text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:WOOD FINISH 209V
CAGE:HO333
CAGE:HO333
CAGE:0K1A4
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT (MINERAL SPIRITS)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 32-40%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:VEHICLE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADDITIVES
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENTS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC CONTENT: 350 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: INCREASE FRESH AIR AND LEAVE AREA. REMOVE CONTAM
CLTHG IMMED & LAUNDER BEFORE REUSE. DO NOT TAKE INTERNALLY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGESTION: CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING & DIARRHEA. SKIN: CAN
CAUSE DEFATTING & DRYING OF THE SKIN, WHICH MAY RESULT IN SKIN
IRRITATION & DERMATITIS. EYES: CAN CAUSE SEVERE IRRITATION,
REDNESS, TEARING/BLURRED VISION. INHALATION: CAN CAUSE NASAL &
RESPIRATORY (EFFECTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: IRRITATION, DIZZINESS, FATIGUE,
NAUSEA, HEADACHE, NERVOUS IRRITABILITY, UNCONSCIOUSNESS AND
ASPHYXIATION. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: REMOVE CONT LENSES IF PRESENT. FLUSH EYES W/PLENTY OF
WATER FOR AT LEAST 15 MIN & GET MED ATTN. SKIN: WASH THORO W/SOAP &
PLENTY OF WATER. IF IRRIT PERSISTS, GET MED ATTN. INGEST: DO NOT
INDUCE V OMIT. CALL MD IMMED. KEEP PATIENT WARM & QUIET. INHAL:
REMOVE TO FRESH AIR. MAINTAIN RESP AS NEC & CALL MD. NOTE TO MD: IF
SWALLOWED: ASPIR OF MATL INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM
(SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:0.9%
Upper Limits:6.0%
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM AND
WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER IS NOT NORMALLY AN EFFECTIVE
EXTINGUISHING AGENT.
Unusual Fire/Explosion Hazard:WHEN BURNING, THIS PROD GIVES THE
OFF-TOXIC BY-PRODS SUCH AS CARBON MONOXIDE. THEREFORE, BREATHING OF
SMOKE & GASES GIVEN OFF DURING BURNING SHOULD BE AVOIDED.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE ADEQUATE VENTILATION. REMOVE IGNITION
SOURCES FROM SPILL AREA. UTILIZE SAND, RAGS, PAPER, VERMICULITE,
FLOOR ABSORBENT, MATERIAL AND PLACE IN LEAK-PROOF DRUMS FOR
DISPOSAL. USE PROTECTIVE EQUI PMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF SURF WATERS & ANY OTHER
COURSES/SEWERS ENTERING/LEADING TO SURF WATERS. DO NOT USE/STORE
NEAR HEAT/SPARKS/OPEN FLAMES/OTHER IGNIT SOURCES.
Other Precautions:CLOSE CONTR AFTER EACH USE. STORE ONLY IN ORIGINAL
CONTR. KEEP OUT OF REACH OF CHILDREN. RAGS & OTHER WASTE SOAKED
W/OIL FINISHES MAY SPONT CATCH FIRE IF IMPROPERLY DISCARDED. PLACE
RAGS & WASTE IMMEDAFTER USE IN SEALED WATER- (SUP DAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ADEQUATE VENTILATION CANNOT BE MAINTAINED,
USE RESPIRATORY PROTECTION (NIOSH/MSHA APPROVED TC 23C OR
EQUIVALENT).
Ventilation:PROVIDE CONSTANT FLOW OF FRESH AIR TO MEET TLV REQS. OPEN
WINDOWS & DOORS TO PERMIT FRESH AIR ENTRY DURING APPLICATION.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH WITH SOAP AND WATER BEFORE EATING,
DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
SPEC GRAV: 0.871-0.968 (H*2O=1). FIRST AID PROC: PNEUMIT, WHICH CAN BE
FATAL. OTHER PREC: FILLED, METAL CONTR. DISP OF I/A/W LOC FIRE
REGS. EMPTY CONTRS MAY RETAIN RESIDUES OF PROD. DO NOT CUT, PUNCTU
RE/WELD ON/NEAR CONTR. AVOID INHAL & USE ONLY W/ADEQ VENT. IF
EMPLOYEE EXPERIENCES EYE WATERING, HDCHS/DIZZ, (ING 6)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:313F,156C
Vapor Pres:2.00
Vapor Density:4.8
Spec Gravity:SUP DAT
Evaporation Rate & Reference:0.09 (BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:WHITE OR DARK AMBER LIQUID, WITH MILD HYDROCARBON
ODOR
Percent Volatiles by Volume:35-40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION PRODUCES CARBON
MONOXIDE, CARBON DIOXIDE AND UNIDENTIFIED ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATION IS PREFERRED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RAPIDSCAN 41 DEVELOPER PART B
Kit Part:Y
CAGE:8S589
CAGE:5L600
CAGE:8S589
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-70%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HYDROXYLAMINE, SULFATE(2:1)
CAS:10039-54-0
RTECS #:NC5425000
Fraction by Wt: 30-40%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: LOW HAZARD FOR USUAL HANDLING.
INGESTION: IF SWALLOWED, INDUCE VOMITING. EYES: MAY CAUSE
IRRITATION. SKIN: MAY CAUSE IRRITATION AND ALLERGIC SKIN REACTION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH EYES W/PLENTY OF WATER FOR AT LEAST 15
MINS. GET MED ATTN IMMED. SKIN: FLUSH SKIN W/PLENTY OF WATER & WASH
W/NON-ALKALINE SKIN CLEANER. INGEST: INDUCE VOMITING. CALL MD
IMMED. INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING(GIVE O*2/ARTF
RESP).
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE AGENT APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LGE AMTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
AWAY FROM CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN.
Ventilation:GOOD VENTILATION OF 10 ROOM VOLUMES PER HOUR. VENT RATES
SHOULD MATCH CONDITIONS OF USE.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:18 @ 20C
Spec Gravity:1.030(H*20=1)
pH:3.40
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, LIQUID ODORLESS SOLUTION.
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE; MAY
PRODUCE OXIDES OF SULFUR AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE (PROVINCIAL IN CANADA) OR LOCAL LAWS.
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 00-079-3760
Product ID: SO-SURE RED 11136 (24-111) P/N 22C811
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ENAMEL
Unit of Issue: PT
UI Container Qty: B
=======================================================
Ingredients
=======================================================
Cas: 8030-30-6
RTECS #: DE3030000
% Wt: 9.30
Other REC Limits: NONE RECOMME
OSHA PEL: 300 PPM
ACGIH TLV: 300 PPM
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
% Wt: 31.15
Other REC Limits: NONE RECOMME
OSHA PEL: 200 PPM
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 67-64-1
RTECS #: AL3150000
% Wt: 13.19
Other REC Limits: NONE RECOMME
OSHA PEL: 1000 PPM
ACGIH TLV: 750 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 74-98-6
RTECS #: TX2275000
% Wt: 16.72
Other REC Limits: NONE RECOMME
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 75-28-5
RTECS #: TZ4300000
% Wt: 6.58
Other REC Limits: NONE RECOMME
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 800 PPM
------------------------------
Cas: 106-97-8
RTECS #: EJ4200000
% Wt: 4.11
Other REC Limits: NONE RECOMME
OSHA PEL: 800 PPM
ACGIH TLV: 800 PPM
------------------------------
RTECS #: 9999999VO
Other REC Limits: NONE RECOMME
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CONCENTRATING & INHALING CONTENTS HARMFUL OR FATAL.
REPEATED/PROLONGED OVEREXPOSURE ASSOCIATED WITH PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. IN CONFINED AREA, HIGH CONCENTRATION ARE ANESTHETIC. SKIN
& RESPIRATORY TRACT IRRITATION. LIGHT HEADED, STAGGERING, GIDDINESS,
NAUSEA. HARMFUL IF SWALLOWED. SEVERE EYE IRRITATION.
Signs And Symptions Of Overexposure: IRRITATION TO EYES, THROAT, AND
RESPIRATORY TRACT. MAY CAUSE HEADACHES, NAUSEA, AND VOMITING.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS.
First Aid: FOR CONTACT WITH SKIN OR CLOTHES, WASH WITH SOAP & WATER; WASH
CLOTHES BEFORE REUSE. FOR CONTACT WITH EYES, FLUSH WITH WATER FOR 15 MINUTES
& CONTACT PHYSICIAN/OPHTHALMOLOGIST IMMEDIATELY. IF SWALLOWE D, DO NOT
INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. IF INHALED, REMOVE TO FRESH AIR.
GIVE ARTIFICIAL RESPIRATION IF NECESSARY & GET MEDICAL AID. NEVER GIVE
ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE IN ACCORD WITH FEDERAL, STATE, LOCAL
REGULATIONS. DO NOT PUNCTURE, INCINERATE OR STORE ABOVE 120F. EXPOSURE TO
HEAT OR PROLONGED EXPOSURE TO SUN MAY CAUSE CAN TO BURST. DISCARD EMPTY CAN
IN TR ASH PICK-UP. DO NOT PLACE IN HOME TRASHCOMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. CONTENTS UNDER
PRESSURE. DO NOT STORE WHERE TEMPERATURE MAY EXCEED 120F. AVOID BREATHING
SPRAY, MIST, OR VAPORS.
Other Precautions: AVOID CONTACT WITH EYES AND SKIN. USE WITH GOOD VENTILATION.
READ ENTIRE LABEL BEFORE USING. FOLLOW ALL LABEL DIRECTIONS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING AND INHALING OR SWALLOWING CO NTENTS MAY
BE HARMFUL OR FATAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NR
Autoignition Temp Text: 874 F
Lower Limits: 1.8
Upper Limits: 9.5
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE, USE TO COOL FIRE EXPOSED
CONTAINERS. WEAR SCBA. USE SHIELDING TO PROTECT PERSONNEL FROM BURSTING,
RUPTURING OR VENTING OF CONTAINERS.
Unusual Fire/Explosion Hazard: DO NOT SPRAY NEAR OPEN FLAME. AT ELEVATED
TEMPERATURE (>120F) CONTAINERS MAY VENT, RUPTURE OR BURST. AEROSOL
CONTAINER; DO NOT EXPOSE TO TEMPERATURE ABOVE 120F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL): ACCEPTABLE AT
POINT OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT, DRINK, OR SMOKE
WHILE USING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V3
Vapor Pres: 60
Vapor Density: >1.5
Spec Gravity: 0.922 (WATER=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: RED / PAINT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Hazardous Decomposition Products: CARBON MONOXIDE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 46341
Product ID: SO-SURE RED 11136 (24-111) P/N 22C811
Review Date: 01/07/1993
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: B
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
IMDG Page Number: SEE 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
AFI UN ID NUM: UN1950
Special Provisions: P4
Back Pack Reference: A6.3
=======================================================
HAZCOM Label
=======================================================
Product ID: SO-SURE RED 11136 (24-111) P/N 22C811
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: CONCENTRATING & INHALING CONTENTS HARMFUL OR FATAL.
REPEATED/PROLONGED OVEREXPOSURE ASSOCIATED WITH PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. IN CONFINED AREA, HIGH CONCENTRATION ARE ANESTHETIC. SKIN
& RESPIRATORY TRACT IRRITATION. LIGHT HEADED, STAGGERING, GIDDINESS,
NAUSEA. HARMFUL IF SWALLOWED. SEVERE EYE IRRITATION.IRRITATION TO EYES,
THROAT, AND RESPIRATORY TRACT. MAY CAUSE HEADACHES, NAUSEA, AND VOMITING.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RAPID CLEAN G
CAGE:0G5Y4
CAGE:0G5Y4
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCHLORIC ACID, HYDROGEN CHLORIDE, MURIATIC ACID
HYDROCHLORIDE
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 24.5%
Other REC Limits:7 PPM
OSHA PEL:5 PPM
ACGIH TLV:C 11 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: SEVERE BURNS OF THE MUCOUS
MEMBRANES OF THE MOUTH, ESOPHAGUS & STOMACH. EYES: SEVERE
IRRITATION, MAY CAUSE PERMANENT VISUAL IMPAIRMENT, BURNS, LOSS OF
SIGHT. SKIN: DESTRUCTIVE, SEVERE BURNS , DERMATITIS. INHALATION:
SEVERE IRRITATION TO UPPER RESPIRATORY TRACT. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS, LIPS TURN WHITE THEN BROWN,
PAIN, DIFFICULTY SWALLOWING, INTENSE THIRST, NAUSEA, VOMITING,
DIARRHEA, COLLAPSE, UNCONSCIOUSNESS, COUGHING, CHOKING SENSATION
======================= First Aid Measures =======================
First Aid:INGESTION: IF CONSCIOUS, GIVE LARGE AMOUNTS OF LIME
WATER/MILK OF MAGNESIA. DON'T GIVE SODIUM BICARBONATE. DON'T INDUCE
VOMITING. EYES: FLUSH W/WATER FOR 15 MINS. SKIN: FLUSH W/WATER.
DON'T NEUTRALIZE W/CHEMICAL AGENTS. KEEP ON BACK/WARM IN CASE OF
SHOCK SYMPTOMS. INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF
BREATHING HAS STOPPED. KEEP WARM/COMFORTABLE. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Unusual Fire/Explosion Hazard:HYDROCHORIC ACID IN CONTACT W/VARIOUS
METALS CAN EVOLVE HYDROGEN WHICH IS POTENTIALLY EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE & FLUSH THE AREA W/LARGE AMOUNTS OF
WATER. IF SODA ASH IS USED, AMPLE VENTILATION IS PROVIDED. THE
GAS/VAPOR IS SO PENETRATING & PUNGENT THAT WHEN HIGH CONCENTRATION
DO OCCUR, THOSE EXPOSED IMMEDIATELY LEAVE THE CONTAMINATED AREA.
Neutralizing Agent:SODA ASH/LIME
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HIGHLY FLAMMABLE
SUBSTANCES & OXIDIZING AGENTS & OTHER POTENTIAL FIRE HAZARDS/IN
DIRECT SUNLIGHT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MIST RESPIRATOR RECOMMENDED
Ventilation:LOCAL EXHAUST-PREFERRED; MECHANICAL ACCEPTABLE
Other Protective Equipment:ACID RESISTANT FACE SHIELD, HEAD COVERING,
APRON, BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: ULECERATION OF THE NOSE, THROAT & LARYNX. EDEMA
OF THE LUNGS MAY OCCUR. IN THE EVENT OF INJURY RESULTING FROM
OVER-EXPOSURE, GIVE CPR IF NOT BREATHING. NEVER GIVE ANYTHING BY MO
UTH TO AN UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES
EVEN IF THE INJURY IS SLIGHT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230F
Vapor Pres:25.8
Spec Gravity:1.123
pH:<1
Solubility in Water:COMPLETE
Appearance and Odor:DARK PURPLE LIQUID, PENETRATING & PUNGENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Hazardous Decomposition Products:HYDROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:THE NEUTRALIZED ACID MAY BE FLUSHED TO THE
SEWAGE. DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:2-BUTANONE, 99+%, 11026-4
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE;(METHYL ETHYL KETONE) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
OSHA PEL:200 PPM;300 STEL
ACGIH TLV:200 PPM;300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT)2737 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY BE HARMFUL BY INHALATION,
INGESTION OR SKIN ABSORPTION. CAUSES SEVERE EYE IRRITATION. CAUSES
SKIN IRRITATION. CAN CAUSE CNS DEPRESSION. MATERIAL IS IRRITATING
TO MUCOUS MEMBRANES AND UPPER R ESPIRATORY TRACT. EXPOSURE CAN
CAUSE NAUSEA, DIZZINESS AND HEADACHE, GI DISTURBANCES, DERMATITIS.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:NARCOTIC EFFECT. TARGET ORGANS:CENTRAL
NERVOUS SYSTEM.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN:IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING
AND SHOES . WASH CONTAMINATED CLOTHING BEFORE REUSE. INHAL:MOVE TO
FRESH AIR. IF NOT BREATHING GIVE ARTF RESP. IF BREATHING DIFFICULT
GIVE O*2. INGEST:WASH OUT MOUTH W/WATER IF PERSON CONSCIOUS. CALL
MD.
===================== Fire Fighting Measures =====================
Flash Point:26.0F,-3.3C
Lower Limits:1.8%
Upper Limits:10.1%
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:DANGER. FLAMMABLE LIQUID. VAPOR MAY
TRAVEL CONSIDERABLE DISTANCE TO SOURCE OF IGNITION AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF ALL SOURCES OF IGNITION. EVACUATE
AREA. WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS & HEAVY RUBBER
FOR DISP. VENT AREA & WAS H SPILL SITE AFTER MATERIAL PICKUP IS
COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE. KEEP
TIGHTLY CLOSED. KEEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME.
Other Precautions:DO NOT BREATHE VAPOR. AVOID CONTACT WITH EYES, SKIN
AND CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE. SEVERE EYE
IRRITANT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NOISH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. PROTECTIVE
CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:176F,80C
Melt/Freeze Pt:M.P/F.P Text:-125F,-87C
Vapor Pres:71 @ 20C
Vapor Density:2.49
Spec Gravity:0.805
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, BASES, STRONG REDUCING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS
MATERIAL IS HIGHLY FLAMMABLE. DISPOSAL MUST BE IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:48909, SUPELPREME-HC KIT
CAGE:54968
CAGE:54968
============= Composition/Information on Ingredients =============
Ingred Name:BENZENE, P-DICHLORO-; (1,4-DICHLOROBENZENE) (SARA III).
LD50: (ORAL,RAT) 500 MG/KG
CAS:106-46-7
RTECS #:CZ4550000
Fraction by Wt: 0.2%
OSHA PEL:75 PPM
ACGIH TLV:10 PPM,A3 9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:TOLUENE, 2,-4-DINITRO-; (2,4-DINITROTOLUENE) (SARA III).
LD50:(ORAL,RAT) 268 MG/KG
CAS:121-14-2
RTECS #:XT1575000
Fraction by Wt: 0.2%
OSHA PEL:1.5 MG/M3;SKIN
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:TOLUENE, 2,6-DINITRO-; (2,6-DINITROTOLUENE) (SARA III).
LD50: (ORAL,RAT) 177 MG/KG
CAS:606-20-2
RTECS #:XT1925000
Fraction by Wt: 0.2%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:1,3-BUTADIENE, HEXACHLORO- (SARA III);
(HEXACHLORO-1,3-BUTADIENE). LD50:(ORAL,RAT) 90 MG/KG
CAS:87-68-3
RTECS #:EJ0700000
OSHA PEL:0.02 PPM
ACGIH TLV:0.02 PPM, S
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:1,3-CYCLOPENTASDIENE, 1,2,3,4,5,5-HEXACHLORO-;
(HEXACHLOROCYCLOPENTADIENE) (SARA III). LD50: (ORAL,RAT) 113 MG/KG
CAS:77-47-4
RTECS #:GY1225000
Fraction by Wt: 0.2%
OSHA PEL:0.01 PPM
ACGIH TLV:0.01 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:2-CYCLOHEXEN-1-ONE, 3,5,5-TRIMETHYL-; (ISOPHORONE)(SARA
III). LD50: (ORAL,RAT) 2330 MG/KG
CAS:78-59-1
RTECS #:GW7700000
Fraction by Wt: 0.2%
Other REC Limits:10 PPM (MRF)
OSHA PEL:25 PPM
ACGIH TLV:C 5 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BENZENE, NITRO-; (NITROBENZENE) (SARA III). LD50:
(ORAL,RAT) 640 MG/KG
CAS:98-95-3
RTECS #:DA6475000
Fraction by Wt: 0.2%
Other REC Limits:5 MG/M3 (MFR)
OSHA PEL:1 PPM, S
ACGIH TLV:1 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE). LD50: (ORAL,RAT)
2524 MG/KG
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 97%
Other REC Limits:100 PPM (MFR)
OSHA PEL:500 PPM;1000 PPM, C
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:AZOBENZENE; (AZOBENZENE, 99%). LD50: (ORAL,RAT) 1000 MG/KG
CAS:103-33-3
RTECS #:CN1400000
Fraction by Wt: 0.2%
Ingred Name:BENZENE, 1,2,4-TRICHLORO-; (1,2,4-TRICHLOROBENZENE) (SARA
III)
CAS:120-82-1
RTECS #:DC2100000
Fraction by Wt: 0.2%
OSHA PEL:5 PPM, C
ACGIH TLV:5 PPM, C
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:BENZENE, HEXACHLORO-; (HEXACHLOROBENZENE) (SARA III).
LD50:(ORAL,RAT) 10000 MG/KG
CAS:118-74-1
RTECS #:DA2975000
Fraction by Wt: 0.2%
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ETHANE, HEXACHLORO-; (HEXACHLOROETHANE) (SARA III). LD50:
(ORAL,RAT) 6000 MG/KG
CAS:67-72-1
RTECS #:KI4025000
Fraction by Wt: 0.2%
Other REC Limits:10 PPM (MFR)
OSHA PEL:S, 1 PPM
ACGIH TLV:S, 1 PPM; A2, 9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:NAPHTHALENE, 2-CHLORO-; (2-CHLORONAPHTHALENE) (SARA III).
LD50: (ORAL,RAT) 2078 MG/KG
CAS:91-58-7
RTECS #:QJ2275000
Fraction by Wt: 0.2%
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BENZENE, O-DICHLORO-; (1,2-DICHLOROBENZENE) (SARA III).
LD50: (ORAL,RAT) 500 MG/KG
CAS:95-50-1
RTECS #:CZ4500000
Fraction by Wt: 0.2%
OSHA PEL:C 50 PPM
ACGIH TLV:S, 25PPM/50 STEL9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:BENZENE, M-DICHLORO-; (1,3-DICHLOROBENZENE) (SARA III)
CAS:541-73-1
RTECS #:CZ4499000
Fraction by Wt: 0.2%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:IRRITATES EYES/SKIN. NAUS, DIZZ.
CHLOROCARBON MATLS HAVE PRODUCED SENS OF THE MYOCARDIUM TO
EPINEPHRINE IN LABORATORY ANIMALS AND COULD HAVE A SIMILAR EFTS IN
HUMANS. ADRENOMIMETICS (E.G. EPINEPHRINE) MAY BE CONTRAINDICATED
EXCEPT FOR LIFESUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY
EXPOSED TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ING 15:IARC GRP 2B, NTP GRP 2, ACGIH GRP
A2. ING 11:ACGIH GRP A2. ING 8:IARC GRP 2B, NTP GRP 2. (SUPP DATA)
Effects of Overexposure:HLTH HAZ: CHLOROCARBONS . SEVERAL CHRONIC
INHALATION STUDIES REPORT SLIGHT LIVER & KIDNEY CHANGES IN
LABORATORY ANIMALS EXPOSED AS HIGH AS 10000 PPM.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:CNTCT MD. IMMED FLUSH W/POTABLE H2O FOR A MINIMUM OF 15
MIN. . SKIN:PROMPTLY WASH W/MILD SOAP & LRG VOL OF H2O. CNTCT MD.
INHAL:IMMED MOVE TO FRESH AIR. GIVE O2 IF BRTHING IS LABORED.IF
BRTH G STOPS, GIVE ARTF RESP. CNTCT MD. INGEST:NEVER GIVE ANYTHING
BY MOUTH TO AN UNCON PERSON. NEVER TRY TO MAKE AN UNCON PERSON
VOMIT. GIVE SYRUP OF IPECAC. IMMED CNTCT MD.
===================== Fire Fighting Measures =====================
Lower Limits:12%
Upper Limits:19%
Extinguishing Media:THIS MATL IS NOT FLAMMABLE. DETERMINED BY
SUPPORTING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:HCL, NOX TOXIC VAPORS ARE FORMED WHEN
MATERIAL IS HEATED TO DECOMPOSITION. THERMAL DECOMPOSITION PRODUCTS
MAY INCLUDE HCL AND PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP WITH ABSORBENT MATERIAL. VENTILATE
AREA. FLUSH AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:REFRIDGERATE IN CLSD CNTNR. KEEP AWAY
FROM OXIDIZERS/BASES. SOLUTION CONTAINS CARCINOGENS OR CANCER
SUSPECT SUBSTANCES AT THE 0.2% LEVEL.
Other Precautions:AVOID EYE OR SKIN CONTACT. AVOID BREATHING VAPORS. NO
SMOKING IN AREAS OF USE. DO NOT USE IN THE GENERAL VICNITY OF ARC
WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR UV RADIATION MAY
CAUSE THE FOR MATION OF HCL AND/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATORY PROTECTION.
Ventilation:USE ONLY IN EXHAUST HOOD.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN: ING 3: IARC GROUP 2B, NTP GROUP 2.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:104F,40C
Vapor Pres:350
Solubility in Water:1.3
Appearance and Odor:CLEAR LIQUID, CHLOROFORM-LIKE ODOR.
Percent Volatiles by Volume:97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, OXIDIZING AGENTS, CHEMICALLY ACTIVE METALS SUCH AS
ALUMINUM OR MAGNESIUM POWDERS, SODIUM, POTASSIUM.
Hazardous Decomposition Products:HCL, OXIDES OF NITROGEN. PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH ALL APPLICABLE FEDERAL, STATE OR
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CALCIUM HYPOCHLORITE
Preparer's Name:MICHAEL J. FOLEY
CAGE:IO301
CAGE:IO301
CAGE:1N060
============= Composition/Information on Ingredients =============
Ingred Name:HYPOCHLOROUS ACID, CALCIUM SALT; (CALCIUM HYPOCHLORITE)
(SARA III)
CAS:7778-54-3
RTECS #:NH3485000
ACGIH TLV:0.5 MG/L (MFR)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INTENSE IRRITATION; PAIN.
CHRONIC: CHEMICAL BURNS AND DAMAGE TO VISION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:INHAL: INTENSE IRRITATION TO MUCOUS MEMBRANES.
DIFFICULT BREATHING. CONTACT WITH SKIN OR EYES: SEVERE IRRITANT -
INTENSE PAIN TO THE EYE - REDDENED SKIN. INGEST: IRRITATION OF
MOUTH, THROAT, AND STOMA CH; PAIN IN ALL AREAS; POSSIBLE
ULCERATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
SKIN: REMOVE CONTAMINATED CLOTHING; WASH WITH SOAP AND WATER FOR AT
LEAST 15 MINUTES. INHAL: REMOVE TO FRESH AIR. CALL MD. INGEST: IF
CONCIOU S, DRINK LG QTYS OF MILK/GELATIN SOLUTION, OR IF THESE ARE
NOT AVAILABLE, DRINK LARGE QUANTITIES OF WATER. DO NOT GIVE VINEGAR
OR OTHER ACIDS. DO NOT INDUCE VOMITING. GET PROMPT MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATL IS STRONG OXIDIZER - CONTACT W/
COMBUSTIBLES MAY INITIATE OR PROMOTE FIRE. ACID & HEAT ACCELERATE
DECOMPOSITION. PRODUCTS OF DECOMP MAY INCLUDE CHLORINE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN AND NEUTRALIZE WITH SODIUM SULFITE,
SODIUM BISULFITE, OR FERROUS SALT SOLUTION. DILUTE COPIOUSLY WITH
WATER. NEUTRALIZE AND PUT IN PLASTIC CONTAINER.
Neutralizing Agent:SODIUM SULFITE, SODIUM BISULFITE, OR FERROUS SALT
SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:NORM GOOD HOUSEKEEPING - STORE IN
CLEAN, NON-CORR CNTNRS. KEEP AWAY FROM HEAT & STORE IN A WELL
VENTILATED SPACE. AVOID MOISUTRE & DIRECT SUNLIGHT.
Other Precautions:DO NOT STORE IF MATL HAS COME IN CONTACT WITH
MOISTURE, HYDROCARBONS, OR BOTH - DISPOSE OF IF THAT IS THE CASE.
DURING MAINT OF CONTAM EQUIPMENT: RINSE WITH LARGE AMOUNTS OF
WATER. NEUTRALIZE IF PRESE NT IN OBJECTIONAL AMOUNTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED FOR CHLORINE GAS.
Ventilation:LOCAL EXHAUST DESIRABLE.
Other Protective Equipment:RUBBER CLOTHING. EMERGENCY EYE WASH AND
DELUGE SHOWER .
Work Hygienic Practices:NORMAL GOOD HOUSEKEEPING.
Supplemental Safety and Health
MATLS TO AVOID: MATERIALS, MOST METALS.
================== Physical/Chemical Properties ==================
HCC:D1
Solubility in Water:COMPLETE
Appearance and Odor:WHITE TABLETS OR POWDER; SHARP, INTENSELY
DISAGREEABLE HALOGEN ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACID, AMMONIA, AMINES, CYANIDES, CHLORINATED ISOCYANURATES, COMBUSTS,
DETERGENTS, REDUCING AGENTS, OXIDIZABLE(SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CONTACT WITH ACID RELEASES CHLORINE
GAS. THERMAL DECOMPOSITION OR BURNING MAY PRODUCE HYDROCHLORIC ACID
OR HCL.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ALL WASTES I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BRULIN 1990 GD
CAGE:DO828
CAGE:DO828
CAGE:94058
============= Composition/Information on Ingredients =============
Ingred Name:MANUFACTURER LISTS NOTHING UNDER "INGREDIENTS" IMPLYING
THAT THERE ARE NO HAZARDOUS INGREDIENTS PER HAZ COM STD.
RTECS #:9999999ZZ
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIRECT EYE CONTACT AND PROLONGED OR
REPEATED SKIN CONTACT MAY CAUSE IRRITATION SEEN AS REDNESS.
Explanation of Carcinogenicity:NOT A CARCINOGEN.
Effects of Overexposure:IRRITATION AS NOTED ABOVE.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MIN. LIFTING
UPPER & LOWER LIDS OCCASIONALLY. GET MEDICAL ATTENTION.
INHALATION-REMOVE TO FRESH AIR. SKIN-WASH WITH MILD SOAP & WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RESUE.
INGESTION-IF CONSCIOUS, DILUTE BY GIVING 2 GLASSES OF WATER. GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL ON SOLID ABSORBENT AND SHOVEL
INTO CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 40 AND 120F.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:MECHANICAL (GENERAL): SUFFICIENT.
Other Protective Equipment:NONE.
Work Hygienic Practices:AVOID BREATHING SPRAY MIST.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:30.0F,-1.1C
Vapor Pres:17 MMHG
Vapor Density: 0.6
Spec Gravity:1.075
Evaporation Rate & Reference:1.0
Solubility in Water:COMPLETE
Appearance and Odor:WATER WHITE, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:FREEZING.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ACCORDING TO
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:1032 CURING AGENT
CAGE:22121
CAGE:22121
============= Composition/Information on Ingredients =============
Ingred Name:HETEROCYCLIC ALCOHOL
Fraction by Wt: 5-10%
ACGIH TLV:10 PPM
Ingred Name:DIETHYLENE TRIAMINE *94-4*
CAS:14-40-0
Fraction by Wt: <5%
ACGIH TLV:1 PPM SKIN
Ingred Name:PHENOL (IARC - GROUP 3) *94-4*
CAS:108-95-2
RTECS #:SJ3325000
Fraction by Wt: <1%
Other REC Limits:5 MG/CUM
OSHA PEL:19 MG/CUM
ACGIH TLV:19 MG/CUM (SKIN)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE. EYES: MODERATE-SEVERE
IRRITATION/PERMANENT DAMAGE POSSIBLE ON PROLONGED EXPOSURE. SKIN:
SEVERE IRRITATION/CHEMICAL BURNS. MAY DEVELOP ALLERGIC
REACTION/HARMFUL IF ABSORBED. INHALATION: IRRI TATION OF THE
RESPIRATORY TRACT. INGESTION: MODERATE TOXICITY. MAY CAUSE BURNS OF
MOUTH & THROAT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN & EYE DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER FOR 15 MINS.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF NECESSARY.
INGESTION: DON'T INDUCE VOMITING. GIVE LARGE DOSES OF WATER. OBTAIN
MEDICAL ATTEN TION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:175F
Lower Limits:1.8
Upper Limits:16.3
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:AVOID BREATHING SMOKE. IN CONFINED AREAS WEAR
FULL FIRE FIGHTING EQUIPMENT & NIOSH APPROVED SCBA. COOL FIRE
EXPOSED CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT W/LIQUID & VAPORS. WIPE W/A
CLOTH/COLLECT ON ABSORBENT MATERIAL. LARGE: DIKE & CONTAIN.
PUMP/SHOVEL INTO SALVAGE VESSELS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA IN TIGHTLY
CLOSED CONTAINERS. USE W/ADEQUATE VENTILATION. FOR INDUSTRIAL USE
ONLY.
Other Precautions:AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR EXCESSIVE VAPORS/TO MAINTAIN BELOW TLV
LIMIT, USE A NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPORS.
Ventilation:LOCAL EXHAUST/MECHANICAL (GENERAL).
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS, EYE WASH
STATION, SAFETY SHOWER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>225F
Vapor Pres:0
Vapor Density:>1
Spec Gravity:1
Evaporation Rate & Reference:(BU AC=1): <1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL/ORGANIC ACIDS, STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN.
Conditions to Avoid Polymerization:LARGE MIXTURES W/EPOXY RESINS IN
BULK. CURING PROCESS IS EXOTHERMIC.
==================== Disposal Considerations ====================
Waste Disposal Methods:CURE W/EPOXY RESIN, THEN BURY/INCINERATE WHERE
PERMITTED & REMOVE SALVAGE VESSELS TO A WASTE DISPOSAL SITE IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS. CORROSIVE. UN1760.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:XE-9860A FIELD DRAB CAMO TYPE II
Kit Part:Y
Preparer's Name:MIKE LICHATOWICH
CAGE:02388
CAGE:02388
============= Composition/Information on Ingredients =============
Ingred Name:PM ACETATE
(VAPOR PRESSURE 3.7 MM @ 20C)
CAS:108-65-6
RTECS #:AF8925000
Fraction by Wt: 19%
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:POLYESTER RESIN
Fraction by Wt: 17%
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 8%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 6%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CHROMIUM (III) OXIDE
CAS:1308-38-9
RTECS #:GB6475000
Fraction by Wt: 7%
OSHA PEL:0.5 MG/M3 (CR)
ACGIH TLV:0.5 MG/M3 (CR); 8990
Ingred Name:VOC. ORGANIC CMPD 4.26 LB/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HISTOLOGIC FIBROSIS OF LUNGS,
INCOHERENCE, CORNEAL VACUOLIZATION, ANOREXIA. TARGET ORGANS:
CNS, LUNGS, EYES, SKIN, RESPIRATORY SYSTEM, GI TRACT, BLOOD,
LIVER, & KIDNEYS
Effects of Overexposure:EYE: SEVERE IRRIT., LACRIMATION, REDNESS,
BLURRED VISION SKIN: REDNESS & IRRIT.,
DEFATTING OF SKIN LEADING TO DERMATITIS INHAL:
NASAL/RESP. IRRIT., CNS DEPRSN.,N
AUSEA,HDACHE,VERTIGO,UNCONSC.,ASPHYXATN.INGST: ABDOMINAL
PAIN,NAUSEA,VOMITING,DIARRHEA,GASTROINTESTINAL IRRITATION
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYE: IMMD. FLUSH W/LG AMNTS OF WTR FOR 15 MINS.,LIFTING
EYELIDS,GET MED ATTN. SKIN: IMMD. FLUSH W/PLNTY OF WTR.,IMMD.
REMV CLTHNG W/WTR, GET MED. ATTN. INHAL: REMOVE TO FRESH
AIR,GIVE ARTIFICI AL RESP. GET MEDICAL ATTENTION IMMED.INGST: DONOT
INDUCE VOMITING,DRINK 1-2 GLS OF WTR. CONSULT A PHYSICIAN IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:20F/-6C
Lower Limits:1.0
Upper Limits:10
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCBA W/FACEPIECE W/POSITIVE PRESS MODE &
FULL PROTECTIVE CLTHNG. WTR MAYBE USED TO COOL CLSD CONTNR TO
PREVNT PRESS BUILDUP & POSS. IGN./EXPLSN TO EXTM HT.
Unusual Fire/Explosion Hazard:KEEP CONTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT,SPARKS,ELEC EQUIP,& OPEN FLAME. CLOSED CONTNR MAY EXPLD
W/EXPSD TO EXTRM HT. VAPORS >AIR & MAY TRVL GRND IGN SOURCE
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. DIKE TO
PREVNT FURTHER MOVEMENT & RECLAIM INTO RECOVERY OR SALV- AGE DRUMS
OR TANK TRUCK FOR DISPOSAL. ABSORB WITH INERT MATL SUCH AS CLAY,
SOIL, OR A COMMERCIALLY A VAILABLE ABSORBENT. AVOID SKIN CONTACT &
VAPORS
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMP AREAS OR
NEAR FIRE,OPENFLAME. KEEP CONTAINERS CLSD WHEN NOT IN USE.
AVOIDROUGH HANDLING.
Other Precautions:CONTNRS OF THE MATL MAY BE HAZ. WHEN EMPTY. DONOT
WELD/FLAME CUT ON EMPTY DRUMS.CONTACT LENS SHOULD NOT BE WORN WHILE
WORKING WITH THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR AN APPROPRIATE PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA) DURING & AFTER APPLICATION UNLESS AIR MONITORING
DEMONSTRATES VAPOR/MIST LVLS ARE BELOW APPLICABLE LIMITS.
Ventilation:SUFFICIENT VENTILATION IN VOLUME/PATTERN TO KEEP AIR
CONCENTRATION BELOW PERMISSIBLE EXPOSURE LIMIT OR TLV LIMIT
Other Protective Equipment:CLOTHING AS NEEDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING,SMOKING,OR USING
RESTROOM. WASH CONTAMINATED CLOTHING & DECONTAM. SHOES BEFORE
REUSE.
Supplemental Safety and Health
EMPOLYEES SHOULD WASH PROMPTLY WHEN SKIN BECOMES CONTAMINATED. REMOVE
ANY CLOTHING THAT BECOMES WET (TO AVOID FLAMMABILITY HAZARD)
& WASH BEFORE REUSE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:***
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:56.23
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, NITRATES, ALKALIES, ACIDS
Stability Condition to Avoid:HIGH TEMPERATURES, SHOCK FROM DROPPING
Hazardous Decomposition Products:CARBON MONOXIDE/DIOXIDE
Conditions to Avoid Polymerization:***BOIL PT: 175-302F/79-150C
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS. SHOVEL
RECLAIMED LIQUID AND ABSORBENT INTO RECVRY OR SALVAGE DRUMS FOR
DISPOSAL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BLACK TONER FOR DC-7090
CAGE:0AH08
CAGE:0AH08
CAGE:65678
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 10%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:ORGANIC PIGMENTS INCLUDING INGREDIENTS 3, 4, & 5.
RTECS #:9999999ZZ
Fraction by Wt: 5%
Ingred Name:DYE
CAS:109125-51-1
Ingred Name:DYE
CAS:109125-50-0
Ingred Name:DYE
CAS:84179-66-8
Ingred Name:NON-HAZARDOUS INGREDIENTS (POLYMER RESINS) INCLUDING
INGREDIENTS 7-10.
RTECS #:9999999ZZ
Fraction by Wt: 85%
Ingred Name:STYRENE-ACRYLATE COPOLYMER
CAS:27136-15-8
Ingred Name:PROPENE, POLYMERS
CAS:9003-07-4
RTECS #:UD1842000
Ingred Name:POLYMERIC RESIN
CAS:68611-44-9
Ingred Name:2-PROPENOIC ACID, 2-METHYL, POLYMER W/METHYL
2-METHYL-2-PROPENOATE
CAS:25086-15-1
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE IN NORMAL HANDLING AND USE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:MINIMAL RESPIRATORY TRACT IRRITATION MAY OCCUR
AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP & WATER. EYE: FLUSH THOROUGHLY WITH
WATER FOR AT LEAST 15 MIN AND SEEK MEDICAL TREATMENT. INGEST:
DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER AND SEEK
MEDICAL TREATMENT.INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING
(GIVE O*2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Flash Point:>350F,>177C
Extinguishing Media:IF PRODUCT BECOMES INVOLED IN FIRE, USE CARBON
DIOXIDE EXTINGUISHER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE AND USE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH A VACUUM CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSE CAP TIGHTLY AND STORE IN A COOL,
DRY DARK PLACE.
Other Precautions:AVOID COMBUSTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:AVOID INHALATION, INGESTION, SKIN OR EYE
CONTACT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:268F,131C
Spec Gravity:1.1 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER, PRACTICALLY ODORLESS.
Corrosion Rate:N/KI
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE IN NORMAL HANDLING AND USE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LOW FLASH STODDARD SOLVENT
CAGE:6G367
CAGE:6G367
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC HYDROCARBON SOLVENT (SATURATES)
Fraction by Wt: 86.6%
ACGIH TLV:NOT SPECIFIED
Ingred Name:AROMATICS
Fraction by Wt: 13.4%
===================== Hazards Identification =====================
Effects of Overexposure:EXCESSIVE INHALATION MAY CAUSE LOCAL
IRRITATION,DROWSINESS,COLLAPSE,MUSCLE TWITCHING,COMA-PNEUMONIA.
======================= First Aid Measures =======================
First Aid:FOLLOW NORMAL FIRST AID PROCEDURES.CALL A DOCTOR IF NEEDED.
DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:106F(ASTM D 56)
Lower Limits:UNKN
Upper Limits:UNKN
Extinguishing Media:CO*2,DRY CHEMICAL,FOAM.
Fire Fighting Procedures:USE SCBA FOR FIREFIGHTING.
Unusual Fire/Explosion Hazard:THE MATERIAL WILL IGNITE ON CONTACT WITH
AN OPEN FLAMES.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN IT UP,USE WIPING CLOTH OR ABSORBENT
PAPER IN A SUITABLE MANNER (USE SAFETY TYPE TRASH RECEPTICLE)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT AND OPEN FLAMES.
FOLLOW NORMAL PROCEDURES FOR HANDLING OIL/PETROLEUM PRODUCT.
Other Precautions:AVOID SKIN AND EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
MSDS DATED 4/1/81.SPEC TYPE I.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:300-400F
Vapor Pres:<11
Vapor Density:UNKN
Spec Gravity:0.7686
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID-ODOR-HYDROCARBON SOLVENT.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY THE MFR.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND OPEN FLAMES.
