravity:1.19
Evaporation Rate & Reference: ZERO (METHYL ACETATE=1)
Solubility in Water:0.04%
Appearance and Odor:VISCOUS, COLORLESS LIQUID. SLIGHT AROMATIC ODOR .
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER AND
SCRUBBER. DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HEAVY DUTY HAND CLEANSER, 2242
CAGE:EO366
CAGE:EO366
CAGE:6P489
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (DEODORIZED KEROSENE)
CAS:64742-47-8
RTECS #:OA5504000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL SPIRITS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CYCLOHEXENE, 1-METHYL-4-(1-METHYLETHENYL)-, (R)-;
(D-LIMONENE)
CAS:5989-27-5
RTECS #:GW6360000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYETHYLENE; (POLYETHYLENE BEADS)
CAS:9002-88-4
RTECS #:TQ3325000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TETRADECANOIC ACID, ISOPROPYL ESTER; (ISOPROPYL MYRISTATE)
CAS:110-27-0
RTECS #:XB8600000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
CAS:102-71-6
RTECS #:KL9275000
OSHA PEL:N/K
ACGIH TLV:5 MG/M3
Ingred Name:GLYCOLS, POLYETHYLENE, MONO(P-NONYLPHENYL) ETHER;
(NONOXYNOL-12)
CAS:26027-38-3
RTECS #:MD0906000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOAP; (COCONUT SOAP)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC ACID, POLYMERS; (CARBOMER 941)
CAS:9003-01-4
RTECS #:AT4680000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-NAPHTHOL, 1-(O-TOLYLAZO)-; (D&C ORANGE #4)
CAS:2646-17-5
RTECS #:QL5425000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT MAY CAUSE TEMPORARY
MODERATE IRRITATION. EXCESSIVE SKIN CONTACT WITHOUT RINSING
THOROUGHLY MAY CAUSE TEMPORARY DRYNESS AND IRRITATION. INGESTION
MAY RESULT IN GASTRIC DISTURBANCES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O*2/ARTF RESP) . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
EYES:AVOID RUBBING EYES. IMMEDIATELY FLUSH W/CLEAN WATER WHILE HOL
DING EYELIDS APART. CONTINUE FLUSHING FOR AT LEAST 15 MINUTES OR
UNTIL IRRITATION SUBSIDES. CONTACT MD AS SOON AS POSSIBLE.
INGESTION:CONTACT MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:>212F,>100C
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP & COLLECT IN SUITABLE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:GENERALLY NONE REQUIRED. IN CASE OF LARGE SPILL,
USE NIOSH APPROVED AIR PURIFYING RESPIRATOR W/ORGANIC VAPOR
CARTRIDGE.
Ventilation:GENERAL MECHANICAL.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:23.8 @ 25C
Spec Gravity:0.95
pH:8.8
Solubility in Water:SOLUBLE
Appearance and Odor:ORANGE, OPAQUE, VISCOUS LIQUID W/CITRUS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC GASES MAY BE GENERATED DURING
FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:ORTHOPHOSPHORIC ACID,TECHNICAL
CAGE:GO854
CAGE:97854
CAGE:GO854
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID (SARA III)
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: 75%
OSHA PEL:1 MG/M3/3 STEL
ACGIH TLV:1 MG/M3/3 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYE/SKIN:IRRITATION & SEVERE BURNS.
INGESTION:SEVERE IRRITATION & INTERNAL DAMAGE.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER 15 MINUTES, OBTAIN MEDICAL ATTN. SKIN:
FLUSH WITH WATER, REMOVE CONTAMINATED CLOTHING UNDER THE
SHOWER,CONTINUE WASHING WITH WATER. INGESTION: DO NOT INDUE
VOMITING,DILUTE ACID WI TH LARGE QUANTITIES OF WATER OR MILK,SEE A
MD.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:PHOSPHORIC ACID CAN REACT WITH METALS TO
PRODUCE HYDROGEN GAS
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE UNNECESSARY PERSONNEL, AVOID EYE/SKIN
CONTACT. NEUTRALIZE WITH CHEMICAL AGENTS.PICK UP. FOR LARGE SPILLS
USE A PREDETERMINED PLAN TO CONTAIN & NEUTRALIZE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY WELL VENTED AREA. AVOID
FREEZING TEMP. STORE IN PROPEALY CONSTRUCTED STORAGE TANKS.
============= Exposure Controls/Personal Protection =============
Ventilation:GENERAL
Other Protective Equipment:HARD HAT, RUBBER BOOTS, SAFETY SHOWER, EYE
WASH FOUNTAIN.
Supplemental Safety and Health
CONT SIZE: 160 LB CARBOY, PH:<1
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:135C
Vapor Pres:15
Spec Gravity:1.58
Solubility in Water:MISCIBLE
Appearance and Odor:WATER WHITE LIQUID, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMMON METALS & ALKALIES (BASES)
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH LOCAL STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:780 RAM POLYESTER COLORS
CAGE:29431
CAGE:29431
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 38-69%
Other REC Limits:100PPM (SKIN) STEL
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYRIC ACID LACTONE, TETRAHYDRO-2-FURANONE, BLO
CAS:96-48-0
RTECS #:LU3500000
Fraction by Wt: 23-26%
ACGIH TLV:10 PPM
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.5-2.8%
Other REC Limits:100 PPM
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION & DAMAGE. SKIN:
IRRITATION, RED, & DRY. INHALATION: RESPIRATORY TRACT IRRITATION,
HEADACHE, DIZZINESS, NAUSEA, VOMITING, LOSS OF CONSCIOUSNESS,
KIDNEY, LIVER, & CENTRAL NERVOUS SYSTEM DAMAGE. INGESTION:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE: IRRITATION & DAMAGE. SKIN: IRRITATION,
RED, & DRY. INHALATION: RESPIRATORY TRACT IRRITATION, HEADACHE,
DIZZINESS, NAUSEA, VOMITING, LOSS OF CONSCIOUSNESS, KIDNEY, LIVER,
& CENTRAL NERVOUS SYSTEM DAMAGE. INGESTION: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
GIVE CPR IF NEEDED. INGESTION: INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN A LL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:111F
Lower Limits:1%
Upper Limits:6.9%
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO2, & DRY CHEMICAL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS. USE
WATER FOG TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:VAPOR IS >AIR, IT MAY TRAVEL & IGNITE OR
FLASHBACK. EMPTY CONTAINERS STILL COULD IGNITE EXPLOSIVELY. KEEP
AREA CLEAR OF SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/SAND. REMOVE ALL SOURCES OF IGNITION.