Hazardous Decomposition Products:MAY GIVE CO OR CO*2 DUE TO INCOMPLETE
COMBUSTION
==================== Disposal Considerations ====================
Waste Disposal Methods:DETERMINE DISPOSAL PROCEDURES AND FOLLOW
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:STADIS 450 CONDUCTIVITY IMPROVER
Preparer's Name:D.C.ZIMMERMAN
CAGE:18873
CAGE:60777
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 50-65%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEAVY AROMATIC NAPHTHA (SOLVENT NAPHTHA)
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:NEW JERSEY TRADE SECRET #0085020100L-5457P
Fraction by Wt: 1-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DODECYLBENZENESULFONIC ACID (SARA III)
CAS:27176-87-0
RTECS #:DB6600000
Fraction by Wt: 1-10%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NEW JERSEY TRADE SECRET REGISTRY NO. 00850201001-5037 P
Fraction by Wt: 1-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <0.06%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MODERATE TO SEVERE IRRITATION OF
SKIN,EYES AND RESPIRATORY TRACT;HEADACHE,NAUSEA,VOMITING.
CHRONIC:DERMATITIS (NO OTHER DATA AVAILABLE).
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO CARCINOGEN OVER
0.1%
Effects of Overexposure:SIMILAR TO TOLUENE. EYE:IRRIT.
SKIN:IRRIT.,POSSIBLE DERMATITIS.
INHALED:ANESTHESIA,HEADACHE,NAUSEA. INGESTED:G/I IRRITATION,NAUSEA,
VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
WORSEN.
======================= First Aid Measures =======================
First Aid:SKIN:WASH W SOAP/WATER.EYES:FLUSH W WATER FOR 15 MIN.GET MED
ATTN.INHAL:REMOVE TO FRESH AIR.GET MED ATTN.INGEST:DO NOT INDUCE
VOMITING.KEEP PERSON WARM & QUIET.CALL A DR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:41.0F,5.0C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST WHEN EXPOSED TO HEAT
OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL:SOAK UP W SAND/EARTH.MAY BE WIPED
UP W KEROSENE SOLVENT &/OR SOAPY WATER USING PROPER PROTEC EQUIP.LG
SPILL:ELIM ALL IGN SOURCES.STOP SPILL AT SOURCE.DIKE SPILL AREA &
PUMP LIQUID TO SALVA GE TANK.SOAK UP REMAINDER LIQ ON ABSORBENT FOR
DIS
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL/DRY PLACE.KEEP
CONTAINER CLOSED,AWAY FROM HEAT,SPARKS & SOURCE OF IGNITIONS.USE
PROTECTIVE EQUIP TO AVOID SKIN/EYE CONTACT.
Other Precautions:EMPTY CONTNR MAY BE HAZ. OBSERVE ALL SAFETY
PRECAUTIONS GIVEN IN THIS DATA SHEET.USE IN WELL VENTILATED
AREA.WASH HANDS THOROUGHLY AFTER USE/HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS
Ventilation:LOCAL:GOOD VENTILATION
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS TO AVOID SKIN
CONTACT.
Supplemental Safety and Health
MSDS NO.1760PC
================== Physical/Chemical Properties ==================
HCC:F2
Spec Gravity:0.91
Evaporation Rate & Reference:> 1(N-BUTYL ACETATE = 1)
Solubility in Water:SLIGHT
Appearance and Odor:AMBER COLOR LIQUID,TOLUENE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR DIOXIDE
Conditions to Avoid Polymerization:UNK
==================== Disposal Considerations ====================
Waste Disposal Methods:DESTROY BY BURNING/LIQUID INCINERATION IAW LOCAL
REGULATIONS PROD ABSORBED ON ABSORBENT MATERIAL MAY BE DEPOSITED IN
A LANDFILL IAW LOCAL,STATE & FED REGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SCOTCH BRAND PROCESS COLOR 708 GREEN
CAGE:94960
CAGE:94960
============= Composition/Information on Ingredients =============
Ingred Name:V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 21-32.4%
Other REC Limits:STEL 400 PPM
ACGIH TLV:300 PPM
Ingred Name:ALKYD RESIN 3133
Fraction by Wt: 19-29.8%
Ingred Name:ALKYD RESIN 2392
Fraction by Wt: 18-28.2%
Ingred Name:POLY (ISOBUTYL METHACRYLATE)
CAS:9011-15-8
Fraction by Wt: 6-10.2%
Ingred Name:PHTHALO-GREEN; CI PIGMENT GREEN 7, HYDROUS ALUMINUM
SILICATE, COPPER PHTHALOCYANINE
CAS:1328-53-6
RTECS #:GE4300000
Fraction by Wt: 3-4.5%
Ingred Name:HEAVY AROMATIC SOLVENT NAPHTHA PETROLEUM
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 2.5-3.8%
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2.3-3.5%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PINE OIL
CAS:8002-09-3
RTECS #:TK5100000
Fraction by Wt: 1.3-1.9%
Ingred Name:2-ETHYLHEXANOL
CAS:104-76-7
RTECS #:MP0350000
Fraction by Wt: 1.3-1.9%
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 0.8-1.2%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:BUTANOL, N-BUTYL ALCOHOL, PROPYL CARBINOL, BUTYL ALCOHOL
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: <0.1%
Other REC Limits:300 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:C 152 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOL ORGANIC CMPD: 450 MG/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: LIQUID/VAPORS MAY CAUSE
IRRITATION ON DIRECT CONTACT. SKIN: IRRITATION. INHALATION:
IRRITATION TO NOSE, THROAT & RESPIRATORY TRACT. INGESTION:
HARMFUL/FATAL. MAY CAUSE GASTROINTESTINAL TRACT IRR ITATION.
ASPIRATION OF THE MATERIAL INTO THE LUNGS CAN OCCUR RESULTING IN
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHES, DIZZINESS, FATIGUE,
NAUSEA, UNCONSCIOUSNESS, VOMITING
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER. SKIN: WASH W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF
NECESSARY. KEEP WARM & QUIET. INGESTION: DON'T INDUCE VOMITING.
GIVE 1-2 GLASS ES OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:104F
Extinguishing Media:CO2, FOAM/DRY CHEMICALS
Fire Fighting Procedures:WEAR FULL PROTECTIVE GEAR & SELF CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH ALL IGNITION SOURCES. VENTILATE
AREA. CONTAIN MATERIAL. COVER W/ABSORBENT MATERIAL. COLLECT
MATERIAL. CLEAN UP RESIDUE. PLACE IN A US DOT APPROVED CONTAINER &
SEAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. PREVENT ALL IGNITION SOURCES. KEEP CONTAINERS CLOSED WHEN
NOT IN USE.
Other Precautions:WEAR LOW-STATIC/PROPERLY GROUNDED SHOES TO PREVENT
STATIC. GROUND CONTAINERS SECURELY WHEN TRANSFERRING CONTENTS.
DON'T GET IN EYES. AVOID SKIN CONTACT. AVOID PROLONGED EXPOSURE TO
ELEVATED CONCENTRAT IONS OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:LOCAL & GENERAL TO MAINTAIN VAPOR LEVELS WITHIN ESTABLISHED
TLV.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS, ARMS & FACE W/SOAP & WATER AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>235F
Vapor Density:>1
Spec Gravity: 1
Evaporation Rate & Reference:(BU AC=1): <1
Solubility in Water:0.1-1%
Appearance and Odor:GREEN, VISCOUS LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume: 40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, IGNITION
SOURCES, STATIC DISCHARGE.
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE/BULK IN A HAZARDOUS WASTE
FACILITY IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS. U.S.
EPA HAZARDOUS WASTE NO: D-001 (IGNITABLE), D-008 (LEAD).
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:6604288 GOAT-RD1
Preparer's Name:S HEALY
CAGE:FO645
CAGE:FO645
CAGE:6Z677
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE, AZIDE *96-4*
CAS:26628-22-8
RTECS #:VY8050000
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL IRRITATION. SKIN:
IRRITATION, ABSORPTION, ALLERGIC REACTION. EYES: IRRITATIONS,
CONJUNCTIVITIS. INGESTION: BRONCHIAL IRRITATION, RESPIRATORY
IRRITATION, RESPIRATORY FAILURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, FAINTNESS,
NAUSEA, LOW BLOOD PRESSURE, BLURRED VISION, SHORTNESS OF BREATH,
COLLAPSE, BRONCHITIS, PALPITATION, WEAKNESS & UNSTEADINESS, COMA,
CONVULSIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
IF BREATHING IS DIFFICULT GIVE OXYGEN. SKIN: WASH OFF THOROUGHLY
FOR 15 MINS. EYES: RINSE THOROUGHLY W/WATER & GIVE PLENTY OF WATER
TO DRIN K. INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICALS SUCH AS AN SODIUM CARBONATE/SAND.
Fire Fighting Procedures:BURNING SODIUM AZIDE WILL EXPLODE IF WATER IS
USED AS AN EXTINGUISHING MEDIA. SCBA MUST BE WORN.
Unusual Fire/Explosion Hazard:MAY EXPLODE & RELEASE TOXIC FUMES UPON
HEATING. DON'T ALLOW TO CONTACT METALS AT HIGH TEMPS.
(SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/RUNNING WATER BEFORE DISCHARGE.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM METALS & ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:GENERAL/LOCAL EXHAUST TO MEET TLV REQUIREMENTS
Other Protective Equipment:ADEQUATE LABORATORY ATTIRE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: FORMS HIGHLY SENSITIVE EXPLOSIVE COMPOUNDS W/HEAVY
METALS SUCH AS LEAD, SILVER & COPPER. WHEN HEATED TO 662F IT
DECOMPOSES EXOTHERMICALLY, BURNING W/A VERY HOT FLAME & PRODUCING N
ITROGEN & MOLTEN SODIUM.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:527F
Spec Gravity:1.85
Solubility in Water:40.16
Appearance and Odor:WHITE-COLORLESS CRYSTALS/POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS, ACIDS, ACID CHLORIDES & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:NITROGEN OXIDES, HYDRAZOIC ACID
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MIL-PRF-81352 LACQUER ACRYLIC
Preparer's Name:ERNEST CARTER
CAGE:05TC0
CAGE:05TC0
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
= Wt:3.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:1-METHOXY-2-PROPYL ACETATE
CAS:108-65-6
RTECS #:AI8925000
Minumum % Wt:45.
Maxumum % Wt:60.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF SKIN, EYES, MUCOUS
MEMBRANES. DRYING, DERFATTING OF SKIN. AVOID INGESTION AND
BREATHING OF VAPORS. CHRONIC: EYE, LIVER, KIDNEY, AND CENTRAL
NERVOUS SYSTEM DAMAGE MAY OCCUR. CONTAINS A SU SPECTED MUTAGEN.
CONTAINS A SUSPECTED TERATOGEN. BLOOD AND REPRODUCTIVE DISORDERS
MAY OCCUR.
Effects of Overexposure:INHALATION: EXCESSIVE INHALATION OF VAPORS CAN
CAUSE NASAL AND RESPIRATORY IRRITATION, DIZZINESS, FATIGUE, NAUSEA,
HEADACHE, POSSIBLE UNCONSCIOUSNESS, AND EVEN ASPHYXIATION. AS
NUISANCE DUSTS, AS RES PIRABLE NUISANCE DUSTS. SKIN: PROLONGED OR
REPEATED CONTACT WITH PRODUCT CAN CAUSE MODERATE SKIN IRRITATION,
DEFATTING, DERMATITIS. EYES: CAN CAUSE SEVERE IRRITATION, REDNESS,
TEARING, BLURRED VISION. SKIN ABSORPTION MAY POTENTIALLY
CONTRIBUTE TO OVERALL EXPOSURE TO THIS MATERIAL. APPROPRIATE
MEASURES SHOULD BE TAKEN TO PREVENT ABSORPTION SO THAT TLV IS NOT
INVALDATED. INGESTION CAN CAUSE GASTROIN TESTINAL IRRITATION,
NAUSEA, VOMITING,
======================= First Aid Measures =======================
First Aid:SKIN: THOROUGHLY WASH EXPOSED AREA WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING. LAUNDER CLOTHING BEFORE REUSE. EYES:
FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING UPPER AND LOWER LIDS
OCCASIONALLY, GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. KEEP PERSON WARM, QUIET, AND GET MEDICAL ATTENTION.
ASPIRATION OF MATERIAL INTO LUNGS DUE TO VOMITING CAN CAUSE
CHEMICAL PNEUMONITIS, WHICH CAN BE FATAL. BREATHING: REMOVE PERSON
TO FRESH AIR. GIVE OXYGEN IF BREATHING DIFFICULT: GIVE ARTIFICIAL
RESPIRATION IF BREATHING STOPS. KEEP PERSON WARM AND GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=7.2C, 45.F
Lower Limits:1.0%
Upper Limits:7.0%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS WITH A
FULL FACE PIECE OPERATED IN PRESSURE DEMAND OR OTHER POSITIVE
PRESSURE MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND OR BY MOVED BY VENTILATION AND IGNITED BY
HEAT, PILOT LIGHTS, OTHER FLAMES AND IGNITION SOURCES AT LOCATIONS
DISTANT FROM MATERIAL HANDLING PORT.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB. PREFERABLY WITH FLOOR
ABSORBENT. TRANSFER TO HOOD. LARGE: ELIMINATE ALL IGNITION SOURCES.
WEAR PROTECTIVE CLOTHING. STOP SPILL, DIKE AREA, PUMP TO SALVAGE
TANK, PREVENT RUN-OFF TO SEWER S. NOTIFY AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE OR USE IN HIGH
TEMPERATURE AREAS OR NEAR HEAT, SPARKS, OR OPEN FLAME. KEEP CLOSURE
TIGHT AND CONTAINER UPRIGHT TO PREVENT LEAKAGE. STORE ONLY IN WELL
VENTILATED AREAS. AVOID CONTACT WITH OR BREATHING OF VAPORS
RELEASED OURING CURING PROCESS.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID CONTACT WITH SKIN AND
EYES. AVOID BREATHING OF VAPORS OR SPRAY MIST, ALL HAZARD
PRECAUTIONS GIVEN IN THE DATA SHEET MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF THE PRODUCT OR ANY COMPONENT IS
EXCEEDED, A NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED RESPIRATOR IS
ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA
REGULATIONS ALSO PERMIT OTHER NIOS H/MSHA RESPIRATORS UNDER
SPECIFIED CONDITIONS (SEE SAFETY EQUIPMENT SUPPLIER). ENGINEERING
OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
REGULATIONS ARE ADVISED. CHECK
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM. SMOKE IN SMOKING PERMITTED AREAS ONLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:231 TO 232 DEG F
Vapor Density:HEAVIER
Spec Gravity:1.1
VOC Pounds/Gallon:540
VOC Grams/Liter:4.5
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT SOLUBLE IN WATER
Appearance and Odor:COLORED VISCOUS LIQUID WITH AROMATIC SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUMS(EVEN EMPTY) BECAUSE PRODUCT(EVEN JUST RESIDUE) CAN
IGNITE EXPLOSIVELY.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE,
VARIOUS HYDROCARBONS, ETC.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL: ALLOW VOLATILE PORTION TO EVAPORATE
IN HOOD. ALLOW SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR HOOD
DUCT WORK. DISPOSE OF BREATHING MATERIAL IN ACCORDANCE WITH
APPLICABLE REGULATIONS. LARGE SPILL: DESTROY BY LIQUID
INCINERATION. CONTAMINATED ABSORBENT MAY BE DEPOSITED IN A LANDFILL
I N ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULA
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RIMULA OIL 40
CAGE:54527
CAGE:0T5C6
CAGE:54527
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (MILD),
HEAVY PARAFFINIC
CAS:64742-54-7
RTECS #:PY8035500
Fraction by Wt: 0-90%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED (MILD),
HEAVY PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 0-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, CATLYTIC DEWAXED, HEAVY
PARAFFINIC
CAS:64742-70-7
RTECS #:PY8045500
Fraction by Wt: 0-50%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SOLVENT REFINED HYDROTREATED RESIDUAL OIL
CAS:64742-57-0
Fraction by Wt: 0-35%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ADDITIVE PACKAGE CONTAINING ZINC COMPOUNDS
Fraction by Wt: <25%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF VAPOR OR OIL MIST
MAY CAUSE MILD IRRITATION OF UPPER RESPIRATORY TRACT. CONTACT MAY
CAUSE MILD IRRITATION OF SKIN AND EYES. INGESTION MAY CAUSE SLIGHT
GI TRACT IRRITATION. CHRONIC : PROLONGED OR REPEATED EXPSOURE MAY
CAUSE SKIN DISORDERS SUCH AS DERMATITIS, FOLLICULITIS OR OIL ACNE.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:MILD EYE & SKIN IRRITATION. INGESTION: NAUSEA,
DIARRHEA. INHALED-COUGH, CHEST DISCOMFORT.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPSOURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:IN ALL CASES GET MEDICAL ATTENTION. EYES-FLUSH WITH WATER FOR
15 MINUTES, HOLD LIDS OPEN. SKIN-REMOVE CONTAMINATED CLOTHES. WIPE
OFF EXCESS. WASH WITH MILD SOAP & WATER. INHALED-REMOVE TO FRESH
AIR. P ROVIDE OXYGEN IF BREATHING DIFFICULT. INGESTED-DO NOT INDUCE
VOMITING! GENERALLY, NO TREATMENT NEEDED UNLESS QUANTITIES ARE
SWALLOWED.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:225F,107C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. DO NOT USE DIRECTS STREAM; PRODUCT FLOATS & WILL
REIGNITE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
COMBUSTION OR HEAT OF FIRE MAY PRODUCE HAZARDOUS DECOMPOSITION
PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY BURN THOUGH NOT READILY IGNITABLE. SHUT OF
SOURCE OF LEAK IF SAFE TO DO SO. CONTAIN SPILL. ELIMINATE ALL
SOURCES OF IGNITION. PUMP TO SALAVGE VESSELS. ABSORB RESIDUE WITH
SAND OR INERT MATERIAL. S WEEP OR SCOOP UP AND TRANSFER TO DISPOSAL
DRUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES, HIGH TEMPERATURES
AND STRONG OXIDIZING AGENTS.
Other Precautions:MINIMIZE SKIN CONTACT. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES, INCLUDING SHOES, THAT CANNOT BE
DECONTAMINATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR WITH
ORGANIC VAPOR CARTRIDGE OR AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS
REQUIRED. USE IAW 29 CFR 1910.134.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
EYE WASH STATION. WASHING FACILITIES.
Work Hygienic Practices:WASH HANDS AFTER HANDLING & BEFORE EATING,
DRINKING, USING TOILET OR SMOKING. LAUNDER CONTAMINATED CLOTHES
BEFORE REUSE.
Supplemental Safety and Health
IARC HAS DETERMINED THAT USED MOTOR OIL CAUSES CANCER IN EXPERIMENTAL
PRESENTED BY CAGE 0T5C6 FOR CONTRACT NUMBER SP0451-96-M-Q506.
================== Physical/Chemical Properties ==================
HCC:V6
Melt/Freeze Pt:M.P/F.P Text:-15F,-26C
Spec Gravity:0.9018
Viscosity:145 CS @ 40C
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK AMBER LIQUID, SLIGHT HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HIGH HEAT, OPEN FLAMES AND OTHER
SOURCES OF IGNITION; STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATE AND GASES WILL EVOLVE UNDER PYROLYSIS OR
COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF PRODUCT BECOMES A WASTE, IT WOULD NOT BE A
HAZARDOUS WASTE BY RCRA CRITERIA (40 CFR 261). PLACE IN AN
APPROPRIATE DISPOSAL FACILITY IN COMPLIANCE WITH LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:806 2200 EKTACOLOR STABILIZER AND REPLENISHER, PART B
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SUBSTITUTED THIAZOLIN-3-ONE MFR SUPPLIED CAS# 55965-84-9
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM CITRATE, DIBASIC (CERCLA)
CAS:3012-65-5
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CITRIC ACID
CAS:77-92-9
RTECS #:GE7350000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): > 5000 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. CAUSES EYE IRRITATION. CAUSES SKIN
IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, ALLERGIC SKIN
REACTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.026
pH:3.2
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:GREEN LIQUID, NO ODOR
Percent Volatiles by Volume:90-95%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AMMONIA, CHLORAMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:STAIN, OIL TYPE, WOOD INTERIOR MAPLE
Preparer's Name:D. KIER
CAGE:0ALO9
CAGE:0ALO9
CAGE:0AL09
============= Composition/Information on Ingredients =============
Ingred Name:S K SOLVENT, MINERAL SPIRITS MIXTURE IS MADE OF THE
FOLLOWING: SOLVENT 390 AND BENZENE (SEE BELOW)
Other REC Limits:NONE SPECIFIED
OSHA PEL:525 MG/M3
ACGIH TLV:100 PPM
Ingred Name:S K SOLVENT: (RAT) ORAL > 8.0 ML/KG; DERMAL: 74.0 ML/KG;
INHALE: +71400.0 PPM 4 HOURS
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:SOLVENT 390
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:PPM BENZENE ( RAT ORAL: > 5600.0 ML/KG; INHALE: 13700.0
PPM 4 HOURS)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: < 10%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL:78ML/KG DERM:74ML/KG INHAL:13700PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALE: NASAL AND RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
POSSIBLE UNCONSCIOUSNESS AND EVEN ASPHYXIATION. SKIN: CAN CAUSE
DEFATTING, DRYING, IRRITATION & DERMATITIS. EY E: CAN CAUSE SEVERE
IRRITATION, REDNESS, TEARING AND BLURRED VISION. INGEST: CAN CAUSE
GASTROINTESTINAL IRRITATION,
Explanation of Carcinogenicity:NONE OF THE MATERIALS IN THIS PRODUCT IS
ON THE IARC, NTP OR OSHA CARCINOGEN LIST.
Effects of Overexposure:NAUSEA, VOMITING AND DIARRHEA. ASPIRATION OF
MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL.
Medical Cond Aggravated by Exposure:REPORTS STATE REPEATED & PROLONGED
OCCUPATIONAL OVER-EXPOSURE TO SOLVENTS WITH PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING/INHALING CAN BE HARMFUL/FATAL.
======================= First Aid Measures =======================
First Aid:INHALE: REMOVE VICTIM FROM FURTHER EXPOSURE AND RESTORE
BREATHING, IF REQUIRED. EYE: FLUSH EYES WITH WATER FOR AT LEAST 15
MINUTES WHILE HOLDING EYELIDS OPEN. SKIN: WASH CONTAMINATED SKIN
WITH MILD SO AP AND WATER. INGEST: DO NOT INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:112F,44C
Lower Limits:0.8
Upper Limits:5.0
Extinguishing Media:DRY CHEMICAL, CO2, FOAM AND WATER FOG
Fire Fighting Procedures:DO NOT ENTER CONFINED SPACE W/OUT PROTECTIVE
CLOTHING & POSI PRESS SCBA. EXCLUDE AIR. DO NOT USE WATER EXCEPT
FOR FOG. USE WATER TO COOL FIRE EXPOSED CONTAINERS
Unusual Fire/Explosion Hazard:AVOID EXCESSIVE HEAT, OPEN FLAMES AND ALL
IGNITION SOURCES. VAPOR FORMS AN EXPLOSIVE MIXTURE WITH AIR BETWEEN
UPPER AND LOWER FLAMMABLE LIMITS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITE SOURCES. VENTILATE AREA.
ABSORB SPILL W/ABSORB MAT'L (SAWDUST,SAND,VERMIC). PUT MAT'L IN
CLOSED CNTNRS. LARGE SPILL: DIKE AREA. DO NOT LET INTO WATERWAYS.
USE PROTECT EQUIPMENT. SPILL S GREATER THAN 220 LBS NOTIFY PROPER
AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL-VENTILATED
AREA, AWAY FROM HEAT & IGNITION SOURCES. AVOID PROLONGED OR
REPEATED CONTACT W/ SKIN. AVOID BREATHING VAPORS/MIST.
Other Precautions:LAUNDER CONTAMINATED CLOTHES PRIOR TO REUSE. USE GOOD
PERSONAL HYGIENE. GROUND CONTAINERS WHEN POURING & LIMIT FREE FALL
TO MINIMIZE STATIC CHARGE BUILD-UP. EMPTY CONTAINERS MAY BE
HAZARDOUS FROM RESI DUES & VAPOR & ALL CAUTIONS APPLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A CANISTER-TYPE RESPIRATOR MUST BE WORN TO
PREVENT THE INHALATION OF VAPORS OR SPRAY MISTS WHEN THE TLV/PEL IS
EXCEEDED.
Ventilation:GENERAL VENTILATION FOR NORMAL USE. LOCAL VENTILATION MAY
BE NEEDED IN TO KEEP EXPOSURE LEVELS BELOW LIMITS.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO PREVENT SKIN
CONTACT. EYE WASH STATION/SAFETY SHOWER SHOULD BE AVAILABLE.
Supplemental Safety and Health
"COMBUSTIBLE LIQUID". DO NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER
EACH USE. KEEP AWAY FROM CHILDREN.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:301 TO 402F
Vapor Pres:>7.0 @ 38C
Vapor Density:4.8
Spec Gravity:0.87
pH:NA
Viscosity:10"-25" #4FC
Evaporation Rate & Reference:SLOWER THAN N-BU AC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:THIN LIQUID, MILD ODOR
Percent Volatiles by Volume:65-69
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS, LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT, OPEN FLAME AND ALL
IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE ARE
PRODUCED ON COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF UNRECLAIMABLE, MATERIAL & CONTAINERS ARE
CONSIDERED HAZARDOUS WASTE (EPA D001). DISPOSE OF AT LICENSED WASTE
DISPOSAL COMPANY OR INCINERATE W/APPROVAL OF ENVIRONMENTAL
AUTHORITY. DISPOSAL MUST BE I N ACCORANCE W/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:3509 SODIUM BICARBONATE
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM BICARBONATE
CAS:144-55-8
RTECS #:VZ0950000
Fraction by Wt: 99-100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 4220 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INGESTION: CONSCIOUS, IMMEDIATELY GIVE LARGE AMOUNTS OF
WATER. INHALATION: MOVE TO FRESH AIR. SKIN: IMMEDIATELY WASH
W/PLENTY OF SOAP & WATER FOR 15 MINS. EYES: IMMEDIATELY FLUSH
W/PLENTY OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIAE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR PROPER EQUIPMENT & SELF CONTAINED
BREATHING APPARATUS W/FULL FACEPIECE OPERATED IN POSITIVE PRESSURE
MODE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. SWEEP UP &
REMOVE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA.
Other Precautions:HANDLING OF MATERIAL SHOULD BE BY A PERSON TRAINED
IN/SUPERVISED BY A PERSON TRAINED IN, CHEMICAL HANDLING. WHEN
HANDLING LIQUID PRODUCTS, SECONDARY PROTECTIVE CONTAINERS MUST BE
USED FOR CARRYING. AV OID BREATHING DUST/CONTACT W/SKIN/EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED W/ADEQUATE VENTILATION. IF
AIRBORNE CONCENTRATION IS HIGH, USE AN APPROPRIATE RESPIRATOR/DUST
MASK.
Ventilation:ADEQUATE GENERAL/LOCAL EXHAUST VENTILATION TO KEEP
FUME/DUST LEVELS AS LOW AS POSSIBLE.
Supplemental Safety and Health
ORAL LD50 INFORMATION IS FOR SODIUM BICARBONATE.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:122F
Spec Gravity:2.16
Solubility in Water:MODERATE (1-10%)
Appearance and Odor:WHITE CRYSTALLINE POWDER. ODORLESS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HEAT, HUMIDITY
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RP6007N PART A
CAGE:57412
CAGE:57412
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE BISPHENYL ISOCYANATE (MDI) (SARA III)
CAS:101-68-8
RTECS #:NQ9350000
Fraction by Wt: 85%
OSHA PEL:C, 0.02 PPM
ACGIH TLV:0.005 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:LABORED BREATHING, IRRITATION OF THE UPPER
RESPIRATORY SYSTEM, BRONCHITIS. ALLERGENIC SENSITIVITY.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE PERSON TO UNCONTAMINATED AREA, ADMINISTER
OXYGEN IF NECESSARY. SKIN CONTACT, WASH THOROUGHLY W/SOAP & WATER.
EYE, IRRIGATE THOROUGHLY W/WATER FOR 15 MINUTES/GET MED ATT.
INGESTION,IF CONSCIOUS GIVE WATER. INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:345F C.O.C.
Extinguishing Media:CHEMICAL FIRE EXTINGUISHERS, CO2, OR FOAM.
Fire Fighting Procedures:AIR-SUPPLIED MASKS OR FULL FACED WORN WHEN
EXPOSED TO VAPORS
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS ARE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB IN AN ABSORBENT SWEEPING COMPOUND AND
DISPOSE. NEUTRALIZE CONTAMINATED AREA WH A 1% AMMONIA SOLUTION OR
ISOPROPYL ALCOHOL. WASH DOWN AREA THOROUGHLY TH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE INDOORS IN A COOL, DRY PLACE;
AVOID MOISTURE CONTAMINATION. WASH HAND THOROUGHLY AFTER U/BEFORE
EATING OR SMOKING.
Other Precautions:AVOID PROLONGED BREATHING OF VAPORS. USE W/ADEQUATE
VENTILATION. AVOID CONTACT W/SKIN/CLOTHING. IF CONTACT OCCURS WASH
AFFECD AREA THOROUGHLY W/SOAP & WATER. CONTACT A PHYSICIAN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE.
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
MSDS UNDATED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:325F
Vapor Pres:.00
Vapor Density:>1
Spec Gravity:1.18
Evaporation Rate & Reference:NIL
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT YELLOW SLIGHT ODOR.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID CONTACT WITH MOISTURE.
Hazardous Decomposition Products:HCN, CO, NOX AND OTHER TOXIC GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY WASTE OR DISPOSE IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS OF ENVIRONMENTAL CONTROL.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: COPPER RED IRON OXIDE, R-3098R
Cage: GO125
=======================================================
Contractor Summary
=======================================================
Cage: GO125
=======================================================
Ingredients
=======================================================
Cas: 1332-37-2
RTECS #: NO7380000
% Wt: >92
OSHA PEL: N/K (FP N)
ACGIH TLV: 5 MG/M3 (MFR)
------------------------------
Cas: 1317-61-9
% Wt: <8
OSHA PEL: 10 MG/M3
ACGIH TLV: 5 MG/M3
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: MAY CAUSE MECH SKIN & EYE IRRIT. RPTD &
PRLNG EXPOS TO IRON OXIDE DUST MAY CAUSE BENIGN PNEUMOCONIOSIS CALLED
SIDEROSIS. CHRONIC: PRLNG INHAL OF IRON OXIDE DUST IS KNOWN TO PRDCE A CNDTN
KNOWN AS SIDEROSIS. ON X-RAYS IT APPEARS TO BE A BENIGN PNEUMOCONIOSIS &
IS NOT ASSOC W/PULM FIBROSIS OR (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: DISABILITY UNLESS THERE IS
CONCURRENT EXPOS TO OTHER FIBROSIS-PRODUCING MATLS SUCH AS SILICA. TLV IS SET
TO PROTECT AGAINST SIDEROSIS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH WITH GENEROUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
CALL MD IF IRRITATION PERSISTS. SKIN: WASH WITH MILD SOAP AND WATER.
INHALATION: REMOVE TO FRESH AIR. CALL MD. INGESTION: IF CONSCIO US, GIVE
LARGE QUANTITIES OF WATER TO INDUCE VOMITING. GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: VACCUM OR USE WET CLEAN-UP TECHNIQUES AND PLACE WASTE
MATERIAL IN CLOSED CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE MADE IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS. PURSUANT TO 40 CFR PART 261 OF THE RCRA. REGULATIONS
CURRENTLY IN EFFECT, DISCARDED IRON OXIDE WOULD NOT BE CLASSIFIED AS
HAZARDOUS WASTE.
Handling And Storage Precautions: FOR TRANSPORTATION EMERGENCIES, CALL
CHEMTREC, 24 HOUR INFORMATION SERVICE, (800) 424-9300.
Other Precautions: AVOID BREATHING DUST. KEEP AWAY FROM FOOD PRODUCTS. KEEP
CONTAINER CLOSED WHEN NOT IN USE. USE WITH ADEQUATE, LOCALIZED VENTILATION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NOT FLAMMABLE
Extinguishing Media: NOT FLAMMABLE. USE APPROPRIATE EXTINGUISHING MEDIA FOR THE
COMBUSTIBLE MATERIAL INVOLVED IN THE FIRE.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE OF NIOSH APPROVED DUST RESPIRATORS IS RECOMMENDED
WHEN EXPOSURE LIMITS MAY BE EXCEEDED.
Ventilation: LOCAL EXHAUST VENTILATION TO COLLECTOR OR CONTAINMENT RECOMMENDED
TO CONTROL DUST TO BELOW EXPOSURE LIMITS.
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: I/A/W GOOD INDUS HYGIENE PRACT, AVOID CONT W/SKIN,
EYES/CLTHG. WASH THORO AFTER HNDLG & BEFORE EATING, (SUP DAT)
Supplemental Safety and Health: HYGIENE PRACT: DRINKING/USING TOBACCO PRODUCTS.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 4.03 (H*2O=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: RED POWDER, NO ODOR
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: IT IS INCOMPATIBLE WITH HYDRAZINE, CALCIUM HYPOCHLORITE,
PERFORMIC ACID, AND BROMINE PENTAFLUORIDE.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: COPPER RED IRON OXIDE, R-3098R
Cage: GO125
Assigned IND: Y
Company Name: HARCROS PIGMENTS INC
Street: 1525 WOOD AVE
Zipcode: 18042
Label Required IND: Y
Date Of Label Review: 10/21/1997
Status Code: C
Label Date: 10/21/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: MAY CAUSE MECHANICAL SKIN AND EYE IRRITATION.
REPEATED AND PROLONGED EXPOSURE TO IRON OXIDE DUST MAY CAUSE BENIGN
PNEUMOCONIOSIS CALLED SIDEROSIS. CHRONIC: PROLONGED INHALATION OF IRON OXIDE
DU ST IS KNOWN TO PRODUCE A CONDITION KNOWN AS SIDEROSIS. ON X-RAYS IT
APPEARS TO BE A BENIGN PNEUMOCONIOSIS AND IS NOT ASSOCIATED WITH PULMONARY
FIBROSIS OR DISABILITY UNLESS THERE IS CONCURRENT EXPOSUR E TO OTHER
FIBROSIS-PRODUCING MATERIALS SUCH AS SILICA. THE TLV IS SET TO PROTECT
AGAINST SIDEROSIS.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DTE 16M, 602771-00
CAGE:1E969
CAGE:1E969
CAGE:0AHK0
============= Composition/Information on Ingredients =============
Ingred Name:BASE OILS (CONTAINS TWO OR MORE OF INGREDIENTS 2 - 4)
Fraction by Wt: >90%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETRO DISTILS, HYDROTREATED (SEV) HEAVY
PARAFFINIC; (DISTILS (PETRO), HYDROTREATED HEAVY PARAFFINIC)
CAS:64742-54-7
RTECS #:PY8035501
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETRO DISTIL, SOLVENT DEWAXED, HEAVY
PARAFFINIC (SEV SOLV-REFINING &/OR HYDROTREATMENT); (DISTILS (ING
4)
CAS:64742-65-0
RTECS #:PY8038501
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 3:(PETROLEUM), SOLVENT-DEWAXED HEAVY PARAFFINIC)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETRO DISTILS, HYDROTREATED (SEV) LIGHT
NAPHTHENIC; (DISTILLATES (PETRO), HYDROTREATED LIGHT NAPHTHENIC)
CAS:64742-53-6
RTECS #:PY8036001
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:2-PROPENOIC ACID, 2-METHYL-, DODECYL ESTER, POLYMER
W/METHYL 2-METHYL-2-PROPENOATE & TETRADECYL 2-METHYL-2-PROPENOATE
CAS:68171-50-6
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 0.06%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPDAT:&/OR SEVERELY HYDROTREATED. CHRONIC MOUSE SKIN
PAINTING STUDIES OF SIMILAR OILS SHOWED NO EVID OF CARCIN EFTS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:WATER & CALL MD, HOSPITAL EMERGENCY ROOM OR
POISON CONTROL CENTER FOR ASSISTANCE. DO NOT INDUCE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:VOMITING OR GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:NOTIFY CHEMTREC (800)424-9300. ADSORB OF FIRE
RETARDANT TREATED SAWDUST, DIATOMACEOUS EARTH, ETC. (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:SHOVEL UP & DISPOSE OF AT APPROPRIATE WASTE DISPOSAL
FACILITY I/A/W CURRENT APPLICABLE LAWS & REGS, & (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:PRODUCT CHARACTERISTICS AT TIME OF DISPOSAL.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:RECYCLING FACILITY/CAN BE DISP OF AT ANY
GOVT APPRVD WASTE DISP FACILITY. USE OF THESE METHS IS (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:SUBJECT TO USER COMPLIANCE W/APPLIC LAWS & REGS &
CONSIDERATION OF PROD CHARACTS AT TIME OF DISP. UNUSED (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:PROD, IN MFR'S OPINION, IS NOT SPECIFICALLY LISTED
BY EPA AS HAZ WASTE (40 CFR, PART 261D); DOES NOT (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:EXHIBIT HAZ CHARACTS OF IGNITABILITY,
CORROSIVITY/REACTIVITY, & IS NOT FORMULATED W/CONTAMS LISTED IN
TOX(ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:CHARACT (TC) RULE AS DETERMINED BY TOX CHARACT
LEACHING PROC (TCLP). HOWEVER, USED PROD MAY BE REGULATED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SLIGHT SKIN IRRIT. ACUTE:ORAL TOX
(RATS)/DERMAL TOX (RABBITS):SLIGHTLY TOXIC - BASED ON TESTING OF
SIMILAR PRODS &/OR COMPONENTS. EYE IRRIT (RABBITS):EXPECTED TO BE
NON-IRRITATING - BASED ON TESTING O F SIMILAR PRODS &/OR
COMPONENTS. SKIN IRRIT (RABBITS):MAY CAUSE SLIGHT IRRIT ON
PRLNG/RPTD CONT - BASED(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:ON TESTING OF SIMILAR PRODS &/OR
COMPONENTS. CHRONIC:SEVERELY SOLV REFINED & SEVERELY HYDROTREATED
MINERAL BASE OILS HAVE BEEN TESTED AT MOBIL ENVIRON & HLTH SCIENCES
LAB BY DERMAL APPLICATIO N TO RATS 5 DAY/WK FOR 90 DAYS AT
DOSESSIGNIFICANTLY HIGHER THAN THOSE EXPECTED DURING NORMAL INDUS
EXPOS. (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER FOR AT LST 15 MINS. SKIN:WASH CONT AREAS
W/SOAP & WATER. HIGH PRESS ACCIDENTAL INJECTION THRU SKIN REQS
IMMED MED ATTN FOR POSS INCISION, IRRIGATION &/OR DEBRIDEMENT.
INHAL:REMOVE FR OM FURTHER EXPOS. IF UNCON OCCURS, SEEKIMMED MED
ASSISTANCE & CALL MD. IF BRTHG HAS STOPPED, USE MOUTH TO MOUTH
RESUSCITATION. INGEST:IF >1/2 LITER (PINT) INGESTED, IMMED GIVE 1-2
GLASSES OF (ING 9)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>330F,>166C
Lower Limits:0.6%
Upper Limits:7%
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL & WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
WATER/FOAM MAY CAUSE FROTHING. USE WATER TO KEEP FIRE EXPOS CNTNRS
COOL. WATER SPRAY MAY BE USED TO(SUPDAT)
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:REPORT SPILLS AS REQD TO APPROP AUTHS. U.S.
COAST GUARD REGS REQ IMMED REPORTING OF SPILLS THAT COULD REACH ANY
WATERWAY INCL INTERMITTENT DRY CREEKS. REPORT SPILL TO COAST GUARD
TOLL FREE NUMBER (800 )424-8802. IN CASE OF ACCIDENT/ROAD SPILL
(ING 11)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS REQUIRED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NO SPECIAL REQUIREMENTS UNDER ORDINARY
CONDITIONS OF USE & W/ADEQUATE VENTILATION.
Ventilation:USE IN WELL VENTILATED AREAS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . NO SPECIAL EQUIPMENT REQUIRED.
Work Hygienic Practices:GOOD PERSONAL HYGIENE PRACTICES SHOULD ALWAYS
BE FOLLOWED.
Supplemental Safety and Health
FIRE FIGHT PROC:FLUSH SPILLS AWAY FROM EXPOS. PVNT RUNOFF FROM FIRE
CONTROL/DILUTION FROM ENTERING STREAMS/DRINKING WATER SUPPLY. EFTS
OF OVEREXP:EXTENSIVE EVALS INCL MICROSCOPIC EXAM OF INTERNAL ORGS
& CLINICAL CHEMISTRY OF BODY FLUIDS, SHOWED NO ADVERSE EFTS. BASE
OILS IN THIS PROD ARE SEVERELY SOLV REFINED (ING 8)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>600F,>316C
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID; MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS . PROD
IS SUITABLE FOR BURNING IN ENCLSD, CONTROLLED BURNER FOR FUEL
VALUE/DISP BY SUPERVISED INCIN. SUCH BURNING MAY BE LTD PURSUANT TO
RCRA. IN ADDN, P ROD IS SUITABLE FOR PROCESSING BY APPRVD (ING 14)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SODIUM SILICOFLUORIDE-SODIUM FLUOSILICATE
CAGE:STINN
CAGE:0HF19
CAGE:STINN
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM SILICOFLUORIDE
CAS:16893-85-9
RTECS #:VV8410000
Other REC Limits:NONE SPECIFIED
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:125MG/KG LD 50 ORAL RAT
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE NOTE;IRRITATION OF EYES,SKIN AND
RESPIRATORY TRACT POSSIBLE.
Explanation of Carcinogenicity:DATA PER MGF MSDS.
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:NONE EXPECTED.