DIKE AREA W/SAND TO CONTAIN SPILLED LIQUID. OPEN ALL WINDOWS &
DOORS. PUMP INTO SALVAGE TANK.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS COOL, DRY & AWAY FROM
IGNITION SOURCES. CHECK ALL CONTAINERS FOR LEAKS.
Other Precautions:OVERHEATING MAY CAUSE CONTAINER TO RUPTURE & EMPTY
CONTAINERS CONTAINING RESIDUE MAY CAUSE A HAZARD. AVOID BREATHING
FUMES & CONTACT W/SKIN. DON'T TAKE INTERNALLY. WASH THOROUGHLY
AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A MSHA/NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:PROVIDE LOCAL EXHAUST/MECHANICAL VENTILATION TO KEEP <TLV.
IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PRODUCT DOES NOT CONTAIN LEAD OR CHROMATE PIGMENTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:279-313F
Vapor Pres:1.22-2.0
Vapor Density:3.38-3.42
Spec Gravity:0.969-1.464
Evaporation Rate & Reference:SLOWER THAN BU AC
Solubility in Water:<0.1%
Appearance and Odor:CLEAR & COLORED PASTE W/PUNGENT ODOR.
Percent Volatiles by Volume:66-71%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALIES, & ACIDS.
Stability Condition to Avoid:EXTREME HEAT, COLD, & ELEVATED TEMPS.
Hazardous Decomposition Products:ACRID SMOKE, CO, CO2, & VARIOUS
HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. KEEP MATERIAL OUT OF SEWERS & STREAMS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:POTASSIUM CHLORIDE, 99.99+%, 20409-9
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CHLORIDE, 99.99+%.
CAS:7447-40-7
RTECS #:TS8050000
Fraction by Wt: 99.99%+
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE SUPP DATA
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. INGEST OF LRG QUANTITIES CAN CAUSE WEAKNESS,
GASTROINTESTINAL IRRITATION AND CIRCULATORY DISTURBANCES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN: IMMEDIATELY WASH WITH SOAP AND COPIOUS
AMOUNTS OF WATER. WASH CONTAM CLTHG BEFORE REUSE. INHAL: REMOVE TO
FRESH AIR . IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. CALL MD. INGEST: CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY. CO2, DRY CHEMICAL POWDER, ALCOHOL OR
POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND PROTECTIVE
CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS
WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND WASH SPILL
SITE AFTER MATERIAL PICKUPIS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT AND INHALATION. HARMFUL
SOLID. KEEP TIGHTLY CLOSED. STORE IN A COOL DRY PLACE.
Other Precautions:DO NOT GET IN EYES, ON SKIN AND CLOTHING. IRRITANT.
HYGROSCOPIC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE AND BEFORE EATING,
DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
LD50-LC50 MIX: LD50:(ORL,RAT) 660 MG/KG, (IV,RAT) 142 MG/KG, (ORL,MUS)
2715 MG/KG, (IPR,MUS) 1181 MG/KG, (IV,MUS) 117 MG/KG, (ORL,GPG)
2500 MG/KG. WASTE DISP METH: REACTIONS MAY GENERATE HEAT AND FUME S
WHICH CAN BE CONTROLLED BY THE RATE OF ADDITION. OBSERVE ALL
FEDERAL, STATE AND LOCAL LAWS.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:1418F,770C
Spec Gravity:1.984
Appearance and Odor:COLORLESS TO WHITE CRYSTALS.
================= Stability and Reactivity Data =================
STRONG OXIDIZING AGENTS & STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:EMITS TOXIC FUMES UNDER FIRE
CONDITIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:SM QTYS: CAUTIOUSLY ADD TO LRG STIRRED EXCESS OF
WATER. ADJUST PH TO NEUTRAL, SEPARATE ANY INSOLUBLE SOLIDS OR
LIQUIDS AND PKG THEM FOR HAZ WASTE DISP. FLUSH AQUEOUS SOLN DOWN
DRAIN W/PLENTY OF WATER. THE HYDROLYSIS AND NEUTRALIZATION
(SEESUPP DATA)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DUNCAN AR 700 SERIES
CAGE:21546
CAGE:21546
============= Composition/Information on Ingredients =============
Ingred Name:LEAD OXIDE YELLOW, LEAD OXIDE *96-2*
CAS:1317-36-8
RTECS #:OG1750000
OSHA PEL:0.5 MG
ACGIH TLV:0.15 MG/CUM
Ingred Name:BARIUM OXIDE
CAS:1304-28-5
RTECS #:CQ9800000
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:ALKALI BOROSILICATE FRITS *96-2*
CAS:65997-18-4
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
CARCINOGEN BY IARC-GROUP 2A; SUSPECTED CARCINOGEN NTP) *96-2*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <8%
Other REC Limits:0.05 MG/CUM (NIOSH)
OSHA PEL:10 MG/CUM %RESP SIO2
ACGIH TLV:0.1 MG/CUM RESP DUST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE TO LEAD MAY CAUSE NERVOUS
SYSTEM, KIDNEY/BONE MARROW DAMAGE/HARM TO THE DEVELOPING FETUS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:WEIGHT LOSS, STOMACHE CRAMPS, LOSS OF
COORDINATION, JOINT & MUSCLE PAINS.