======================= First Aid Measures =======================
First Aid:EYES AND SKIN:FLUSH WITH LARGE AMOUNT OF WATER FOR ABOUT
15-20 MINUTES;SEEK MEDICAL ATTENTION IMMEDIATELY.INHALATION:REMOVE
TO FRESH AIR;CALL A PHYSICIAN.INGESTION:SEEK MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NOT FLAMMABLE ;USE WATER FOG, CARBON DIOXIDE, FOAM,
OR DRY CHEMICAL IF APPLICABLE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE NOTED
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;SWEEP UP OR
VACUUM AND COLLECT FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA.KEEP CONTAINER CLOSED WHEN NOT IN USE. AVOID CREATING DUSTY
SITUATION.
Other Precautions:WASH THOROUGHLY AFTER EACH USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR DUST/MIST
IF ABOVE PEL/TLV.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:PROTECTIVE CLOTHINGS.EYE-WASH
FACILITIES,SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST/DUST.WASH THOROUGHLY AFTER EACH USE;DO NOT
EAT,DRINK,SMOKE.
Supplemental Safety and Health
AVOID BLOWING MATERIAL INTO AIR;DO NOT BREATHE DUST/MIST.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.7
Solubility in Water:SLIGHT
Appearance and Odor:WHITE ODORLESS CRYSTALLINE POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NONE NOTED
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES;DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:21227 NICKEL CADMIUM AIRCRAFT BATTERY
CAGE:09052
CAGE:09052
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL OXIDE
CAS:1313-99-1
RTECS #:QR8400000
Fraction by Wt: 18%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3 AS NI
ACGIH TLV:1 MG/M3 AS NI
Ingred Name:ELECTROLYTE SOLUTION (30% POTASSIUM HYDROXIDE) (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 19%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CADMIUM OXIDE (SARA 302/313) (CERCLA)
CAS:1306-19-0
RTECS #:EV1925000
Fraction by Wt: 13%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 MG (CD)/M3 DUST
ACGIH TLV:0.01 MG(CD)/M3; 9495
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME; 9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NYLON (PP) (CASE)
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:CONTACT WITH ELECTROLYTE MAY
CAUSE SKIN & EYE IRRITATION OR BURNS;PERMANEANT EYE
DAMAGE/BLINDNESS.INGESTION OF ELECTROLYTE MAY CAUSE TISSUE DAMAGE
TO THROAT & GI TRACT;INTESTINAL DISORDERS.INHAL ATION MAY CAUSE
RESPIRATORY TRACT IRRITATION.CHRONIC:PROLONGED/REPEATED EXPOSURE
MAY CAUSE RESPIRATORY/KIDNEY DAMAGE.
Explanation of Carcinogenicity:CONTAINS CADMIUM AND NICKEL AND THEIR
COMPOUNDS WHICH ARE LISTED BY NTP AND IARC AND REGULATED BY OSHA AS
A CARCINOGEN.
Effects of Overexposure:INHALED: COUGHING, SNEEZING, WHEEZING,
SHORTNESS OF BREATH, CHILLS, WEAKNESS, COUGHING, CHEST PAINS. SKIN:
REDNESS, ITCHING, DISCOMFORT. INGESTED: NAUSEA, VOMITING, DIARRHEA,
ABDOMINAL CRAMPS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
DLA-HMIS: RESPIRATORY SYSTEM DISORDERS, PROSTATE DISORDERS, LIVER
AND KIDNEY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION-REMOVE TO FRESH AIR.GIVE ARTIFICIAL RESPIRATION IF
NOT BREATHING.GET MEDICAL ATTENTION.EYE-FLUSH WITH WATER FOR 15
MINUTES.GET MEDICAL ATTENTION.SKIN-FLUSH WITH WATER.REMOVE
CONTAMINATED CL OTHING.GET MEDICAL ATTENTION.INGESTION-DO NOT
INDUCE VOMITING.IF CONSCIOUS,GIVE WATER TO DILUTE.GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, SAND.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING. DISCONNECT OR CUT ALL CABLES TO & FROM
BATTERY.
Unusual Fire/Explosion Hazard:ELECTROLYTE IS CORROSIVE TO BODY TISSUES;
IT MAY REACT WITH MANY ORGANIC COMPOUNDS, ACTIVE METALS. CADMIUM
FUMES MAY BE RELEASED WHEN BATTERY SUNJECTED TO FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROPER PROTECTIVE CLOTHING/EQUIPMENT.
CONTAIN SPILL. FLUSH WITH WATER AND NEUTRALIZE WITH DILUTE CITRIC
ACID SOLUTION.
Neutralizing Agent:DILUTE CITRIC ACID SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA.
Other Precautions:DO TRANSPORT UNLESS VENT CAP IS IN PLACE. WHEN
REMOVING BATTERY, VISUALLY INSPECT FOR LEAKAGE PRIOR TO HANDLING.
IF LEAKAGE HAS OCCURRED, FOLLOW SPILL/RELEASE PROCEDURES. BATTERY
MAY CONTAIN HIGH ELEC TRICAL CHARGE, AVOID SHORTS/MISUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF EMERGENCY OCCURS; USE
NIOSH/MSHA APPROVED RESPIRATOR. USE IN ACCORDANCE WITH 29 CFR
1910.134 AND THE RESPIRATOR MANUFACTURER'S RECOMMENDATIONS.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW PEL/TLV.
Other Protective Equipment:WEAR COVERALLS WHEN HANDLING. DLA-HMIS:EYE
WASH STATION & SAFETY SHOWER AVAILABLE.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
Spec Gravity:1.2-ELECTROLYTE
Solubility in Water:COMPLETE-ELECTROLYTE
Appearance and Odor:BATTERY; 0.94 BY 2.17 BY 4.090 INCHES; 5 AMP/HOUR;
FILLING PLUG OPENINGS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ELECTROLYTE-ALUMINUM, ZINC, TIN, OTHER ACTIVE METALS, CHLORINATED &
AROMATIC HYDROCARBONS, TRICHLORETHYLENE.
Stability Condition to Avoid:DO NOT ADD SULFURIC ACID TO BATTERY!! KEEP
AWAY FROM INCOMPATIBLE MATERIALS. ENSURE PROPER VENTING.
Hazardous Decomposition Products:NICKEL OXIDE, CADMIUM, CADMIUM OXIDE,
POTASSIUM HYDROXIDE. HYDROGEN GAS FORMED DURING NORMAL OPERATIONS
OF BATTERY.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:THE BATTERY IS A HAZARDOUS WASTE UNDER RCRA. IT
MAY BE RETURNED TO SAFT FOR RECYCLING. BATTERY IS TCLP TOXIC.
BATTERY AND ELECTROLYTE SOLUTION ARE CORROSIVE. IF NOT RECYLCED,
MUST BE DISPOSED OF IN AC CORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATION.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PHOSPHORIC ACID (70-85%)
CAGE:0TYC8
CAGE:0TYC8
CAGE:91976
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID (SARA 313) (CERCLA) (CONTAINS INGREDIENTS
3-5). LD50: (ORAL, RAT) 75%: 4400 MG/KG; 85%: 4200 (ING 2)
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: 70-85%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 3 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ING 1: MG/KG; 85%: 3500 MG/KG.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ARSENIC (SARA 313) (CERCLA) % WT: 3 PPM
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:0.01 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CADMIUM (SARA 313) (CERCLA) % WT: 2 PPM
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: <0.1%
OSHA PEL:0.2 MG/M3 DUST
ACGIH TLV:0.01 MG/M3 DUST
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:LEAD (SARA 313) (CERCLA) % WT: 0.5 PPM
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:0.15 MG/M3 DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: ESOPHAGEAL BURNS, PERFORATIONS OR STRICTURES MAY
OCCUR. CAREFUL GASTRIC LAVAGE W/AN ENDOTRACHEAL TUBE IN (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: PLACE SHOULD BE CONSIDERED. OBSERVATION MAY BE
WARRANTED. TREATMENT IS CONTROLLED REMOVAL OF EXPOSURE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: FOLLOWED BY SYMPTOMATIC & SUPPORTIVE CARE.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: DISCHARGED TO TREATMENT I/A/W FEDERAL,
STATE AND LOCAL REGULATORY PROCEDURES.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR PRECS: FREEZING POINT. CONTACT W/REACTIVE METALS
IE MILD STEEL & ALUMINUM MAY GENERATE HYDROGEN THAT (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: MAY FORM AN EXPLOSIVE MIXTURE IN STORAGE VESSELS.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS:DISCONNECT. WHEN UNLOADING BULK VEHICLES, PERS
SHOULD WEAR ANSI APPRVD CHEM GOGGS & RUB OR NEOPRENE (ING 14)
RTECS #:9999999ZZ
PRIOR TO ENERGIZING UNLOADING SYS. CARE SHOULD BE TAKEN (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:TO AVOID ACID CNTCT WHEN DISCONNECTING LINES/HOSES
AFTER UNLOADING. FOR BULK STORAGE TYPE 316L STAINLESS (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: IS RECOMD. GLASS, POLYETHYLENE & FRP (DEPENDING ON
RESIN USED) ARE SATISFACTORY. STEEL, ALUMINUM & TYPE (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: 304 STAINLESS ARE NOT RECOMD BECAUSE OF RAPID OR
POTNTL CORR. VESSELS SHOULD BE VENTED & OPERATED AT (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:AMBIENT CNDTNS. MAINT HEAT (HOT WATER PREF) MAY BE
USED TO PVNT FREEZING. DIKE AREA AROUND STORAGE TANK (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: W/SUFFICIENT VOLUME TO HOLD ENTIRE TANK CONTENTS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: OF EXPOSURE. RUBBER OR NEOPRENE FOOTWEAR.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES SENSORY IRRIT. CNTCT OF TISS
W/PHOSPHORIC ACID ALSO CUASES CORR BURNS. THE MIST CAUSES MILD
IRRIT OF EYES, THROAT & SKIN. PHOSPHORIC ACID HAS LOW ACUTE ORAL &
MOD DERMAL TOX. SLIGHTLY TOX WHEN INHALED. CHRONIC: SLIGHTLY TOX
W/RPTD INHAL OR INGEST FOR CONCS 70-80%. LEAD APPEARS ON THE NAVY
LIST (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OF OCCUP CHEM REPRO HAZS. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ
LIST INFO & SAFE HNDLG & EXPOS INFO .
Medical Cond Aggravated by Exposure:NO INFORMATION WAS FOUND OR IS
AVAILABLE.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/LG AMTS OF WATER FOR AT LEAST 15 MIN
LIFTING UPPER & LOWER LIDS INTERMITTENTLY. SEE MD OR
OPHTHALMOLOGIST. SKIN: IMMED REMOVE CONTAMD CLTHG & WASH W/SOAP &
WATER. IF IRRIT PERSISTS , OBTAIN MED ATTN. INHAL: REMOVE TO FRESH
AIR. IF BRTHG DISCOMFORT OCCURS, CALL MD. INGEST: RINSE MOUTH
W/WATER. DO NOT INDUCE VOMIT. SEE MD IMMED. NOTES TO MD: PHOSPHORIC
ACID AT CONCS OF (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE WATER SPRAY TO KEEP FIRE EXPOSED CONTAINERS
COOL. EXTINGUISH FIRE USING AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . NOT COMBUSTIBLE. EVOLVES HYDROGEN ON CONTACT WITH MOST
METALS.
Unusual Fire/Explosion Hazard:NOT APPLICABLE. HAZARDOUS DECOMPOSITION
PRODUCTS: OXIDES OF PHOSPHORUS.
================== Accidental Release Measures ==================
Spill Release Procedures:APPROACH RELEASE FROM UPWIND. STOP OR CONTROL
LEAK USING SPECIAL PROTECTIVE CLOTHING AND NIOSH APPROVED POSITIVE
PRESSURE SELF-CONTAINED BREATHING APPARATUS. CONTROL RUNOFF AND
ISOLATE DISCHARGED MATE RIAL FOR PROPER DISPOSAL.
Neutralizing Agent:SODA ASH AND LIME FOR MATERIAL THAT CANNOT BE
SALVAGED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY WELL VENTD AREA
AWAY FROM ALKALIES & MOST METALS. DO NOT STORE IN DIRECT SUNLIGHT.
DO NOT DOUBLE STACK. STORE ABOUT (ING 11)
Other Precautions:TRANSFER PROD FROM DRUMS TO PROCESS IN CLSD SYS
(HERMITIZED) & IF NOT POSS USE EFTIVE LOC EXHST VENT. EMPTY DRUM AS
THOROUGHLY AS POSS TO FACILITATE DISPOSAL. FOR BULK TRANSFER, PURGE
LINES W/NITROGEN TO REMOVE RESIDUAL LIQ BEFORE (ING 13)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED ACID/GAS CARTRIDGE OR
CANISTER WITH FULL FACEPIECE UNLESS BREAK-THROUGH OCCURS THEN USE
NIOSH APPROVED AIRLINE SUPPLIED OR SELF CONTAINED BREATHING
APPARATUS WITH FULL FACEPIECE.
Ventilation:PROVIDE MECH LOC EXHST VENT TO PVNT RELS OF MIST INTO WORK
AREA. IF RELS IS EXPECTED USE NIOSH APPRVD RESP PROT.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
RUBBER OR NEOPRENE APRONS OR FULL PROT CLTHG DEPENDING ON DEGREE
(ING 21)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MP: 1F,-17.5C (75%); 89.6F,32C (85%). PH (AS IS): ABOUT 1.5; PH (1%
SOLN): 1.7. % VOLAT: NON-VOLAT. HAZ DECOMP PRODS: MIXS. REACTS
VIOLENTLY W/STRONG BASES. FIRST AID PROC: 70-85% HAS LOW ORAL TOX
BUT MAY BE CORR TO EYES, SKIN & MUC MEMBS.CONSIDERATION SHOULD BE
GIVEN TO CAREFUL ENDOSCOPY AS STOMACH OR (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>266F,>130C
Melt/Freeze Pt:M.P/F.P Text:SUPDAT
Vapor Pres:8-2 @ 25C
Vapor Density:NON VOLAT
Spec Gravity:1.5-1.7(H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:NON-VOLATILE
Solubility in Water:INFINITE BY WT
Appearance and Odor:CLEAR, COLORLESS LIQUID; NO ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SEE ABOVE. MILD STEEL & ALUMINUM MAY REACT TO PRDCE HYDROGEN GAS THAT
CAN PRDCE AN EXPLOSIVE IN CONFINED VESSELS.
Stability Condition to Avoid:CONTACT WITH ALKALINE MATERIALS. REACTIVE
METALS.
Hazardous Decomposition Products:OXIDES OF PHOSPHORUS. CONTACT
W/REACTIVE METALS (EG MILD STEEL & ALUMINUM) MAY PRDCE FLAM/EXPLO
HYDROGEN - AIR (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:IF PHOSPHORIC ACID IS TO BE USED IN WATER RXNS,
TRIPLE RINSE DRUM W/WATER & PUT INTO PROCESS (REDUCE WATER VOL
EQUAL TO RINSING). SODA ASH & LIME MAY BE USED AS NEUTRALIZING
AGENTS FOR MATL THAT CANNO T BE SALVAGED. NEUTRALIZED LIQ MAY BE
(ING 10)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:OXYGEN CELL, 66
CAGE:DO808
CAGE:51906
CAGE:DO808
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE; (POTASSIUM HYDROXIDE, SOLUTION) (KOH)
(CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 20%
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SEVERE BURNS, PERMANENT EYE
DAMAGE, SEVERE IRRITATION, ULCERATION OF MUCOUS MEMBRANES. CHRONIC:
LUNG DAMAGE. TARGET ORGANS: EYES, SKIN, RESPIRATORY SYSTEM, LUNGS,
GASTROINTESTINAL TRACT.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DERMATITIS.
======================= First Aid Measures =======================
First Aid:INGESTION: CALL MD. DO NOT INDUCE VOMITING. GIVE LARGE
AMOUNTS OF WATER. FOLLOW WITH DILUTED VINEGAR OR FRUIT JUICE.
INHALATION: PROVIDE FRESH AIR OR OXYGEN. EYES: IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. SKIN: IMMEDIATELY FLUSH WITH
WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE CLOTHING, ABSORB
SPILLED MATERIAL WITH ABSORBENT MATERIALS SUITABLE FOR CORROSIVES
(PH=13). FLUSH AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE SAFE CHEMICAL HANDLING PROCEDURES.
WASH HANDS AFTER HANDLING. SUITABLE FOR GENERAL STORAGE. ISOLATE
FROM INCOMPATIBLES.
Other Precautions:WARNING: LEAKING CELL MAY CAUSE CHEMICAL BURNS. DO
NOT GET IN EYES, ON SKIN, OR ON CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:VENTILATION RECOMMENDED.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . APRON RECOMMENDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:356F,180C
Melt/Freeze Pt:M.P/F.P Text:680F,360C
Vapor Pres:0.05
Vapor Density:2.0
Spec Gravity:1.5
Evaporation Rate & Reference:0.01
Solubility in Water:APPRECIABLE
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZERS, CHEMICALLY ACTIVE METALS, SULFURIC
ACID, NITRIC ACID, POLYMERIZATION CATALYSTS.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:HYDROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL REGULATIONS. SENSOR CONTAINS LEAD WHICH
EXCEEDS FEDERAL TTLC STANDARDS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:URALITE 3124 PART B
Kit Part:Y
Preparer's Name:DEIRDRE S CRUTCHFIELD
CAGE:6P700
CAGE:6P700
CAGE:01490
============= Composition/Information on Ingredients =============
Ingred Name:POLYOL
Fraction by Wt: >99%
Ingred Name:MERCURY, (NEODECANOATO-O) PHENYL *95-1*
CAS:26545-49-3
Fraction by Wt: <1%
Ingred Name:VOLATILE ORGANIC CONTENT: 19 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 60 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT CONTAINS A
MERCURY-CONTAINING CATALYST. EXPOSURE TO MERCURY MAY CAUSE DAMAGE
TO KIDNEYS, INFLAMMATION OF MOUTH, BIRTH DEFECTS &/MISCARRIAGE.
CHRONIC OVEREXPOSURE TO MERCURY MAY CAUSE DAMA GE TO NEUROMUSCULAR
SYSTEM. SYMPTOMS INCLUDE TREMORS, NERVOUS IRRITABILITY & MEMORY
LOSS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:THIS PRODUCT CONTAINS A MERCURY-CONTAINING
CATALYST. EXPOSURE TO MERCURY MAY CAUSE DAMAGE TO KIDNEYS,
INFLAMMATION OF MOUTH, BIRTH DEFECTS &/MISCARRIAGE. CHRONIC
OVEREXPOSURE TO MERCURY MAY CAUSE DAMA GE TO NEUROMUSCULAR SYSTEM.
SYMPTOMS INCLUDE TREMORS, NERVOUS IRRITABILITY & MEMORY LOSS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF LUKEWARM WATER FOR 15
MINS. SKIN: IMMEDIATELY WASH W/SOAP & PLENTY OF WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. INGESTION: INDUCE
VOMITING ONLY UPON ADVICE OF A PHYSICIAN. OBTAINMEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:275F
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2,
Fire Fighting Procedures:USE WATER TO KEEP CONTAINERS COOL. WEAR A SELF
CONTAINED POSITIVE PRESSURE BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN W/SUITABLE DIKING MATERIAL. WEAR
PROTECTIVE EQUIPMENT & IMPERMEABLE BOOTS. VENTILATE AREA
THOROUGHLY. EVACUATE AREA. ABSORB W/SAWDUST/SAND/OTHER ABSORBENT &
PLACE INTO OPEN-TOPPED CONTAINER &COVER LOOSELY. STORE 12 HRS
BEFORE SEALING.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
IGNITION SOURCES. STORE IN A COOL, WELL VENTILATED AREA IN TIGHTLY
CLOSED CONTAINER.
Other Precautions:AVOID MOISTURE CONTAMINATION, CONTACT
W/EYES/SKIN/CLOTHING, BREATHING VAPOR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED ORGANIC VAPOR/MIST
RESPIRATOR IF VAPORS/MISTS ARE GENERATED.
Ventilation:LOCAL EXHAUST & MECHANICAL VENTILATION IF HANDLED INDOORS
TO KEEP AIRBORNE LEVELS <OSHA RECOMMENDED EXPOSURE LIMITS.
Other Protective Equipment:IMPERVIOUS PROTECTIVE CLOTHING, BOOTS,
WORN.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
ORAL LD50 INFORMATION IS FOR PHENYLMERCURIC NEODECANOATE.
================== Physical/Chemical Properties ==================
Vapor Pres:<1
pH:6-7
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR YELLOW LIQUID W/A SWEET ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, NITRIC ACID, OXYGEN, HYDROGEN PEROXIDE.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:CO & CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED INCINERATION/BURIED LANDFILL DISPOSAL
IAW/FEDERAL, STATE & LOCAL REGULATIONS. RCRA WASTE CODE: D009.
======================================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LEAD-ACID BATTERY
CAGE:60038
CAGE:20038
CAGE:60038
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 60%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY (SARA III)
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG SB/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC (SARA III)
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3 (AS)
ACGIH TLV:0.01,A1 MG/M3; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM, METAL
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:POLYPROPYLENE
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYSTYRENE
CAS:9003-53-6
RTECS #:WL6475000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:STYRENE ACRYLONITRILE
CAS:9003-54-7
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:ACRYLONITRILE BUTADIENE STYRENE
CAS:9003-56-9
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:STYRENE BUTADIENE
CAS:9003-55-8
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYVINYLCHLORIDE
CAS:9002-86-2
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYCARBONATE
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:HARD RUBBER
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: BURNS, SEVERE IRRITATION OF
SKIN, EYES, MOUTH, THROAT, ESOPHAGUS AND STOMACH; INFLAMMATION OF
BRONCHIAL MEMBRANES. CHRONIC: EROSION OF TEETH, INFLAMMATION OF
NOSE, THROAT AND BRONCHIAL TUBES.
Explanation of Carcinogenicity:LEAD IS LISTED BY IARC AND NTP. ARSENIC
IS LISTED BY IARC, NTP AND OSHA.
Effects of Overexposure:COUGH, INCREASED RESPIRATORY RATE, STINGING,
BURNING SENSATION ON SKIN, EYE IRRITATION, DISCOLORATION OF TEETH,
DAMAGE TO CORNEA. LEAD COMPOUNDS: SYMPTOMS OF TOXICITY INCLUDE
HEADACHE, FATIGUE, ABDOMI NAL PAIN, LOSS OF APPETITE, SLEEP
DISTURBANCE.
Medical Cond Aggravated by Exposure:EXPOSURE TO MISTS MAY CAUSE LUNG
DAMAGE AND AGGRAVATE PULMONARY CONDITIONS. CONTACT WITH SKIN MAY
AGGRAVATE SKIN DISEASES SUCH AS ECZEMA AND CONTACT DERMATITIS. LEAD
CAN AGGRAVATE KIDNEY DISEASES.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH WITH PLENTY OF WATER. SEE DOCTOR
IMMEDIATELY. REMOVE CONTAMINATED CLOTHING AND SHOES. INHALATION:
REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED. SEE DOCTOR.
INGESTION: DO NOT INDUCE VOMITING. GIVE MILK OR WATER, FOLLOWED BY
2 OUNCES OF MILK OF MAGNESIA (NO CARBONATES). SEE DOCTOR
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:4.1(HYDROGN)
Upper Limits:74(HYDROGEN)
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, HALOGEN.
Fire Fighting Procedures:IF BATTERIES ARE ON CHARGE, SHUT OFF POWER.
USE POSITIVE PRESSURE SCBA. WATER APPLIED TO ACID GENERATES HEAT
AND CAUSES SPATTER. WEAR ACID-RESISTANT CLOTHING.
Unusual Fire/Explosion Hazard:FLAMMABLE AND EXPLOSIVE HYDROGEN GAS IS
PRODUCED DURING CHARGING AND OPERATION. REMOVE ALL IGNITION
SOURCES. VENTILATE AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPIATE PROTECTIVE EQUIPMENT. DILUTE
CAUTIOUSLY WITH WATER. CAREFULLY COVER WITH SODA ASH OR QUICKLIME.
SCOOP UP AND PLACE IN APPROPIATE DISPOSAL CONTAINER. FLUSH AREA
WITH LARGE AMOUNTS OF WA TER. DO NOT ALLOW UNNEUTRALIZED ACID
TOSEWER.
Neutralizing Agent:SODA ASH (SODIUM CARBONATE), BAKING SODA OR
QUICKLIME (CALCIUM OXIDE).
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE. STORE AWAY
FROM FLAMES, IGNITION SOURCES, COMBUSTIBLE AND ORGANIC MATERIALS.
AVOID PROLONGED OVERCHARGING.
Other Precautions:DO NOT CARRY BATTERY BY TERMINALS. DO NOT DROP
BATTERY, PUNCTURE OR ATTEMPT TO OPEN BATTERY CASE. KEEP TERMINALS
COVERED IN PLASTIC CASE. AVOID SHORTING BATTERIES. STORE AND HANDLE
ONLY IN AREAS WITHADEQUATE WATER SUPPLY. STORE UNDER ROOF.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
CARTRIDGE RESPIRATOR FOR ACIDS OR FULL FACE MASK AS APPROPIATE FOR
EXPOSURE OF CONCERN WHEN TLV IS EXCEEDED.
Ventilation:GENERAL (MECHANICAL) VENTILATION. LOCAL EXHAUST IN CONFINED
AREAS. USE ACID RESISTANT COMPONENTS.
Other Protective Equipment:RUBBER APRON AND BOOTS IF CONTACT IS
EXPECTED. EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
THIS MSDS WAS PREPARED FOR SULFURIC ACID EXPOSURE. HAZARDOUS EXPOSURE
TO LEAD COMPOUNDS CAN OCCUR ONLY WHEN PRODUCT IS HEATED, OXIDIZED
OR OTHERWISE PROCESSED OR DAMAGED TO CREATE DUST, VAPOR OR FUME.
IN AREAS WHERE SULFURIC ACID IN CONCENTRATIONS GREATER THAN 1%,
EMERGENCY EYEWASH STATIONS AND SHOWERS AVAILABILITY.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:=95.C, 203.F
Vapor Pres:10
Vapor Density:>1
Spec Gravity:1.23-1.35
pH:ACIDIC
Evaporation Rate & Reference:<1 (BUTYL ACETATE = 1)
Solubility in Water:COMPLETE
Appearance and Odor:ELECTROLYTE IN BATTERY IS CLEAR LIQUID WITH SHARP,
PENETRATING, PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLES, ORGANIC MATERIAL, STRONG REDUCING AGENTS, METALS, SULFUR
TRIOXIDE GAS, STRONG OXIDIZERS, WATER.
Stability Condition to Avoid:AVOID SHORTING, USE ONLY APPROVED CHARGING
METHODS. AVOID PROLONGED OVERCHARGING AND SOURCES OF IGNITION.
Hazardous Decomposition Products:SULFURIC ACID FUMES, SULFUR DIOXIDE,
SULFUR TRIOXIDE, CARBON MONOXIDE, HYDROGEN GAS, SULFUR DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGUALTIONS. SPEND BATTERIES: SEND TO SECONDARY LEAD
SMELTER FOR RECYCLING.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:49-08-0500 TYPE A GREASE
CAGE:40817
CAGE:40817
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBONS, SOLVENT DEWAXED RESIDUAL OIL
(PETROLEUM) *95-4*
CAS:64742-62-7
Fraction by Wt: 20%
Ingred Name:PETROLEUM OIL, HYDROTREATED HEAVY NAPHTHENIC DISTILLATE
(PETROLEUM), PETROLEUM DISTILLATES, MINERAL OIL (SEVERE)
CAS:64742-52-5
RTECS #:PY8035001
Fraction by Wt: 35%
Ingred Name:RESIDUAL OILS (PETROLEUM), HYDROTREATED *95-4*
CAS:64742-57-0
Fraction by Wt: 20%
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: PROLONG/REPEATED SKIN CONTACT
TENS TO REMOVE SKIN OILS & MAY CAUSE IRRITATION. INHALATION: MAY
CAUSE MUCOUS MEMBRANES IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER. SKIN: REMOVE EXCESS,
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION:
GIVE WATER. INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:400F BASE FLUID
Lower Limits:1
Upper Limits:6
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, SAND/EARTH, WATERFOG.
Fire Fighting Procedures:CAREFUL TO PREVENT FROTHING. USE SELF
CONTAINED BREATHING APPARATUS W/FACE SHIELD IN ENCLOSED AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. RECOVER FREE
PRODUCT & TRANSFER TO NEW CONTAINER. ADD ABSORBENT TO AREA.
SWEEP/SCRAPE UP.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. DON'T
STORE/MIX W/STRONG OXIDIZING AGENTS. AVOID OPEN FLAMES & HEAT.
Other Precautions:AVOID PROLONGED/REPEATED CONTACT W/SKIN & EYES &
INHALATION OF FUMES, MISTS/VAPORS. DON'T INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR IF FUMING/MISTING.
Ventilation:LOCAL EXHAUST TO CAPTURE HOT FLAMES/VAPORS. MECHANICAL IF
FUMING/MISTING.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DON'T WEAR CONTAMINATED CLOTHING. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>600F
Vapor Pres:<0.01
Vapor Density:>10
Spec Gravity:0.91
Evaporation Rate & Reference:(N-BU AC=1): <0.01
Solubility in Water:COMPLETE
Appearance and Odor:AMBER COLORED GREASE W/A MILD PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:EXCESSIVE HEAT & OPEN FLAME
Hazardous Decomposition Products:OXYGENATES & OXIDES OF CALCIUM, SODIUM
& CARBON DURNING BURNING. OXIDES OF CARBON ON INCOMPLETE
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:EPOXY MOUNT RESIN PART A, 145-10020
Kit Part:Y
Preparer's Name:EDDIE PADILLA
CAGE:0WVC6
CAGE:0WVC6
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A-EPICHLOROHYDRIN COPOLYMER; (BISPHENOL A
DIGLYCIDYL (ETHER RESIN))
CAS:25068-38-6
RTECS #:SL6475000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALKYL GLYCIDYL ETHERS
CAS:686909-97-2
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:NO REMARKABLE EFFECTS.
INGESTION/SKIN:MODERATELY TOXIC. EYE:IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. INGEST:IF CONSCIOUS, GIVE LARGE
QUANTITIES OF WATER. CALL MD. SKIN:WASH W/SOAP & WATER. EYE:FLUSH
W/WATER FOR AT LEAST 30 MINUTES. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:375F,191C
Extinguishing Media:CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB INTO SAND OR OTHER ABSORBENT MATERIAL.
SCOOP INTO CLOSABLE CONTAINER FOR DISPOSAL OF LARGE QUANTITIES.
CLEAN AREA W/WATER OR APPROPRIATE SOLVENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING.
AVOID BREATHING OF VAPORS WHEN OPENING CONTAINER.
Other Precautions:ADEQUATE VENTILATION; STORE IN CLOSED CONTAINER IN A
COOL, DRY AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE NORMALLY NEEDED.
Ventilation:LOCAL:PREFERRED. MECHANICAL:ACCEPTABLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. WASH
CONTAMINATED CLOTHING. DESTROY CONTAMINATED LEATHER SHOES.
Supplemental Safety and Health
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Spec Gravity:1.16
Evaporation Rate & Reference:1
Solubility in Water:INSOLUBLE
Appearance and Odor:LOW VISCOSITY LIQUID; LITTLE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS; ACIDS.
Stability Condition to Avoid:LARGE QUANTITIES OF RESIN/CURING AGENT MIX
DUE TO EXOTHERM.
Hazardous Decomposition Products:CO, CO*2 & ALDEHYDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DECORATOR, 4448
CAGE:OUXB5
CAGE:OUXB5
============= Composition/Information on Ingredients =============
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL; (TEXANOL) VP: 0.50
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-15%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 6.400%
OSHA PEL:0.1 MG/M3 RDUST
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL) VP: 0.20
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 0.98 LBS/GAL (LB/GAL OF
SOLIDS: 1.12)
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CONTAINS SILICA WHICH WHEN DRY &
REDUCED TO DUST IS HAZARDOUS & CAN CAUSE LUNG DAMAGE (SILICOSIS).
CONTAINS SOLID MATERIALS WHEN SUBJECTED TO OPERATIONS SUCH AS
WELDING, SAWING/SANDING OF THE CURED CO ATINGS. THE RESULTANT DUST
CONSTITUTES A HAZARDOUS DUST OF THE NON-VOLATILE INGREDIENTS.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPPLEMENT, VOL 7, PG 341, 1987:GROUP 2A. NTP 6TH
ANNUAL REPORT ON (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . EYES: FLUSH EYES WITH EYE-WASH OR
WATER FOR AT LEAST 15 MINUTES. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTIO N PROMPTLY. SKIN: WIPE MATERIAL OFF & WASH CONTACTED AREA.
INGEST: DO NOT INDUCE VOMITING. GET PATIENT TO FRESH AIR & CONSULT
MD. PROMPTLY REMOVE CONTAMINATED CLOTHING & WASH BEFORE REUSE.
===================== Fire Fighting Measures =====================
Lower Limits:NONE
Extinguishing Media:WATER BORNE PAINTS WILL NOT BURN UNTIL H*2O HAS
EVAP. FOR RESIDUAL SOLIDS USE H*2O SPRAY, CO*2, DRY CHEM/UNIVERSAL
FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:MAJOR SPILLS SHOULD BE COLLECTED FOR DISPOSAL.
FOR MINOR SPILLS, REMOVE EXCESS & USE SOAP & WATER. DO NOT USE
GASOLINE OR FLAMMABLE SOLVENTS FOR CLEANING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINS WATER. PROTECT FROM FREEZING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. WHEN USING SPRAY APPLICATION A
PROPERLY FITTED NIOSH/MSHA APPROVED RESPIRATOR IS RECOMMENDED. USE
NIOSH/MSHA APPROVED DUST RESPIRATOR WHEN SANDING, WELDING OR SAWING
ANY ITEMS PAINTED W ITH THIS PRODUCT.
Ventilation:NORMAL.
Other Protective Equipment:EYE WASH.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER AFTER
USE.
Supplemental Safety and Health
EXPLAN OF CARCIN:CARCINOGENS, 1991:ANTICIPATED TO BE CARCINOGEN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>162F,>72C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.34
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:WHEN WATER IS EVAPORATED, PAINT CAN
BURN PRODUCING CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . BURY IN A LANDFILL WHERE PERMITTED AS
LOCAL REGULATIONS ALLOW.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:POTASSIUM BROMATE
CAGE:62910
CAGE:62910
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM BROMATE
CAS:7758-01-2
RTECS #:EF8725000
Fraction by Wt:
Other REC Limits:
OSHA PEL:
ACGIH TLV:
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:IRRIT TO UP RESP TRACT,COUGH &
SHORT OF BREATH.INGEST:NAUSEA,VOMIT,DIARRHEA.ABD PAIN.REDU URINE
OUTPUT.LOW
BP.METHEMOGLOBINEMIA,CONVULSION.LIVER&KIDNEDAMAGE,COMA,CYANOSIS MAY
OCCUR AS LATER SYMP TOM.DEATH MAY OCCUR FROM RENAL FAILURE W/IN 1
TO 2 WKS.EST.LETHAL DOSE 1GM.EYE:IRRIT/CORNEAL
DAMAGE.CHRONIC:LIVER/KIDNEY
Effects of Overexposure:SEE HEALTH HAZARDS(ACUTE & CHRONIC)
Medical Cond Aggravated by Exposure:PERSONS W/ PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPARED LIVER,KIDNEY OR RESPIRATORY
FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.GET MED ATT FOR ANY BREATH
DIFFICULTY.INGEST:INDUCE VOMITING IMMED.GIVE TWO GLASSES OF H*2O &
STICKING FINGER DOWN THROAT.NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSO N.CALL PHYS.SKIN:WASH EXPOSED AREA W/SOAP &
H*2O.GET MED ADVICE IF IRRIT DEVELOPS.EYE:WASH EYE W/ PLENTY OF
H*2O FOR AT LEAST 15 MIN.LIFT LOWER & UPPER EYELIDS
OCCASIONALLY.GET MED ATT IMMED.
===================== Fire Fighting Measures =====================
Flash Point:
Lower Limits:
Upper Limits:
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING & NIOSH-APPROVED
SCBA W/FULL FACEPIECE OPERATED IN PRESS DEMAND OR OTHER POS.PRESS
MODE.H*2O SPRAY KEEP FIRE EXPOS CONTR COOL.
Unusual Fire/Explosion Hazard:NOT COMBUSTIBLE IS A STRONG OXIDIZER.HEAT
OF REACTION W/ REDUC AGENT/COMBUST MAY CAUSE IGNITION.CONTACT W/
OXIDIZABLE SUBS.CAUSE EXTREME VIOLENT COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA.CLEAN UP PERSONNEL MAY REQUIRE RESP
PROTECTION FROM DUST. SPILLS: SWEEP UP & CONTAINERIZE FOR
RECLAMATION OR DISPOSAL. VACUUMING OR WET SWEEPING MAY BE USED TO
AVOID DUST DISPOSAL.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN A TIGHTLY CLOSED CONTR STORE
IN A COOL,DRY VENT AREA.PROT AGAINST PHYSICAL DAMAGE.SEPARATE FROM
COMBUSTIBLE,ORGANIC OR OTHER OXIDIZABLE MAT.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED.COND OF USE WHERE EXPOS TO DUST
IS APPARENT DUST/MIST RESP MAY BE WORN FOR EMERGENCIES A SCBA MAY
BE USED.
Ventilation:LOCAL EXHAUST WHICH CAPTURE THE CONTAM AT ITS SOURCE IS
RECOMMENDED.PREVENT DISPERSION INTO THE WORK PLACE.
Other Protective Equipment:CLEAN BODY-COVERING CLOTHING
Work Hygienic Practices:OBSERVE GOOD WORK HYGIENIC PRACTICES.
Supplemental Safety and Health
SOL IN H*2O:20C.MAT TO AVOID:PHOSPHONIUM IODINE,PHOSPHORUS,LEAD
ACETATE,SELENIUM & SULFUR.HLTH HAZ(ACUTE/CHRONIC)DAMAGE.
================== Physical/Chemical Properties ==================
HCC:D1
Boiling Pt:B.P. Text:698F, 370C
Melt/Freeze Pt:M.P/F.P Text:662F 350C
Decomp Temp:Decomp Text:
Vapor Pres:NO INFO
Vapor Density:NO INFO
Spec Gravity:3.27
pH:
Evaporation Rate & Reference:NO INFO FOUND
Solubility in Water:8G1100G H*2O AT68F
Appearance and Odor:WHITE POWDER OR GRANULES ODORLESS
Percent Volatiles by Volume:
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS,REDUCING AGENTS,ORGANIC MAT,AL,ARSENIC,CALCIUM
HYDRIDE,CARBON,COPPER,POWDER METALS,METAL SULFIDES (SEE SUP DATA)
Stability Condition to Avoid:
Hazardous Decomposition Products:EMITS OXYGEN & TOXIC FUMES OF BROMINE
WHEN HEATED TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECLAMATION MAY BE
DELIVERED TO AN APPROVED WASTE DISPOSAL FACILITY.ENSURE COMPLIANCE
W/ LOCAL,STATE & FED REGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:R-1009
CAGE:9X013
CAGE:9X013
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-3*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *96-3*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIBUTYLTIN DILAURATE, URETHANE CATALYST * 96-3 *
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: 1%
Other REC Limits:0.1 MG/CUM (SN)
OSHA PEL:0.1 MG/CUM (SN)
ACGIH TLV:0.1 MG/CUM, SN(SKIN)
Ingred Name:BENZENE (SUSPECTED HUMAN CARC BY ACGIH, IARC, ANIMAL
CARCINOGEN BY IARC, CARCINOGEN BY NTP - IARC GROUP 1) *96-3*
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 0.1%
Other REC Limits:16 MG/CUM
ACGIH TLV:0.3 MG/CUM (A2) IC
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: SUBSTANCES W/VAPOR PRESSURE OF
=>0.5 MM HG AT 219.2F.
RTECS #:9999999VO
Ingred Name:PARAFFINS & NAPHTHENES
Fraction by Wt: 70%
Ingred Name:CYCLOSILOXANES,DI-ME,POLYMERS
W/1,1,3,3-TETRA-METHYLDISILOXANE
CAS:69430-30-4
Fraction by Wt: 15%
Ingred Name:METHYL-TRIS-(METHYL ETHYL KETOXIMO) SILANE, 2-BUTANONE,
0,0',0''-(METHYLSILYLIDYNE) TRIOXIME *96-3*
CAS:22984-54-9
Fraction by Wt: 10%
Ingred Name:HEXAMETHYLDISILAXANE, SILICA REACTION PRODUCT*96-3*
CAS:68909-20-6
Fraction by Wt: 5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGESTION: SLIGHTLY TOXIC, ASPIRATION
INTO THE LUNGS MAY OCCUR, RESULTING IN LUNG INJURY. INHALATION:
IRRITATION, SEVERE OVEREXPOSURE MAY RESULT IN PERMANENT LUNG
INJURY. SKIN: MODERATE IRRITATION. EY ES: IRRITATION. BENZENE MAY
CAUSE BLOODDISORDERS, ANEMIA & LEUKEMIA. EFFECT MAY BE DELAYED IF
EXPOSURE HAS CEASED.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:NAUSEA, ABDOMINAL DISCOMFORT, VOMITING,
DIARRHEA, CNS DISTURBANCES, CONVULSIONS, DEPRESSION, COMA,
IRRITATION, NASAL DISCOMFORT, DISCHARGE, HEADACHE, GIDDINESS,
UNCONSCIOUSNESS, REDNESS, SWELLING, TEA RING, WEAKNESS, PAIN IN THE
LIMBS, PARESTHESIAS, NERVOUSNESS, ANEMIA, WEIGHT LOSS.
Medical Cond Aggravated by Exposure:EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. DON'T GIVE ANYTHING TO
DRINK. SKIN: WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
GIVE CPR/OXYGEN BY QUALIFIED PERSONNEL. EYES: FLUSH W/WATER &
CONTINUE WASHI NG FOR 15 MINS. NOTES TO PHYS: IF A SMALL AMOUNT IS
INGESTED, USE AN IPACAC TO PRODUCE VOMITING. IF VOMITING IS
INDUCED, PATIENTS HEAD & UPPER BODY MUST BE KEPT AT A LOWER LEVEL
THAN HIPS. (SEE SUPP)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:48F
Lower Limits:1
Upper Limits:6
Extinguishing Media:ALCOHOL TYPE/UNIVERSAL TYPE FOAMS FOR LARGE FIRES.
CO/DRY CHEMICALS FOR SMALL FIRES.
Fire Fighting Procedures:DON'T SPRAY A SOLID STREAM OF WATER/FOAM
DIRECTLY INTO A POOL OF HOT BURNING LIQUID, MAY CAUSE FROTHING &
INTENSIFY FIRE. USE SCBA IN AN ENCLOSED AREA.
Unusual Fire/Explosion Hazard:VAPORS TRAVEL BY AIR & IGNITE AT
LOCATIONS DISTANT FROM HANDLING POINT. IN LOW/CONFINED AREAS,
VAPORS MAY TRAVEL TO A DISTANT IGNITION SOURCE/FLASHBACK. (SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH & DON'T TURN ON ANY IGNITION SOURCE
UNTIL THE AREA IS FREE FROM EXPLOSION/FIRE HAZARDS. CONTAIN AREA &
REMOVE BY VACUUM. SMALL AREA MAY BE SOAKED UP W/ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
KEEP CONTAINER CLOSED. USE W/ADEQUATE VENTILATION.
Other Precautions:DON'T INDUCE VOMITING. CONTAINS BENZENE-CANCER
HAZARD. AVOID CONTACT W/SKIN, EYES & CLOTHING. AVOID BREATH VAPOR,
MIST/GAS. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES, ALL
HAZARD PRECAUTIONS MUS T BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED RESPIRATOR/SCBA AS NEEDED TO
MAINTAIN PERSONNEL EXPOSURE BELOW TLV.
Ventilation:MECHANICAL (GENERAL) W/LOCAL EXHAUST AS NEEDED TO MAINTAIN
EXPOSURE BELOW TLV.
Other Protective Equipment:EYE BATH & SAFETY SHOWER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRE HZRD: FLAMMABLE LIQUID, VAPOR MAY IGNITE BY STATIC SPARKS. NOTES
CONT'D: REMOVE BY GASTRIC LAVAGE USING ACTIVATED CHARCOAL. A CUFFED
ENDOTRACHEAL TUBE MAY BE USED. WHEN EVACUATION OF THE STOMACH IS
COMPLETE, 30-60 ML OF FLEETS PHOSPHO-SODA DILUTED IN WATER MAY BE
GIVEN. KEEP IN OBSERVATION FOR 24 HOURS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:258F
Vapor Pres:15
Vapor Density:0.2
Spec Gravity:0.82
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSLUCENT LIQUID W/SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING SOURCES.
Stability Condition to Avoid:OPEN FLAMES, IGNITION SOURCES.
Hazardous Decomposition Products:COMBUSTION: CO, CO2 & OXIDES OF
SILICON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:190 0752/808 6597 EKTAPRINT L TONER
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE BUTYLACRYLATE COPOLYMER
CAS:67338-64-1
Fraction by Wt: 90-95%
Other REC Limits:NONE SPECIFIED BY M.
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED BY M.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DUST MAY CAUSE IRRITATION TO THE EYES
AND SKIN. INHALATION OF DUST MAY CAUSE PULMONARY TRACT IRRITATION.
AVOID BREATHING DUST. INGESTION:EXPECTED TO BE LOW HAZARD.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:IRRITAION, COUGHING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. EYE CONTACT:FLUSH WITH WATER
FOR 15 MINUTES. GET MEDICAL HELP. SKIN CONTACT:WASH WITH SOAP AND
WATER. INGESTION:DRINK 1-2 GLASSES OF WATER. GET MEDICAL HELP
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL; CARBON DIOXIDE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR PROTECTIVE CLOTHING
AND SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:THIS MATERIAL, LIKE MOST ORGANIC
MATERIALS IN POWDER FORM, WHEN MIXED WITH AIR, IS CAPABLE OF
CREATING A DUST EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR DUST MASK. VACUUM OR WET SWEEP MATERIAL
AND PLACE IN FIBER CARTON FOR INCINERATION OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT WITH OXIDIZING
MATERIALS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH APPROVED DUST
MASK IF DUST IS CREATED.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:DO NOT CREAT DUST.
Supplemental Safety and Health
THIS PRODUCT IS SUPPLIED UNDER TWO P/N., SAME NSN AND SAME INGREDIENTS,
BUT DIFFERENT U/I. P/N: 190 0752 - 900 GRAMS; AND P/N: 808 6597 -
4X900 GRAMS PER CARTRIDGE.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:140F,60C
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.17
Evaporation Rate & Reference:NEGLIGI (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK, FINELY GROUND POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
AND CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL. DISCHARGE, TREATMENT, OR
DISPOSAL MAY BE SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:CHERVON#325 SOLVENT
Preparer's Name:C.A. EISENHARD
CAGE:0AHD1
CAGE:60777
CAGE:0AHD1
============= Composition/Information on Ingredients =============
Ingred Name:PARAFFIN WAX
CAS:8002-74-2
RTECS #:RV0350000
Fraction by Wt: 98.0%
OSHA PEL:2 MG/M3 (FUME)
ACGIH TLV:2 MG/M3 (FUME); 9192
Ingred Name:AROMATICS (C*8)
Fraction by Wt: 2.0%
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <0.1%
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT:15.3G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES,SKIN AND
RESPIRATORY TRACT;CNS DEPRESSION;HEADACHE,DIZZINESS,LOSS OF
APPETITE,WEAKNESS,LOSS OF CO-ORDINATION. CHRONIC:DERMATITIS,CNS
DEPRESSION.
Explanation of Carcinogenicity:BENZENE IS <0.1%;MAY BE IN TRACE;A
SUSPECTED HUMAN CARCINOGEN.USE PROPER PERSONAL PROTECTION;DO NOT
BREATHE VAPORS/MIST
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
WORSEN.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR;CONSULT A PHYSICIAN. SKIN &
EYES:FLUSH WITH PLENTY OF WATER FOR ABOUT 15 MINUTES,CALL A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:98F/36.7C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:CO*2,DRY CHEMICAL,FOAM,WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA IN AN ENCLOSED
AREA.
Unusual Fire/Explosion Hazard:AVOID EXTREME HEAT;VAPORS ARE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;CONTAIN FREE
LIQUID IF POSSIBLE;ELIMINATE ALL IGNITION SOURCES;USE SUITABLE
INERT ABSORBENT MATERIAL AND RECOVER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA.KEEP AWAY FROM HEAT,OPEN FLAMES OR SPARKS.KEEP CONTAINERS
CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS/MIST IF ABOVE PEL/TLV.
Ventilation:LOCAL/MECHANICAL TO MAINTAIN PEL/TLV.
FACILITIES.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST;DO NOT SMOKE,EAT OR DRINK IN WORK AREA.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:310-370F
Vapor Pres:5MMHG
Vapor Density:8.0
Spec Gravity:0.78
Evaporation Rate & Reference:0.22 (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS LIQUID.
Percent Volatiles by Volume:99.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:EXTREME HEAT,OPEN FLAMES.
Hazardous Decomposition Products:CO*2 OR CO (OXIDES OF CARBON)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CAF 9
CAGE:U1309
CAGE:01384
CAGE:U1309
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Fraction by Wt: 65%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
Ingred Name:INERT FILLERS
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:RUBBER BINDERS
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CURING AGENTS
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:CONTAINS ASBESTOS [12001-29-5] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT REQUIRED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:ITEM IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED ITEMS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE ITEM WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
ITEMS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDE RAL REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING ITEM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:INSOLUBLE
Appearance and Odor:RED SHEET MATERIAL, SLIGHT RUBBERY SMELL
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ULTRALINER
CAGE:CERTA
CAGE:89638
CAGE:CERTA
============= Composition/Information on Ingredients =============
Ingred Name:GLASS, FIBROUS
RTECS #:LK3651000
Fraction by Wt: 75-97%
Other REC Limits:N/K
OSHA PEL:15 MG/M3 (DUST)
ACGIH TLV:10 MG/M3 (DUST);9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHAL:UPPER RESPIRATORY
IRRITATION.SKIN:IRRITATION.EYES:IRRITATION.INGEST:N/K.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE.GET MEDICAL HELP IF IRRITATION
PERSISTS.SKIN:CLEANSE WITH SOAP AND WATER.GET MEDICAL HELP IF
IRRITATION PERSISTS.EYES:FLUSH WELL WITH RUNNING WATER FOR AT LEAST
15 MINUTES.G ET MEDICAL HELP IF IRRITATION PERSISTS.INGEST:CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE THAT WHICH IS APPLICABLE TO SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .TREAT AS WITH RESIDENTIAL BUILDING MATERIALS.
Unusual Fire/Explosion Hazard:TAKE CARE & DO NOT LEAVE PRODUCT FACINGS
EXPOSED WHEN NEAR FLAME.OXIDES OF CARBON,NITROGEN,& SULFER,HCL,HF
AND CARBON-HYDROGEN-NITROGEN COMPOUNDS MAY BE EMITTED
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID SPREAD OF FIBROUS GLASS DUST.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL REQUIREMENTS.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .WEAR A DISPOSABLE MASK DESIGNED FOR NUISANCE
DUST WHERE SENSITIVITY TO DUST & AIRBORNE PARTICLES MAY CAUSE
IRRITATION TO THE N OSE OR THROAT.
Ventilation:EACH SITUATION MUST BE EVALUATED BASED UPON EXPOSURES OF
CONCERN.CONSULT LOCAL SFTY/HLTH AUTHOR IF ADDNL INFO NEC
Other Protective Equipment:WEAR LONG SLEEVES AND CAP WHEN HANDLING AND
APPLYING MATL.WASH WORK CLOTHES SEPARATELY AND RINSE WASHER.
Work Hygienic Practices:N/K
Supplemental Safety and Health
N/K
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1200F
Decomp Temp:Decomp Text:N/K
Spec Gravity:2.5
Evaporation Rate & Reference:N/K
Solubility in Water:N/K
Appearance and Odor:FIBERS ASSEMBLED INTO TUBES,BLANKETS,OR
BOARDS.FAINT RESIN ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
N/K
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:OXIDES OF CARBON,NITROGEN,&
SULFER;HCL,HF & CARBON-HYDROGEN-NITROGEN COMPOUNDS MAY BE EMITTED
IN CASE OF FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:SCRAP MATERIAL SHOULD BE DISPOSED OF IN A
SANITARY LANDFILL.DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,STAT
AND LOCAL REGULATIONS .
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:VELVA-GRAIN, #05996
CAGE:EO806
CAGE:0UXB5
CAGE:EO806
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 87.7%
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION: HEADACHE, NAUSEA, EYE AND LUNG
IRRITATION.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WATER FOR 5-10 MINUTES. SKIN CONTACT: WIPE
MATERIAL OFF/WASH CONTACTED AREA. INGESTED: DON'T INDUCE VOMITING.
GET PATIENT TO FRESH AIR/CONSULT PHYSICIAN. REMOVE CONTAMINATED
CLOTHIN G AND WASH BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:107F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, OR SAND
Fire Fighting Procedures:GENERAL PROCEDURES RECOMMENDED. AVOID USE OF
WATER.
Unusual Fire/Explosion Hazard:CONTAINERS MAY RUPTURE DUE TO VERY HIGH
TEMPERATURE INDUCED PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. STOP SPILL OR LEAK
AT ONCE, BY CREATING DIKE, COVER WITHNERT ABSORBANT MATERIAL.
SHOVEL OR SWEEP INTO DISPOSABLE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SPARKS, HEAT, AND OPEN
FLAMES.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED CONTACT OR
INHALATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROVIDE ADEQUATE VENTILATION FOR CONFINED
AREA/WHEN USING SPRAY.
Ventilation:LOCAL EXHAUST PREFERABLE/MECHANICAL IS BEST.
Other Protective Equipment:WASH HANDS THROUGHLY WITH SOAP & WATER AFTER
USE.
Supplemental Safety and Health
MSDS DATE: 07 FEB 1986. WT/GAL: 6.71.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165-400F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:CLEAR BASE
Percent Volatiles by Volume:91%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT AND OPEN FLAMES, SPARKS
==================== Disposal Considerations ====================
Waste Disposal Methods:SHOVEL INTO DRUMS. INCINERATE AS LOCAL LAWS
PERMIT.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:10-OK01
CAGE:62589
CAGE:62589
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:6596-57-0
Fraction by Wt: >95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACRYLIC VINYL ACETATE POLYMER
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUMES,
GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS, NAUSEA,
FEVER, DRYNESS AND/OR IRRITATION OF NOSE, THROAT AND EYES. SKIN
SENSITIVITY MAY ALSO BE NOTED. A CUTE EXPOSURE FROM SOME TOXIC
GASES MAYCAUSE PULMONARY EDEMA, ASPHYXIATION AND EXCESSIVE EXPOSURE
CAN BE FATAL.
Explanation of Carcinogenicity:NICKEL AND CHROMIUM ARE CONSIDERED
POSSIBLE CARCINOGENS UNDER OSHA. RESPIRATORY CANCER FROM WELDING IS
UNCONFIRMED.
Effects of Overexposure:EXPOSURE TO WELDING FUMES MAY RESULT IN
DISCOMFORT SUCH AS DIZZINESS, NAUSEA, FEVER, DRYNESS AND/OR
IRRITATION OF NOSE, THROAT AND EYES. SKIN SENSITIVITY MAY ALSO BE
NOTED. WATERY EYES, HEADACHE, BREA THING DIFFICULTY, FREQUENT
COUGHING AND/OR CHEST PAINS MAY OCCUR FROM ACUTE EXPOSURE. TOXIC
GASES CAN BE FATAL.
Medical Cond Aggravated by Exposure:SOME WORKERS MAY BE AFFECTED BY A
PRE-EXISTING CONDITION OR OTHER OCCUPATIONAL ILLNESS BECAUSE OF THE
WIDE VARIATION IN INDIVIDUAL SUSCEPTIBILITIES.
======================= First Aid Measures =======================
First Aid:EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED
CROSS.
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES
AND PLACE IN SUITABLE DOT APPROVED CONTAINERS AND DISPOSE OF IN
FULL COMPLIANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS. AVOID
INHALATION AND SKIN EXPOSU RE.
======================Handling and Storage ======================
CLOTHING WHEN CUTTING, GRINDING OR WELDING. DO NOT EXPOSE SKIN TO
RADIATION WHEN HOT CUTTING OR WELDING.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE WELD FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN CUTTING, GRINDING OR WELDING IN A CONFINED SPACE OR
WHERE LOCAL EXHAUST OR GENERAL VENTILATION DOES NOT KEEP EXPOSURE
BELOW RECOMMENDED LIMITS. USE ONLY NIOSH APPROVED RESPIRATORS.
Ventilation:USE ENOUGH VENTILATION WHEN CUTTING, GRINDING OR WELDING TO
KEEP THE DUST, FUMES & GASES FROM THE WORKERS BREATHING ZONE
Other Protective Equipment:FLAME RETARDANT CLOTHING WHEN CUTTING,
GRINDING OR WELDING. DO NOT EXPOSE SKIN TO RADIATION WHEN HOT
CUTTING OR WELDING.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING OR SMOKING.
LAUNDER CONTAMINATIED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THERE ARE NO CHEMICAL HAZARDS FROM THESE LEAF SPRINGS IN SOLID FORM.
DUST OR FUNES GENERATED BY MACHINING, GRINDING OR WELDING ON THE
LEAF SPRING WILL PUT CONTAMINANTS IN THE AIR. SINCE THE LEAF SPRIN
G IS MORE THAN 95% IRON, MOST OF THE DUST OR FUME WILL BE IRON OR
IRON OXIDE. SEE MSDS FOR THE WELDING ROD BEING USED.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:LEAF SPRING, FRONT & REAR SHACKLE, BOLT, NUTS, LUBE
FITTING, COTTER PIN, U-BOLT
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:WELDING AND CUTTING OPERATION MAY
INCLUDE OXIDES OF THE METALS, CHROMATES, FLUORIDES, COMPLEX
METALLICS, AND OZONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL, STATE & LOCAL REGULATIONS
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TUFFILM FINAL FIXATIVE-MATTE 649
CAGE:IO807
CAGE:72925
CAGE:IO807
============= Composition/Information on Ingredients =============
Ingred Name:2-PENTANONE, 4-HYDROXY-4-METHYL-; (DIACETONE ALCOHOL)
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 1-10%
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 40-50%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM,S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 1-10%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1-10%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ZINC COMPOUNDS
Fraction by Wt: 0.4-1.0%
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0.4-1.0%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE (ISOBUTANE/N-BUTANE)
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 20-30%
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ACRYLIC RESIN
Fraction by Wt: 1-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NONHAZARDOUS INGREDIENTS
Fraction by Wt: 1-10%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOTE: TOLUENE APPEARS ON THE NAVY
LISTING OF OCCUPATIONAL CHEM REPRO HAZ. SEEK CONSULTATION FROM
APPROP HEALTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO AND
SAFE HANDLING AND EXPOSURE INFO . ACUTE:MAY CAUSE DIZZ/NARCOSIS IN
HIGH VAP CONC. WILL CAUSE DEFAT OF SKIN. EFTS ARE REVERSIBLE. LONG
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:TERM EXPOS (YEAR) TO HIGH CONC OF VAP
MAY CAUSE LUNG, LIVER/KIDNEY DAM. SOLV LISTED HAVE BEEN RPTD TO
AFFECT CNS. ASPIRATION HAZ IF SWALLOWED. EYE/SKIN IRRITANT. MAY
IRRIT RESP TRACT. DIACETO NE ALCOHOL MAY PRDCE ANEMIA. AVOID USING
IF PREGNANT OR CONTEMPLATING PREGNANCY. MAY HARM DEVELOPING FETUS.
(SUPP DATA)
Medical Cond Aggravated by Exposure:HEART DISEASE; RESPIRATORY
DISORDERS
======================= First Aid Measures =======================
First Aid:INHAL:GIVE OXYGEN. INGEST:DO NOT INDUCE VOMITING-GASTRIC
LAVAGE. EYES:WASH EYES WITH WATER FOR AT LEAST 15 MINUTES .
SKIN:WASH SKIN WITH WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-40F,-40C
Lower Limits:1.8%
Upper Limits:12%
Extinguishing Media:USE WATER FOG, DRY CHEMICAL/CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . AEROSOL CANS MAY RUPTURE WHEN HEATED.
Unusual Fire/Explosion Hazard:HEATED CANS MAY BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT SWEEPING COMPOUND TO SOAK UP
MATERIAL. PUT INTO CONTAINER. DISPOSE AS HAZARDOUS WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, OR OPEN
FLAME. STORE AT TEMPERATURES BELOW 120F.
Other Precautions:WHEN SPRAYING MORE THAN ONE HALF CAN CONTINUOUSLY OR
MORE THAN ONE CAN CONSECUTIVELY, USE NIOSH/MSHA APPROVED
RESPIRATOR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SCBA IF ABOVE TLV LIMIT
EXCEEDING.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:NONE
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HLTH HAZ: OVEREXPOSURE TO TOLUENE MAY CAUSE NASAL AND BRAIN DAMAGE.
CHRONIC:INHAL: DIFFICULTY IN BREATHING. SKIN-REDNESS.
INGESTION:VOMITING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>40F,>4C
Vapor Density:4(HVR/AIR)
Spec Gravity:0.8(H*2O=1)
Evaporation Rate & Reference:>1(BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:CLEAR/SOLVENT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPS.
Hazardous Decomposition Products:IN FIRE, WILL DECOMPOSE TO CARBON
DIOXIDE, WATER AND NH*3.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE AS HAZARDOUS WASTE IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:6 IMP
CAGE:69482
CAGE:69482
============= Composition/Information on Ingredients =============
Ingred Name:IRON (III) OXIDE; (IRON OXIDE)
CAS:1309-37-1
RTECS #:NO7400000
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATE)
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:CELLULOSE
CAS:9004-34-6
RTECS #:FJ5691460
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3
Ingred Name:POTASSIUM TITANATE
CAS:12030-97-6
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICATE, MICA; (MICA)
CAS:12001-26-2
RTECS #:VV8760000
OSHA PEL:20 MPPCF
ACGIH TLV:3 MG/M3 RDUST
Ingred Name:SUPP DATA:NITROGEN OXIDES MAY BE FORMED BY THE RADIATION
FROM THE ARC.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:D.C. 20402 FOR MORE DETAILS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:LENS. AS A RULE OF THUMB, START W/SHADE WHICH IS
TOO DARK TO SEE WELD ZONE. THEN GO TO NEXT LIGHTER (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:SHADE WHICH GIVES SUFFICIENT VIEW OF WELD ZONE.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:PVNT INJURY FROM RADIA, SPKS & ELEC SHOCK.
SEE ANSI Z49.1. THIS MAY INCL ARM PROTECTORS, (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:APRONS, HATS, SHOULDER PROTECTION, AS WELL AS DARK
SUBSTANTIAL CLOTHING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:FUMES & GASES CAN BE DANGEROUS TO YOUR
HEALTH. ACUTE:SHORT-TERM OVEREXPOSURE TO WELDING FUMES MAY RESULT
IN DISCOMFORT SUCH AS: DIZZINESS, NAUSEA OR DRYNESS/IRRITATION OF
NOSE, THROAT OR EYES. CHRONIC :LONG-TERM OVEREXPOSURE MAY LEAD TO
SIDEROSIS (IRON DEPOSITS IN LUNG) & IS BELIEVED BY SOME (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INVESTIGATORS TO AFFECT PULMONARY
FUNCTION. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN
KILL.
Medical Cond Aggravated by Exposure:AGGRAVATION OF PREEXISTING
RESPIRATORY OR ALLERGIC CONDITIONS MAY OCCUR IN SOME WORKERS.
======================= First Aid Measures =======================
First Aid:CALL FOR MEDICAL AID. EMPLOY FIRST AID TECHNIQUES RECOMMENDED
BY THE AMERICAN RED CROSS. INGEST:CALL MD IMMEDIATELY .
INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
EY ES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15
MINUTES, SEEK ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONFLAMMABLE: WELDING ARC & SPARKS CAN
IGNITE COMBUSTIBLES. SEE Z-49.1.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF
FUMES. TRAIN WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS & TO
INSULATE HIMSELF FROM WORK & GROUND.
Other Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS & PREC LBL ON
THIS PROD. SEE ANSI Z-49.1, SFTY IN WELDING & CUTTING, PUBLISHED BY
AWS, P.O.BOX 351040, MIAMI, FL 33135 & OSHA PUBLICATION 2206 (29
CFR 1910), U.S. GOVT PRINTING OFC, WASHINGTON, (ING 8)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRABLE FUME
RESPIRATOR OR AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED
SPACE OR WHERE LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE
BELOW TLV.
Ventilation:USE ENOUGH VENT, LOCAL EXHAUST AT THE ARC, OR BOTH, TO KEEP
FUMES & GASES BELOW TLV'S IN WORKER'S BRTHG ZONE & GEN AREA.
Other Protective Equipment:EMER EYE WASH & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR HEAD, HAND & BODY PROT WHICH HELP TO
(ING 11)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD:USED, COATINGS, NUMBER OF WORKERS, QUALITY & AMT OF
VENT, CONTAM IN ATM. FUMES & GASES MAY VARY IN FORM & PERCENT FROM
INGS LISTED. REAS EXPECTED FUME CONSTITUENTS FROM THESE PRODS WOU
LD INCL FLUORIDES & COMPLEX OXIDES OF INGS. GASEOUS RXN PROD MAY
INCL CARBON MONOXIDE & CARBON DIOXIDE. OZONE & (ING 7)
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMPOSITION & QTY OF FUMES & GASES ARE
DEPENDENT UPON METAL BEING WELDED, PROCESS, PROCS, ELECTRODES USED,
GASES(SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
W/FEDERAL, STATE & LOC AL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SOLUTION B KSTS
CAGE:HO166
CAGE:75384
CAGE:HO166
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM CHLORIDE
CAS:10361-37-2
RTECS #:CQ8750000
Fraction by Wt: 30%
OSHA PEL:0.5 MG/M3 (BA)
ACGIH TLV:0.5 MG/M3 (BA); 8990
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70%
===================== Hazards Identification =====================
Effects of Overexposure:HARMFUL OR FATAL IF ING. ING/INH:POSS
WEAKNESS/SALIVATION/NAUSEA/VOMIT/DIARRHEA/COLDNESS/PARALYSIS.
======================= First Aid Measures =======================
First Aid:ING:IMMED GIVE 2TBS EPSOM OR GLAUBERS SALT IN H*20,FOLLOWED
BY LRG AMT MILK/WATER.INDUCE VOMITING W/SYRUP OF IPECAC OR OTHER
MEANS. NEVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON. CALL MD.
EYES/SK IN:FLUSH W/WATER 15 MINS. INH:REMOVE TOFRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-FLAMMABLE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLS, AVOIDING POSSIBILITY OF
SPILLED MATL BEING FLUSHED INTO STREAMS OR WATERWAYS. IN SOME
INSTANCES IT MAY BE NECESSARY TO ADD A SULFATE TO PRECIPITATE
SOLUBLE BARIUM AS BARIUM SULFATE, SU CH AS MAGNESIUM OR SODIUM
SULFATE.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN, WASH HANDS &
CLOTHING AFTER HANDLING. AVOID CONTAMINATION OF FOODSTUFFS OR
LEFTOVER FOOD SCRAPS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD
Ventilation:LOCAL EXHAUST USUALLY SATISFACTORY.
Other Protective Equipment:CLTHNG AS NEC TO AVOID EXCESSIVE SKIN
CONTACT.
Supplemental Safety and Health
DATA WAS PROVIDED BY MFR VIA MSDS FROM EK INDUSTRIES,INC, ADDISON,ILL,
FOR BARIUM CHLORIDE. SP GRAVITY:3.1-3.8. NO ODOR.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:2840F,1560C
Vapor Pres:NIL
Evaporation Rate & Reference:NIL
Solubility in Water:APPRECIABLE
Appearance and Odor:FINE WHITE CRYSTAL OR GRANULAR POWDER IN SOLUTION.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS, WHERE THERE IS NO POSSIBILITY OF CONTAMINATION
OF FOODSTUFFS OR WATER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TRECON RA DEVELOPER & REPLENISHER PART C, 1
Kit Part:Y
CAGE:40003
CAGE:40003
CAGE:40023
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 35-40%
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 1-5%
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE A LOW HAZARD
UNDER NORMAL CONDITIONS. EYES:VAPOR MAY CAUSE IRRITATION. CONTACT
WILL CAUSE SEVERE BURNS. SKIN:POSSIBILITY OF CAUSING SEVERE BURNS.
INGEST:DO NOT TAKE INTERNALLY. HA RMFUL IF SWALLOWED. CAN CAUSE
SEVERE BURNS OF MOUTH, ESOPHAGUS & STOMACH.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
SEEK MEDICAL ATTENTION IMMEDIATELY. SKIN:IMMEDIATELY FLUSH W/WATER
FOR 15 MINUTES. REMOVE CONTAMINATED CLOTHING. SEEK MEDICAL
ATTENTION. IN GEST:DO NOT INDUCE VOMITING. SEEK MEDICAL ATTENTION
IMMEDIATELY GIVING FULL DETAILS OF AMOUNT INGESTED & TOXICITY.
INHAL:MOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING AS SPECIFIED IN THIS
MSDS. NEUTRALIZE W/SODIUM BICARBONATE. IF FEDERAL, STATE & LOCAL
LAWS PERMIT, FLUSH TO SEWER W/LARGE AMOUNTS OF WATER.
Neutralizing Agent:SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM STRONG ACIDS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . SHOULD NOT BE NECESSARY UNDER NORMAL
CONDITIONS.
Ventilation:GOOD LOCAL MECHANICAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:AS NECESSARY TO PREVENT SKIN CONTACT.
EYEWASH FACILITIES IN VICINITY OF USE. DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
WASTE DISP METH:AGENCIES TO ASCERTAIN PROPER DISPOSAL PROCEDURES.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:<212F,<100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.4
pH:13
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS & ODORLESS.
Percent Volatiles by Volume:60(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:NEUT W/SODIUM BICARBONATE. IF FED, STATE &/OR
LOC LAWS PERMIT, FLUSH TO SEWER W/LG AMTS OF WATER. OTHERWISE DISP
OF CONTAM PROD & MATLS USED IN CLEANING UP SPILL IN MANNER APPRVD
FOR MATL. CONSULT PRO PER FED, STATE &/OR LOC REGULATORY (SUPDAT)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TONER FOR CLASS II AND CLASS III (BLACK)
Preparer's Name:KRISTINA SAGE
CAGE:54726
CAGE:54726
CAGE:29382
CAGE:4M009
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLIC POLYMER
CAS:26655-10-7
Fraction by Wt: 74%
Other REC Limits:NONE SPECIFIED
Ingred Name:STYRENE, ACRYLIC POLYMER
CAS:25213-39-2
Fraction by Wt: 13%
Other REC Limits:NONE SPECIFIED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 11%
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:DYE
CAS:84179-66-8
Fraction by Wt: <2%
Other REC Limits:NONE SPECIFIED
Ingred Name:DYE
CAS:109125-50-0
Fraction by Wt: < 2%
Other REC Limits:NONE SPECIFIED
Ingred Name:DYE
CAS:109125-51-1
Fraction by Wt: < 2%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE TEMPORARY EYE
DISCOMFORT. SKIN: MAY CAUSE SLIGHT IRRITATION ON PROLONGED AND
REPEATED CONTACT WITH THE SKIN. MILDLY IRRITATING. INHALATION:
GASPING. INGESTION: >5G/KG BODYWEIGHT, PRACT ICALLY NON-TOXIC.
Explanation of Carcinogenicity:IARC HAS FOUND THE EVIDENCE FOR THE
CARCINOGENICITY OF CARBON BLACK INADEQUATE TO INDICATE A RISK FOR
HUMANS.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION. INHALATION:
GASPING. INGESTION: NO TOXIC EFFECT EXPECTED FROM INGESTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: TRY TO REMOVE WITH EYE DROPS OR FLUSH WITH WATER. IF
UNSUCCESSFUL, GET MEDICAL ATTENTION. SKIN: WASH THOROUGHLY WITH
SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE. INGESTION: DILUTE
STOMACH C ONTENTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, WATER SPRAY, DRY CHEMICALS, OR CARBON
DIOXIDE.
Fire Fighting Procedures:NO SPECIAL FIRE-FIGHTING PROCEDURE IS
NECESSARY.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, SWEEP UP USING AN APPROVED TONER
VACUUM CLEANER WITH A 0.5 MICRON FILTER SUCH AS THE ATRIX AAA TONER
VACUUM. USE OF A VACUUM CLEANER NOT RATED FOR TONER PARTICULATE
COULD BE A POTENTIAL FI RE HAZARD. REMOVE RESIDUE WITH SOAP
ANDWATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP OUT
OF REACH OF CHILDREN.
Other Precautions:DO NOT HANDLE IN AREAS WHERE WIND BLOWS. FLYING
POWDER MAY ENTER EYES. MINIMIZE INHALATION OF DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED UNDER NORMAL CONDITIONS OF USE.
Ventilation:MECHANICAL(GENERAL) EXHAUST TO PROVIDE ADEQUATE
VENTILATION. LOCAL EXHAUST IS NOT NEEDED UNDER NORMAL CONDITIONS OF
USE.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:MINIMIZE BREATHING DUST. CLEANSE SKIN
THOROUGHLY AFTER CONTACT, BEFORE BREAKS AND MEALS, AND AT THE END
OF WORK PERIODS.
Supplemental Safety and Health
IDENTIFIED ON MSDS AS SAVIN PRODUCT CODE: 4346, 4347, 4348, 4352, 4353,
4354.
================== Physical/Chemical Properties ==================
HCC:V7
Spec Gravity:0.34
Solubility in Water:NEGLIGIBLE,< 0.1%
Appearance and Odor:BLACK POWDER. ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER
DECOMPOSITION PRODUCTS IN THE CASE OF INCOMPLETE COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF USED TONER WASTE IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:LATEX FLOOR PAINT TILE RED,3-424
CAGE:GO796
CAGE:47695
CAGE:GO796
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:INHAL: MAY CAUSE HEADACHES,NAUSEA WHEN USED IN
POORLY VENTILATED AREAS. SKIN:POSSIBLE (SEE SUPP DATA
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SPLASH (EYES): FLUSH IMMED
W/COPIOUS QUANTITIES OF RUNNING H*2O FOR AT LEAST 15 MIN,TAKE TO A
PHYSICIAN FOR DEFINITIVE MED TREATMENT. SPLASH (SKIN): REMOVE
W/SOAP & H*2O. R EMOVE CONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:>200F (PMCC)
Fire Fighting Procedures:MAY USE H*2O TO COOL CLOSED CNTNRS TO PREVENT
(SEE SUPP DATA
Unusual Fire/Explosion Hazard:CLOSED CNTNRS MAY EXPLODE/BURST (DUE TO
BUILDUP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:RETURN MATERIAL TO CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM FREEZING. DONT TAKE
INTERNALLY. DONT FLAME CUT,BRAZE OR WELD W/O NIOSH/MSHA APPROVED
RESPIRATOR OR APPROPRIATE VENTILATION.
Other Precautions:HAZARDOUS DECOMP PRODS: DECOMP AS IN WELDING. FUMES
MAY CONTAIN CO. RESP PROTECTION: COMBINATN ORGANIC VAPOR-FILTER
TYPE RSPTR IN RESTRICT VENT AREA,AIR-SUPPLIED RSPTR/HOOD IN
CONFINED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD:FILTER TYPE RESPIRATOR IN OPEN
AREA,(SEE OTHR PREC
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST VENTILATION
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT TO
CONTAMINATED CLOTHING.
Supplemental Safety and Health
SPECL FIRE FIGHT PROC: PRESSURE BUILDUP & POSSIBLE EXPLOSION/BURSTING
WHEN EXPOSED TO EXTREME HEAT. IF USE H*2O,PREFER FOG NOZZLES.
EFFECTS OF OVEREXP: PRIMARY IRRIT. EYES: PRIMARY IRRITATION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:100-197C
Vapor Density:<1
Spec Gravity:1.2656
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:59.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO (SEE OTHR PRECAUT
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/LOCAL,STATE & FEDERAL
REGULATIONS. DO NOT INCINRATE CLOSED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HUSKEY MOLYPLEX
CAGE:65539
CAGE:65539
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES, HYDROTREATED HEAVY PARAFFINIC
CAS:64742-54-7
RTECS #:PY8035500
Fraction by Wt: 40-45%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:PROPRIETARY SYNTHETIC OIL
Fraction by Wt: 38-42%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA GEL
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 5-8%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:MOLYBDENUM DISULFIDE
CAS:1317-33-5
RTECS #:QA4697000
Fraction by Wt: 1-3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:PROPRIETARY ADDITIVES
Fraction by Wt: 5-8%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN IRRITATION TO SENSITIVE
INDIVIDUALS.
Explanation of Carcinogenicity:NO CARCINOGENS PRESENT.
Effects of Overexposure:NOT ESTABLISHED, NO PROBLEMS NORMALLY PRESENT.
Medical Cond Aggravated by Exposure:NOT ESTABLISHED.
======================= First Aid Measures =======================
First Aid:INGESTION-TREAT AS OIL INGESTION. EYES-FLUSH WITH WATER.
CONTACT PHYSICIAN IF IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:450F,232C
Autoignition Temp:Autoignition Temp Text:N.D.
Lower Limits:N.D.
Upper Limits:N.D.
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER FOG, FOAM.
Fire Fighting Procedures:TREAT AS OIL FIRE USE SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE UP EXCESS - DISPOSE OR BURN IN
ACCORDANCE WITH LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:USE STANDARD INDUSTRIAL HANDLING
PROCEDURES.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NEEDED.
Ventilation:LOCAL EXHAUST VENTILATION.
Other Protective Equipment:NONE USUALLY REQUIRED.
Work Hygienic Practices:STANDARD METHODS.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V7
Boiling Pt:B.P. Text:N.A.
Melt/Freeze Pt:M.P/F.P Text:N.A.
Vapor Pres:N.A.
Vapor Density:N.A.
Spec Gravity:0.93
pH:N.A.
Viscosity:N.A.
Evaporation Rate & Reference:N.A.
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK COLOR - SEMI SOLID WITH MILD ODOR.
Percent Volatiles by Volume:N.A.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:WELDING.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, TRACE
METAL OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ABLEFILM 501
CAGE:9V874
CAGE:9V874
CAGE:21109
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS.
===================== Hazards Identification =====================
Effects of Overexposure:EYES/SKIN: MAY IRRITATE OR CAUSE
IRRITATION/SENSITIZATION.;INHAL: IRRITATES WHEN HEATED TO HI-TMP
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER FOR @ LEAST 15MIN.-GET MED. ATTN; SKIN:
WASH IMMED. W/SOAP & WATER. IF IRRITATION PERSISTS,SEEK MED. ATTN.;
INHAL: REMOVE TO FRESH AIR IMMEDIATELY. GIVE 0*2/CPR AS SITUATION
DICTATE S;INGEST: SEEK IMMED. MED. ATTN.
===================== Fire Fighting Measures =====================
Flash Point:>300F/>148C PMCC
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA' WHEN FIGHTING CHEMICAL TYPE FIRES
Unusual Fire/Explosion Hazard:NONE KNOWN TO MFR.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & COLLECT IN AN APPROPRIATE CONTAINER
FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE FROZEN AT -40F. VENT CURING
OVEN TO OUTDOORS. AVOID CONTACT W/SKIN, EYES, & CLOTHING. USE GOOD
INDUSTR. HYG. PRACTICE. AVOID INHALING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPRVD ORGANIC VAPOR RESP. IF NEEDED.
Ventilation:MECHANICAL (GENERAL) ACCEPTABLE LOCAL EXHAUST IF NEEDED.
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
MSDS DATE:8/19/86
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>400F/>204C
Spec Gravity:1.2
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR AMBER DRY FILM; ODORLESS
Percent Volatiles by Volume:<1.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALIES, & STRONG ACIDS.
Stability Condition to Avoid:NONE-KNOWN TO MFR.
Hazardous Decomposition Products:CARBON MONOXIDE & ALDEHYDES, ACIDS, &
CARBON DIOXIDE
Conditions to Avoid Polymerization:WILL NOT POLYMERIZE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN AN APPROVED CHEMICAL DISPOSAL AREA OR
IN A MANNER WHICH COMPLIES W/ALL LOCAL, STATE, & FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:84 WOODMASTER CLEAR VARNISH-SATIN SHEEN
CAGE:72818
CAGE:72818
============= Composition/Information on Ingredients =============
Ingred Name:HEXANOIC ACID, 2-ETHYL-, COBALT(2+) SALT
CAS:136-52-7
Minumum % Wt:.1
Maxumum % Wt:1.
OSHA PEL:.05 MG/M3
ACGIH TLV:.02 MG/M3
Ingred Name:BENZENE
CAS:71-43-2
RTECS #:CY1400000
Minumum % Wt:.01
Maxumum % Wt:.1
OSHA PEL:1 PPM
OSHA STEL:5 PPM
ACGIH TLV:.5 PPM
ACGIH STEL:2.5 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-
CAS:95-63-6
RTECS #:DC3325000
Minumum % Wt:.1
Maxumum % Wt:1.
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED LIGHT
CAS:64742-47-8
RTECS #:OA5504000
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC
CAS:64742-95-6
RTECS #:WF3400000
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:SOYBEAN OIL, POLYMER WITH PENTAERYTHRITOL, TDI AND TUNG OIL
CAS:67989-28-0
Minumum % Wt:20.
Maxumum % Wt:30.
Ingred Name:SILICA SOL, AMORPHOUS, CRYSTALLINE-FREE
CAS:112926-00-8
RTECS #:VV7315000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:NAPHTHA (PETROLEUM), HEAVY ALKYLATE
CAS:64741-65-7
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:FATTY ACIDS, TALL-OIL, POLYMERS WITH ETHYLENE GLYCOL,
GLYCEROL, ISOPHTHALIC ACID, PENTAERYTHRITOL AND PROPYLENE GLYCOL
CAS:68333-62-0
Minumum % Wt:20.
Maxumum % Wt:30.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:CONTAINS A CHEMICAL THAT IS MODERATELY
TOXIC BY INHALATION. NOTICE-REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL
OR FATAL.
Explanation of Carcinogenicity:BENZENE, COBALT
Effects of Overexposure:INHALATION: LOSS OF APPETITE, MUCOUS MEMBRANE
IRRITATION, DROWSINESS, DIZZINESS AND/OR LIGHTHEADEDNESS, HEADACHE,
UNCOORDINATION, NAUSEA, CENTRAL NERVOUS SYSTEM DEPRESSION,
INTOXICATION, ALLERGIC RESP ONSE, ASTHMATIC REACTION. SKIN:
DERMATITIS, DEFATTING. MAY RESULT IN DERMAL ABSORPTION OF
COMPONENTS OF THIS PRODUCT. EYE: CONJUNCTIVITIS. INGESTION: LUNG
INFLAMMATION AND DAMAGE DUE TO ASPIRATION OF MATERIAL INTO LUNGS,
MOUTH AND THROAT IRRITATION, MUCOUS MEMBRANE IRRITATION, NAUSEA,
VOMITING, GASTRO-INTESTINAL DISTURBANCES, CENTRAL NERVOUS SYSTEM
DEPRESSION, INTOXICATION, CONVULSIONS.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE AND SUPPORT
CONTINUED BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY.
SKIN: FLUSH FROM SKIN WITH WATER. THEN WASH THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING.EYE: FLUSH IMMEDIATELY
WITH LARGE AMOUNTS OF WATER, ESPECIALLY UNDER LIDS FOR AT LEAST 15
MINUTES. IN ALL CASES, GET MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:=39.4C, 103.F
Lower Limits:.7%
Upper Limits:13.3%
Extinguishing Media:DRY CHEMICAL OR FOAM, WATER FOG, CARBON DIOXIDE
Fire Fighting Procedures:WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS. FIREFIGHTERS SHOULD USE FULL PROTECTIVE CLOTHING, EYE
PROTECTION, AND SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT OR FIRE. VAPORS CAN FORM EXPLOSIVE
MIXTURES IN AIR AT ELEVATED TEMPERATURES. MAY DECOMPOSE UNDER FIRE
CONDITIONS EMITTING IRRITANT AND/OR T OXIC GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS. ELIMINATE ALL SOURCES OF IGNITION.