Medical Cond Aggravated by Exposure:ABRASIVE, CAN SCRATCH EYES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER AT LEAST 15 MINS. SKIN: WASH W/SOAP &
WATER. SKIN: WASH W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE. WILL NOT BURN.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP PROPERLY W/PAPER TOWELS & A WET
SPONGE.
======================Handling and Storage ======================
Handling and Storage Precautions:WHEN USING, DON'T EAT, DRINK/SMOKE.
WASH HANDS IMMEDIATELY AFTER USE. KEEP SEALED. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:AVOID USING IF PREGNANT/CONTEMPLATING PREGNANCY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED DUST & MIST RESPIRATOR.
Ventilation:LOCAL EXHAUST: RECOMMENDED. MECHANICAL(GENERAL):
RECOMMENDED WHEN SPRAYING. SPECIAL: USE RESPIRATOR WHEN SPRAYING.
Other Protective Equipment:IF IN THE GLAZE FORM & APPLYING BY SPRAY,
USE SPRAY BOOTH & RESPIRATORY. CLEAN SPRAY BOOTH FILTERS OFTEN.
Work Hygienic Practices:WEAR PROTECTIVE CLOTHING THAT IS REMOVED BEFORE
EATING, DRINKING, SMOKING/LEAVINGWORK. (SEE SUPP)
Supplemental Safety and Health
WORK HYGIENIC PRACTICES CONT'D: WASH THOROUGHLY, IMMEDIATELY AFTER
SPRAYING. IF GLAZE SPRAYING, REGULAR BLOOD LEADLEVEL TESTING IS
ADVISEABLE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:1800F
Spec Gravity:1.7
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED LIQUID W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:ARCON 2795
CAGE:JO373
CAGE:65483
CAGE:JO373
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE, 1-BUTOXY-2,3-EPOXY-; (BUTYL GLYCIDYL ETHER) (BGE)
CAS:2426-08-6
RTECS #:TX4200000
Fraction by Wt: <15%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: NO ESTABLISHED AS OF
THE CURRENT ISSUE DATE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MIN, CONSULT MD. SKIN:
REMOVE UNCURED PROD W/DRY CLOTH/TOWEL, WASH THORO W/SOAP & WATER.
CONSULT MD IF IRRIT DEVELOPS. DO NOT USE SOLV TO REMOVE PROD.
INHAL: REMOVE TO FRESH AIR IMMED. INGEST: GIVE MILK/WHITE OF EGG
BEATEN W/WATER, & REPEAT UNTIL VOMIT FLUID IS CLEAR. IF VOMIT DOES
NOT OCCUR, INDUCE VOMIT BY GAGGING VICTIM. DO NOT INDUCE VOMIT/GIVE
(SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:200F,93C
Extinguishing Media:MOST STANDARDS FIREFIGHTING AGENTS ARE SUITABLE,
I.E. SAND, FOAM, CARBON MONOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DURING FIRE IRRITATING AND/OR TOXIC GASES
MAY BE PRESENT FROM DECOMP/COMBUST PRODUCTS. DO NOT USE FOAM/FIRES
INVOLVING ELECTRICAL EQUIPMENT.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER SPILLS WITH DRY ABSORBENT SUCH AS SAND
OR SAWDUST; SCOOP UP AND PLACE IN AN APPROPRIATE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN AT AMBIENT TEMPERATURE
AND 80F (27C). TWELVE MONTHS IN ORIGINAL SEALED CONTAINERS.
Other Precautions:STORE IN DRY AREA AWAY FROM EXCESSIVE HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNLESS VAPOR CONCENTRATIONS ARE
EXCESSIVE. A NIOSH APPROVED ORGANIC VAPOR CARTRIDGE RESPIRATOR CAN
BE USED. OBSERVE THE MANUFACTURER'S DIRECTIONS CONCERNING THE USE
OF RESPIRATORY PROTEC TION.
Ventilation:NO SPECIAL REQUIREMENTS. LOCAL EXHAUST/DILUTION VENT WILL
HELP DISSIPATE VAPS IN ENCLOSED OR POORLY VENTILATED AREAS.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: ANYTHING BY MOUTH TO AN UNCON PERS. CALL MD IMMED.
================== Physical/Chemical Properties ==================
Vapor Pres:2
Vapor Density:3.78
Spec Gravity:1.13
Solubility in Water:<1%
Appearance and Odor:CLEAR TO STRAW VISCOUS LIQUID, WITH SWEET PLEASANT
ODOR
Percent Volatiles by Volume:15
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDIC/BASIC OXIDIZING AGENTS, WATER, HEAT.
Stability Condition to Avoid:MOISTURE AND EXCESSIVE HEAT.