VENTILATE AREA. EVACUATE ALL UNNECESSARY PERSONNEL. LARGE
SPILLS-SHUT OFF LEAK IF SAFE TO DO SO. DIK E AND CONTAIN SPILL.
PUMP TO STORAGE OR SALVAGE VESSELS. USE ABSORBENT TO PICK UP EXCESS
RESIDUE. KEEP SALVAGABLE MATERIAL AND RINSE WATER OUT OF SEWERS AND
WATER COURSES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100 F. KEEP AWAY FROM
HEAT, SPARKS, AND OPEN FLAME.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. DO NOT TAKE
INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN. AVOID CONTACT WITH
SKIN AND EYES, AND BREATHING OF VAPORS. WASH HANDS THOROUGHLY AFTER
HANDLING, ESPECIAL LY BEFORE EATING OR SMOKING. KEEP CONTAINERS
TIGHTLY CLOSED AND UPRIGHT WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE EXPOSURE STANDARDS WHEN USING THIS MATERIAL. WHEN
RESPIRATORY PROTECTION IS DETERMINED TO BE NECESSARY, USE A
NIOSH/MSHA APPROVED ELASTOMERIC SEAL ING SURFACE FACEPIECE
RESPIRATOR OUTFITTED WITH ORGANIC VAPOR CARTRIDGES AND PAINT SPRAY
PREFILTERS.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS. USE EXPLOSION-PROOF EQUIPMENT.
Other Protective Equipment:EYE WASH, SAFETY SHOWER, IMPERVIOUS
CLOTHING, FACE SHIELD
Supplemental Safety and Health
WT/GAL = 7.56
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:281-400 F
Spec Gravity:0.907
Appearance and Odor:CLEAR LIQUID
Percent Volatiles by Volume:61.81
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, HYDROGEN CHLORIDE, VINYL POLYMERS, METAL
COMPOUNDS, HYDROGEN FLUORIDE, MAGNESIUM.
Stability Condition to Avoid:ELEVATED TEMPERATURES, SPARKS, OPEN FLAME,
IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, ACID
FUMES, TOXIC GASES.
=================== Toxicological Information===================
Toxicological Information:BENZENE IS LISTED AS A CARCINOGEN.
CARCINOGENICITY: IARC HAS CLASSIFIED COBALT AND CERTAIN COBALT
COMPOUNDS AS POSSIBLY CARCINOGENIC TO HUMANS. INJECTION OF METALLIC
COBALT, COBALT ALLOYS, AND CERTAI N COBALT COMPOUNDS HAS RESULTED
IN THE DEVELOPMENT OF LOCALIZED TUMORS IN LABORATORY ANIMALS.
SILICA GEL, AMORPHOUS: LD50:>2000.00 MG/KG SKN RBT, LD50:>31.60
GM/KG ORL RAT, LC50:>2.00 PPM; LIGHT AROM ATIC SOLVENT NAPHTHA:
LD50:>5.00 GM/KG ORL RAT, LC50:>3670.00 PPM IHL RAT; BENZENE: LD50:
930.00 MG/KG ORL RAT, LD50:>9400.00 MG/KG SKN RBT; MINERAL SPIRITS:
LD50:>3.00 GM/KG SKN RBT, LD50:>5.00 GM/KGORL RAT
===================== Ecological Information =====================
Ecological:NO ECOLOGICAL TESTING HAS BEEN DONE BY ICI PAINTS ON THIS
PRODUCT AS A WHOLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
=================== MSDS Transport Information ===================
Transport Information:DOT: PAINT, COMBUSTIBLE LIQUID, UN 1263, PGIII
===================== Regulatory Information =====================
SARA Title III Information:COBALT ALKANOATE: SARA 313: YES, HAZ AIR
POLLUTANT : YES; BENZENE: SARA 313: YES, CERCLA 302.4: YES, HAZ AIR
POLLUTANT: YES
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RTV-9858 CATALYST MIL-S-23586 TYI
CAGE:01139
CAGE:01139
============= Composition/Information on Ingredients =============
Ingred Name:DIBUTYL TIN DILAURATE (AS TIN)
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: 5.0%
OSHA PEL:S, 0.1 MG/M3
ACGIH TLV:S, 0.1 MG/M3; 8990
Ingred Name:BENZOTRIAZOLE
CAS:95-14-7
RTECS #:DM1225000
Fraction by Wt: 0.1%
===================== Hazards Identification =====================
Effects of Overexposure:SKIN & EYE IRRITATION MAY OCCUR WITH SOME
INDIVIDUALS
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/ MILD SOAP & WATER & APPLY SKIN CREAM. EYE:
FLUSH W/ WATER FOR 15 MIN. IF IRRIT PERSISTS, CONSULT DOCTOR.
INGEST: INDUCE VOMIT & CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:>400F
Extinguishing Media:ALL STANDARD FIRE FIGHTING AGENTS ARE SUITABLE
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE OR SCRAPE UP SPILLS & PLACE IN A
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQ'D
Ventilation:ADEQUATE
Supplemental Safety and Health
PART B OF A THREE PART KIT. MFG STATES ILV IS NOT DETERMINED. ALSO,
BEYOUND THE INGRED. LISTED, THE MATERIAL HAS NO OTHER HAZ INGRED.
ACCORDING TO FED HAZ SUB-STANCES LABELING ACT.KEY1:N1.
================== Physical/Chemical Properties ==================
Spec Gravity:1.6100
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BROWN PASTE; SOAPY ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:N OXIDES, SIO*2, CO*2 & TOXIC METAL
FUMES AT TEMP >450F
==================== Disposal Considerations ====================
Waste Disposal Methods:LEACHPROOF LANDFILL IN ACCORDANCE W/ FED., STATE
& LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AQUASHADE AQUATIC PLANT GROWTH CONTROL
CAGE:SHADE
CAGE:SHADE
============= Composition/Information on Ingredients =============
Ingred Name:BASIC CHROMATE SULFATE
CAS:12336-95-7
RTECS #:GB6240000
Ingred Name:C.I. ACID BLUE 9*94-3*
CAS:2650-18-2
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (MALLARD DUCKS): >42.4 ML/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: PROLONGED/REPEATED CONTACT MAY
RESULT IN MECHANICAL IRRITATION. SKIN: MAY RESULT IN MINIMAL
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: PROLONGED/REPEATED CONTACT MAY RESULT IN
MECHANICAL IRRITATION. SKIN CONTACT MAY RESULT IN MINIMAL
IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/FLOWING WATER FOR 15 MINS. SKIN: WASH AFFECTED
AREAS THOROUGHLY W/SOAP & WATER. INGESTION: DILUTE W/WATER & INDUCE
VOMITING. NEVER GIVE FLUIDS/INDUCE VOMITING IF UNCONSCIOUS/HAVING
CONVU LSIONS. OBTAIN MEDICAL ATTENTION IN ALLCASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, CO2, DRY CHEMICAL, MEDIA APPROPRIATE FOR
PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:WEAR SCBA & TURNOUT GEAR.
Unusual Fire/Explosion Hazard:NONE
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:COVERALLS, APRON & BOOTS. CLEAN CLOTHING
SHOULD BE WORN DAILY.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Melt/Freeze Pt:M.P/F.P Text:>212F
Vapor Pres:AS WATER
Spec Gravity:1.23-1.26
pH:3.2
Solubility in Water:COMPLETE
Appearance and Odor:DARK BLUE LIQUID W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T DISCHARGE TO WATERWAYS. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:EVAPORATOR REPAIR KIT, EP538A
Kit Part:Y
CAGE:91714
CAGE:52918
CAGE:91714
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN SYSTEM
Ingred Name:SILICONE, DIOXIDE, AMORPHOUS (SILICA GEL)
CAS:7631-86-9
Fraction by Wt: <05%
OSHA PEL:6 MG/M3 (TDUST)
ACGIH TLV:10 MG/M3 (TDUST)
Ingred Name:SILICA
CAS:7631-86-9
Fraction by Wt: <05%
OSHA PEL:6 MG/M3 (TDUST)
ACGIH TLV:10 MG/M3 (TDUST)
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: <25%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <25%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN IRRIT AND POSSIBLE
ALLERGIC REACTIONS. PROLONGED AND REPEATED CONTACT MAY CAUSE
SENSITIZATION WHICH WILL RESULT IN ALLERGIC REACTIONS.
Explanation of Carcinogenicity:CRYSTALLINE SILICA: CLASS 2A (IARC)
Effects of Overexposure:SKIN RASH, IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH SKIN WITH PLENTY OF WATER. WASH SKIN THOROUGHLY
WITH SOAP AND WATER, RUBBING ALCOHOL, OR HAND CLEANER. DO NOT USE
SOLVENTS. REMOVE SOILED CLOTHING AND WASH BEFORE REUSE. IF IRRIT
PERSISTS/ INCR, SEE PHYS. EYE: FLUSH EYE WITH WATER FOR AT LEAST 15
MINUTES. INHAL: REMOVE FROM EXPOS. SUPPORT BRTHG(GIVE ARTF
RESP/O2). CALL MD IMMED . INGEST: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>300F,>149C
Extinguishing Media:DRY CHEMICAL, HALON FIRE EXTINGUISHER, WATER SPRAY,
FOAM OR FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DENSE SMOKE AND TOXIC GASSES MAY BE
LIBERATED.
================== Accidental Release Measures ==================
GLASSES. COVER WITH ABSORBENT MATERIAL, THEN SCRAPE UP AND TRANSFER
TO METAL CONTAINER. WIPE UP REMAINING RESIDUE WITH SOLVENTS,
OBSERVING SOLVENT FLAMMABI LITY CAUTIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT COOL IN ACCORDANCE WITH
LABEL INSTRUCTIONS. STORE AT ROOM TEMPERATURE (70 F) FOR 12 MONTHS.
Other Precautions:FOLLOW RECOMMENDED CURING SCHEDULE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WITH GOOD INDUSTRIAL VENTILATION.
USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:LOCAL AND MECHANICAL EXHAUST RECOMMENDED.
Other Protective Equipment:AS NEEDED TO PROTECT SKIN AND CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
CNDTNS (POLYM): SURFACES TO BE BONDED. FAILURE TO OBSERVE CAUTIONS MAY
RESULT IN EXCESSIVE HEAT BUILD-UP WITH THE RELEASE OF TOXIC GASSES.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>500F,>260C
Vapor Pres:<0.1
Vapor Density:NIL
Spec Gravity:1.62
Evaporation Rate & Reference:>1 (REF:N/K)
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS BLUE LIQUID WITH PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:SEE CONDITIONS TO AVOID (POLY).
Hazardous Decomposition Products:CO, NOX, ALDEHYDES, ACIDS AND
UNDETERMINED ORGANICS.
Conditions to Avoid Polymerization:AVOID MIX RESIN & CURING AGENT IN
BATCHES >1 LB TOTAL. DO NOT HEAT MIXED ADHESIVE ABOVE 125 F UNLESS
CURING (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS AS HAZARDOUS WASTE ACCORDING TO DOT HAZARD
CLASS. IF NOT REGULATED BY DOT DISPOSE OF AS ORM-E.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:GIBBERELLIC ACID SOLUTION 0.1-1.0% 100 ML
Preparer's Name:LAEXANDER A. PICCIRILLI
CAGE:11273
CAGE:11273
============= Composition/Information on Ingredients =============
Ingred Name:GIBBERILLIC ACID
CAS:77-06-5
RTECS #:LY8990000
Fraction by Wt: 0.1-1.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 99%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL;9495
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGESTION OF GREATER THAN 100
ML MAY BE FATAL. INHALATION MAY CAUSE RESPIRAOTRY IRRITATION,
NARCOSIS. CONTACT WITH EYES AND SKIN MAY CAUSE IRRITATION;
DEFATTING/CRACKING OF SKIN. CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INGESTION-DEATH. EYES-IRRITATION.
SKIN-IRRITATION, CRACKING, DRING. INHALED-IRRITATION, NARCOSIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IN ALL CASES. EYES-FLUSH WITH WATER FOR
15 MINUTES. SKIN-REMOVE CONTAMINATED CLOTHES. WASH WITH MILD SOAP &
WATER. INHALED-REMOVE TO FRESH AIR. ADMINISTER OXYGEN OR ARTIFICIAL
RE SPIRATION AS NEEDED. INGESTED-IF CONSCIOUS, GIVE 1-2 GLASSES
WATER. CONTACT POISON CONTROL CENTER AND OBTAIN IMMEDIATE MEDICAL
ATTENTION. IF DOCTOR OKS, INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:52.0F,11.1C
Lower Limits:2.5
Upper Limits:12.1
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE FLOODING AMOUNTS OF WATER IN EARLY STAGES
OF FIRE. WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR, MAY TRAVEL
TO DISTANT SOURCE OF IGNITION AND IGNITE. BURNS WITH A CLEAR,
ALMOST INVISIBLE FLAME. REACTS VIGOUROUSLY WITH OXIDIZERS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. PROVIDE
ADEQUATE VENTILATION. ABSORB SPILLS ON PAPER OR OTHER SUITABLE
ABSORBENT MATERIAL. PLACE IN A CONTAINER FOR LATER DISPOSAL OR BURN
PAPER AFTER EVAPORTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
PLACE AWAY FROM SOURCES OF IGNITION AND STRONG OXIDIZING AGENTS.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. AVOID CONTACT WITH
SKIN AND EYES. REMOVE AND WASH CONTAMINATED CLOTHES. FOR LABORATORY
USE ONLY. NOT FOR DRUG, FOOD OR HOUSEHOLD USE. KEEP OUT OF REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF ENGINEERING CONTROLS
FAIL OR NON-ROUTINE USE OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH
APPROVED RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE OR AN AIR-SUPPLIED
RESPIRATOR OR SCB A, AS REQUIRED. USE IAW 29 CFR 1910.134.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:LAB COAT, EYE WASH STATION & SAFETY SHOWER,
VENTILATION HOOD, FIRE EXTINGUISHER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
MSDS PRESENTED BY CAGE 11273 FOR CONTRACT MA414-96-P2027.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:180F,82C
Melt/Freeze Pt:M.P/F.P Text:-130F,-90C
Vapor Pres:33
Vapor Density:2.1
Spec Gravity:0.786
Evaporation Rate & Reference:1.5 (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID; MILD ALCOHOL ODOR.
Percent Volatiles by Volume:99.99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE TEMPERATURES, HEAT, SPRAKS,
FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE AND/OR CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROVED INCINERATOR OR
CONTRACT WITH A LICENSED WASTE DISPOSAL SERVICE. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ACETONITRILE 00170, BP1170SS115
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ACETONITRILE LD50: (ORAL, RAT) 2730 MG/KG
CAS:75-05-8
RTECS #:AL7700000
= Wt:99.
OSHA PEL:70 MG/M3;40 PPM
ACGIH TLV:67 MG/M3;40 PPM
ACGIH STEL:101 MG/M3;60 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MAY CAUSE MODERATE EYE IRRIT.
VAPS MAY CAUSE EYE IRRIT. SKIN: MAY BE HARMFUL IF ABSORBED THRU
SKIN. MAY BE METABOLIZED TO CYANIDE WHICH IN TURN ACTS BY
INHIBITING CYTOCHROME OXIDASE IMPAIRING CEL LULAR RESPIRATION.
INGEST: MAY CAUSE IRRIT OF DIGESTIVE TRACT. MAY CAUSE EFTS SIMILAR
TO THOSE FOR INHAL EXPOS. INHAL: HARMFUL IF INHALED. INHAL OF HIGH
CONCS MAY CAUSE CNS EFTS CHARACTERIZED BY HDCH, DIZZ, UNCON &
COMA. MAY CAUSE LIVER & KIDNEY DMG. VAPS MAY CAUSE DIZZ OR
SUFFOCATION. MAY CAUSE NAUS, DIZZ & HDCH. INHAL MAY LEAD TO DIZZ,
WEAK & DROW, LEADING TO STUPOR, UNCON & EVEN DEATH. INHAL MA Y LEAD
TO(EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: HEMATEMESIS, CONVULSIONS, CHOCK, COMA
& POSSIBLE DEATH. CHRONIC: CHRONIC INHAL & INGEST MAY CAUSE EFTS
SIMILAR TO THOSE OF ACUTE INHAL & INGEST. MAY BE METABOLIZED TO
CYANIDE WHICH IN TURN A CTS BY INHIBITING CYTOCHROME OXIDASE
IMPAIRING CELLULAR RESPIRATION. ANIMAL STUDIES HAVE REPORTED THAT
FETAL EFTS/ABNORMALITIES MAY OCCUR WHEN MATERNAL TOXICITY IS SEEN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN, OCCASNLY
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN: GET MED AID
IMMED. FLUSH SKIN W/PLENTY OF SOAP & WATER FOR AT LEAST 15 MIN
WHILE REMOV ING CONTAM CLTHG & SHOES. INGEST: IF VICTIM CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK OR WATER. NEVER GIVE ANYTHING BY
MOUTH TO UNCON PERSON. GET MED AID IMMED. INHAL: GET MED AID
IMMED. REMOVE FRO M EXPOS TO FRESH AIR IMMED. IF BRTHG IS DFCLT,
GIVE OXYG. NOTES TO MD: EXPOS SHOULD BE TREATED AS CYANIDE
POISONING. EFTS MAY BE DELAYED. ANTIDOTE: ALWAYS HAVE CYANIDE
ANTIDOTE KIT ON HAND WHEN WORING W/CYANIDE CMPDS. GET MED ADVICE
TO USE.
===================== Fire Fighting Measures =====================
Flash Point:=6.C, 42.8F
Autoignition Temp:=524.C, 975.2F
Lower Limits:4.4%
Upper Limits:16.0%
Extinguishing Media:SM FIRES:USE DRY CHEM, CO*2, WATER
SPRAY/ALCOHOL-RESIST FOAM. USE WATER SPRAY TO COOL FIRE-EXPOS
CNTNRS. WATER MAY BE INEFFECTIVE. DO NOT USE STRAIGHT STREAMS OF
WATER. LG (SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . NFPA RATING: HEALTH-2; FLAMMABILITY-3; REACTIVITY-0.
Unusual Fire/Explosion Hazard:CNTNRS CAN BUILD UP PRESS IF EXPOS TO
HEAT &/OR FIRE. VAPS MAY FORM EXPLO MIX W/AIR. VAPS CAN TRAVEL TO
IGNIT SOURCE & FLASH BACK. COMBUST GENERATES TOX FUMES. USE WATER
SPRAY TO KEEP FIRE-EXPOS CNTNR S COOL. FLAM LIQ. VAPS MAY BE
HVR/AIR. THEY CAN SPREAD ALONG GROUND & COLLECT IN LOW/CONFINED
AREAS. CNTNRS MAY (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT.
AVOID RUNOFF INTO STORM SEWERS AND DITCHES WHICH LEAD TO WATERWAYS.
REMOVE ALL SOURCES OF IGNITION. ABSORB SPILL USING AN ABSORBENT,
NON-COMBUSTIBLE MATERIAL SUCH AS EARTH, SAND OR VERMICULITE. A
VAPOR SUPPRESSING FOAM MAY BE USED TO REDUCE VAPORS. WATER SPRAY
MAY REDUCE VAPOR BUT MAY NOT PREVENT IGNITION IN CLOSED SPACES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPKS & FLAME.
KEEP AWAY FROM SOURCES OF IGNIT. STORE IN TIGHTLY CLOSED CNTNR.
KEEP FROM CNTCT W/OXIDIZING MATLS. STORE IN COOL, DRY, WELL-VENTD
AREA AWAY FROM INCOMPAT SUBSTANCES. WASH THOROUGHLY AFTER HNDLG.
REMOVE CONTAM CLTHG & WASH BEFORE USE. USE ONLY IN WELL VENTD AREA.
Other Precautions:GROUND & BOND CNTNRS WHEN TRANSFERRING MATL. AVOID
CNTCT W/EYES, SKIN & CLTHG. EMPTY CNTNRS RETAIN PROD RESIDUE (LIQ
&/OR VAP) & CAN BE DANGEROUS. KEEP CNTNR TIGHTLY CLSD. AVOID CNTCT
W/HEAT, SPKS & F LAME. DO NOT INGEST/INHALE. DO NOT PRESSURIZE,
CUT, WELD, BRAZE, SOLDER, DRILL, GRIND/EXPOSE EMPTY C NTNRS TO
(SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE ADEQ GEN/LOC EXHST VENT TO KEEP AIRBORNE CONCS BELOW
PEL. ACETONITRILE: EXPOS LIMS: ACGIH-40PPM; 67 MG/M3; 60PPM STEL;
101 MG/M3 STEL. NIOSH-20PPM (SUPDAT)
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Supplemental Safety and Health
OTHER PRECS:HEAT, SPKS/OPEN FLAME. EXTING MEDIA:FIRES:USE DRY CHEM,
CO*2, ALCOHOL-RESIST FOAM/WATER SPRAY. COOL CNTNRS W/FLOODING QTYS
OF WATER UNTIL WELL AFTER FIRE IS OUT. EXPLO HAZ:MAY EXPLODE WHEN
HEATED. VENT:TWA; 34MG/M3 TWA; 500PPM IDLH. OSHA-40PPM TWA; 70
MG/M3 TWA. OSHA VACATED PELS:40PPM TWA; 70MG/M3 TWA.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:=-50.C, -58.F
Decomp Temp:Decomp Text:NOT AVAILABLE
Vapor Pres:73 MM HG
Vapor Density:1.4(AIR=1)
Spec Gravity:0.7810
pH:NOT AVAILABLE
Viscosity:0.36 CP 20 DEG
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; SWEETISH ODOR - AROMATIC
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORINE FLUORIDE, FLUORINE, 2-CYANO-2-PROPYL NITRATE, DINITROGEN
TETRAOXIDE, INDIUM, DIPHENYL SULFOXIDE, TRICHLOROSILANE, N-FLUORO
CMPDS, IRON (III) PERCHLORATE, LANTHANIDE, NITRIC ACID, PERCHLORIC
ACID, SULFURIC ACID, SUL
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES AND
PRESSURES. AVOID INCOMPATIBLE MATERIALS, IGNITION SOURCES.
Hazardous Decomposition Products:HYDROGEN CYANIDE, NITROGEN OXIDES,
CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:CAS #75-05-8, RTECS #AL7700000. LD50/LC50 -
INHAL, MOUSE: LC50=2693 PPM/1H; INHAL, RABBIT: LC50=2828 PPM/4H;
INHAL, RAT: LC50=7551 PPM/8H; ORAL, MOUSE: LD50=269 MG/KG; ORAL,
RABBIT: LD50=50 MG/KG; ORA L, RAT: LD50=2730 MG/KG; SKIN,
RABBIT:LD50=1250 MG/KG; CARCINOGENICITY - ACGIH: A4 - NOT
CLASSIFIABLE AS HUMAN CARCIN. EPIDEMIOLOGY - NO INFO AVAIL.
TETRAGENICITY - EMBRYO OR FETUS: STUNTED FETUS, IHL -HAMSTER
TCLO=8000 PPM/1H. SPECIFIC DEVELOPMENTAL ABNORMS: MUSCULOSKELETAL,
ORL-HAMSTER TCLO=300 MG/KG. REPRO EFTS - FERTILITY:
POST-IMPLANTATION MORTALITY, ORL-HAMSTER TDLO=400 MG/KG &
IHL-HAMSTER TC LO=5000 PPM/1H. (OTHER INFO)
===================== Ecological Information =====================
Ecological:EXOTOXICITY: FATHEAD MINNOW (HARD WATER) TLM=1150 PPM/24H.
ENVIRONMENTAL FATE: NO INFO REPORTED. PHYSICAL/CHEMICAL: NO INFO
AVAIL. OTHER: NONE. OTHER INFO: ADVICE IMMED (SHOW LABEL WHERE
POSS). WGK (W ATER DANGER/PROT) CAS #75-05-8: 2. CANADA: CAS
#75-05-8 IS LISTED ON CANADA'S DSL/NDSL LIST, HAS A WHMIS
CLASSIFICATION OF B2, D1B, D2B. IT IS NOT LISTED ON CANADA'S INGRED
DISCLOSURE LIST. EXPOS LIMS : CAS #75-05-8: OEL-ARAB REPUBLIC OF
EGYPT:TWA 40 PPM (70 MG/M3); SKIN OEL-AUSTRALIA: TWA 40 PPM (70
MG/M3); STEL 60 PPM; SKIN OEL-AUSTRIA; TWA 40 PPM (70 MG/M3)
OEL-BELGIUM:TWA 40 PPM (67 MG/M3); STE L 60 PPM (10 MG/M3);
(TRANSPORT INFO)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. RCRA D-SERIES MAXIMUM CONCENTRATION OF
CONTAMINANTS: NONE LISTED. RCRA D-SERIES CHRONIC TOXICITY REFERENCE
LEVELS: NONE LIS TED. RCRA F-SERIES: NONE LISTED. RCRA P-SERIES:
NONE LISTED. RCRA U-SERIES: CAS #75-05-8: WASTE #U00 3 (IGNITABLE
WASTE; TOXIC WASTE).
=================== MSDS Transport Information ===================
Transport Information:SHIPPING NAME - US DOT: ACETONITRILE; IATA: NO
INFO AVAIL; RID/ADR: NO INFO AVAIL. IMO: NO INFO AVAIL.
ACETONITRILE. HAZ CLASS - US DOT: 3; IMO: 3(6.1). UN NUMBER: US
DOT: UN1648; IMO: UN1648. PACKING GROUP: US DOT: II; IMO: II.
ADDNL INFO: IMO: FLASHPOINT 6C. ECOLOGICAL INFO: SKIN
OEL-DENMARK:TWA 40 PPM (70 MG/M3); STEL 60 PPM (10 MG/M3);
OEL-FINLAND: TWA 40 PPM (70 MG/M3); STEL 60 PPM (10 MG/M3) ;
OEL-FRANCE: TWA 50 MG/M3; STEL 100 MG/M3; SKIN JAN9 OEL-THE
NETHERLANDS: TWA 40 PPM (70 MG/M3) OEL-THE PHILIPPINES: TWA 40 PPM
(70 MG/M3) OEL-RUSSIA: STEL 10 MG/M3; OEL-SWITZERLAND: TWA 40 PPM
(70 M G/M3); STEL 80 PPM; (STATE REG INFO)
===================== Regulatory Information =====================
SARA Title III Information:CAS #75-05-8: SARA SECTION 302(RQ): FINAL
RQ=5000 LBS (2270 KG). SECTION 302(TPQ): NONE OF CHEMICALS IN
PRODUCT HAVE TPQ. SARA CODES: ACUTE, CHRONIC, FLAMMABLE. SECTION
313: MATERIAL CONTAINS ACETONIT RILE (CAS #75-05-8, 99%) WHICH IS
SUBJECT TO REPORTING REQS OF SECTION 313 OF SARA TITLE III & 40 CFR
PART 373.
Federal Regulatory Information:CAS #75-05-8: TSCA: LISTED ON TSCA
INVENTORY. HLTH & SFTY REPORTING LIST: EFTIVE DATE: OCT 4, 1982;
SUNSET DATE: OCT 4, 1992. CHEM TEST RULES: NONE OF CHEMS IN PROD
UNDER CHEM TEST RULE. SECTION 12B:NONE OF CHEMS LISTED UNDER TSCA
SECTION 12B. TSCA SIGNIFICANT NEW USE RULE: NONE OF CHEMS IN MATL
HAVE SNUR UNDER TSCA. CLEAN AIR ACT: LISTED AS HAZ AIR POLLUTANT
(HAP). MATL DOES NOT CNTN ANY CLASS 1 OR CLASS 2 OZONE DEPLETORS.
CLEAN WATER ACT: NONE OF CHEMS IN PROD LISTED AS HAZ SUBSTANCES
UNDER C WA. NONE OF CHEMS LISTED AS PRIORITY OR TOX POLLUTANTS
UNDER CWA. NONE CONSIDERED HIGHLY HAZ BY OSHA.
EUROPEAN/INTERNATIONAL (OTHER INFO)
State Regulatory Information:CAS #75-05-8 CAN BE FOUND ON FOLLOWING
STATE RIGHT TO KNOW LISTS: CALIFORNIA, NEW JERSEY, FLORIDA,
PENNSYLVANIA, MINNESOTA, MASSACHUSETTS. CALIFORNIA NO SIGNIFICANT
RISK LEVEL: NONE OF CHEMS IN THIS P ROD ARE LISTED. TRANSPORT INFO:
SKIN OEL-TURKEY: TWA 40 PPM (70 MG/M3) OEL-UNITED KINGDOM:TWA 40
PPM (70 MG/M3); STEL 60 PPM; OEL IN BULGARIA, COLOMBIA, JORDAN,
KOREA CHECK ACGIH. TLV OEL IN NEW ZEALA ND, SINGAPORE, VIETNAM
CHECK ACGIH TLV.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 01-385-7247
Product ID: POLYURETHANE AEROSOL COLORS
Cage: 58977
Box: 183
=======================================================
Contractor Summary
=======================================================
Cage: 58977
Box: 183
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: POLYURETHANE COATING
Unit of Issue: BX
Quantitative Expression: 00000000012EA
UI Container Qty: 1
Type of Container: BX
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Effects of Exposure: INHALATION: ANESTHETIC. IRRITATION OF THE RESPIRATORY
TRACT, OR NERVOUS SYSTEM, DEPRESSION CHARACTERIZED BY HEADACHE, DIZZINESS,
NASEA, OR POSSIBLE UNCONSCIOUSNESS.SKIN OR EYE CONTACT: PRIMARY IRRITA TION.
PROLONGED OR REPEATED CONTACT TO SKIN MAY CAUSE DERMATITIS-EXERCISE DUE CARE.
Explanation Of Carcinogenicity: NTP? NO IARC MONOGRAPHS? NO OSHA REGULATED? NO
=======================================================
Handling and Disposal
=======================================================
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
Handling And Storage Precautions: DO NOT STORE ABOVE 120 DEG.F. DO NOT STORE OR
USE NEAR HEAT, SPARKS, OR FLAME.
Other Precautions: DO NOT GET IN EYES. DO NOT BREATHE VAPORS. AVOID SKIN
CONTACT. DO NOT TAKE INTERNALLY. SMOKING WHILE USING THIS PRODUCT MUST BE
STRICTLY PROHIBITED. IN ADDITION TO ALL OTHER HAZARDS AND PRECAUTIONS-DU ST
FROM SANDING THE DRY PAINT FILMS SHOULD BE TREATED AS A NUISANCE DUST WITH A
TLV OF 10MG/CUBIC ME TER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures: WATER SPRAY MAY BE INEFFECTIVE, BUT WATER SPRAY MAY
BE USED TO COOL CONTAINERS EXPOSED TO HEAT OR FIRE TO PREVENT PRESSURE BUILD
UP.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY EXPLODE DUE TO BUILD UP OF
PRESSURE FROM EXTREME HEAT OR FIRE.AEROSOL SPRAY IS EXTREMELY
FLAMMABLE.FLAMMABILITY-T.D.G.R. CLASS: CONSUMER COMMODITY ORM-D.
=======================================================
Control Measures
=======================================================
Respiratory Protection: OUTDOORS: WE RECOMMEND AN APPROVED PARTICULATE FILTER
TO REMOVE ANY AIRBORNE OVERSPRAY IN RESTRICTED AREAS WITH POOR VENTILATION
AND CLOSE TO THE T.L.V. INDOORS: A NIOSH APPROVED REPIRATOR WITH ORGANI C
VAPOR CARTRIDGE IS RECOMMENDED.
Ventilation: ALL APPLICATION AREAS SHOULD BE ADEQUATELY VENTILATED IN ORDER TO
KEEP THE INGREDIENTS IN SECTION11 BELOW THEIR EXPOSURE LIMITS.
CONTACT.
Other Protective Equipment: EYE WASH FOUNTAIN AND SAFETY SHOWER. IMPERVIOUS
APRON TO PREVENT SKIN CONTACT IS RECOMMENDED.
Work Hygienic Practices: AVOID PROLONGED OR REPEATED CONTACT.DO NOT BREATHE
VAPORS. WASH CONTAMINATED CLOTHING PRIOR TO RE-USE.
=======================================================
Physical/Chemical Properties
=======================================================
=======================================================
Reactivity Data
=======================================================
Stability Condition To Avoid: HIGH TEMPERTURES
Materials To Avoid: STRONG OXIDIZING AGENTS
Hazardous Decomposition Products: CO, CO2, HCL, AND POSSIBLY TRACES OF PHOSGENE
Conditions To Avoid Polymerization: WILL NOT OCCUR
=======================================================
HAZCOM Label
=======================================================
Product ID: POLYURETHANE AEROSOL COLORS
Cage: 58977
Company Name: PACIFIC WEST CHEMICAL CORP
Street: 337 SUMMIT DR
PO Box: 183
Zipcode: 94925-0183
Label Required IND: Y
Date Of Label Review: 04/18/2001
Status Code: A
Origination Code: G
Hazard And Precautions: INHALATION: ANESTHETIC. IRRITATION OF THE RESPIRATORY
TRACT, OR NERVOUS SYSTEM, DEPRESSION CHARACTERIZED BY HEADACHE, DIZZINESS,
NASEA, OR POSSIBLE UNCONSCIOUSNESS.SKIN OR EYE CONTACT: PRIMARY IRRITA TION.
PROLONGED OR REPEATED CONTACT TO SKIN MAY CAUSE DERMATITIS-EXERCISE DUE CARE.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:XUPER 16 XFC 3/32,E 1358
CAGE:72271
CAGE:72271
============= Composition/Information on Ingredients =============
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 30 - 40%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME; 9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 30 - 40%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 5 - 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9495
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG BORATES/M3
ACGIH TLV:5 MG BORATES/M3
Ingred Name:ACRYLIC OLIGOMER/RESIN
CAS:9003-01-4
RTECS #:AT4680000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT RELEVANT.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:LUNGS, EYES, SKIN.
ACUTE- NO HAZARD BEFORE WELDING. WELDING FUMES CAN CAUSE
IRRITATION, DIZZINESS, HEADACHE, NAUSEA, COUGH, CHEST PAINS, METAL
FUME FEVER, BODY ACHE, CHILLS, UNCONSCIOUSN ESS. ARC RAYS & UV CAN
INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN KILL. ORAL:MAY BE
HARMFUL/FATAL. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:CONTAINS NICKEL.
Effects of Overexposure:EYES, SKIN, RESPIRATORY TRACT IRRITATION,
DIZZINESS, WATERY EYES, HEADACHE, NAUSEA, BREATHING DIFFICULTY,
COUGHING, CHEST PAINS, FEVER, BODY ACHE, CHILLS. EYE INJURY, SKIN
BURNS, CONVULSION, MUSCULAR WEAKNESS, LOSS OF CONSCIOUSNESS
Medical Cond Aggravated by Exposure:PERSONS WITH IMPAIRED PULMONARY
FUNCTION, AIRWAY DISEASES AND CONDITIONS SUCH AS ASTHMA, EMPHYSEMA,
CHRONIC BRONCHITIS, ETC... CAN BE AGGRAVATED BY THE EXPOSURE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EMPLOY FIRST AID
TECHNIQUE RECOMMENDED BY RED CROSS. IF BREATHING IS DIFFICULT,
PROVIDE OXYGEN AND CALL PHYSICIAN. PROVIDE CPR IF NEEDED. FOR
ELECTRIC SHOCK, DISCONNECT POWER. FOR ARC BURNS, APPLYCOLD, CLEAN
COMPRESSES AND CALL A PHYSICIAN. IF IN EYES, FLUSH WITH WATER FOR
15 MINUTES. IF INGESTED, CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:WELDING ARC AND SPARKS CAN IGNITE
COMBUSTIBLES. SOME FLUXES AND CHEMICAL AIDS MAY GIVE OFF HYDROGEN
CHLORIDE, PHOSGENE AND CHLORINE GASES. CANS MAY EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. SWEEP UP OR VACUUM.
CAREFULLY TRANSFER INTO A SEALABLE WASTE CONTAINER. MINIMIZE
GENERATION OF DUST.
Neutralizing Agent:NOT RELEVENT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY, VENTILATED AREA AWAY
FROM ACIDS.
Other Precautions:AVOID BREATHING OF FUMES. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING AND
DRINKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED SUPPLIED AIR RESPIRATORY
PROTECTION OR RESPIRABLE FUME RESPIRATOR WHEN WELDING, BRAZING OR
SOLDERING IN CONFINED SPACE OR WHERE LOCAL EXHAUST OR VENTILATION
DOES NOT KEEP EXPOSURE B ELOW TLV.
Ventilation:LOCAL EXHAUST VENTILATION SHOULD BE USED TO CONTROL
EXPOSURE TO AIRBORNE FUMES WHENEVER POSSIBLE.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
NRC/State Lic Num:NOT RELEVENT
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVENT
Appearance and Odor:ELECTRODE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Hazardous Decomposition Products:COMPLEX OXIDES OF COPPER, ZINC,
NICKEL; OZONE, CARBON MONOXIDE, CARBON DIOXIDE, OXIDES OF NITROGEN
& CERTAIN INERT GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:PRIOR TO DISPOSAL, CONSIDER IF MATERIAL HAS
RECOVERY VALUE. DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS. PREVENT WASTE FROM CONTAMINATING ENVIRONMENT.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:COLD VULCANIZING FLUID, 207
CAGE:GO624
CAGE:GO624
CAGE:03795
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE, TRICHLORO-; (TRICHLOROETHYLENE) (SARA 313)
(CERCLA)
CAS:79-01-6
RTECS #:KX4550000
OSHA PEL:100 PPM
ACGIH TLV:50 PPM/100STEL, A5
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT:PRODUCED SENSIT OF THE MYOCARDIUM TO EPINEPHRINE IN
LAB ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS. (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:ADRENOMIMETICS (EG, EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY/
(ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:CHRONICALLY EXPOSED TO CHLOROCARBONS .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:TAKE IMMED TO HOSPITAL/MD. IF UNCON/IN
CONVLS, TAKE IMMED TO HOSPITAL. DO NOT ATTEMPT TO GIVE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:ANYTHING BY MOUTH TO AN UNCON PERS. NOTES TO MD:NEVER
ADMIN ADRENALINE FOLLOWING TRICHLOROETHYLENE OVEREXP.(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:INCREASED SENSITIVITY OF THE HEART TO ADRENALINE MAY
BE CAUSED BY OVEREXPOSURE TO TRICHLOROETHYLENE.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:SWEEP INTO APPRVD CONTRS FOR DISP. DO NOT FLUSH
TO SEWER. IF SPILLED INTO ENVIRONMENT, NOTIFY LOC & (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:STATE OFFICIALS IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:I/A/W CLEAN AIR ACT, CLEAN WATER ACT, RCRA,
AS WELL AS APPLIC FED, STATE & LOC REGS REGARDING DISPOSAL.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:SUPPLIES. HNDLG, STOR & USE PROC MUST BE
CAREFULLY MONITORED TO AVOID SPILLS &/LEAKS. ANY SPILL/LEAK (ING
13)
RTECS #:9999999ZZ
Ingred Name:ING 12:HAS POTENTIAL TO CAUSE UNDERGROUND WATER CONTAM
WHICH MAY, IF SUFFICIENTLY SEV, RENDER A DRINKING WATER (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:SOURCE UNFIT FOR HUMAN CONSUMPTION. DO NOT USE
CUTTING/WELDING TORCHES ON CONTRS USED TO STORE (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:VULCANIZING FLUID UNLESS EMPTIED & CLEANED. DO NOT
BREATHE VAPS. USE ONLY W/ADEQ VENT. VENT MUST BE (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:SUFFICIENT TO LIM EMPLOYEE EXPOS TO
TRICHLOROETHYLENE BELOW PERMISSIBLE LIMS. DO NOT EAT, DRINK/SMOKE
IN (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:WORK AREA. NO SMKNG IN AREA OF USE. DO NOT USE IN
GEN VICIN OF ARC WELDING, OPEN FLAMES/HOT SURFACES. (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:HEAT AND/OR UV RADIATION MAY CAUSE THE FORMATION OF
HCL AND/OR PHOSGENE .
RTECS #:9999999ZZ
Ingred Name:RESP PROT:ROOMS, & OTHER CONFINED AREAS. RESPIRATORY
PROTECTION PROGRAMS MUST BE IN ACCORDANCE WITH 29 CFR 1910.134.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT): 4900-7000 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL: CONTAINS ING KNOWN AS CNS
DEPRESS WHICH CAN CAUSE IRRIT OF RESP TRACT, DIZZ, NAUS, HDCH, LOSS
OF COORD & EQUILIBRIUM, POSS CNS DMG, UNCON & DEATH IN
CONFINED/POORLY VENTD AREAS. EYE:CAN R SLT IN DISCOMFORT, PAIN &
IRRIT. SKIN:PRLNG/RPTD CONT W/LIQ CAN CAUSE IRRIT & DERM.
INGEST:MAY RSLT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IN IRRIT OF MOUTH & GI TRACT ALONG
W/OTHER EFTS AS LISTED FOR INHAL. VOMIT & SUBSEQUENT ASPIR INTO
LUNGS MAY LEAD TO CHEM PNEUMONIA EDEMA WHICH IS A POTENTIALLY FATAL
CNDTN. CHRONIC:PRLNG EXP OS ABOVE OSHA PERMISSIBLE LIMS MAY RSLTIN
LIVER & KIDNEY DMG. TRICHLOROETHYLENE HAS BEEN EXTENSIVELY (SUP
DAT)
Medical Cond Aggravated by Exposure:RESPIRATORY ILLNESS, LIVER AND
KIDNEY DISEASES.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP, PREF
MOUTH-TO-MOUTH. IF BRTHG IS DFCLT, GIVE OXYGEN. CALL MD.
EYES/SKIN:FLUSH W/PLENTY OF WATER (SOAP & WATER FOR SKIN) FOR MIN
OF 15 MIN, WHIL E REMOVING CONTAM CLTHG & SHOES. IF IRRIT OCCURS,
CONSULT MD. THORO CLEAN CONTAM CLTHG & SHOES BEFORE REUSE/DISCARD.