Hazardous Decomposition Products:THERMAL DECOMPOSITION WILL PRODUCE
CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR INCINERATE UNDER CONDITIONS WHICH
MEET FEDERAL, STATE AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:183A105 SEVEN STAR FLAT LATEX WALL PAINT
CAGE:ACEHA
CAGE:ACEHA
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 17.9%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 22.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:BARIUM, CALCIUM, MAGNESIUM, STRONTIUM, ALUMINUM SILICATE
FLUX; (ALUMINUM SILICATE)
CAS:66402-68-4
Fraction by Wt: 13.3%
OSHA PEL:5 MG/CUM (MFR)
ACGIH TLV:5 MG/CUM (MFR)
Ingred Name:NEPHELINE SYENITE
CAS:37244-96-5
Fraction by Wt: 3.1%
OSHA PEL:N/K
ACGIH TLV:5 MG/CUM (MFR)
Ingred Name:1-PROPANOL, 2-AMINO-2-METHYL-;
(2-AMINO-2-METHYL-1-PROPANOL)
CAS:124-68-5
RTECS #:UA5950000
Fraction by Wt: 0.2%
OSHA PEL:20 PPM (MFR)
ACGIH TLV:10 PPM (MFR)
Ingred Name:AMMONIA (SARA 302/313) (CERCLA)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: <0.1%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IN A CONFINED AREA VAPORS IN
HIGH CONCENTRATIONS ARE ANESTHETIC, IRRITANT TO UPPER RESPIRATORY
SYSTEM. SIGNS AND SYMPTOMS OF EXPOSURE:LIGHTHEADEDNESS AND
STAGGERED GAIT. CHRONIC:PROBLEMS WITH RE SPIRATORY SYSTEM MAY BE
AGGRAVATED BY EXPOSURE TO VAPORS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:CHRONIC PROBLEMS WITH RESPIRATORY
SYSTEM MAY BE AGGRAVATED TO EXPOSURE TO VAPORS.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE.
RESTORE BREATHING. KEEP WARM AND QUIET. SKIN:WASH WITH SOAP AND
WATER. EYES:FLUSH WITH WATER FOR @ LEAST 15 MINUTES. GET MEDICAL
AID. LAU NDER CONTAMINATED CLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:199F,93C
Extinguishing Media:NON-COMBUSTIBLE. FOR DRY SOLIDS USE WATER, FOAM
CO*2, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO EXTREME HEAT
MAY RUPTURE DUE TO PRESSURE BUILD-UP. CONTENTS MAY SPATTER IF
TEMPERATURE EXCEEDS 212F.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOT STORAGE CATEGORY 3B.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST:PREFERABLE. MECHANICAL (GENERAL):ACCEPTABLE.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:AVOID BREATHING VAPOR OR SPRAY MIST. AVOID
CONTACT WITH SKIN OR EYES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Density:HVR/AIR
Spec Gravity:1.35 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED PIGMENTED LIQUID WITH SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO HAZARDOUS REACTIONS ARE EXPECTED UNDER NORMAL USE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ACRYMET PLUS
Preparer's Name:RICHARD J PETSCHE
CAGE:HO278
CAGE:HO278
CAGE:58380
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE,BUTYL ACRYLATE,ETHYL ACRYLATE,METHYL
METHACRYLATE,METHACRYLIC ACID COPOLYMER; (ACRYLATE COPOLYMER)
CAS:63744-68-3
Fraction by Wt: >1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2-(2-METHOXYETHOXY)-; (DIETHYLENE GLYCOL
MONOMETHYL ETHER)
CAS:111-77-3
RTECS #:KL6125000
Fraction by Wt: 4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZINC COMPOUND; (ZINC OXIDE COMPLEX)
Fraction by Wt: 0.4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AMMONIUM HYDROXIDE (CERCLA)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 0.8%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAUSES EYE IRRITATION.
INGESTION: IRRITATES DIGESTIVE TRACT. SKIN: PROLONGED CONTACT MAY
CAUSE IRRITATION. SIGNS & SYMPTOMS OF EXPOSURE: EYES: REDNESS.
SKIN: REDNESS. INGESTION: DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . EYES: FLUSH WITH PLENTY OF WATER
FOR AT LEAST 15 MINUTES. SEEK PROMPT MEDICAL ATTENTION. INGESTION:
DRIN L LARGE QUANTITIES OF WATER. CALL A PHYSICIAN. SKIN: FLUSH
WITH WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:WATER, FOAM, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . TOXIC GASES MAY BE RELEASED.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP SPILL WITH OIL ABSORBENT. REMOVE
RESIDUE WITH WATER AND DETERGENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP OUT OF THE
REACH OF CHILDREN.
Other Precautions:FOR INDUSTRIAL AND INSTITUTIONAL USE ONLY. READ AND
FOLLOW ALL LABEL DIRECTIONS AND PRECAUTIONS BEFORE USING. DO NOT
MIX WITH ANY OTHER CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE.
Ventilation:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN . NONE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Density:>1
Spec Gravity:1.012 (H*2O=1)
Evaporation Rate & Reference:>1 (BUTYL ACETATE =1)
Solubility in Water:COMPLETE
Appearance and Odor:OFF-WHITE MILKY EMULSION WITH A MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, AND OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:BURNING MAY YIELD TOXIC CHEMICALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD USED ABSORBANT IN TRASH CONTAINER. THIS
MATERIAL IS NOT AN EPA-RCRA HAZARDOUS WASTE. FOLLOW FEDERAL, STATE
AND LOCAL DISPOSAL REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: 70-2005-2307-7 2721 SCOTCHPRIME CERAMIC PRIMER
Cage: 76381
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 76381
=======================================================
Contractor Summary
=======================================================
Cage: 76381
=======================================================
Ingredients
=======================================================
Cas: 64-17-5
RTECS #: KQ6300000
% Wt: 70-80
Other REC Limits: 1900 MG/CUM
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 20-30
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES/SKIN: MILD IRRITATION. INHALATION: UPPER RESPIRATORY
IRRITATION, CNS DEPRESSION. INGESTON: IRRITATION OF GI TISSUES, CNS
DEPRESSION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure:
IRRITATION/REDNESS/SWELLING/PAIN/TEARING/ITCHING/SORENESS OF
NOSE/THROAT/COUGHING/SNEEZING/HEADACHE/DIZZINESS/DROWSINESS/INCOORDINATION/SL
OWED REACTION TIME/SLURRED SPEECH/GIDDINESS/UNCONSCIOUSNESS/VO
MITING/ABDOMINAL TENDERNESS/NAUSEA/BLOOD IN VOMITUS/FECES/MUSCULAR
WEAKNESS/FATIGUE/BLURRED VISION/TREMORS/CONVULSIONS.
First Aid: EYES: IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER. SKIN: WASH
AFFECTED AREA W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION:
DRINK 2 GLASSES OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EXTINGUISH ALL IGNITION SOURCES. COVER W/ABSORBENT
MATERIAL. COLLECT SPILLED MATERIAL, PLACE IN A U.S. DOT APPROVED CONTAINER
& SEAL.
Waste Disposal Methods: INCINERATE IN A PERMITTED HAZARDOUS WASTE INCINERATOR
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY FROM
HEAT, SPARKS, OPEN FLAME/OTHER IGNITION SOURCES. STORE IN A COOL PLACE/WELL
VENTILATED AREA.
Other Precautions: AVOID EYE/SKIN CONTACT. DON'T TAKE INTERNALLY.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 70F
Extinguishing Media: DRY CHEMICAL , CO2
Fire Fighting Procedures: NONE
Unusual Fire/Explosion Hazard: MODERATELY VOLATILE. SHOULD PROVIDE GOOD
VENTILATION. FLAMMABLE LIQUID & VAPOR.
=======================================================
Control Measures
=======================================================
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 180F
Spec Gravity: 0.86
Solubility in Water: INFINITE
Appearance and Odor: CLEAR LIQUID W/ALCOHOL ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS, OPEN FLAME/OTHER IGNITION SOURCES.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 70-2005-2307-7 2721 SCOTCHPRIME CERAMIC PRIMER
Cage: 76381
Company Name: MINNESOTA MINING AND MFG CO, DBA 3M
Street: 3M CENTER BLDG 224-5S-04
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: EYES/SKIN: MILD IRRITATION. INHALATION: UPPER
RESPIRATORY IRRITATION, CNS DEPRESSION. INGESTON: IRRITATION OF GI TISSUES,
CNS DEPRESSION.
IRRITATION/REDNESS/SWELLING/PAIN/TEARING/ITCHING/SORENESS
OF
NOSE/THROAT/COUGHING/SNEEZING/HEADACHE/DIZZINESS/DROWSINESS/INCOORDINATION/SL
OWED REACTION TIME/SLURRED SPEECH/GIDDINESS/U
NCONSCIOUSNESS/VOMITING/ABDOMINAL TENDERNESS/NAUSEA/BLOOD IN
VOMITUS/FECES/MUSCULAR WEAKNESS/FATIGUE/BLURRED VISION/TREMORS/CONVULSIONS.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PHENOL RED,WTER SOLUBLE
CAGE:32939
CAGE:32939
============= Composition/Information on Ingredients =============
Ingred Name:PHENOL RED,SODIUM SALT.
CAS:143-74-8
RTECS #:SJ7490000
Fraction by Wt: 95%
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER,CARBON DIOXIDE,DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SOLUTIONS SHOULD BE ABSORBED ON SUITABLE
MATERIAL (SAW DUST,ZIP SORB,ETC)AND GATHERED WITH SOLID SPILLS FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL PRUDENT PROCEDURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:MECHANI CAL/LOCAL
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:APPRECIABLE
Appearance and Odor:RED-BROWN CRYSTALS
Percent Volatiles by Volume:2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON
MONOXIDE,SO*2,SO*3.
==================== Disposal Considerations ====================
Waste Disposal Methods:BY METHODS CONSISTENT WITH LOCAL,STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LAYOUT YELLOW DX-251
CAGE:HO995
CAGE:HO995
CAGE:98148
============= Composition/Information on Ingredients =============
Ingred Name:DYE: LUXOL FAST YELLOW TN
CAS:71077-14-0
Fraction by Wt: 1-3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 25-35%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM; 200 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ALCOHOL; (ETHANOL) (DENATURED ETHYL ALCOHOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 55-65%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:BUTYL ALCOHOL; (N-BUTYL ALCOHOL) (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 3-6%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM, S, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NITROCELLULOSE; (CELLULOSE, NITRATE)
CAS:9004-70-0
RTECS #:QW0970000
Fraction by Wt: 3-6%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOPROPYL ALCOHOL; (RUBBING ALCOHOL) (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 3-6%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 500 STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:RESPIRATORY IRRITATION. HIGH
CONCENTRATIONS OF VAPORS MAY PRODUCE HEADACHE, DIZZINESS AND
NAUSEA. EYE CONTACT CAUSES BURNING AND IRRITATION. PROLONGED OR
REPEATED SKIN CONTACT MAY LEAD TO DRYING, IRRI TATION AND
DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:EYE CONTACT CAUSES BURNING &
IRRITATION. REPEATED OR PROLONGED SKIN CONTACT MAY LEAD TO DRYING,
IRRITATION & DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES WITH LARGE AMOUNT OF WATER FOR AT LEAST 15
MINUTES. SKIN: FLUSH SKIN WITH LARGE AMOUNT OF WATER. INHAL: REMOVE
TO FRESH AIR. INGEST: CONTACT LOCAL POISON CONTROL CENTER OR MD
IMMEDIAT ELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:57.0F,13.9C
Lower Limits:1.4%
Upper Limits:11.2%
Extinguishing Media:CARBON DIOXIDE, REGULAR FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER MAY BE USED TO COOL FIRE-EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG GROUND OR MAY BE MOVED BY VENTILATION & IGNITED BY SPARK,
FLAME & OTHER IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PERSONAL PROTECTIVE EQUIPMENT. REMOVE
HEAT AND IGNITION SOURCES. VENTILATE THE AREA; CLEAN UP WITH INERT
ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE COOL AND DRY AWAY FROM HEAT,
SPARKS OR OPEN FLAME.