INGEST:IF CONSCIOUS, DRINK LGE QTYS OF WATER. DO NOT INDUCE VOMIT.
(ING 6)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:8%
Upper Limits:52%
Extinguishing Media:CARBON DIOXIDE, WATER FOG, AND/OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED PRESSURE DEMAND SCBA AND
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPS CONC IN CONFINED/POORLY VENTD AREA
CAN BE IGNITED UPON CONT W/HIGH ENERGY SPK, FLAME/HIGH INTENSITY
SOURCE OF HEAT. THIS CAN OCCUR IN CONCS (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:LGE SPILL:IMMED EVACUATE AREA & PROVIDE MAX
VENT. UNPROT PERS SHOULD BE EVACUATED. WEAR PPE. DIKE AREA TO
CONTAIN SPILL. TAKE PREC AS NEC TO PVNT CONTAM OF GROUND & SURF
WATERS. RECOVER SPILLED MATL O N ABSORB SUCH AS SAWDUST/VERMICULITE
& (ING 9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE W/REASONABLE CARE. AVOID BRTHG
VAPS. STORE IN COOL PLACE, USING CLSD CONTRS THAT ARE LABELED I/A/W
STATE & FED REGS.
Other Precautions:CONC VAPS OF THIS PROD ARE HVR/AIR & WILL COLLECT IN
LOW AREAS. DO NOT ENTER AREAS WHERE VAPS OF THIS PROD ARE SUSPECTED
UNLESS SPECIAL NIOSH APPRVD BRTHG APPARATUS IS USED & AN OBSERVER
IS PRESENT FO R ASSIST. AVOID CONTAM OF WATER (ING 12)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED/IN EVENT OF SPILL, WEAR NIOSH
APPRVD RESP EQUIP FOR ORG VAPS. USE NIOSH APPRVD SCBA/FULL
FACEPIECE AIRLINE RESP W/AUXILIARY SCBA OPERATED IN PRESS DEMAND
MODE FOR WORK PERFORMED INSTOR VESSELS, POORLY VENTD (ING 19)
Ventilation:USE LOCAL EXHAUST OR DILUTION VENTILATION AS APPROPRIATE TO
CONTROL EXPOSURES TO BELOW PERMISSIBLE LIMITS.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
BOOTS, APRONS/CHEM SUITS SHOULD BE USED WHEN NEC TO PVNT SKIN
CONTACT.
Work Hygienic Practices:PERSONAL PROTECTIVE CLOTHING & USE OF EQUIPMENT
MUST BE IN ACCORDANCE WITH 29 CFR 1910.132 AND 29 CFR 1910.133.
Supplemental Safety and Health
EXPLO HAZ:RANGING BETWEEN 7.8%-52%. DECOMP/BURNING CAN PRDCE HYDROGEN
CHLORIDE/TRACES OF PHOSGENE. EFTS OF OVEREXP:STUDIED FOR CHRONIC
EFTS IN ANIMALS. WHILE THERE ARE STUDIES IN WHICH TUMORS WERE IND
UCED IN MICE, THERE IS NO EVIDENCE THATTRICHLOROETHYLENE POSES
CARCIN RISK TO HUMANS. CHLOROCARBON MATLS HAVE (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:198F,92C
Melt/Freeze Pt:M.P/F.P Text:-124F,-86C
Vapor Pres:57.8
Vapor Density:4.5
Spec Gravity:1.45 (H*2O=1)
Evaporation Rate & Reference:0.28 (ETHYL ETHER=1)
Solubility in Water:0.11%
Appearance and Odor:CLEAR, MOBILE LIQ W/MILDLY SWEET, ETHER-LIKE ODOR.
IRRIT ODOR AT HIGH TEMPS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES (CAUSTIC SODA, POTASH), OXIDIZERS.
Stability Condition to Avoid:AVOID EXTREME HEAT, OPEN FLAME AND WELDING
ARCS.
Hazardous Decomposition Products:HCL, PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAM ABSORB, SOIL, WATER MUST BE DISP OF IN
PERMITTED HAZ WASTE MANAGEMENT FACILITY. RECOVERED LIQ MAY BE
REUSED, REPROCESSED/MUST BE TREATED IN PERMITTED HAZ WASTE
MANAGEMENT FACILITY. IT IS YOUR D UTY TO DISP OF CHEM MATLS &/THEIR
CONTRS (ING 11)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ASBESTOS BRAKE PADS (AAMVA CODE: FIBRO-90-FG)
CAGE:0V8E2
CAGE:0V8E2
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS (FRIABLE)(SARA III)
CAS:1332-21-4
RTECS #:CI6425000
Fraction by Wt: 30-50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1001
ACGIH TLV:0.2 - 2 FIBERS/CC
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PHENOL FORMALDEHYDE RESIN
CAS:9003-35-4
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:GRAPHITE, NATURAL
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.5 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 5-20%
Other REC Limits:30 PPM/FT3
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:NOT HAZARDOUS BY INGESTION OR SKIN
ABSORPTION. ACUTE:NO IMMEDIATE REACTION TO OVER EXPOSURE, HOWEVER,
MAY CAUSE EYE AND/OR SKIN IRRITATION. CHRONIC:OVEREXPOSURE TO
OABESTOS DUST CAN CAUSE ASBESTOSIS , LUNG CANCER AND MESOTHELIOMA
OF PLURAAND PERITONEUM.
Explanation of Carcinogenicity:CONTAINS A [1332-21-4] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:ASBESTOS IS ASSOCIATED WITH SYMPTOMS OF LABORED
BREATHING, CHEST PAIN, WEAKNESS AND CHEST TIGHTNESS. SYMPTOMS ARE
USUALLY MANIFESTED 15-20 YEARS AFTER EXPOSURE.
Medical Cond Aggravated by Exposure:NO INFORMATION GIVEN ON MSDS BY
MFR.
======================= First Aid Measures =======================
First Aid:EYE CONTACT:INERT DUST. FLUSH WITH WTER. IF IRRITATION
DEVELOPS, CONSULT PHYSICIAN. SKIN CONTACT:INERT DUST. WASH WITH
SOAP AND WATER.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:CO2, WATER, FOAM, DRY CHEMICALS
Fire Fighting Procedures:WEAR MSHA/NIOSH APPROVED SELF-CONTAINED
BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CREATING AIRBORNE DUST. COLLECT DUST BY
ASBESTOS (HEPA) VACUUM OR BY WET SWEEPING OR WET WIPING.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:MAINTAIN GOOD HOUSEKEEPING PRACTICES
SUCH AS VACUUM CLEANING OR WET WIPING DUSTY SURFACES TO PREVENT
ACCUMULATION OF ASBESTOS CONTAINING DUST.
Other Precautions:EMPLOYEES SHOULD BE INSTRUCTED TO KEEP PROPER
PERSONAL HYGIENE. SMOKING GREATLY INCREASES RISK TO HEALTH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REUSEABLE OR SINGLE USE AIR PURIFYING RESPIRATOR
FOR EXPOSURE TO 10% OVER PEL. POWERED AIR PURIFYING RESPIRATOR FROM
10% TO 100% OVER PEL. TYPE "C" CONTINUOUS FLOW OR PRESSURE SUPPLIED
AIR RESPIRATOR FOR GREATER THAN 100% OVER PEL. SEE SUPP
Ventilation:LOCAL EXHAUST SYSTEM AND/OR DUST COLLECTION TO WITHIN TLV.
Other Protective Equipment:WHOLE BODY CLOTHING REQUIRED WHEN OSHA
CEILING CONCENTRATION OF 10 FIBERS/CC IS EXCEEDED.
Work Hygienic Practices:MFR: ?HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICE. AVOID ANY ACTIVITY WHICH RELEASES AIRBORNE ASBESTOS
FIBERS.
Supplemental Safety and Health
KEY2:KT FROM RESPIRATORY PROTECTION: ALL RESPIRATORS MUST BE NIOSH
APPROVED.
================== Physical/Chemical Properties ==================
HCC:T6
NRC/State Lic Num:NONE
Spec Gravity:2.0-2.2
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK GRAY SOLID. ODOR:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS DUE TO THE ORGANIC CONTENT.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:INCOMPLETE COMBUSTION MAY RELEASE
TOXIC MATERIALS. HMIS:MAY ALSO RELEASE ASBESTOS FIBERS
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN CLOSED, IMPERMEABLE BAG OR CONTAINER
AND LABEL PER CFR1910.1001. DISPOSE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PR-1750 CLASS B-2,PART A
Kit Part:Y
Preparer's Name:D.J.
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE DIOXIDE (AS MANGANESE)
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 5.0%
OSHA PEL:C,5 MG/M3/1 FUME TWA
ACGIH TLV:5 MG/M3 DUST/1 FUME
Ingred Name:TERPHENYLS HYDROGENATED
RTECS #:NZ6535000
Fraction by Wt: 3.0%
ACGIH TLV:0.2 PPM
Ingred Name:THIRAM (SARA III)
CAS:137-26-8
RTECS #:JO1400000
Fraction by Wt: <0.5%
OSHA PEL:5 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:UNKNOWN Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN:IRRITATION;INHALATION:NOT
SPECIFIED BY MANUFACTURER,BUT POSSIBLY LIGHT
HEAD,NAUSEA,HEADACHE,CHEMICAL PNEUMONIA,GIDDINESS,NOSE
IRRITATION;INGESTION:WEAKNESS & SLEEPINESS DUE TO MANGANESE POIS
ONING.
Explanation of Carcinogenicity:CARBON BLACK DEFINED AS CARCINOGEN BY
NIOSH WITH NO FURTHER CATEGORIZATION.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ANY MEDICAL CONDITION AFFECTING
SAME ORGANS AS THOSE AFFECTED BY OVEREXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LUKE WARM WATER FOR 15 MINUTES.IF SYMPTOMS
PERSIST,SEE DOCTOR;SKIN:WASH WITH SOAP AND WATER.IF SYMPTOMS
PERSIST,SEE DOCTOR;INHALATION:REMOVE TO FRESH AIR.IF SYMPTOMS
PERSIST,SEE DOCTOR ;INGESTION:SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:CO*2,DRY CHEMICAL,FOAM,WATER
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT MAY CAUSE DECOMPOSITION OF
MANGANESE DIOXIDE,RESULTING IN OXIDATION & POSSIBLE IGNITION OF
HYDROCARBON VEHICLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS.CLEAN UP RESIDUE WITH
1,1,1-TRICHLOROETHANE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN CLOSED CONTAINERS IN SHELTERED
AREA.
Other Precautions:AVOID INGESTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED. NIOSH-APPROVED RESPIRATOR IF TLV
IS EXCEEDED.
Ventilation:GENERAL (MECHANICAL) VENTILATION.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
SMOKING OR EATING.
Supplemental Safety and Health
USED F6X01 HAZARD CLASS FOR PRODUCTS WITH FLASH POINTS OVER 200F.
MANUFACTURER STATES PRODUCT IS NOT FLAMMABLE,HOWEVER,MANUFACTURER
STATES EXCESSIVE HEAT MAY CAUSE IGNITION OF HYDROCARBON VEHICLE.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.95
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK GRADE PASTE,SLIGHT SULFIDE ODOR
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS--PRODUCT CONTAINS EASILY OXIDIZABLE MATERIALS.
Stability Condition to Avoid:HEAT,SPARKS,OPEN FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON AND
NITROGEN,MANGANESE COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. DISPOSE OF IAW FEDERAL,STATE & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:7190, ASPHALT EMULSION
Preparer's Name:MSDS ADMINISTRATOR
CAGE:15445
CAGE:15445
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT; (PETROLEUM ASPHALT)
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 25-70%
ACGIH TLV:5 MG/M3 FUME
Ingred Name:SUPDAT:RPTD EXPOS OF SHAVED SKIN WHICH WAS NEVER WASHED
FREE OF TEST MATL. THE REAL HLTH RISK FOR ANY CHEM EXPOS (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:IS RELATED TO DEGREE OF EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
CALL MD. NOTE TO MD:ACTIVATED CHARCOAL SLURRY MAY (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:BE ADMIN. TO PREPARE ACTIVATED CHARCOAL SLURRY,
SUSPEND 50 GRAMS ACTIVATED CHARCOAL IN 400ML WATER & (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:MIX THORO. ADMIN 4 ML/KG OR 350 ML FOR AN AVERAGE
ADULT.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:OTHER ABSORBENT MATERIAL. SHOVEL OR SWEEP UP.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEATED PROD MAY CAUSE IRRIT TO EYES,
SKIN & LUNGS AFTER PRLNGD/REPEATED EXPOS; HOT ASPHALT CAN CAUSE
THERM BURNS & UNHEATED ASPHALT CAN CAUSE IRRIT. OVEREXPOS TO FUMES
OF HEATED PROD SHOULD BE AVOIDED . IARC CONCLUDED THAT MOUSE SKIN
PAINTING STUDIES SHOWED THAT EXTRACTS OF ASPHALT CAUSES SKIN (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:TUMORS. HOWEVER, THESE EXTRACTS WERE
DERIVED BY USING BENZENE/TOLUENE AS SOLVENT & RESULTING EXTRACT
DOES NOT REALISTICALLY CHARACT ASPHALT TO WHICH HUMANS ARE EXPOS.
THE SAME CRITICISM APPLI ES TO RECENT STUDIES WHERE ROOFING ASPHALT
FUME CONDENSATE/ STEAM-REFINED ASPHALT CAUSED SKIN CANCER IN
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTIF RESP. IF
BRTHG IS DFCLT, GIVE O2. CALL MD. SKIN:IMMED WASH W/ SOAP & WATER.
WASH CONTAM CLTHG BEFORE REUSE. IF EXPOS TO HOT MATL, COOL IMMED
W/COLD WATER. DO NOT ATTEMPT TO REMOVE MATL. CONSULT MD.
EYES:IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN. CALL MD.
INGEST:DO NOT INDUCE VOMIT. IMMED GIVE 2 GLASSES OF WATER. NEVER
GIVE (ING 4)
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING MATERIALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
STEAM MAY EVOLVE IN FIRE SITUATION. IF ALL WATER IS BOILED OFF,
MATL WILL EXHIBIT PROPERTIES OF (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP PERSONNEL REMOVED AND UPWIND OF
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROP PERSONAL PROT EQUIP DURING CLEANUP.
DIKE SPILL. PREVENT LIQ FROM ENTERING SEWERS, WATERWAYS/LOW AREAS.
RECOVER FREE LIQ FOR REUSE/RECLAMATION.RECOVER UNDMG & MIN CONTAM
MATL FOR REUSE/RECLA MATION. SOAK UP W/SAWDUST, SAND, OIL DRY/(ING
7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE OVER 180F NOR USE A
HEATING SURF OVER 200F AT SEA LEVEL.
Other Precautions:REFER TO FOLLOWING PUBLICATIONS ENTITLED "SAFE
STORAGE & HANDLING OF HOT ASPHALT", THE ASPHALT INSTITUTE,
INFORMATION SERIES NO 180, AUGUST 1981.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELECT APPROP NIOSH/MSHA APPRVD RESP PROT WHERE
NEC TO MAINTAIN EXPOS BELOW ACCEPTABLE LIMS. PROPER RESP SELECTION
SHOULD BE DETERMINED BY ADEQ TRAINED PERSONNEL & BASED ON CONTAM,
DEGREE OF POTENTIAL EXPOS & PUB RESP PROT FACTORS.
Ventilation:NORMAL VENT UNLESS VAPS/FUME CONC ARE HIGH, THEN MECHANICAL
VENT SHOULD BE USED.
Other Protective Equipment:COMPLETE PROTECTIVE CLOTHING IF MATERIAL IS
Work Hygienic Practices:CLEAN EXPOSED SKIN WITH WATERLESS HAND CLEANER
FOLLOWED BY SOAP & WATER. LAUNDER CONTAMINATED CLOTHING.
Supplemental Safety and Health
FIRE FIGHT PROC:ASPHALT. SEE ASPHALT MSDS FOR FURTHER INFO. EFTS OF
OVEREXPOS:SIMILAR MOUSE PAINTING STUDIES. THESE ANIMAL DATA SHOULD
BE INTERPRETED CAUTIOUSLY SINCE HLTH EFTS MAY BE DEPENDENT ON VAR
IABLES SUCH AS SOLV EXTRACTION/SOLV DILUTION, SOURCE OF CRUDE OIL,
MFG PROCESS & THAT THESE STUDIES INVOLVED (ING 2)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1 (H2O = 1)
Solubility in Water:DILUTES WITH WATER.
Appearance and Odor:BROWN TO BLACK LIQUID OR SEMISOLID WITH PETROLEUM
HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:TO AVOID FOAMING, DO NOT HEAT TO BOILING
POINT (212F @ SEA LEVEL).
Hazardous Decomposition Products:HAZ GASES/VAPORS PRODUCED ARE CO, CO2
& SO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:TREATMENT, STORAGE, TRANSPORTATION AND DISPOSAL
MUST BE IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE/PROVINCIAL &
LOCAL REGULATIONS. DO NOT FLUSH TO SURFACE WATER OR SANITARY SEWER
SYSTEM.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:850 INSULATION BOARD
CAGE:02746
CAGE:02746
============= Composition/Information on Ingredients =============
Ingred Name:FIBROUS (FIBER) GLASS, OXIDE GLASS, GLASS FIBERS
RTECS #:LK3651000
Fraction by Wt: 58-97%
Other REC Limits:3000000 FB/CUM
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:UREA EXTENDED PHENOL FORMALDEHYDE RESIN CURED *93-1*
CAS:25104-55-6
Fraction by Wt: 3-17%
Ingred Name:PARAFFIN WAX FUME, PARAFFIN
CAS:8002-74-2
RTECS #:RV0350000
Fraction by Wt: 7%
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM
Ingred Name:ETHYLENE-VINYL ACETATE COPOLYMER
(ACETIC ACID ETHENYL ESTER, POLYMER W/ETHENE) *93-1*
CAS:24937-78-8
Fraction by Wt: 11%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE: TEMPORARY IRRITATION.
INHALATION: TEMPORARY UPPER RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:GLASS WOOL IS A 2B POSSIBLE HUMAN
CARCINOGEN.
Medical Cond Aggravated by Exposure:CONDITIONS WHICH MAY BE AGGRIVATED
BY MECHANICAL IRRITANTS UPON INHALATION OR SKIN CONTACT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. EYE: FLUSH WELL W/RUNNING
WATER FOR 15 MINS. SKIN: CLEANSE W/SOAP & WATER. INGESTION:
UNLIKELY. OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTE TO PHYSICIAN:
SKIN IRRITAT ION RESPONDS WELL TO A MILD HYDROCORTISONE CREAM.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE THAT WHICH IS APPLICABLE TO SURROUNDING FIRE.
Fire Fighting Procedures:TREAT AS RESIDENTIAL BUILDING MATERIALS.
Unusual Fire/Explosion Hazard:FACINGS MAY BURN, DON'T LEAVE FACINGS
EXPOSED WHEN WORKING CLOSE TO AN OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM DUST DEPOSITS/CLEAN WITH WET METHODS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UNDER COVER TO PROTECT PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROPER NIOSH/MSHA RESPIRATOR, SUCH AS: 3M 8710,
3M 9900, MSA ULTRA TWIN FULL FACE W/TYPE H FILTER (HEPA).
Ventilation:GENERAL &/OR LACAL EXHAUST TO CONTROL AIRBORNE DUST LEVELS
BELOW EXPOSURE LIMITS.
Other Protective Equipment:LONG SLEEVES, CAP
Work Hygienic Practices:WASH WORK CLOTHES SEPARATELY AND RINSE WASHER
AFTER USE. BATHE W/SOAP & WARM WATER.
Supplemental Safety and Health
PHYSICAL DATA FOR BOILING POINT, MELTING POINT & SPECIFIC GRAVITY ARE
FOR GLASS. PRODUCT MAY BE FACED W/KRAFT/ALUMINUM FOIL/VINYL OR A
COMBINATION THEREOF/SOME PRODUCTS MAY HAVE A COATING/CONTAIN A PH
ENOLIC-BASED BINDER; BINDER & KRAFT FACINGS MAY EMIT TOXIC
FUMES/SMOKE WHEN THERMALLY DECOMPOSING OR IN FIRE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>2550F
Melt/Freeze Pt:M.P/F.P Text:2550F
Spec Gravity:2.5
Solubility in Water:SLIGHT
Appearance and Odor:YELLOW FIBERS, RESIN ODOR. ASSEMBLED INTO
TUBES/BLANKETS/BOARDS (SEE SUPP).
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID
Hazardous Decomposition Products:CO, CO2, HYDROGEN CHLORIDE, HYDROGEN
FLUORIDE & SULFUR DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:SCRAP MATERIAL SHOULD BE DISPOSED OF IN A
SANITARY LANDFILL IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS. WASTE IS NOT HAZARDOUS AS DEFINED BY RCRA (40 CFR
261).
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DELRIN ACETAL RESIN, 900D NC010
Preparer's Name:J.B. ARMITAGE
CAGE:18897
CAGE:18897
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:ADDITIVES:ANTIOXIDANTS, LUBRICANTS & STABILIZERS.
Ingred Name:POLYOXYMETHYLENE, POLYACETAL
CAS:9002-81-7
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST:NOT A PROBABLE ROUTE OF
EXPOSURE. SKIN:NOT TOXIC. HOT POLYMER WILL CAUSE THERMAL BURNS.
EYE:MECHANICAL IRRITATION. INHAL:FORMALDEHYDE IS HIGHLY IRRITATING
TO EYES & UPPER RESP TRACT. CHRO NIC:FORMALDEHYDE RELEASED IN SMALL
QUANTITY DURING MELT PROCESSING IS CLASSIFIED AS ANIMAL CARCINOGEN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:PERSONS W/PRE-EXISTING DISEASES OF
LUNGS MAY HAVE INCREASED SUSCEPTIBILITY TO TOXICITY OF EXCESSIVE
EXPOSURE TO FORMALDEHYDE.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. CALL MD IF SYMPTOMS PERSIST.
EYES:FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN. CALL MD IF
SYMPTOMS PERSIST. SKIN:IF MOLTEN POLYMER CONTACTS SKIN, COOL
RAPIDLY W/COLD WATER. DO NOT ATTEMPT TO PEEL POLYMER FROM SKIN.GET
MD FOR THERMAL BURN. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:612F,322C
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . PROTECTION FROM FUMES OF FORMALDEHYDE.
Unusual Fire/Explosion Hazard:BURNS W/COLORLESS FLAME. DELRIN DUST
CLOUD IGNITION TEMPERATURE 440C.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP TO PREVENT SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DRY STORAGE. KEEP CNTNRS CLOSED TO
PREVENT CONTAM. OPEN CNTNRS ONLY IN WELL-VENT AREA. READ "SAFETY
PRECAUTIONS TO OBSERVE WHEN HANDLING (SUPP DATA)
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR IF LOCAL EXHAUST
VENTILATION DOES NOT KEEP FORMALDEHYDE CONCENTRATION BELOW 1 PPM.
Ventilation:LOCAL EXHAUST AT PROCESSING EQUIPMENT.
Other Protective Equipment:LONG SLEEVE COTTON SHIRT & LONG PANTS IF
HANDLING MOLTEN POLYMER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FL PT METH:ASTM 1929-62. HAZ DECOMP PROD:SHORT TERM EXPOSURE LIMIT OF 2
PPM (15-MIN). HNDLG/STOR PREC:MOLTEN DELRIN ACETAL RESIN" E-49703 &
"SAFETY PRECAUTIONS" IN MOLDING MANUAL E-09143, BEFORE USING
DELRIN. AVOID PROLONGED HEATING ABOVE MELTING POINT (178C).
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:342F,172C
Spec Gravity:1.42
Solubility in Water:INSOLUBLE.
Appearance and Odor:GRANULES OR POWDER, SLIGHT FORMALDEHYDE ODOR.
================= Stability and Reactivity Data =================
STRONG ACIDS AND BASES (DECOMPOSES FORMING FORMALDEHYDE). STRONG
OXIDIZING AGENTS.
Stability Condition to Avoid:HEATING ABOVE 230C FORMS FORMALDEHYDE.
Hazardous Decomposition Products:CO. FORMALDEHYDE IS CLASSIFIED AS
ANIMAL CARCINOGEN & HAS OSHA PERMISSIBLE EXPOS LIM OF 1 PPM (8-HR
TWA), & (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION OR LANDFILL IN COMPLIANCE
W/FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PENTANE, 9331
CAGE:HO851
CAGE:HO851
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:PENTANE
CAS:109-66-0
RTECS #:RZ9450000
Fraction by Wt: 98-100%
OSHA PEL:1000 PPM
ACGIH TLV:600 PPM/750STEL;9495
Ingred Name:SPILL:COLLECT LIQ IN APPROP CNTNR/ABSORB W/INERT
MATL(E.G.,VERMICULITE, DRY SAND, EARTH), & PLACE IN A CHEM (ING 3)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 2:WASTE CNTNR. DO NOT USE COMBUST MATLS, SUCH AS SAW
DUST. DO NOT FLUSH TO SEWER! IF LEAK/SPILL HAS NOT (ING 4)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 3:IGNITED, USE WATER SPRAY TO DISPERSE VAPS, TO PROT
PERSONNEL ATTEMPTING TO STOP LEAK, & FLUSH SPILLS AWAY (ING 5)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 4:FROM EXPOS. J.T. BAKER SOLUSORB(TM) SOLVENT ABSORBENT
IS RECOM FOR SPILLS OF THIS PROD.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHER PREC:UNLESS CONTENTS ARE @ ROOM TEMP (72F)/BELOW.
ALLOW @ LST 24 HRS FOR MATL TO COOL TO ROOM TEMP (ING 7)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 6:BEFORE OPENING CNTNR. CNTNRS OF THE MATL MAY BE HAZ
WHEN EMPTY SINCE THEY RETAIN PROD RESIDUES (VAPORS,LIQ)(ING 8)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 7:OBSERVE ALL WARNINGS AND PRECAUTIONS LISTED FOR THE
PRODUCT.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VENT:IS GENRLY PREF BECAUSE IT CAN CONTROL THE EMISSIONS OF
CONTAMINANT AT ITS SOURCE, PVNTG DISPERSION OF IT (ING 10)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 9:INTO THE GENRL WORK AREA. PLEASE REFER TO THE ACGIH
DOCUMENT, INDUST VENT, A MANUAL OF RECOMND PRACTICES,(ING 11)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 10:MOST RECENT EDITION, FOR DETAILS.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WASTE DISP METH:DISP REGULATIONS. DISPOSE OF CONTAINER &
UNUSED CONTENTS IN ACCORD W/FED, STATE AND LOCAL REQUIREMENTS.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL: VAPS HAVE MILD NARC EFT.
SYMPS OF OVEREXP MAY INCLUDE DROW & IRRIT OF RESP PASSAGES. GREATER
EXPOS MAY CAUSE UNCON & DEATH. INGEST: TENDS TO VAPORIZE WHEN
SWALLOWED CAUSING ASPIR INTO LUN GS. THE RESULT CAN BE A RAPID FALL
IN OXYG CONTENT W/ASPHYXIA & CONSEQUENT BRAIN DMG/CARDIAC ARREST.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: SKIN CNTCT: CAUSES IRRIT,
CRACKING/FLAKING DUE TO DEHYDRATION & DEFATTING ACTION. EYE CNTCT:
VERY HIGH VAP CONC & LIQ MAY CAUSE IRRIT, REDNESS, & PAIN. CHRONIC
EXPOS: PRLNG SKIN CNTCT MAY CA USE DRYING, CRACKING & DERM.
Medical Cond Aggravated by Exposure:PERSONS W/PRE-EXISTING SKIN
CONDITIONS/IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE TO
THE EFFECTS OF THIS SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMIT. GIVE LRG QTIES OF WATER. NEVER
GIVE ANYTHING BY MOUTH TO UNCON PERS. CALL MD IMMED. INHAL:REMOVE
TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG DFCLT, GIVE
OXYG. CALLMD. EYES:WASH THOROUGHLY W/RUNNING WATER AT LST 15
MINS. GET MED ADVICE IF IRRIT DEVELOPS. SKIN:REMOVE CONTAM CLTHING.
WASH W/SOAP/MILD DETERGENT & WATER FOR @ LST 15 MINS. WASH CLTHS
BEFORE (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:-56F,-49C
Lower Limits:1.5%
Upper Limits:7.8%
Extinguishing Media:DRY CHEMICAL, FOAM/CARBON DIOXIDE. WATER MAY BE
INEFFECTIVE. WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CNTNRS
COOL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . THIS HIGHLY FLAMM LIQ MUST BE KEPT FROM SPARKS, OPEN
FLAME, HOT SURFACES & ALL SOURCES (SUP DAT)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM LIQ AND VAPOR! VAPOR MAY
CAUSE FLASH FIRE. ABOVE FLASH POINT, VAPOR-AIR MIXTURES ARE
EXPLOSIVE W/IN FLAMM LIMITS NOTED ABOVE. (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA OF LEAK/SPILL. REMOVE ALL SOURCES OF
IGNIT. WEAR APPROPRIATE PPE AS SPECIFIED IN SEC 8. ISOLATE HAZ
AREA. KEEP UNNECESSARY & UNPROTECTED PERSONNEL FROM ENTERING. CNTN
& RECOVER LIQ WHEN POSS IBLE. USE NON-SPARKING TOOLS & EQUIP. (ING
2)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROT AGAINST PHYSICAL DMG. STORE IN
COOL, DRY WELL-VENT LOC, AWAY FROM ANY AREA WHERE FIRE HAZ MAY BE
ACUTE. OUTSIDE/DETACHED STOR PREFERRED.
Other Precautions:SEPARATE FROM IMCOMPATIBLES. CNTNRS SHOULD BE BONDED
& GROUNDED FOR TRANSFERS TO AVOID STATIC SPARKS. STOR & USE AREAS
SHOULD BE NO SMKNG AREAS. USE NON-SPARKING TYPE TOOLS & EQUIP,
INCLUDING EXPLO PR OOF VENT. DANGER! DO NOT OPEN (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE EXPOS LIM IS EXCEEDED, WEAR A NIOSH
SUPPLIED AIR, FULL-FACEPIECE RESPIRATOR, AIRLINED HOOD, OR
FULL-FACEPIECE SELF-CONTAINED BRTHG APPARATUS. THIS SUBSTANCE HAS
QUESTIONABLE WARNING PROPERTIES.
Ventilation:A SYSTEM OF LOC AND/OR GEN EXHST IS RECOM TO KEEP EMPLOYEE
EXPOS BELOW THE AIRBORNE EXPOS LIM. LOC EXHST VENT (ING 9)
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . IMPERVIOUS BOOTS, APRON/COVERALLS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:OF HEAT & IGNIT. VAPOR EXPLO HAZ EXISTS INDOORS,
OUTDOORS/IN SEWERS. UNUSUAL FIRE/EXPLO HAZ:VAPS CAN FLOW ALONG
SURFACES TO DIST IGNIT SOURCE & FLASH BACK. SENSITIVE TO STATIC
DISCHARG E. FIRST AID:REUSE. GET MED ATTN IF IRRIT
DEVELOPS/PERSIST.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:96.8F,36.0C
Melt/Freeze Pt:M.P/F.P Text:-202F,-130C
Vapor Pres:426 @ 20C
Vapor Density:2.5
Spec Gravity:0.63
Evaporation Rate & Reference:28.6 (BUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, COLORLESS SOLUTION. MILD GASOLINE-LIKE ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT, FLAMES, IGNITION SOURCES AND
INCOMPATIBLES.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE MAY
FORM WHEN HEATED TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY/RECYCLING
SHOULD BE HNDLD AS HAZ WASTE & SENT TO RCRA APPRVD WASTE FACILITY.
PROCESSING, USE/CONTAM OF THIS PROD MAY CHANGE THE WASTE MANAGEMENT
OPTIONS. STATE & LOC DISP REGS MAY DIFFER FROM FED (ING 12)
| 1 |
gloves_mandatory
|
=======================================================
Product ID: KELTAN EPDM OIL EXTENDED POLYMERS, GRADES 5531D, P558, P597
Cage: TO966
Box: 2591
Resp. Party Other MSDS No.: KEL5531B
=======================================================
Contractor Summary
=======================================================
Cage: TO966
Box: 2591
=======================================================
Ingredients
=======================================================
Percent by Wt: 67.
-----------------------------
Cas: 64741-88-4
RTECS #: PY8040500
Percent by Wt: 54.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50 = NE; LC50 =NA
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NO ACUTE OR CHRONIC HAZARDS OR EFFECTS KNOWN. EYE: NOT A
PROBABLE ROUTE OF EXPOSURE. PARTICULATES MAY SCRATCH EYE SURFACE/CAUSE MILD
IRRITATION. SKIN: SINGLE PROLONGED EXPOSURE NOT LIKELY TO RESULT IN MATL
BEING ABSORBED THRU SKIN IN HARMFUL AMOUNTS. REPEATED/PROLONGED EXPOSURE MAY
CAUSE MILD SKIN IRRITATION IN SOME INDIVIDUALS. EXPOSURE TO HOT MATL MAY
CAUSE THERMAL BURNS. INGESTION: NOT A PROBAB LE ROUTE OF EXPOSURE.
INHALATION: NOT A PROBABLE ROUTE OF EXPOSURE UNDER CONDITIONS OF NORMAL USE.
HOT FUMES OR VAPORS THAT MAY FORM DURING PROCESSING OR BURNING CAN CAUSE
IRRITATION TO RESPIRATORY TR ACT.
Explanation Of Carcinogenicity: THIS PARTICULAR GRADE OF PARAFFINIC OIL IS THE
SEVERELY SOLVENT REFINED HEAVY PARAFFINIC DISTILLATE, CAS #64741-88-4. IT
CONTAINS LESS THAN 0.1 WEIGHT PERCENT POLYNUCLEAR AROMATIC COMPOUNDS AND
THEREF ORE IS NOT CONSIDERED AS CARCINOGENIC UNDER HAZARD COMMUNICATION
STANDARD TITLE 29 CFR 1910.1200.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: SOME INDIVIDUALS W/SPECIFIC SENSITIVITIES
MAY EXHIBIT EYE, NOSE, THROAT OR THERMAL IRRIT W/PROLONGED EXPOSURE TO FUMES.
INDIVIDUALS W/PRE-EXISTING SKIN DISORDERS SHOULD AVOID CONTACT W/THIS
MATERIAL.
First Aid: EYE: REMOVE AS FOR ANY FOREIGN OBJECT. FLUSH WITH CLEAN WATER FOR AT
LEAST 15 MINUTES. OBTAIN MEDICAL ATTENTION IF IRRITATION PERSISTS. SKIN: WASH
W/SOAP & H2O. IF THERMAL IRRITATION, FLUSH AFFECTED A REA W/COLD WATER TO
DISSIPATE HEAT, THENCOVER W/CLEAN COTTON SHEETING OR GAUZE AND GET PROMPT
MEDICAL ATTENTION. INHALATION: IF FUMES/VAPORS ARE INHALED, MOVETO FRESH AIR,
AID BREATHING IF NECESSARY. OBTAIN MEDICAL ATTENTION IF IRRITATION PERSISTS.
INGESTION: UNLIKELY TO OCCUR.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REPACKAGE UNCONTAMINATED RUBBER. REUSE OR DISPOSE
ACCORDING TO DISPOSAL INSTRUCTIONS.
Waste Disposal Methods: REUSE IF POSSIBLE. MATERIAL AS SUPPLIED IS NOT
CHARACTERIZED AS HAZARDOUS UNDER RCRA. DISPOSE IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS AND APPLICABLE ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: STORAGE: STORE BELOW 35C (95F) IN DRY AREA
AND IN THE ABSENCE OF DIRECT, NATURAL OR ARTIFICIAL LIGHT. HANDLING: AVOID
SKIN/EYE CONTACT, PRACTICE GOOD PERSONAL HYGIENE. AVOID INHALATION OF
FUMES/VAPORSFROM HOT RUBBERS/COMPOUNDS/VULCANIZATES.
Other Precautions: (CONTROL MEASURES)-EXPOSURE GUIDELINES: RESPIRABLE DUST FOR
PETROLEUM HYDROCARBON OIL (AS MIST): PEL (OSHA): 5.0 MG/M3. TLV (ACGIH): 5.0
MG/M3. REMARKS: NOTES 1 (OTHER INFO SEC.), 2 & 3 (TOXICOLOGICAL SEC.).
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point: =240.C, 464.F
Flash Point Text: SEE NOTE 2-TOX).
Autoignition Temp: =385.C, 725.F
Autoignition Temp Text: EST.
Lower Limits: NA
Upper Limits: NE
Extinguishing Media: ALL FIRE EXTINGUISHING MEDIA PERMITTED - FOAM OR WATER FOG
RECOMMENDED.
Fire Fighting Procedures: DURING EMERGENCY CONDITIONS, EXPOSURE TO THERMAL
DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. USE OF A NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS IS RECOMMENDED.
Unusual Fire/Explosion Hazard: COMBUSTIBLE: NO, BUT THE PRODUCT WILL BURN IF
IGNITED. HAZARDOUS COMBUSTION PRODUCTS: CARBON MONOXIDE, CARBON DIOXIDE,
PRODUCTS FROM INCOMPLETE COMBUSTION, SILICATES, AND VARIOUS HYDROCARBONS.
SENSITI VITY TO STATIC DISCHARGE/IMPACT/SHOCK: NA.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY REQUIRED AT AMBIENT TEMPERATURES. IF
PROCESING IN AREA WHERE VENT IS INADEQUATE OR IGNITION HAS OCCURRED, WEAR A
NIOSH APPROVED ORGANIC VAPOR RESPIRATOR WITH MECHANICAL FILTRATION.
Ventilation: LOCAL EXHAUST VENTILATION IS RECOMMENDED DURING ALL HOT PROCESSING
OPERATIONS.
(SEE WORK HYGIENE)
Other Protective Equipment: EYEWASH/DELUGE SHOWER MEETING ANSI DESIGN CRITERIA
(FP N). WEAR CLOTHING APPROPRIATE TO PREVENT SKIN CONTACT.
PROTECTION, AND A FACE SHIELD.
Supplemental Safety and Health: CHEMICAL NAME: ETHYLENE, PROPYLENE, ETHYLIDENE
NORBOMENE, TERPOLYMER RUBBER, OIL EXTENDED. CAS NUMBER: MIXTURE-NA. CAS NAME
(RUBBER ONLY): BICYCLO(2,2,1-)HEPT-2-ENE, 5-ETHYLIDENE, POLYMER W/ETHENE
& 1 -PROPENE. PRODUCT USE: RUBBER AND MODIFIED ARTICLES. COEFFICIENT IN
WATER/OIL DISTRIBUTION: NE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: NA
M.P/F.P Text: NA
Vapor Pres: NA
Vapor Density: NA
Spec Gravity: 0.86-0.87
Solubility in Water: INSOLUBLE
Appearance and Odor: PALE YELLOW TO AMBER. PHYSICAL STATE: BALES. ODOR: NONE TO
SLIGHT.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT (65.5C, 150F MAX) WILL CAUSE THERMAL
DECOMPOSITION; IGNITION SOURCE. PRODUCT IS STABLE AT AMBIENT TEMPERATURE AND
PRESSURE.
Materials To Avoid: NONE KNOWN.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, VARIOUS
HYDROCARBONS AND PARTIALLY OXIDIZED HYDROCARBONS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: REPRODUCTIVE EFFECTS/MUTAGENICITY/TETRAGENICITY:
NONE REPORTED. NOTE 2: THIS DATA REPRESENTS LOWEST POSSSIBLE LIMIT & IS
FOR PETROLEUM OIL INGREDIENT IN PRODUCT. PETROLEUM OIL IS SOLUBLE IN EPDM
COMPO NENT & DATA ON BLEND NOT BEEN ESTABLISHED. NOTE 3: SPECIFIC EXPOS
STANDARDS FOR PRODUCTS/THEIR COMPONENTS NOT BEEN ESTABLISHED. LIMITS SHOWN
ARE SUGGESTED MINIMUM CONTROL GUIDELINES. THESE EXPOS LIMIT S APPLY ONLY IF
AEROSOLS EMITTED FROM PRODUCTS. (ECOLOGICAL).
=======================================================
Ecological Information
=======================================================
Ecological: (TOX): NOTE 4: SEVERELY REFINED HEAVY PETROLEUM OIL, WHEN
INCORPORATED INTO RUBBER IN FORM DELIVERED, IS NO LONGER BELIEVED TO BE A
HAZ BY DSM ELASTOMERS UNLESS SUBJECTED TO FIRE/EXCESSIVE HEAT/OR SE VERE
GRINDING GENERATING PARTICULATE MATTER OR AEROSOLS WHICH BECOME AIRBORNE.
(STATE): LC50: CONCENTRATION IN AIR THAT CAUSES DEATH IN 50% OF ANIMALS
EXPOSED. LD50: DOSE THAT CAUSES DEATH IN 50% OF A NIMALS EXPOS. MG/M3:
MILLIGRAMS(MG) OF SUBSTANCE PER CUBIC METER (M3) OF AIR; METHOD OF EXPRESSING
CONCENTRATION OF A SUBSTANCE IN AIR. (TRANSP).
=======================================================
=======================================================
Transport Information: U.S. D.O.T: DESIGNATION & LABELING ARE NOT
APPLICABLE, AS PROD ARE NOT DEFINED OR DESIGNATED AS A HAZ MATL BY U.S.
DEPARTMENT OF TRANSPORTATION UNDER TITLE 49 OF CFR. CANADA: THESE PRODUCTS
ARE NOT RE GULATED UNDER CANADIAN TRANSPORTATION OF DANGEROUS GOODS
REGULATIONS. IATA: PRODUCTS NOT REGULATED UNDER INTERNATIONAL AIR TRANSPORT
ASSOC DANGEROUS GOODS REGULATIONS. LABELS: OSHA/W: NOT REQUIRE D. (ECOLOG):
IATA: INTERNATION AIR TRANSP ASSOC. NIOSH: NATL INSTITUTE FOR OCCUPATIONAL
SAFETY/HEALTH.
OSHA: OCCUPATIONAL SAFETY/HEALTH ADMIN. SARA: SUPERFUND AMENDMENTS &
REAUTHORIZATION ACT. W: WORKPLACE HAZ MATL INFO SYS.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SECTION 302/304: EXTREMELY HAZ SUBSTANCES - NONE.