Other Precautions:USE WITH ADEQUATE VENTILATION. AVOID PROLONGED SKIN
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED OR FOR SYMPTOMS OF
OVEREXPOSURE, WEAR NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:LOCAL EXHAUST NECESSARY UNDER SOME HANDLING/USE CONDITIONS.
MECHANICAL (GENERAL) IS ACCEPTABLE UNDER NORMAL CONDITIONS.
Other Protective Equipment:APRON AS NEEDED TO PREVENT REPEATED OR
PROLONGED SKIN CONTACT.
Work Hygienic Practices:USE WITH ADEQUATE VENTILATION.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:160F,71C
Melt/Freeze Pt:M.P/F.P Text:LIQUID
Vapor Pres:36
Vapor Density:>1
Spec Gravity:0.86 (H*2O=1)
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:INTENSE COLOR; SWEET SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE BURNED IN AN APPROVED INCINERATOR
OR DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:C86300, COPPER BASE ALLOYS
CAGE:1S741
CAGE:1S741
============= Composition/Information on Ingredients =============
Ingred Name:ING 12:SYMP OF LEAD POISON ARE FATG/HDCH/LOSS OF APPETITE,
ACHING BONES/MUSCULAR WEAK. LONG TERM OVEREXP CAN CAUSE(IN14)
RTECS #:9999999ZZ
Ingred Name:ING 13:KIDNEY DAM, NERV SYS DAM & REPROD EFTS. NOTE:LEAD
CAS# 7439-92-1 APPEARS ON NAVY LIST OF OCCUP REPROD HAZ.(ING15)
RTECS #:9999999ZZ
Ingred Name:ING 14:SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERNING LASTEST HAZ LIST INFO & SAFE HNDLG & EXPOS (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:RECOM . ING 2:IN COPPER BASE ALLOYS, OVEREXP TO
COPPER FUMES & DUST MAY CAUSE IRRIT TO SKIN, EYES, (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:NOSE/THROAT. OVEREXP BY INHAL MAY CAUSE
SWEET/METALLIC TASTE IN MOUTH & METAL FUME FEVER, WHICH
RESEMBLES(ING18)
RTECS #:9999999ZZ
Ingred Name:ING 17:THE FLU. ING 8: OVEREXP SYMP ARE SIMILAR TO THOSE OF
COPPER.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: AVOID EXCEEDING TLV & PEL LEVELS FOR EACH
ELEMENT CONTAINED IN EACH CASTING.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: IN CLOSE PROXIMITY TO WORK AREAS. EAR
PLUGS/EAR MUFFS WHERE NOISE LEVELS REACH/EXCEED 90 DB. (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: BARRIER CREAMS MAY BE NECESSARY TO PREVENT SKIN
SENSITIZATION & DERM. DUST COLLECTION SYSTEMS.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT: HLTH PRACTICES AFTER CONTACTING CASTING DUST
INCL WASHING HANDS BEFORE EATING/USING RESTROOM. FOR(ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:THOSE LEAVING FOR THE DAY, SHOWERING SOON AFTER WORK
IS ADVISABLE.
RTECS #:9999999ZZ
Ingred Name:MP: >1630F, >888C
RTECS #:9999999ZZ
Ingred Name:ALUMINUM
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 5.0-7.5%
OSHA PEL:15MG/M3 TDUST;5 FUME
ACGIH TLV:10MG/M3 DUST;5 FUME
Ingred Name:COPPER. BP: 4215F,2324C
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 60-66%
OSHA PEL:1.0MG/M3DUST;0.1FUME
ACGIH TLV:1.0MG/M3DUST;0.2FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON (PEL/TLV AS IRON OXIDE)
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 2-4%
OSHA PEL:10(FE)MG/M3
ACGIH TLV:5(FE)MG/M3
Ingred Name:LEAD
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 0.10%
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.15 MG/M3 DUST&FUME
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 2.5-5.0%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:NICKEL; (NICKEL (INCLUDES COBALT))
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 0.8%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0.10%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:ZINC (PEL/TLV AS ZINC OXIDE)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 22-28%
OSHA PEL:5 MG/M3 FUME;10TDUST
ACGIH TLV:5 MG/M3 FUME;10TDUST
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:EFTS OF OVEREXP:CANCER IN LAB ANIMALS. ING 5:OVEREXP TO
MANGANESE DUST/FUMES MAY CAUSE METAL FUME FEVER W/ (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 10:FLU-LIKE SYMP. CHRONIC OVEREXP CAN CAUSE MANGANESE
POISONING. EARLY SYMP INCL HDCH/APATHY/INSOM, & WEAK/ (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:CRAMPS IN LEGS.CONTINUED OVEREXP CAN AFFECT
CNS/ULTIMATELY LEADING TO EMOTIONAL DISTURB/GAIT & BALANCE (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:DFCTLY, & PARALYSIS. ING 4: OVEREXP BY
BRTHG/SWALLOWING OF LEAD FUMES & DUST CAN CAUSE LEAD POISON.