SECTION 311: HAZ SUBSTANCES - NOT APPLICABLE. SECTION 313: PRODUCT NOT
SUBJECT TO REPORTING REQUIREMENTS. CEPA: COMPONENTS OF THESE PRODUCTS ARE
INCLU DED IN CANADA'S DSL. EC: THE EUROPEAN COMMISSION DOES NOT CONSIDER
PRODUCTS HAZARDOUS. W: PRODUCTS NOT CONSIDERED CONTROLLED PRODUCTS UNDER
CANADA'S WORKPLACE HAZARDOUS MATERIAL INFORMATION SYSTEM .
Federal Regulatory Information: OSHA: FOLLOWING INGREDIENTS INPRODUCT ARE
REGULATED INDIVIDUALLY AS HAZARDOUS MATERIALS UNDER OSHA HAZ COMMUNICATION
STANDARD 29CFR 1910.1200. THE PETROLEUM HYDROCARBON OIL-COMPONENT IF PRESENT
AS A N OIL MIST. (SEE NOTE 4). FDA: THESE GRADES ARE APPROVED FOR USE IN
COMPLYING WITH 21 CFR 177.2600, "RUBBER ARTICLES FOR REPEATED USE." 5531D,
P558, P597 . TSCA: COMPONENTS OF THESE PRODUCTS ARE LISTE D UNDER TSCA
CHEMICAL SUBSTANCE INVENTORY.
=======================================================
Other Information
=======================================================
Other Information:: HEALTH -1, FLAMMABILITY -1, REACTIVITY -0. E-MAIL:
CORPSHE@DSMCOPO.COM.ODOR THRESHOLD: NE. VOLATILES (% BY WEIGHT, 2 105C0:
0.75 MAX. EPDM: HAZ CLASSIFICATION - NH. SEVERELY REFINED HEAVY PETR OLEUM
OIL: HAZ CLASSIF- NH. IGNITION TEMP: ABOVE 200C, 392F. COEFFICIENT IN
WATER/OIL DISTRIBUTION: NE. MSDS SUPERSEDES 10/15/98. EXPOSURE GUIDELINES:
RESPIRABLE DUST - PETROLEUM HYDROCARBON OIL (AS M IST): PEL(OSHA) 5.0 MG/M3;
TLV(ACGIH) 5.0 MG/M3. REMARKS - NOTES 1,2 & 3.
=======================================================
HAZCOM Label
=======================================================
Product ID: KELTAN EPDM OIL EXTENDED POLYMERS, GRADES 5531D, P558, P597
Cage: TO966
Assigned IND: Y
Company Name: DSM ELASTOMERS CORPORATE ENVIRONMENTAL HEALTH AND SAFETY
Street: 5955 SCENIC HIGHWAY
PO Box: 2591
Zipcode: 70821-2591
Label Required IND: Y
Date Of Label Review: 11/07/2000
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE/CHRONIC: EYE: NOT A PROBABLE ROUTE OF EXPOSURE.
PARTICULATES MAY SCRATCH EYE SURFACE/CAUSE MILD IRRITATION. SKIN: SINGLE
PROLONGED EXPOSURE NOT LIKELY TO RESULT IN MATERIAL BEING ABSORBED THRU S KIN
IN HARMFUL AMOUNTS. REPEATED/PROLONGED EXPOSURE MAY CAUSE MILD SKIN
IRRITATION IN SOME INDIVIDUALS. EXPOSURE TO HOT MATL MAY CAUSE THERMAL BURNS.
INGESTION: NOT A PROBABLE ROUTE OF EXPOSURE. INHAL ATION: NOT A PROBABLE
ROUTE OF EXPOSURE UNDER CONDITIONS OF NORMAL USE. HOT FUMES OR VAPORS THAT
MAY FORM DURING PROCESSING OR BURNING CAN CAUSE IRRITATION TO RESPIRATORY
TRACT.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ZP-9F DEVELOPER
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 60.0%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 25.0%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:PENTAERYTHRITOL
CAS:115-77-5
RTECS #:RZ2490000
Fraction by Wt: 15.0%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:CONTAINS NO OTHER INGREDIENT SUSPECTED OF BEING
HAZARDOUS,PER MANUFACTURER MSDS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE: CAUSES SKIN/EYE IRRITATION. IF
INHALED, WILL CAUSE DIZZINESS, DROWSINESS, OR NAUSEA.
Effects of Overexposure:INHALATION:CAUSES DIZZINESS,DROWSINESS,NAUSEA;
SKIN:LIQUID IRRITATES BY DISSOLVING SKIN OIL; EYES:VAPORS/LIQUID
CAUSES IRRITATION.
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.IF BREATHING IS DIFFICULT,GIVE
OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES.WASH OFF WITH FLOWING
WATER.USE SOOTHING LOTION.IF IRRITATION PERSISTS,GET MEDICAL ATTN;
EYES:IMM EDIATELY RINSE/FLUSH WITH COPIOUS AMOUNTOF RUNNING
WATER,AND GET MEDICAL ATTENTION. INGESTION:NOT SPECIFIED BY MFRG.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:2F (-16.7C)
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,DECOMPOSES TO
GIVE TOXIC GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SMALL SPILL:WIPE UP OR
MOP UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LARGE
SPILL:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIA L ABSORBENT.TRANSFER WASTE MATL IN SALVAGE
TANKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A RESPIRATOR WITH ABSORBENT CARTRIDGE IN
POORLY VENTILATED AREAS.IN CONFINED,UNVENTILATED SPACES,WEAR FULL
MASK WITH AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW TLV LIMITS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.LAUNDER
CONTAMINATED CLOTHES BEFORE RE-USE.
Supplemental Safety and Health
ITEM IS ONE PART PRODUCT.THE QPL-25135-15 OF MIL-I-25135 COVERS THIS
DEVELOPR(ZP-9F) UNDER FORM "D" AND TYPES I & II.EACH TYPE UNDER
DIFFERENT NSN;THIS NSN(EST. IN 1987 IS FOR TYPE "I".FORM D;THE QPL
ALSO COVERS ZP-5A,ZP-9E,& SKD-LT DEVELOPERS UNDER TYPE I, FORM D.
SEE OTHER PNI,THIS NSN,FOR THESE DEVELOPERS.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:135F(57.3C)
Vapor Pres:380MM@100F
Vapor Density:>1.0
Spec Gravity:0.86
Evaporation Rate & Reference:0.5 (ETHER=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:HAZY WHITE LIQUID
Percent Volatiles by Volume:83.0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS,(CORROSIVE MATERIAL)
Stability Condition to Avoid:HIGH TEMPERATURE/HEAT
Hazardous Decomposition Products:IF INVOLVE IN COMBUSTION,EMITS OXIDES
OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AMMONIUM HYDROXIDE
CAGE:JO957
CAGE:JO957
CAGE:92792
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM HYDROXIDE(SARA III)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 100%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:CONTACT MAY CAUSE TISSUE DAMAGE TO
SKIN,EYES,MUCOUS MEMBRANE,GASTRO-INTESTIAL & RESPIRATORY MUCOSA
======================= First Aid Measures =======================
First Aid:REMOVE TO UNCONTAMINATED AREA IMMEDIATELY,REMOVE CONTAMINATE
CLOTHING FLUSH EXPOSED BODY AREAS WITH WATER. INHALATION: GIVE
ARTIFICAL RESPIRATION IF NEEDED,GET MEDICAL ATTENTION. EYE: FLUSH
WITH WATER15 MIN,GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:SEE SUP DATA
Lower Limits:16
Upper Limits:25
Extinguishing Media:WATER SPRAY
Fire Fighting Procedures:SELF-CONT BREATH APP,STOP RELEASE OF GAS,WATER
TO COOL CONTA
Unusual Fire/Explosion Hazard:OIL OR OTHER COMBUSTIBLES MAY INCREASE
FIRE HAZARD
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING VAPORS OR CONTACT WITH
EYES,SKIN,CLOTHING.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINER AWAY FROM HEAT,DO NOT
PRESSURIZE DRUMS OR CARBONS. AVOID UNCONTROLLED MIXING WITH
HALOGENS OR ACIDS.
Other Precautions:AVOID USE OF PIPE,VALVES AND FITTINGS OF
COPPER,COPPER ALLOYS,GALVANIZED COATINGS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:MECHANICAL
Other Protective Equipment:SAFETY SHOWER,EYE WASH
Supplemental Safety and Health
FLASH POINT: IGNITION TEMP (NH*3 GAS): 1204F/651C. TYPE I. CONTAINER
SIZE: 55 GAL DRUM
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:85F/29C
Vapor Pres:2.3
Spec Gravity:0.8974
Solubility in Water:APPRECIABLE
Appearance and Odor:COLORLESS LIQUID,PUNGENT
Percent Volatiles by Volume:29.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
Stability Condition to Avoid:APPLICATION OF HEAT
Hazardous Decomposition Products:RELEASES NH*3 GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:CHECK WITH LOCAL,STATE AND FEDERAL AUTHORITIES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CA WHITE EPOXY PRIMER,PT A,05510WEP,SER. N
CAGE:HO401
CAGE:HO401
CAGE:09225
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 0.5-5.0%
Other REC Limits:N/K
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 5-10%
Other REC Limits:N/K
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 20-25%
Other REC Limits:N/K
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICA, AMORPHOUS, DUST
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 5-10%
Other REC Limits:3.33 MG/CUM TWA
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3; 8990
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 10-15%
Other REC Limits:N/K
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.5-5.0%
Other REC Limits:N/K
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MINERAL SPIRITS,(SOLVENT NAPHTHA (PETROLEUM),MEDIUM
ALIPHATIC).VP=4.0 MMHG.LEL=0.8.
CAS:64742-88-7
Fraction by Wt: 0.5-5.0%
Other REC Limits:100 PPM TWA
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 15-20%
Other REC Limits:N/K
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5-10%
Other REC Limits:N/K
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:REPEATED EXPOSURE MAY PRESENT
UNFORSEEN HAZARDS.
Explanation of Carcinogenicity:AMORPHOUS SILICA:EVIDENCE FOR CARCIN IN
HUMANS INADEQUATE,EVIDENCE FOR CARCIN IN ANIMALS INADEQUATE
(IARC,1987).
Effects of Overexposure:INHAL:ANESTHETIC.IRRITATION OF THE RESPIRATORY
TRACT OR ACUTE NERVOUS SYSTEM DEPRESSION CHARACTERIZED
PROGRESSIVELY BY:HEADACHE,DIZZINESS,STAGGERING GAIT,CONFUSION OR
COMA.SKIN AND EYES:PRIMARY IRRITA TION.INGEST:N/K .
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS,CHEMICAL SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE.RESTORE BREATHING.KEEP WARM &
CALM.GET MD ATTN.SKIN:WASH AREA W/ SOAP & WATER.REMOVE CONTAM
CLOTHING.GET MD ATTN.EYES:FLUSH IMMED W/ LARGE AMT RUNNING WATER
FOR AT LEAST 15 MINUTES.TAKE TO PHYSICIAN FOR MEDICAL
TREATMENT.INGEST:IF SWALLOWED,CALL A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:42.0 F
Lower Limits:0.8
Upper Limits:N/K
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICAL.WATER SPRAY MAY BE
INEFFECTIVE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .PREFER FOG NOZZLES IF H*2O USED.MAY USE H*2O TO COOL
CNTNR TO PREVENT POSS AUTOIGNIT/EXPLOSION.
Unusual Fire/Explosion Hazard:THERMAL DECOMP PROD INCL OXIDES OF C.CLSD
CNTNR MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.KEEP CNTNR TIGHTLY
CLSD.ISOLATE FROM IGNIT SOURCES.(SEE SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES,HOT
SURFACES, & ELEC,STATIC OR FRICTIONAL SPARKS).AVOID BREATHING
VAPORS.VENTILATE AREA.CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NONSPARKING TOOLS.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F,49C.STORE LG
QTY IN APPROVED BUILDING ONLY.KEEP FROM SPARKS & OPEN FLAME.CNTNR
SHOULD BE GROUNDED WHEN POURING.(SEE SUPP DATA)
Other Precautions:DO NOT TAKE INTERNALLY.AVOID PRLNG BREATHING OF VAPOR
OR SPRAY MIST.AVOID PRLNG/RPTD SKIN CONTACT.EMPTIED CNTNRS MAY
RETAIN HAZ RESIDUE OR EXPLOSIVE VAPORS.FOLLOW EVERY HAZ PREC IN
THIS DATA SHEET UNT IL CNTNR THOROUGHLY CLEANED/DESTROYED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY FOR TO KEEP AIR
CONCENTRATION BELOW TLV
Other Protective Equipment:PROT SKIN CREAM WHERE CONTACT LIKELY.PREVENT
PRLNG SKIN CONT W/ CONTAM CLOTHING.WASH CONTAM CLOTHING BEFORE
REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.SMOKE IN
SMOKING AREAS ONLY.
Supplemental Safety and Health
UNUSUAL FIRE & EXPLO HAZ:DO NOT APPLY MTL TO HOT SURFACES.NEVER USE
WELDING/CUTTING TORCH ON/NEAR DRUM (EVEN EMPTY) BECAUSE PROD (EVEN
ESIDUE) CAN IGNITE EXPLOSIVELY.HNDLING/STORAGE PREC:AVOID FREE FA
LL OF LIQUID IN EXCESS OF A FEW INCHES.USE ADEQ VENTIL AND
RESPIRATORY EQUIPMENT.WEIGHT PER GALLON:11.17.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230-385F
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:22 MMHG
Vapor Density:>1 (AIR=1)
Spec Gravity:1.343
Evaporation Rate & Reference:<1 (1=BUTYL ACETATE)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID,SOLVENT ODOR.
Percent Volatiles by Volume:56.87
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT AVAILABLE.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DO NOT INCINERATE CLOSED
CONTAINERS.INCINERATE IN APPROVED FACILITY.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BATTERY,STORAGE
CAGE:74025
CAGE:74025
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM,CD(OH)*2.OSHA 0.2 MG(CD)/M3 DUST.ACGIH TLV FOR
TOTAL DUST & 0.002 MG(CD)/M3 RESP FRACTION (INT CHG LIST,1991).
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: 15%
Other REC Limits:N/K
OSHA PEL:SEE 1910.1027
ACGIH TLV:0.01 MG/M3 DUST;9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NICKEL,NI(OH)*2.OSHA PEL FOR METAL & INSOL CMPDS.ACGIH TLV
FOR METAL & NI COMPOUNDS (INTENDED CHANGE LIST,1991).
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 25%
Other REC Limits:N/K
OSHA PEL:1 MG(NI)/M3
ACGIH TLV:0.05 MG(NI)/M3
Ingred Name:POTASSIUM HYDROXIDE
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 7%
Other REC Limits:N/K
OSHA PEL:2 MG/M3 C
ACGIH TLV:2 MG/M3 C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:EXPLAN OF CARC:SUFF EVID FOR CARC IN HUM & ANIM
(IARC,1987).NI & NI CMPDS:ACGIH A1=CONFIRMED HUM CARC (INT CHG
1991).
RTECS #:9999999ZZ
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:BATTERY ELECTROLYTES ARE CORROSIVE.
Explanation of Carcinogenicity:CD & CERTAIN CD CMPDS:SUSP HUM
CARC/KNOWN ANIM CARC (NTP,1989).CD & CD CMPDS:LTD EVID FOR CARC IN
HUM;SUFF EVID(SEE SUP)
Effects of Overexposure:EYES/SKIN/INGESTION/INHALATION:CHEMICAL ATTACK
THROUGH SKIN AND MUCOUS MEMBRANES UPON CONTACT WITH BATTERY
ELECTROLYTE.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES .GET PROMPT MEDICAL ATTENTION.SKIN:REMOVE CONTAMINATED
CLOTHING AND WASH AFFECTED AREAS WITH WATER FOR AT LEAST 15
MINUTES.GET PROM PT MEDICAL ATTENTION.INGESTION:GET PROMPT MEDICAL
ATTENTION.INHALATION:GET PROMPT MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Lower Limits:N/K
Upper Limits:N/K
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS (SCBA)
AND FULL TURNOUT GEAR .
Unusual Fire/Explosion Hazard:HAZARDOUS DECOMPOSITION PRODUCTS:CADMIUM
OXIDE FUMES/VAPORS/DUST.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT FOR SPILLS OF ELECTROLYTE FROM
BATTERY.
Neutralizing Agent:WEAK ACID SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM STRONG ACIDS.CONTAINER
SHOULD BE PROTECTED FROM BREAKAGE DURING HANDLING.
Other Precautions:DO NOT BREAK OPEN BATTERY CASE.DO NOT INCINERATE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:NONE
Work Hygienic Practices:N/K
Supplemental Safety and Health
CONTRACT NO:DAAB07-89C-C017.ENTRY RTE:INHAL/SKIN/INGEST .EXPLAN OF
CARC:FOR CARC IN ANIM (IARC,1987).KNOWN TO CAUSE CANCER (CAL PROP
65,1987).ACGIH A2=SUSP HUM CARC (INT CHG LIST 1991).NI & CERT AIN
NI CMPDS:SUSP HUM CARC/KNOWN ANIM CARC (NTP,1989).KNOWN TO CAUSE
CANCER (CAL PROP 65,1989).NI & NI CMPDS:(SEE ING 4)
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:B.P. Text:N/K
Solubility in Water:N/K
Appearance and Odor:ARTICLE (BATTERY)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Hazardous Decomposition Products:SUBLIMES AS CADMIUM OXIDE AT
2800F,1537C.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE IAW FEDERAL,STATE,& LOCAL
REGS.COORDINATION W/ SUPPORTING INSTALLATION/MACOM ENVIRONMENTAL
COORDINATION PRIOR TO DISPOSAL IS REC TO DETERMINE APPROPRIATE DISP
METHODS .SEND TO A CER TIFIED HAZARDOUS WASTE DISPOSAL SITE.DONOT
INCIN.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:185 6772 EKTACOLOR RA BLEACH FIX AND REPELENISHER NR, PART A
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM SULFITE (CERCLA)
CAS:10196-04-0
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM BISULFITE (CERCLA)
CAS:10192-30-0
RTECS #:WT3595000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 50-55%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 35-40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BISULFITE (SASA III) (CERCLA)
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. KEEP
FROM CONTACT WITH OXIDIZING MATERIALS. KEEP AWAY FROM INCOMPATIBLE
SUBSTANCES. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE. THIS CATALOGUE
NUMBER FOR PART A ONLY.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.34
pH:5.8
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, AMMONIA ODOR
Percent Volatiles by Volume:50-55%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS, ACIDS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF NITROGEN, SULFUR DIOXIDE,
AMMONIA, CHLORAMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NEUTRACIT-2 CAUSTIC NEUTRALIZER,PROD CODE:4470,4441 (SUPPLE)
Kit Part:Y
CAGE:70829
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL
CAS:63231-67-4
RTECS #:VV7322000
Fraction by Wt: 15-35%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:80 MG/M3 / % SIO2
ACGIH TLV:10 MG/M3
Ingred Name:CITRIC ACID, ANHYDROUS
CAS:77-92-9
RTECS #:GE7350000
Fraction by Wt: 55-75%
Other REC Limits:NONE RECOMMENDED
Ingred Name:FLOUR
Fraction by Wt: 5-20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BROMOTHYMOL BLUE SODIUM SALT
CAS:34722-90-2
Fraction by Wt: 1-10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE MSOT SEVERE HEALTH HAZ ASSOCIATED
W/SILICA GEL ARE LISTED SINCE EXACT FORM OF SILICA CONTAINED IN
PROD IS UNK.INHAL:UPPER RESP TRACT IRRIT. SKIN/EYE:IRRITATION.
INGEST:GI IRRIT. CHRONIC EFFECTS:NO NE IDENTIFIED.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY:NONE
IDENTIFIED.
Effects of Overexposure:UPPER RESP TRACT/EYE/SKIN IRRITATION. COUGHING,
TIGHTNESS & PAIN IN CHEST, DIFFICULT BREATHING, LEUKOCYTOSIS.
HEADACHE, NAUSEA, VOMITING, DIZZINESS, GASTROINTESTINAL IRRITATION.
Medical Cond Aggravated by Exposure:RESPIRATORY SYSTEM DISEASE. TARGET
ORGANS:RESPIRATORY SYSTEM.
======================= First Aid Measures =======================
First Aid:INGEST:IF PERSON CONSC IMMED GIVE LG AMTS OF WATER. GET MED
ATTN. INHAL:IF PERSON BREATHES IN LG AMTS MOVE TO FRESH AIR.
SKIN:IMMED WASH W/PLENTY OF SOAP/WATER FOR @LEAST 15MINS. EYE:IMMED
FLUSH W/PLE NTY OF WATER FOR @LEAST 15MINS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR PROPER PROT EQPMT &
SELF-CONTAINED BREATHING APPARATUS W/FULL FACEPIECE OPERATED IN
POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:NONE IDENTIFIED.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. CAREFULLY
SWEEP UP & REMOVE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLSD.SUITABLE FOR
ANY GENERAL CHEMICAL STORAGE AREA.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCEN IS HIGH USE AN APPROPRIATE
RESP OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL/LOC EXHAU VENTILATION TO KEEP FUME OR
DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:SAF-T-DATA STORAGE COLOR CODE:ORANGE(GENERAL
STORAGE).
Supplemental Safety and Health
THIS KIT PART OF 3-INDIVIDUAL SPILL KIT;SEE SAME NSN PNIND:A(MAIN
KIT),B,D.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:SLIGHT (0.1-1%)
Appearance and Odor:SOLID, YELLOW CRYSTALS OR POWDER. ODORLESS.
Percent Volatiles by Volume:0 @21C
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, COPPER, ALUMINUM, STRONG OXIDIZING AGETNS.
Stability Condition to Avoid:NONE DOCUMENTED.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE LOCAL,
STATE AND FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:10-4410-010 ABRASIVE CUT-OFF WHEELS
CAGE:09410
CAGE:09410
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
*96-3*
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 48-92%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:SILICON CARBIDE
CAS:409-21-2
RTECS #:VW0450000
Fraction by Wt: 48-92%
ACGIH TLV:10 MG/CUM
Ingred Name:FLUORIDE
CAS:16984-48-8
RTECS #:LM6290000
Fraction by Wt: 8-24%
OSHA PEL:2.5 MG/CUM
ACGIH TLV:2.5 MG/CUM
Ingred Name:SULFUR
CAS:7704-34-9
RTECS #:WS4250000
Fraction by Wt: 1-8%
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 2-10%
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM (FE)
Ingred Name:CALCIUM OXIDE; LIME
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 0-1%
OSHA PEL:5 MG/CUM
ACGIH TLV:2 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY AFFECT BREATHING
CAPACITY. SKIN: IRRITATION. EYES: IRRITATING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:COUGHING, SHORTNESS OF BREATH, IRRITATION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR AS NEEDED. SKIN:
WASH W/SOAP & WATER. EYES: WASH W/LARGE AMOUNTS OF WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE WHEELS IN A FLAT POSITION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE STANDARD DUST MASK. SEE OSHA 29 CFR 1910.94.
Ventilation:DON'T USE W/O ADEQUATE VENTILATION TO KEEP DUST PARTICLES
TO A MINIMUM. ADEQUATE EXHAUST VENTILATION.
Other Protective Equipment:WHEEL GAURD, SEE OSHA 29 CFR 1910.25.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:2-3
Solubility in Water:INSOLUBLE
Appearance and Odor:BROWN TO BLACK W/RUBBER ODOR WHEN IN USE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LUSTRE COAT INT W B 19%, 43020
CAGE:0H831
CAGE:0H831
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: <0.5%
OSHA PEL:200 PPM; 300 STEL
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACRYLONITRILE (SARA III)
CAS:107-13-1
RTECS #:AT5250000
Fraction by Wt: <15%
OSHA PEL:2 PPM, C; 10 PPM, S
ACGIH TLV:2 PPM, S
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:STYRENE (SARA III)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: <0.1%
OSHA PEL:50 PPM; 100 STEL
ACGIH TLV:50 PPM; 100 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:URETHANE RESIN
Fraction by Wt: 25-50%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 75-100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CONTAINS INGREDS 4-7 IN TRACE AMOUNTS
RTECS #:9999999ZZ
Ingred Name:TRIETHYLAMINE (SARA III)
CAS:121-44-8
RTECS #:YE0175000
Fraction by Wt: <0.5%
OSHA PEL:10 PPM; 15 STEL
ACGIH TLV:10 PPM; 15 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: SLIGHT IRRITATION TO SKIN, EYES
& RESPIRATORY TRACT. CHRONIC: PROLONGED CONTACT W/SKIN MAY CAUSE
DERMATITIS. PROLONGED BREATHING OF VAPORS MAY CAUSE DIZZINESS,
NAUSEA OR HEADACHE.
Explanation of Carcinogenicity:ACRYLONITRILE: IARC MONOGRAPHS,
SUPPLEMENT, VOL 7, PG 79, 1987:GROUP 2A. NTP 6TH ANNUAL RPT ON
CARCINOGENS, (SUP DAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMEDIATELY W/LARGE VOLUMES OF WATER FOR AT LEAST
15 MINS. CONSULT MD. SKIN:REMOVE W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING. INGEST:DRINK 1 TO 2 GLASSES OF WATER TO
DILUTE. DO NOT INDUC E VOMITING. CONSULT MD OR POISON CONTROL
CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID ON PAPER & PICK UP W/SHOVEL.
POWDERS & CEMENTS MAY BE SWEPT UP USING DUSTLESS METHOD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRACTICE REASONABLE CARE &
CLEANLINESS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR CARTRIDGE OR
RESPIRATOR DESIGNED TO REMOVE COMBINATION OF PARTICULATES & VAPOR.
Ventilation:LOCAL EXHAUST CAPABLE OF MINIMIZING VAPOR CONCENTRATION.
USE W/ADEQUATE VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:PRACTICE REASONABLE CARE & CLEANLINESS.
Supplemental Safety and Health
EXPLAN OF CARCIN: 1991:ANTICIPATED TO BE CARCINOGEN. CFR VOL 29,
1910.1045, 1984:OSHA-CANCER HAZARD. STYRENE: IARC MONOGRAPHS,
SUPPLEMENT, VOL 7, PG 345, 1987:GROUP 2B
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:1
Vapor Density:HVR/AIR
Spec Gravity:1.03
Evaporation Rate & Reference:SLOWER (BUTYL ACETATE=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:81
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:AVOID ELEVATED TEMPERATURES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DO NOT CLOSE
CONTAINER TIGHTLY AS GASSING MAY DEVELOP IN SOME PRODUCTS.
CAREFULLY INCINERATE OR USE SANITARY LANDFILL IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: SAFE STEP BASE
Kit Part: Y
Cage: ADSSI
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: ADSSI
=======================================================
Contractor Summary
=======================================================
Cage: ADSSI
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50(RATS): >10,000 MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: SKIN: MODERATE IRRITANT. EYES: SLIGHT IRRITATION.
OVEREXPOSURE MAY CAUSE IRRITATION, SENSITIZATION & DERMATITIS.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION
First Aid: SKIN: PROMPTLY WASH W/MILD SOAP & WATER. EYES: IMMEDIATELY FLUSH
W/WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR, GIVE OXYGEN IF
DIFFICULTY BREATHING. INGESTION: DRINK WATER & INDUCE VOMITING. OB TAIN
MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CONTAIN W/ABSORBENT MATERIAL. IF NECESSARY, SOAK
CONTAMINATED AREA W/5% ACETIC ACID & WASH W/WATER. COLLECT IN A METAL
WASTE CONTAINER.
Waste Disposal Methods: DISPOSE OF IN A APPROVED LANDFILL/INCINERATE IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE CLOSED IN COOL, DRY AREA. WHEN
HANDLING/POURING, WEAR PROTECTIVE CLOTHING & RESPIRATORY PROTECTION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: CC
Flash Point Text: 490F
Extinguishing Media: WATER, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures: USE SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard: DECOMPOSITION & COMBUSTION PRODUCTS MAY BE
TOXIC.
=======================================================
Control Measures
=======================================================
Respiratory Protection: ORGANIC CHEMICAL CARTRIDGE RESPIRATOR IF NEEDED.
Ventilation: GOOD GENERAL MECHANICAL VENTILATION & LOCAL EXHAUST
Other Protective Equipment: BARRIER CREAM RECOMMENDED
Work Hygienic Practices: MAINTAIN A SCHEDULE OF REGULAR HOUSEKEEPING TO INSURE
CLEANLINESS IN THE WORK AREA.
Supplemental Safety and Health: PH: (10% IN WATER).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 392F
Vapor Pres: 1
Spec Gravity: 1.17
PH: (SUPP)
Solubility in Water: INSOLUBLE
Appearance and Odor: CLEAR LIQUID W/SLIGHT ODOR
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG OXIDIZING AGENTS
Hazardous Decomposition Products: CO, CO2, ALDEHYDES
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: STRONG ACIDS/BASES IN BULK
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: SAFE STEP BASE
Cage: ADSSI
Company Name: ADVANCED SAFETY SYSTEMS INC
Street: 6834 S W 81 STREET
Zipcode: 33143-7708
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: SKIN: MODERATE IRRITANT. EYES: SLIGHT IRRITATION.
OVEREXPOSURE MAY CAUSE IRRITATION, SENSITIZATION & DERMATITIS.
IRRITATI
ON
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:STP (R) LEAD SUBSTITUTE
CAGE:STPCO
CAGE:58402
CAGE:STPCO
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS
CAS:64742-47-8
Ingred Name:TRADE SECRET ADDITIVES MIXTURES
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:SWALLOWING:NAUSEA AND VOMITING MAY
OCCUR.ASPIRATION INTO THE LUNGS MAY OCCUR DURING INGESTION OR
VOMITING.INHALATION:NOSE AND THROAT IRRITATION,RESPIRATORY
IRRITATION,DIZZINESS,DROWSINESS AND COMA.SKI N IRRITATION CAUSING
REDDENING,SWELLING.EYE CONTACT:MAY CAUSE DISCOMFORT,EXCESS
TEARS,REDDENING OF THE CONJUNCTIVA.
Effects of Overexposure:PROLONGED INHALATION TO HYDROCARBONS CAN CAUSE
DIZZINESS,WEAKNESS,WEIGHT LOSS,ANEMIA,A FEELING OF AGITATION,PLUS
PAIN,NUMBNESS AND A TINGLING SENSATION IN THE LIMBS.THE RED BLOOD
CELL COUNT MAY BE RED UCED,BONE MARROW MAY BE
HYPOPLASTIC,ANDPROTEINURIA AND HEMATURIA MAY BE FOUND.SKIN
IRRITATION CAN OCCUR.
Medical Cond Aggravated by Exposure:PRE-EXISTING DERMATITIS.BREATHING
OF VAPOR AND/OR MIST MAY AGGRAVATE ASTHMA AND INFLAMMATORY OF
FIBROTIC PULMONARY DISEASE.
======================= First Aid Measures =======================
First Aid:DO NOT INDUCE VOMITING.SEEK MEDICAL ATTENTION.SKIN:REMOVE
CONTAMINATED CLOTHING AND WASH SKIN THOROUGHLY W/SOAP AND
WATER.SEEK MEDICAL ATTENTION IF IRRITATION
PERSISTS.INHALATION:REMOVE FROM EXPOSURE. GENERAL SUPPORTIVE
MEASURES.IF EXPOSUREIS SEVERE,HOSPITALIZE AND OBSERVE.EYES:FLUSH
WITH COPIOUS AMOUNTS OF WATER.SEEK MEDICAL ATTENTION IF IRRITATION
PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:119F
Extinguishing Media:WATER FOG,ALCOHOL FOAM,CARBON DIOXIDE,AND DRY
CHEMICAL.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE EXPECTED.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
AND REMOVE ALL SOURCES OF IGNITION.COLLECT MATERIAL FOR DISPOSAL IN
A CONTAINER SUITABLE FOR FLAMMABLE WASTE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF HEAT AND
FLAME.USE WITH ADEQUATE VENTILATION.
Other Precautions:AVOID EYE AND SKIN CONTACT.WASH THOROUGHLY AFTER
HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:N/R UNDER NORMAL USE.FOR VAPOR BUILD-UP AND FOR
MAJOR SPILL CLEAN-UP,USE NIOSH/MSHA APPROVED RESPIRATION EQUIPPED
WITH DUAL CARTRIDGES FOR PROTECTION AGAINST ORGANIC VAPOR AND
MISTS.
Ventilation:GENERAL(MECHANICAL)VENTILATION IS ADEQUATE FOR NORMAL
HANDLING.FOR VAPOR BUILD-UP,LOCAL EXHAUST VENTILATION IS REQUIRED.
Other Protective Equipment:EYE WASH AND SAFETY SHOWERS.LONG SLEEVE
SHIRTS RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:318-383
Vapor Pres:LOW
Vapor Density:>1
Evaporation Rate & Reference:<1
Solubility in Water:NIL
Appearance and Odor:AMBER LIQUID,HEAVY ODOR.
Percent Volatiles by Volume:80
================= Stability and Reactivity Data =================
THIS PRODUCT IS INCOMPATIBLE WITH STRONG OXIDIZING AGENTS,STRONG ACIDS
OR BASES,AND SELECTED AMINES.
Hazardous Decomposition Products:COMBUSTION MAY PRODUCE OXIDES OF
CARBON,SULFUR AND SODIUM
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL IS A RCRA HAZARDOUS WASTE DUE TO
IGNITABILITY IF DISCARDED IN ITS PURCHASED FORM.INCINERATION OR
LANDFILLING SHOULD BE CARRIED OUT IN ACCORDANCE W/APPLICABLE
RCRA,FEDERAL,STATE AND LOCA L REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ZYTEL, FE3415 NC010
Kit Part:Y
Preparer's Name:D.L. LICZWEK
CAGE:B0589
CAGE:82348
CAGE:B0589
============= Composition/Information on Ingredients =============
Ingred Name:NYLON (NYLON 66)
CAS:32131-17-2
Fraction by Wt: >98%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LUBRICANT
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STABILIZER
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:MAY NOT PROVIDE ADEQ PROTECTION.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:SHIELD WHEN POSSIBILITY EXISTS FOR EYE & FACE CONT
DUE TO SPLASHING/SPRAYING OF MOLTEN MATL. NIOSH/MSHA (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:FULL FACE MASK RESP PROVIDES PROTECTION FROM EYE
IRRITATION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT)>10,000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SINGLE LG ORAL EXPOS (10,000
MG/KG) PRODUCED ONLY SLIGHT INITIAL WEIGHT LOSS. TWO-YEAR TESTS IN
RATS & ONE YEAR TESTS IN DOGS @ LEV OF 10% IN DIET PRODUCED NO
ADVERSE EFTS. RPTD INHAL EXPOS PROD UCED NO GROSS CHANGES & ONLY
MICROSCOPIC LUNG & KIDNEY CHANGES. THE CMPD IS NOT SKIN IRRITANT.
TESTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IN ANIMALS DEMONSTRATE NO CARCIN
ACTIVITY. NO ADVERSE HLTH EFTS ARE EXPECTED FROM HUMAN EXPOS TO
POLYHEXAMETHYLENE ADIPAMIDE, EXCEPT FOR MECH IRRIT OF SKIN & EYES
CAUSE BY PARTICLES. SIGNIFIC ANT SKIN PERMEATION, AND SYSTEMIC TOX,
AFTER CONTACT APPEARS UNLIKELY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:CONSULT PHYS IF NEC. IF EXPOS TO FUMES FROM
OVERHEATING/COMBUST, MOVE TO FRESH AIR. CONSULT PHYS IF SYMP
PERSIST. SKIN:CLEANSING SKIN AFTER USE IS ADVISABLE. IF MOLTEN
POLYMER GETS ON SKIN, COOLRAPIDLY W/COLD WATER. DO NOT ATTEMPT TO
PEEL POLYMER FROM SKIN. OBTAIN MED TREATMENT FOR THERMAL BURN.
EYE:IMMED FLUSH W/PLENTY OF WATER FOR @ LEAST 15 MINS. CALL PHYS.
INGEST:CONSULT PHYS IF NEC.
===================== Fire Fighting Measures =====================
Flash Point:752F,400C
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . KEEP PERSONNEL REMOVED AND UPWIND OF FIRE.
Unusual Fire/Explosion Hazard:LG MOLTEN MASSES MAY IGNITE SPONT IN AIR.
WATER QUENCHING OF SUCH MASSES IS GOOD PRACTICE. HAZ GASES/VAP
PRODUCED IN FIRE ARE:AMMONIA, CO; SM AMTS OF (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:NOTE:REVIEW FIRE FIGHT MEASURES & HNDLG (PERS)
SECTIONS BEFORE PROCEEDING W/CLEAN-UP. USE APPROP PERSONAL PROT
EQUIP DURING CLEAN-UP. SWEEP UP TO PVNT A SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:COOL, DRY PLACE. KEEP CNTNRS TIGHTLY
CLSD TO PVNT MOISTURE ABSORPTION & CONTAMINATION.
Other Precautions:MEDICAL USE: CAUTION:DO NOT USE IN MED APPLIC
INVOLVING PERM IMPLANTATION IN HUMAN BODY. FOR OTHER MED APPLIC SEE
DU PONT CAUTION BULLETIN NO. H-50102.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD AIR PURIFYING RESP W/ORG VAP
CARTRIDGE & NIOSH/MSHA DUST/MIST FILTER MAY BE PERMISSIBLE UNDER
CERTAIN CIRCUMSTANCES WHERE AIRBORNE CONC ARE EXPECTED TO EXCEED
EXPOS LIM. PROT PROVIDE D BY NIOSH/MSHA AIR PURIFYING (SUPDAT)
Ventilation:LOCAL VENTL TO CONTROL FUMES FROM HOT PROCESSING.
Other Protective Equipment:IF THERE IS POTENTIAL CONT W/HOT MOLTEN
MATL, WEAR HEAT RESIST CLOTHING AND FOOTWEAR.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT:1% (WATER). EXPLO HAZ:HYDROGEN CYANIDE & ALDEHYDES. WASTE DISP
METH:PROVINCIAL, & LOCAL REGS. RESP PROT:RESP IS LIM. USE
NIOSH/MSHA POSITIVE PRESS AIR SUPPLIED RESP IF THERE IS ANY POTNTL
FOR UNCONTROLLED RELEASE, EXPOS LEV ARE NOTKNOWN, OR ANY OTHER
CIRCUMSTANCE WHERE NIOSH/MSHA AIR PURIFYING RESP (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>482F,>250C
Spec Gravity:1.22-1.38
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:INSOLUBLE
Appearance and Odor:GRANULES, NO ODOR
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS.
Stability Condition to Avoid:HEATING ABOVE 340 DEGREES C.
Hazardous Decomposition Products:CYCLOPENTANONE, CARBON MONOXIDE,
ALDEHYDES, AND AMMONIA.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREF OPTIONS FOR DISP ARE (1)RECYCLING, (2)INCIN
W/ENERGY RECOVERY, & (3) LANDFILL. HIGH FUEL VALUE OF PROD MAKES
OPTION 2 VERY DESIRABLE FOR MAT THAT CANNOT BE RECYCLED. TREATMENT
STOR, TRANSPORTATIO N & DISP MUST BE I/A/W APPLIC FED, STATE/
(SUPDAT)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ALCIDE BRAND EXSPOR ACTIVATOR CONCENTRATE EPA REG # 45631-03
Kit Part:Y
CAGE:3J700
CAGE:3J700
============= Composition/Information on Ingredients =============
Ingred Name:LACTIC ACID
CAS:50-21-5
RTECS #:OD2800000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES TEMPORARY EYE IRRITATION ON
CONTACT.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH IMMEDIATELY W/WATER.
INGESTION: GIVE MILK OR WATER. DON'T INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:THE SOLUTION WILL NOT BURN. USE WATER TO COOL
FIRE-EXPOSED CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SPILLS W/WATER.
======================Handling and Storage ======================
Other Precautions:AVOID CONTACT W/EYES.
============= Exposure Controls/Personal Protection =============
Work Hygienic Practices:WASH HANDS W/SOAP & WATER AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:100.5C
Melt/Freeze Pt:M.P/F.P Text:-1.8C
Vapor Pres: 17
Spec Gravity:1.030
pH:1.9
Evaporation Rate & Reference:(BU AC = 1): AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS SOLUTION W/SLIGHT FRUITY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES, BLEACH
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE W/WATER & FLUSH DOWN DRAIN IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BORALLOY, 26
CAGE:IO898
CAGE:IO898
CAGE:05397
============= Composition/Information on Ingredients =============
Ingred Name:BORON NITRIDE
CAS:10043-11-5
Fraction by Wt: >99%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: NONTOXIC. EYE: DUST FROM
MACHINING OR CRUSHING MAY BE IRRITATING TO EYES AS NUISANCE DUST.
INGEST: NONTOXIC. INHAL: DUST FROM MACHINING OR CRUSHING MAY
IRRITATE EXISTING RESPIRATORY DISEA SE.MASSIVE OVEREXPOSURE TO
RESPIRABLE DUST FROM MACHINING MAY CAUSE PNEUMOCONIOSIS. BORON
NITRIDE IS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INERT/NONTOXIC. DUST IS CONSIDERED A
"NUISANCE DUST". CHRONIC: SEVERE AND REPEATED OVEREXPOSURE TO
RESPIRABLE DUST MAY CAUSE PNEUMOCONIOSIS.
Medical Cond Aggravated by Exposure:OVEREXPOSURE TO RESPIRABLE DUST
FROM MACHINING OR CRUSHING MAY AGGRAVATE EXISTING RESPIRATORY
DISEASES.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . SKIN: WASH WITH SOAP AND WATER.
INHAL: REMOVE TO FRESH AIR. IF DISCOMFORT PERSISTS, SEEK MEDICAL
ASSISTANCE. EYE: FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15
MINUTES . IF DISCOMFORT PERSISTS, SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NON FLAMMABLE SOLID
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP INTO APPROPRIATE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED DUST MASK FOR NUISANCE
DUSTS WHEN MACHINING OR CRUSHING.