EARLY(ING 13)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CASTINGS IN THEIR SOLID FORM PRESENT 2
TYPES OF HLTH HAZS. FIRST WOULD BE AN ALLERGIC RXN CAUSED BY PRLNG
CONT TO CASTING IN ITS SOLID FORM/DUST FORM. 2ND HAZ WOULD OCCUR IF
CONT IS MADE W/ CASTING W/ SUFFICIENT FORCE TO CAUSE PHYS
DEFORMATION OF PERSON W/WHOM IT COMES IN CONT. CARE SHOULD BE TAKEN
TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:COBALT: GROUP 2B(IARC). NICKEL: GROUP
2B(IARC), ANTICIPATED TO BE CARCINOGEN (NTP).
Effects of Overexposure:HLTH HAZ:AVOID DANGEROUS SITUATIONS. WELD/
CUTTING/GRIND ON CASTING MAY GENERATE IRRITATING &/OR TOX DUST &/OR
FUMES. ING 3: OVER A LONG PERIOD OF TIME, SIDEROSIS/IRON
PIGMENTATION OF LUNGS MAY DEVELO P. THIS WILL BE VISIBLE ON CHEST
X-RAY BUT SHOULD CAUSE LITTLE/NO DISABILITY. ING 6:NICKEL HAS BEEN
SHOWN TO CAUSE(ING 9
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:ALLERGIC RXN:WASH THORO/AVOID FUTURE CONT. SEEK MED ADVICE.
PHYS DEFORM:CTL BLEEDING/ADMINISTER CPR, KEEP WARM, CALL PARAMEDIC.
IF BROKEN BONES, DO NOT MOVE VICTIM. EYE:FLUSH W/RUNNING H2O FOR @
LST 1 5 MIN TO REMOVE PARTICULATE. GET MED ATTN. SKIN:BRUSH OFF
EXCESS DUST. WASH AREA WELL W/SOAP/H2O. INHAL:REMOVE TO FRESH AIR.
GET MED ATTN. INGEST:SEEK MED HELP IF LG QTYS OF MATL HAVE BEEN
INGESTED.
===================== Fire Fighting Measures =====================
Extinguishing Media:SAND, DOLOMITE, GRAPHITE POWDER & SODIUM CHLORIDE
ARE ALL ADEQUATE EXTINGUISHING MEDIA.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CASTINGS WILL NOT BURN/EXPLODE IN THEIR
SOLID FORM. DUST & POWDER GENERATED BY CUTTING & GRIND SHOULD BE
DISPOSED OF @ REGULAR INTERVALS AS THERE IS (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:IF LG CENTRIFUGAL CASTING IS ROLLING IN YOUR
DIRECTION, GET OUT OF WAY. LG QTY OF DUST SHOULD BE REMOVED BY
VACUUMING/ WET SWEEPING TO PREVENT HEAVY CONC OF AIRBORNE DUST.
CLEAN-UP PERSONNEL SHOULD WE AR NIOSH/MSHA APPRVD RESP & PROTECTIVE
CLOTHING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE GOOD HOUSEKEEPING PRACTICES TO
PVNT ACCUMULATIONS OF DUST & TO KEEP AIRBORNE DUST CONC @ MINIMUM.
AVOID BRTHG DUST/FUMES. USE ADEQ VENT.
Other Precautions:STORE MATL AWAY FROM INCOMPATIBLE MATLS & KEEP DUST
AWAY FROM IGNIT SOURCES. LG CENTRIFUGAL CASTINGS SHOULD NOT BE
STORED ON INCLINES W/OUT ADEQ BLOCK. DUST & FUMES GENERATED BY
CUTTING, GRIND/ MACHIN ING & WELD SHOULD BE CONTROLLED TO(ING19
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENT IS NOT SUFFICIENT, THE EMPLOYEES SHOULD
WEAR NIOSH/MSHA APPRVD RESP FOR PROT AGAINST DUST/FUMES. NIOSH/MSHA
APPROVED DUST MASKS.
Ventilation:WHEN WELD, CUTTING/GRIND ON CASTINGS, USE GEN & LOC EXHAUST
VENT TO KEEP AIRBORNE CONC OF DUST/FUMES BELOW TLV.
Other Protective Equipment:WEAR FULL PROT CLTHG & SFTY SHOES EQUIPPED
W/ STEEL TOES & METATARSALS. SFTY EYEWASH STATIONS SHOULD BE
PROVIDED (ING 20
Work Hygienic Practices:FOOD SHOULD NOT BE CONSUMED IN WORK AREA.
SHOWERING SHOULD BE REQD BEFORE CHANGING INTO STREET CLOTHES. GOOD
(ING 22)
Supplemental Safety and Health
EXPLO HAZ:A MOD FIRE & EXPLO HAZ IN SOME ALLOYS WHEN EXPOS TO
HEAT/FLAME/ELECTRIC CURRENT/SPARK IN PRESENCE OF SUFFICIENT O2.
SAND, DOLOMITE, GRAPHITE POWDER & SODIUM CHLORIDE ARE ALL ADEQ
EXTING MEDI A. MATL TO AVOID: MAY REACT VIOLENTLY W/H2O.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:ING 2
Melt/Freeze Pt:M.P/F.P Text:ING 24
Spec Gravity:7.70-8.96
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID, YELLOW TO RED IN COLOR, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COPPER REACTS VIOLENTLY W/ACETYLENE. MATL MAY BE INCOMPATIBLE W/CERTAIN
ACIDS/BASES & OXIDIZERS. MOLTEN SCRAP(SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:SCRAP METAL CAN BE RECLAIMED FOR REUSE. FOLLOW
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING DISPOSAL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:463-07-0056 ULTRAGUARD/IMPACT RES. PRIMER GREEN
CAGE:98502
CAGE:98502
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),
AEROTHANE TT, CHLOROTHENE
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 44.8%
Other REC Limits:450 PPM STEL
OSHA PEL:350 PPM
ACGIH TLV:1910 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:MUSCOVITE *92-2*
CAS:1318-94-1
Fraction by Wt: 5-10%
OSHA PEL:3 MG/CUM
ACGIH TLV:3 MG/CUM
Ingred Name:PROPYLENE GLYCOL METHYL ETHER (1-METHOXY-2-PROPANOL)
PROPYLENE GLYCOL MONO METHYL ETHER
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 1-5%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CHROMIUM VI, ION (CR 6+) (OSHA CARCINOGEN); SOLUBLE
CHROMIUM COMPOUNDS, CR
CAS:18540-29-9
RTECS #:GB6262000
Fraction by Wt: 2.3%
OSHA PEL:0.1 MG/CUM
ACGIH TLV:50 UG/CUM (A1)
Ingred Name:SYNTHETIC CRYSTALLINE-FREE SILICA GEL *93-1*
CAS:112926-00-8
Fraction by Wt: 1-5%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-5%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:DIETHYLENE ETHER (DIOXANE), (DIETHYLENE DIOXIDE),
1,4-DIOXANE (A2 ANIMAL CARCINOGEN BY NTP, IARC)
CAS:123-91-1
RTECS #:JG8225000
Fraction by Wt: 0.2%
Other REC Limits:25 PPM
OSHA PEL:360 MG/CUM
ACGIH TLV:90 MG/CUM (SKIN)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:WEIGHT PER GALLON IN POUNDS: 11.80
RTECS #:9999999WG
Ingred Name:VOL ORGANIC CMPD: LESS WATER 6.41, LESS WATER & EXEMPT
2.17; TOTAL ORGANIC SOLVENTS 6.41, TOTAL NON-EXEMPT SOLVENTS 1.12
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED/INGESTED. EYES:
IRRITANT. SKIN: IRRITANT & DERMATITIS. NOSE/THROAT IRRITATION, LUNG
INJURY & PNEUMOCONIOSIS. CHRONIC: LIVER & CARDIAC ABNORMALITIES;
LUNG, KIDNEY, PERMANENT BRAIN & CENTRAL NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: DIZZINESS, HEADACHE, NAUSEA,
VOMITING, WEAKNESS, DRYING OF NASAL MUCOUS, FATIGUE,
UNCONSCIOUSNESS, ASPHYXIA, DROWSINESS, DIARRHEA, SHORTNESS OF
BREATH, NARCOSIS, GASTRITIS, REDUCED VISIBIL ITY, IRREGULAR
HEARTBEAT, INFLAMMATION OF MUCOUS MEMBRANE/NOSE/THROAT, DEPOSITS IN
EYES, ANESTHESIA, INTOXICATION.
Medical Cond Aggravated by Exposure:SKIN DISORDERS, PULMONARY
CONDITIONS
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH W/PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING.
EYES: FLUSH W/WATER FOR AT LEAST 15 MINS. INHALATION: REMOVE TO
FRESH AIR. IF BREATHING STOPS, GIVE ARTIFICIAL RESPIRATION,
PREFERABLY MOUT H-TO-MOUTH. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
INGESTION: GET MEDICAL ATTENTION IMMEDIATELY. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:40F/4C
Lower Limits:1.2%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. IF WATER IS USED TO
COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP, FOG NOZZLES
ARE PREFERRED. WEAR PROTECTIVE EQUIPMENT & SCBA.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID. DECOMPOSITION PRODUCTS
MAY CAUSE SYMPTOMS THAT MAY NOT BE IMMEDIATELY APPARENT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. WEAR APPROPRIATE
SAFETY EQUIPMENT. ABSORB ON INERT MATERIAL & DISPOSE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL-VENTILATED AREA AWAY
FROM IGNITION SOURCES. KEEP CONTAINERS CLOSED WHEN NOT IN USE.
STORE IN CLEAN, DRY AREA. GROUND ALL EQUIPMENT.
Other Precautions:EMPTY CONTAINER MAY RETAIN PRODUCT RESIDUE (VAPOR OR
LIQUID). INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING CONTENTS OF THIS PACKAGE MAY BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE, PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA APPROVED) WHEN VAPOR/MIST LEVELS ARE EXCEEDED
Ventilation:SUFFICIENT TO MAINTAIN AIRBORNE CONCENTRATIONS BELOW
TLV/PEL.
Other Protective Equipment:RUBBER APRON, EYE BATH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DISCARD CONTAMINATED SHOES. GOOD PERSONAL HYGIENE PRACTICES
REQUIRED.
Supplemental Safety and Health
DECOMPOSITION PRODUCTS: OXIDES OF NITROGEN, CARBON & CHROME.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:101-280F
Vapor Density:>1
Spec Gravity:1.4
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID
Percent Volatiles by Volume:64.08
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANICS, ZINC, OXIDIZERS, WATER, ALUMINUM
Stability Condition to Avoid:SPARKS, OPEN FLAME, TEMPERATURES >140F
Hazardous Decomposition Products:CHLORINE, PHOSGENE, VARIOUS
HYDROCARBONS, ACIDS, HYDROGEN CHLORIDE, ALDEHYDES, SILICON DIOXIDE
(SEE SUPPLEMENTAL INFO)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. INCINERATION IS PREFERRED. FLAMMABLE LIQUID.
| 1 |
gloves_mandatory
|
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.