Ventilation:LOCAL VENTILATION RECOMMENDED WHEN CRUSHNG OR MACHINING.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
BP:5432F, 3000C (SUBLIMES)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:SUPP DATA
Spec Gravity:2.1-2.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE WHITE SHAPES; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CAT, MIL-C-83286, 32356 P/C 030R039CAT
Kit Part:Y
Preparer's Name:NORM GAUL
CAGE:5M511
CAGE:33461
CAGE:5M511
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC ISOCYANATE (HEXAMETHYLENE DIISOCYANATE
[HDI];CAS:822-06-0;FREE MONOMER CONTENT >0.5%,AFTER 3-6MO 1.6% MAX)
CAS:28182-81-2
Fraction by Wt: 30%
Other REC Limits:MOBAY CEIL: 0.02 PPM
ACGIH TLV:0.005 PPM TWA
Ingred Name:N-BUTYL ACETATE (VAPOR PRESSURE 13 MM HG @ 68F)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SARA III) (VAPOR PRESSURE 21 MM HG @ 100F)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 4.09%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III) (VAPOR PRESSURE 7.1 MM HG @ 68F)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0.84%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM;STEL 125 PPM
ACGIH TLV:100 PPM;STEL 125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III) (VAPOR PRESSURE 22 MM HG @ 68F) (KNOWN
TO CALIF TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2.98%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE (VAPOR PRESSURE 0.7 MM HG @ 68F)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 5%
Other REC Limits:50 PPM;STEL 100 PPM
Ingred Name:METHYL ISOBUTYL KETONE (SARA III) (VAPOR PRESSURE 15 MM HG
@ 68F)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 8.94%
Other REC Limits:NONE SPECIFIED
OSHA PEL:50 PPM;STEL 75 PPM
ACGIH TLV:50 PPM;STEL 75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 70 MM HG @
68F)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 43.4%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM;STEL 300 PPM
ACGIH TLV:200 PPM;STEL 300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 633 G/L
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: RESP TRACT IRRIT, ACUTE NERVOUS
SYS DEPRESSN (HEADACHE, DIZZY, STAGGERING, CONFUSION, UNCONSCIOUS,
COMA). SKIN: IRRIT (SWELL, RED, RASH). ABSORPTN: IRRIT, DRYING,
DEFATTING (CRACKING). EYE: IRR IT (TEARING, RED, SWELL W/STING).
INGEST: IRRIT, CORROSIVE IN GI TRACT. VOMITING MAY CAUSE
ASPIRATION-CHEM PNEUMONITIS.
Effects of Overexposure:CHRONIC: AS A RESULT OF PREVIOUS REPEATED
OVEREXPOSURE OR A SINGLE LARGE DOSE, CERTAIN INDIVIDUALS WILL
DEVELOP ISOCYANATE SENSITIZATION WHICH WILL CAUSE THEM TO REACT TO
A LATER EXPOSURE OF ISOCYANAT E LEVELS WELL BELOW THE TLV VALUE OF
ISOCYANATES.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS. ISOCYANATE
SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC TYPE
SYMPTOMS MAY DEVELOP. GET MEDICAL AID. SKIN: REMOVE CONTAMINATED
CLOTHES. WASH AFFECTED AREAS W/SOAP & WATER. WASH CONTAMINATED
CLOTHING BEF ORE REUSE. EYES: FLUSH W/LUKEWARM WATER(LOW PRESSURE)
15 MIN, OCASSIONALLY LIFTING EYELIDS. GET MED AID. INGESTION: DO
NOT INDUCE VOMITING. DO NOT GIVE ANYTHING TO AN UNCONSCIOUS PERSON.
GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1.00
Upper Limits:11.00
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:USE FULL PROTECT CLOTH/FIREFIGHT EQUIP W/SCBA.
WATER MAY BE USED TO COOL CLSD CNTNRS (PREVENT PRESS
BLDUP/AUTOIGNIT/EXPLOS). HDI/IRRIT VAPOR GENERATED BY FIRE.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACES REQ
PRECAUTION. OVEREXPOSURE TO DECOMP PRODUCT-HEALTH HAZARD
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BLDGS IN COMPLY W/OSHA
1910.106. AVOID STORING NEAR HIGH TEMPS, FIRE, OPEN FLAMES, &
SPARKS. STORE IN TIGHTLY CLOSED CNTNRS. DON'T INGEST.
Other Precautions:STORE IN VENTED AREA. KEEP CONTAINER TIGHT & UPRIGHT
(PREVENT LEAKAGE). PREVENT PROLONGED BREATHING OF VAPOR/MIST.
PROLONGED OVEREXPOSURE MAY CAUSE ALLERGIC REACTION. AVOID CONTACT
W/SKIN & EYES. READ /UNDERSTAND MFR PRECAUTIONS BEFORE USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR FOR ORGANIC VAPOR ENVIRONMENT (AIR
SUPPLYING/FRESH AIR SUPPLIED). OBSERVE OSHA REGS FOR RESPRTR USE.
VENT TO KEEP BELOW PEL. AIR SUPPLIED RESPIRATOR RECOMMENDED. VAPOR
PARTICULATE RESPIRATO R (TC23C) WHEN BELOW 10X EXPOSURE LIMITS
Ventilation:EXHAUST VENT TO KEEP CONCENTRATION OF SOLVENT & HDI &
POLYISOCYANATES BELOW PEL/TLV. REMOVE ALL IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175 TO 338F
Vapor Density:> AIR
Spec Gravity:0.90156
Viscosity:*
Evaporation Rate & Reference:3.24 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:76.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIAL WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, AND
OXIDES OF NITROGEN, TRACES OF HCN & HDI.
Conditions to Avoid Polymerization:CONTACT WITH MOISTURE, MATERIALS
WHICH REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. HANDLE
EMPTY CONTAINERS WITH CARE DUE TO PRODUCT RESIDUES AND FLAMMABLE
VAPOR. DO NOT INCINERAT E CLOSED CONTAINERS. EPA WASTE #:
D001,F003, F005
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:6602137 T11
Preparer's Name:S HEALY
CAGE:FO645
CAGE:FO645
CAGE:6Z677
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE, AZIDE *96-4*
CAS:26628-22-8
RTECS #:VY8050000
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL IRRITATION. SKIN:
IRRITATION, ABSORPTION, ALLERGIC REACTION. EYES: IRRITATIONS,
CONJUNCTIVITIS. INGESTION: BRONCHIAL IRRITATION, RESPIRATORY
IRRITATION, RESPIRATORY FAILURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, FAINTNESS,
NAUSEA, LOW BLOOD PRESSURE, BLURRED VISION, SHORTNESS OF BREATH,
COLLAPSE, BRONCHITIS, PALPITATION, WEAKNESS & UNSTEADINESS, COMA,
CONVULSIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
IF BREATHING IS DIFFICULT GIVE OXYGEN. SKIN: WASH OFF THOROUGHLY
FOR 15 MINS. EYES: RINSE THOROUGHLY W/WATER & GIVE PLENTY OF WATER
TO DRIN K. INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICALS SUCH AS AN SODIUM CARBONATE/SAND.
Fire Fighting Procedures:BURNING SODIUM AZIDE WILL EXPLODE IF WATER IS
USED AS AN EXTINGUISHING MEDIA. SCBA MUST BE WORN.
Unusual Fire/Explosion Hazard:MAY EXPLODE & RELEASE TOXIC FUMES UPON
HEATING. DON'T ALLOW TO CONTACT METALS AT HIGH TEMPS.
(SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/RUNNING WATER BEFORE DISCHARGE.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM METALS & ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:GENERAL/LOCAL EXHAUST TO MEET TLV REQUIREMENTS
Other Protective Equipment:ADEQUATE LABORATORY ATTIRE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: FORMS HIGHLY SENSITIVE EXPLOSIVE COMPOUNDS W/HEAVY
METALS SUCH AS LEAD, SILVER & COPPER. WHEN HEATED TO 662F IT
DECOMPOSES EXOTHERMICALLY, BURNING W/A VERY HOT FLAME & PRODUCING N
ITROGEN & MOLTEN SODIUM.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:527F
Spec Gravity:1.85
Solubility in Water:40.16
Appearance and Odor:WHITE-COLORLESS CRYSTALS/POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS, ACIDS, ACID CHLORIDES & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:NITROGEN OXIDES, HYDRAZOIC ACID
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:005XX HE 200
Preparer's Name:MARC C TAROLEE
CAGE:59256
CAGE:59256
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT REFINED HYDROTREATED HEAVY PARAFFINIC DISTILLATE,
HYDROTREATED HEAVY PARAFFINIC DISTILLATE, LUBRICATING OIL.
CAS:64742-54-7
RTECS #:PY8035500
OSHA PEL:5 MG/CUM (MIST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NAUSEA. EYES: IRRITATION.
DETAILED STUDIES HAVE NOT BEEN MADE, BUT MATERIAL IS NOT EXPECTED
TO BE DERMATITIC OR A SENSITIZER.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER. INGESTION:
GIVE LIQUIDS & INDUCE VOMITING IF VICTIM IS CONSCIOUS. SMALL
AMOUNTS IN MOUTH MAY BE WASHED OUT. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>213C
Extinguishing Media:WATER FOG, CHEMICAL FOAM OR CO2
Fire Fighting Procedures:WEAR BREATHING GEAR WHEN FIGHTING FIRES IN
ENCLOSED SPACES, INCOMPLETE COMBUSTION OF THIS MATERIAL PRODUCES
CO.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS: MAY BE WIPED UP W/A RAG. LARGE
SPILLS: SHOULD BE PICKED UP IMMEDIATELY W/AN ABSORBENT.
======================Handling and Storage ======================
Other Precautions:AVOID INHALATION OF OIL MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED FOR EXPOSURES ABOVE TLV.
Ventilation:LOCAL OR MECHANICAL AS REQUIRED TO KEEP EXPOSURE BELOW TLV.
Other Protective Equipment:NONE SHOULD BE REQUIRED UNDER NORMAL USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>200C
Vapor Pres:<0.001
Vapor Density: 14
Spec Gravity:0.87
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE YELLOW, VISCOUS LIQUID W/FAINT PETROLEUM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:CONTINUOUS EXPOSURE TO TEMPERATURES >200C
Hazardous Decomposition Products:INCOMPLETE COMBUSTION MAY PRODUCE CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:PROPER WASTE DISPOSAL PROCEDURES ARE DEPENDENT
ON THE PRODUCT'S END-USE. CHECK APPLICABLE FEDERAL, STATE & LOCAL
COVERING TREATMENT, STORAGE & DISPOSAL OF YOUR PROCESS EFFLUENTS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:EA 9320 NA PART A
Kit Part:Y
CAGE:33564
CAGE:33564
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN SYSTEM
Ingred Name:SILICA
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <05%
OSHA PEL:20 MPPCF
ACGIH TLV:0.1 MG/M3
Ingred Name:VOC <10 G/L ESTIMATE
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:MAY CAUSE EYE AND SKIN IRRITATION AND
POSSIBLE ALLERGIC REACTIONS. PROLONGED AND REPEATED CONTACT MAY
CAUSE SENSITIZATION WHICH WILL RESULT IN ALLERGIC REACTIONS. AVOID
CONTACT WITH EYES OR SKIN.
Effects of Overexposure:SKIN RASH, IRRITATION.
======================= First Aid Measures =======================
First Aid:FLUSH SKIN AND EYE CONTACT WITH PLENTY OF WATER. WASH
THOROUGHLY WITH SOAP AND WATER, RUBBING ALCOHOL OR HAND CLEANER. DO
NOT USE SOLVENTS. REMOVE SOILED CLOTHING AND WASH BEFORE REUSE. IF
IRRITATIONPERSISTS, SEE PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>300F,>149C
Extinguishing Media:DRY CHEMICAL OR HALON FIRE EXTINGUISHER, WATER
SPRAY, FOAM OR FOG.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING FIRES IN CONFINED AREAS.
Unusual Fire/Explosion Hazard:DENSE SMOKE AND TOXIC GASES MAY BE
LIBERATED.
================== Accidental Release Measures ==================
GLASSES. SCRAPE UP AND TRANSFER TO METAL CONTAINER. WIPE UP
REMAINING RESIDUE WITH SOLVENTS, OBSERVING SOLVENT FLAMMABILITY
CAUTIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP COOL IN ACCORDANCE WITH LABEL
INSTRUCTIONS. STORE AT ROOM TEMPERATURE (77 DEG. F) FOR 12 MONTHS.
Other Precautions:FOLLOW RECOMMENDED CURING SCHEDULE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED WITH GOOD INDUSTRIAL VENTILATION.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:AS NEEDED TO PROTECT SKIN AND CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FAILURE TO OBSERVE CAUTION MAY RESULT IN EXCESSIVE HEAT BUILD-UP WITH
THE RELEASE OF TOXIC GASES. DO NOT HANDLE OR USE UNTIL MSDS HAS
BEEN READ & UNDERSTOOD. CONTAINS EPOXY RESINS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Pres:<0.01MM
Vapor Density:NIL
Spec Gravity:>1
Evaporation Rate & Reference:NIL
Solubility in Water:NIL
Appearance and Odor:OPAQUE-AMBER COLORED PASTE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Hazardous Decomposition Products:CO, NOX, ALDEHYDES, ACIDS AND
UNDETERMINED ORGANICS.
Conditions to Avoid Polymerization:MIXING RESIN/CURING AGENT IN BATCHES
GREATER THAN 1/2 LB. DON'T HEAT MIXED ADHESIVE UNLESS CURING
SURFACES TO BE BONDED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE ACCORDING TO
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NI65, NICKEL OXIDE
Preparer's Name:VANAJA SIVAKUMAR
CAGE:07977
CAGE:07977
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL OXIDE; (NIO)
CAS:1313-99-1
RTECS #:QR8400000
Fraction by Wt: 100%
OSHA PEL:1 MG/M3 (NI)
ACGIH TLV:0.05 MG/M3 (NI)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:THIS COMPOUND MAY BE HARMFUL IF
INHALED, INGESTED OR CONTACTED WITH THE SKIN OR EYES. POISON BY
INTRATRACHEAL, INTRAVENOUS AND SUBCUTANEOUS ROUTES. EXPOSURE TO
NICKEL COMPOUNDS CAN CAUSE DERMATITIS. S YMPTOMS ARE BURNING AND
ITCHING OF THE HAND FOLLOWED BY ERYTHEMA AND MODULAR ERUPTION IN
WRISTS, (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:ANTICIPATED TO BE A CARCINOGEN (NTP).
Effects of Overexposure:HLTH HAZ:FINGERS, AND FOREARMS. ULCERATION OF
THE SKIN MAY OCCUR. RECOVERY WILL TAKE FROM ONE TO SEVERAL WEEKS.
OVEREXPOSURE TO THIS COMPOUND MAY RESULT IN CANCER OF THE LUNG OR
NASAL SINUSES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES OCCASIONALLY
LIFTING UPPER AND LOWER LIDS. SKIN: REMOVE CONTAMINATED CLOTHING,
THEN FLUSH WITH WATER FOR AT LEAST 15 MINUTES. WASH CLOTHING
THOROUGHLY BEF ORE REUSE. INHAL: MOVE TO FRESH AIR. ALL EXPOSURES:
IF IRRITATION CONTINUES, GET MEDICAL ATTENTION IMMEDIATELY. INGEST:
CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AND VENTILATE AREA. SWEEP UP AND
PLACE IN BAG, HOLD FOR PROPER DISPOSAL. WEAR PROTECTIVE CLOTHING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA IN A TIGHTLY
SEALED CONTAINER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:CHEMICAL FUME HOOD.
Other Protective Equipment:LAB COAT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:T6
Melt/Freeze Pt:M.P/F.P Text:3603F,1984C
Spec Gravity:6.67
Solubility in Water:INSOLUBLE
Appearance and Odor:GREEN POWDER WITHOUT AN ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT VIOLENTLY WITH FLUORINE; HYDROGEN PEROXIDE; HYDROGEN SULFIDE;
IODINE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT LOCAL HAZARDOUS OR CHEMICAL WASTE
DISPOSAL AGENCY FOR REGULATIONS. DISPOSE OF I/A/W FEDERAL, STATE
AND LOCAL REGULATIONS .
| 1 |
gloves_mandatory
|
=======================================================
Product ID: ICE PELLETS (50#), 4854
Cage: 20913
Box: 152170
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 0AGH9
Box: UNKNOW
Cage: 20913
Box: 152170
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENT 1.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:MAY CAUSE SLIGHT NASAL IRRITATION IF DUST IS
INHALED. SWALLOWING MAY CAUSE NAUSEA. MAY CAUSE IRRITATION TO SKIN ESPECIALLY
BROKEN SKIN. IT WILL CAUSE DISCOMFORT & IRRITATION IF IT GETS INTO EYES .
CHRONIC:REPEATED OR PROLONGED EYE CONTACT MAY CAUSE DAMAGE. REPEATED OR
PROLONGED SKIN CONTACT MAY (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:CAUSE DERMATITIS.
Medical Cond Aggravated By Exposure: CONTACT MAY AGGRAVATE PRE-EXISTING SKIN
CONDITIONS.
First Aid: INHAL:REMOVE FROM AREA TO FRESH AIR. SEEK MED ATTN IF RESP IRRIT
OCCURS/IF BRTHG BECOMES DFCLT. EYE:IMMED RINSE W/WATER. REMOVE ANY CONTACT
LENSES & CONTINUE FLUSHING FOR AT LST 15 MINS. HOLD EYELIDS APART TO
ENSURE RINSING OF ENTIRE SURF OF EYES & LIDS W/WATER. GET IMMED MED ATTN.
SKIN:WASH AFFECTED AREAS W/PLENTY OF SOAP & WATER FOR SEVERAL MINS.
REMOVE & CLEAN CONTAM CLTHG & SHOES. (SUPP DATA)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SHOVEL UP INTO LABELED BARRELS. FLUSH AREA W/WATER TO
REMOVE ANY RESIDUE.
Waste Disposal Methods: DISPOSE OF I/A/W ALL FEDERAL, STATE & LOCAL
REGULATIONS.
Handling And Storage Precautions: STORE INDOORS - STORAGE TEMPS: 100F(MAX), 20F
(MIN). STORE AT MOD TEMPS. KEEP TIGHTLY CLOSED IN A DRY AREA AS PROD CAN
ABSORB MOISTURE FROM AIR.
Other Precautions: KEEP OUT OF REACH OF CHILDREN. READ THE ENTIRE LABEL BEFORE
USING THIS PRODUCT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: NON-FLAMMABLE
Extinguishing Media: FOAM, "ALCOHOL" FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). PRODUCT IS NON-FLAMMABLE. CHOICE OF EXTING MEDIA DEPENDS ON
THE NATURE OF THE FIRE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED. IF DUSTING OCCURS, WEAR
NIOSH/MSHA APPROVED DUST MASK.
Ventilation: PRODUCT IS TYPICALLY USED OUTDOORS SO NO VENTILATION IS NECESSARY.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). FIRST AID PROC:SEEK MED ATTN IF IRRIT
DEVELOPS. INGEST:GIVE 3-4 GLASSES OF WATER. INDUCE VOMIT BY PLACING
FINGER/BLUNT OBJE CT ON BACK OF VICTIM'S TONGUE. GIVE FLUIDS UNTIL VOMITUS IS
CLEAR. SEEK MED ATTN.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 1500F,816C
Spec Gravity: 2.2 (H*2O=1)
Solubility in Water: COMPLETE
Appearance and Odor: WHITE, OPAQUE, GRANULAR; ODORLESS.
Percent Volatiles by Volume: <5
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: PRODUCT ABSORBS MOISTURE FROM THE AIR.
Hazardous Decomposition Products: CHLORINE, CHLORIDE & HCL FUMES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ICE PELLETS (50#), 4854
Cage: 20913
Company Name: NCH CORP
Street: 2727 CHEMSEARCH BLVD
PO Box: 152170
Zipcode: 75015-2170
Label Required IND: Y
Date Of Label Review: 07/06/1995
Status Code: C
Label Date: 07/06/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:MAY CAUSE SLIGHT NASAL IRRITATION IF DUST IS
INHALED. SWALLOWING MAY CAUSE NAUSEA. MAY CAUSE IRRITATION TO SKIN ESPECIALLY
BROKEN SKIN. IT WILL CAUSE DISCOMFORT & IRRITATION IF IT GETS INTO EYES .
CHRONIC:REPEATED OR PROLONGED EYE CONTACT MAY CAUSE DAMAGE. REPEATED OR
PROLONGED SKIN CONTACT MAY CAUSE DERMATITIS.
=======================================================
| 1 |
gloves_mandatory
|
=======================================================
Product ID: RICH LUX PATIO AND DECK ENAMEL, 077150
Cage: 85519
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 85519
Box: 600
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION: IRRITATION OF RESPIRATORY TRACT. PROLONGED
INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION DROWSINESS, AND/OR
LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN: IRRITATION OF SKIN. PROLONGED OR R
EPEATED CONTACT CAN CAUSE DERMATITIS. EYE: IRRITATION OF EYES. PROLONGED OR
REPEATED CONTACT CAN (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: CREATE BLURRED VISION, CORNEAL
INJURY. INGESTION: AMOUNTS INGESTED INCIDENTAL TO CONSUMER AND INDUSTRIAL
HANDLING ARE NOT LIKELY TO CAUSE INJURY; HOWEVER, INGESTION OF LARGER AMOUNTS
COULD C AUSE SERIOUS INJURY.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
HAVE TRAINED PERSON GIVE OXYGEN IF NEC. GET EMER MED ATTN. SKIN: WASH OFF
QUICKLY W/PLENTY OF H*2O, THEN SOAP & H*2O; REMOVE CONTAMD CLTH G. WASH
CONTAMD CLTHG BEFORE REUSE. EYE: FLUSH IMMED W/LRG AMTS OF H*2O, ESP UNDER
LIDS, FOR AT LEAST 15 MIN. OBTAIN EMER MEDICAL TREATMENT. INGEST: IF
SWALLOWED, OBTAIN MEDICAL TREATMENT IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COLLECT IN CONTAINER FOR DISPOSAL, ACCORDING TO
HEALTH AND ENVIRONMENTAL REGULATIONS. CLEAN UP WITH WATER BEFORE ALLOWING TO
DRY.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE BELOW 100 DEGREE F. KEEP FROM FREEZING.
Other Precautions: DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON-FLAMMABLE
Lower Limits: SEE INGRED
Extinguishing Media: DRY CHEMICAL OR FOAM.
Fire Fighting Procedures: NON-FLAMMABLE. WATER MAY BE USED TO COOL AND PROTECT
EXPOSED CONTAINERS. USE NIOSH APPROVED SCBA & FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE ONLY NIOSH APPROVED
RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation: MAINTAIN ADEQUATE VENTILATION TO ENSURE AIR ENTRY DURING
APPLICATION AND DRYING TO PREVENT BUILD-UP OF VAPORS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). SKIN CREAM (IF NEEDED).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Vapor Pres: SEE INGRED
Spec Gravity: 1.13-1.37(FP N)
Evaporation Rate & Reference: SLOWER THAN ETHYL ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 64-68
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES. CONTACT WITH OXIDIZING
AGENTS.
Materials To Avoid: OXIDIZERS, ACIDS, BASES, AMINES.
Hazardous Decomposition Products: IF INVOLVED IN FIRE (FROM OTHER SOURCES)
COULD CONCEIVABLY RESULT IN RELEASE OF CARBON DIOXIDE AND CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: RICH LUX PATIO AND DECK ENAMEL, 077150
Cage: 85519
Company Name: M A BRUDER & SONS INC
Street: 600 REED RD
PO Box: 600
Zipcode: 19008
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: INHALATION: IRRITATION OF RESPIRATORY TRACT. PROLONGED
INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION DROWSINESS, AND/OR
LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN: IRRITATION OF SKIN. PROLONGED OR R
EPEATED CONTACT CAN CAUSE DERMATITIS. EYE: IRRITATION OF EYES. PROLONGED OR
REPEATED CONTACT CAN (EFTS OF OVEREXP)
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MERCURIC OXIDE CELL, RM12RT2
CAGE:90303
CAGE:90303
CAGE:0BSY9
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MERCURIC OXIDE (SARA III)
CAS:21908-53-2
RTECS #:OW8750000
Fraction by Wt: 35 - 45%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG HG/M3;SKIN;C
ACGIH TLV:0.1 MG HG/M3; 9293
Ingred Name:MERCURY (SARA III)
CAS:7439-97-6
RTECS #:OV4550000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, C, 0.1 MG/M3
ACGIH TLV:S, 0.05 MG/M3; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MANGANESE OXIDE
CAS:1317-35-7
RTECS #:OP0895000
Fraction by Wt: 6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:(C),5 MG/M3(MN)
ACGIH TLV:5 MG MN/M3; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC- RISK OF EXPOSURE
OCCURS ONLY IF CELL IS MECHANICALLY, PHYSICALLY OR ELECTRICALLY
ABUSED. KOH IS CAUSTIC AND MAY CAUSE SKIN BURNS, SEVERE EYE INJURY.
AT ELEVATED TEMPERATURES, MERCUR Y VAPORS MAY BE GENERATED WHICH
CAN CAUSE MERCURY INTOXICATION.
Explanation of Carcinogenicity:MFR LISTED NO FURTHER INFORMATION ABOUT
THE CARCINOGENICITY OF THIS MATERIAL.
Effects of Overexposure:SKIN & EYE CONTACT WITH KOH MAY CAUSE CHEMICAL
BURNS. AT ELEVATED TEMPERATURES, MERCURY VAPOR MAY BE GENERATED
WHICH SHOULD NOT BE INHALED.
Medical Cond Aggravated by Exposure:AN ACUTE EXPOSURE WILL NOT
GENERALLY AGGRAVATE ANY MEDICAL CONDITION.
======================= First Aid Measures =======================
First Aid:IF LEAKAGE FROM CELL COMES INTO CONTACT WITH THE SKIN, FLUSH
IMMEDIATELY WITH WATER. FOR EYE CONTACT, FLUSH EYES IMMEDIATELY
WITH COPIOUS AMOUNTS OF WATER FOR 15 MINUTES AND SEE A PHYSICIAN AT
ONCE. F OR INHALATION OF HG VAPORS, REMOVE TO FRESH AIR. IF
SWALLOWED, CONSULT PHYSICIAN AT ONCE. FOR INFO, CALL NATIONAL
POISON CONTROL CENTER, 202-625-3333.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MFR: "N/A" HMIS: USE MEDIA APPROPRIATE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING FIRE WHERE THESE CELLS ARE
INVOLVED.
Unusual Fire/Explosion Hazard:CELL MAY RELEASE TOXIC MERCURY VAPOR WHEN
THE INTEGRITY OF THE CELL IS BROKEN.
================== Accidental Release Measures ==================
Spill Release Procedures:HMIS:BATTERY AND CELL CASES WILL NORMALLY
CONTAIN MATERIALS OF CONCERN. USE INDUSTRIAL ABSORBENT TO COLLECT
LIQUID POTASSIUM HYDROXIDE. MFR:AVOID SKIN AND EYE CONTACT. DO NOT
INHALE VAPORS.
Neutralizing Agent:WEAK ACID FOR POTASSIUM HYDROXIDE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE. AVOID
BREAKING, CRUSHING OR OTHERWISE DESTROYING THE PHYSICAL INTEGRITY
OF BATTERY. OBSERVE THE CORRECT POLARITY.
Other Precautions:DO NOT INCINERATE. DO NOT TOUCH BROKEN OR LEAKING
BATTERIES. AVOID MECHANICAL OR ELECTRICAL ABUSE. DO NOT ATTEMPT TO
RECHARGE. AVOID SHORT CIRCUITS. DO NOT CARRY BATTERIES LOOSE IN
POCKET OR BAG. KEEP BATTERIES AWAY FROM SMALL CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF CONTAINED BREATHING APPARATUS IF CELLS ARE
ENVOLVED IN A FIRE.
Ventilation:WHEN CELLS ARE INVOLVED IN A FIRE USE AS MUCH VENTILATION
AS POSSIBLE.
Other Protective Equipment:NONE
Work Hygienic Practices:MFR: ?HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICE. AVOID UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING
OR DRINKING.
Supplemental Safety and Health
KEY2:KT REPLACE ALL BATTERIES IN EQUIPMENT AT THE SAME TIME. DO NOT
MIX BATTERY SYSTEMS (I.E. MERCURY, ALKALIND, ZINC-CARBON) IN THE
SAME EQUIPMENT. INSTALL CELLS ACCORDING TO EQUIPMENT INSTRUCTIONS.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Appearance and Odor:DRY CELL TYPE BATTERY0.62 IN O.D. X 1.953 IN LONG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO INFORMATION GIVEN ON MSDS BY MFR.
Stability Condition to Avoid:HEAT, DISASSEMBLY, CRUSHING, PUNCTURE OR
RECHARGE
Hazardous Decomposition Products:TOXIC MERCURY VAPORS AND CAUSTIC
POTASSIUM HYDROXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS. NO SPECIAL PRECAUTIONS ARE NECESSARY FOR SMALL
QUANTITIES OF MERCURY BATTERYS. FOR DISPOSAL OF LARGE QUANTITIES OF
BATTERYS, CONSULT LOCAL ENVIRONMENT AL AGENCYS OR DURACELL. ***DO
NOT INCINERATE!***
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:20-8122/20-8126 HARDNER FOR CASTOLITE/GLAS
CAGE:09410
CAGE:09410
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE PEROXIDE (MEKP) (SARA III)
CAS:1338-23-4
RTECS #:EL9450000
Fraction by Wt: 60%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 0.7 PPM
ACGIH TLV:C 0.2; 9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:DIMETHYLPHTHALATE (SARA III)
CAS:131-11-3
RTECS #:TI1575000
Fraction by Wt: 40%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYE:EXTREME IRRITATION WITH POSS PERM EYE
INJURY. SKIN:SEVERE IRRITATION AND BLISTERS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER 15 MINUTES,GET MEDICAL ATTENTION.
SKIN:WASH WITH SOAP & WATER. INGESTION:DRINK LARGE AMOUNT OF MILK
OR WATER AND SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:140F?60C (SETAF)
Extinguishing Media:WATER FOG,CARBON DIOXIDE,DRY CHEMICAL
Fire Fighting Procedures:WATER TO COOL EXPOSED CONT,FIGHT FIRE FROM
EXPLOSE SAFE AREA
Unusual Fire/Explosion Hazard:DANGEROUS WHEN EXPOSED TO HEAT OR
FLAMES,SPONTANEOUS REACTION OR IGNITION MAY OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES OF IGNITION,AND COVER
WITH NON-COMBUSTIBLE ABSORBENT MATERAL. TO CONTAIN SPILLAGE. USE
NON-SPARKING TOOLS TO GATHER ABSROBED MATERIAL.WASH AREA WITH
DETERGENT AND WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FRON OTHER MATERIALS IN A
COOL PLACE IN ORIGINAL CONTAINERS AWAY FROM ANY SOURCE OF IGNITION.
DO NOT ADD TO HOT MATERIALS.
Other Precautions:AVOID ALL SOURCES OF CONTAMINATION. USE ONLY
GLASS,POLYETHYLENE OR CERAMIC CONTAINERS,FUNNELS OR MEASURING
DEVICES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN
Ventilation:LOCAL EXHAUST
Other Protective Equipment:SAFETY SHOWERS & EYE WASH STATIONS.
Supplemental Safety and Health
INCOMPATABILITY CONT:FRIDEL-CRAFT TYPE CATALYST,METAL CONTAMINATION.
SUCH AS COPPER,BRASS,LEAD,IRON & ZINC.
================== Physical/Chemical Properties ==================
Vapor Density:>1
Spec Gravity:1.10
Evaporation Rate & Reference:<1(ETHER)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
MINERAL ACIDS,REDUCING AGENTS,OXIDIZING AGENTS(SEE SUP DATA)
Stability Condition to Avoid:DIRECT SUNLIGHT,IGNITION SOURCES,ACIDS &
ALKALIES,PLASTICS
Hazardous Decomposition Products:CARBON MONOXIDE & DIOXIDE,DENSE BLACK
SMOKE & INTENSE HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH LOCAL STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:6273 ASPHALT CEMENTS/TROWEL COATINGS
CAGE:EO591
CAGE:33394
CAGE:EO591
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
Effects of Overexposure:SKIN:PRLNG/RPTD CONTACT-SLIGHT
IRRIT.EYE:IRRIT,RED,BLURRED VISION.INHAL:EXCESS INHAL (SEE OTHR
PREC)
======================= First Aid Measures =======================
First Aid:SKIN:WASH W/SOAP&H*2O.REMOVE CONTAM CLOTHES.EYES:FLUSH W/LRG
AMTS H*20 @ LEAST 15 MIN.GET MED ATTN.INHAL:REMOVE TO FRESH
AIR.BREATHING DIFF,GIVE O*2.IF STOP BREATHING,GIVE ARTIFICIAL
RESP.INGEST:DONT INDUCE VOMITING.KEEP WARM,QUIET&GET MEDATTN IMMED
===================== Fire Fighting Measures =====================
Flash Point:100F MIN (PMCC)
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICALS
Fire Fighting Procedures:RECM SCBA FOR FIRE FIGHTERS. WATER MAY CAUSE
(SEE SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP AWAY FROM SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL AREA. REMOVE SOURCES OF
IGNITION.VENTILATE AREA IF NECESSARY.RECOVER FREE LIQUID. ADD
ABSORBENT TO SPILL AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
USE ONLY W/ADEQUATE VENTILATION. AVOID PROLONGED/REPEATED CONTACT
W/SKIN. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:OF HIGH VAPOR CONC-NASAL & RESP
IRRIT,DIZZINESS,NAUSEA,HEADACHE,POSS
UNCONSCIOUS,ASPHYXIATION.INGEST:GI
IRRIT,NAUSEA,VOMITING,DIARRHEA.ASPIRATION OF MATL INTO LUNGS-CHEM
PNEUMONITIS,POSS FATAL
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORM NEEDED IN WELL VENT AREA.IF EXCEED
TLV,RECM (SEE SUPP DATA)
Ventilation:SUFFICIENT MECHANICAL &/OR LOCAL EXHAUST TO KEEP EXPOS <
TLV
Other Protective Equipment:AS NECESSARY
Supplemental Safety and Health
BOIL PT:FOR MINERAL SPIRITS.SPEC GRAV:0.9615-1.5625.%
VOLATILE:25-40.FLASH PT:37.8C MIN.FIRE FIGHT:FROTHING,APPLY
CAUTIOUSLY.RESP PROTECT:NIOSH/MSHA APVD BREATHING APPARATUS.DATE OF
PREP:9/85.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300-315F
Vapor Pres:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON DIOXIDE/CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL,STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:R74-3001-120, APPLE COLOR LASER WRITER SETUP(SUP DAT)
CAGE:EO274
CAGE:EO274
============= Composition/Information on Ingredients =============
Ingred Name:POLYESTER RESIN
CAS:109909-27-5
Fraction by Wt: 85-95%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENT
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <2%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CHROMIUM (III) (SARA 313) (CERCLA) %: 0.5-5
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <5%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT): > 5000 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: MINIMAL RESPIRATORY
TRACT IRRITATION MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY
NON-TOXIC DUST. EYES: MAY CAUSE IRRITATION. SKIN: UNLIKELY TO CAUSE
IRRITATION. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION: DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF
WATER. INHALATION: REMOVE VICTIM TO FRESH AIR. EYES: FLUSH WITH
RUNNING WATER FOR AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP AND
WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CARBON DIOXIDE, WATER, DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TONER MATERIAL, LIKE MOST ORGANIC
MATERIAL IN POWDER FORM, IS CAPABLE OF CREATING A DUST EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:NO TONER SPILLAGE OCCURS IN NORMAL OPERATIONS
OR HANDLING. IF IT SHOULD OCCUR, AVOID INHALATION OF THE DUST.
SWEEP MATERIAL ONTO PAPER AND CAREFULLY TRANSFER TO A SEALABLE
WASTE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
Other Precautions:KEEP AWAY FROM CONTACT WITH OXIDIZING MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER INTENDED USE. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT UNDER
INTENDED USE.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
TRADE NAME/PART #: KIT (TONER CARTRIDGE YELLOW).
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>212F,>100C
Spec Gravity:1-1.4 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW FINE POWDER, WITH SLIGHT PLASTIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
AND POSSIBLY TOXIC CHEMICALS SUCH AS CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT IS CONSTRUCTED FROM PLASTICS AND
METALS. THE WASTE TONER COULD BE CONSIDERED AS PLASTIC WASTE.
DISPOSAL SHOULD BE SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 00-623-6806
Product ID: NATURAL GRAPHITE, LS-10, L-300, L-600, LT-30, DG-11
Cage: 06705
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 06705
=======================================================
Item Description Information
=======================================================
Item Name: GRAPHITE,DRY
Specification Number: UNKNOWN
Unit of Issue: EA
UI Container Qty: 1
Type of Container: UNKNOWN
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: UNKNOWN
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: INHAL OF DUST MAY RESUTL IN IRRIT OF MUCOUS MEMBRANES.
LONG TERM INHAL MAY RESULT IN SILICOSIS OR PNEUMOCONIOSIS.
Explanation Of Carcinogenicity: PER MSDS:IARC YES (SILICA AS QUARTZ), ANIMAL
SUFFICIENT EVIDENCE, HUMAN LIMITED EVIDENCE.
Signs And Symptions Of Overexposure: NOT KNOWN OTHER THAN THAT MENTIONED IN
HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NO MEDICAL CONDITIONS ARE KNOWN TO BE
AGGRAVATED BY THIS PRODUCT.
First Aid: EYE:FLUSH W/PLENTY OF WATER FOR 15MINS. SEEK MED ATTN IF IRRIT
PESISTS. SKIN:WASH EXPO SKIN W/SOAP & WATER. IF IRRIT PERSISTS GET MED
ATTN. INGEST:DO NOT INDUCE VOMIT. SEEK MED ATTN. INHAL:REMOVE TO F RESH AIR
AREA. SEEK MED ATTN IF BREATHING BECOMES DIFFICULT.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: GRAPHITE CAUSES SLIPPERY CONDITIONS. CAREFULLY SWEEP
UP MATERIAL & WAST FLOOR WITH SOAP & WATER. RECYCLE OR CONTAINERIZE
FOR SOLID WASTE DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MFG.
Waste Disposal Methods: DISPOSE ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: GRAPHITE BEING CONDUCTIVE CAN CAUSE SHORT
CIRCUITS & OTHER ELECT MALFUNCTIONS.KEEP CNTNR TIGHTLY CLSD WHEN NOT IN
USE.HANDLE CAREFULLY TO AVOID SPILL.
Other Precautions: NONE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: NONE WILL NOT SUPPORT COMBUSTION. HOWEVER USE EXT MEDIA
FOR FOR SURROUNDING FIRE.
Fire Fighting Procedures: WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS TO FIGHT FIRE IN CONFINED AREA.
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR NIOSH APPROVED MASK FOR PROTECTION AGAINST DUST
PARATICLES.
Ventilation: LOCAL EXHAUST NOT NECESSARY EXCEPT TO STAY BELOW EXPOSURE LIMITS.
MECHANICAL(GENERAL) NECESSARY TO KEEP DOWN DUST.
Other Protective Equipment: EYEWASH STATION & SAFETY SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices: LAUNDER SEVERELY CONTAMINATED CLOTHING BEFORE REUSE.
WASH THOROUGHLY W/SOAP & WATER AFTER HANDLING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Spec Gravity: 2.25
Solubility in Water: INSOLUBLE
Appearance and Odor: DARK GRAY SOLID, NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MFG.
Materials To Avoid: NONE
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 80190
Product ID: NATURAL GRAPHITE, LS-10, L-300, L-600, LT-30, DG-11
Review Date: 01/12/1995
Net Unit Weight: UNKNOWN
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: EA
Container QTY: 1
Type Of Container: UNKNOWN
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: NATURAL GRAPHITE, LS-10, L-300, L-600, LT-30, DG-11
Cage: 06705
Company Name: SUPERIOR GRAPHITE CO.
Street: 10 S RIVERSIDE PLAZA
Zipcode: 60606-3913
Label Required IND: Y
Date Of Label Review: 01/12/1995
Status Code: C
Label Date: 01/12/1995
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: INHAL OF DUST MAY RESUTL IN IRRIT OF MUCOUS MEMBRANES.
LONG TERM INHAL MAY RESULT IN SILICOSIS OR PNEUMOCONIOSIS. GRAPHITE BEING
CONDUCTIVE CAN CAUSE SHORT CIRCUITS & OTHER ELECT MALFUNCTIONS.KEEP CNT
NR TIGHTLY CLSD WHEN NOT IN USE.HANDLE CAREFULLY TO AVOID SPILL. TARGET
ORGANS:MUC MEMBRANES. FIRST AID: EYE:FLUSH W/PLENTY OF WATER FOR 15MINS. SEEK
MED ATTN IF IRRIT PESISTS. SKIN:WASH EXPO SKIN W/S OAP & WATER. IF IRRIT
PERSISTS GET MED ATTN. INGEST:DO NOT INDUCE VOMIT. SEEK MED ATTN.
INHAL:REMOVE TO FRESH AIR AREA. SEEK MED ATTN IF BREATHING BECOMES DIFFICULT.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:1125, DEX-O-TEX QUIK-SET PASTE 10 GAL
CAGE:88167
CAGE:88167
============= Composition/Information on Ingredients =============
Ingred Name:LATEX EMULSION
OSHA PEL:3 PPM (MFR)
ACGIH TLV:1 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE EYE AND SKIN
IRRITATION. CHRONIC: NONE ESTABLISHED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT ESTABLISHED.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE SUBJECT TO FRESH AIR. EYES: FLUSH WITH WATER FOR
AT LEAST 15 MINUTES AND CALL MD. SKIN: WASH AFFECTED AREAS WITH
SOAP AND WATER - REMOVE CONTAMINATED CLOTHING. INGEST: INDUCE
VOMITING AND CALL MD AT ONCE.
===================== Fire Fighting Measures =====================
Flash Point:212F,100C
Extinguishing Media:WATER, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH WATER AND ALLOW TO DRY. SODIUM
OR CALCIUM CHLORIDE CAN BE SPRINKLED ON SPILL WHICH WILL COAGULATE
THE LATEX, THEN FLUSH WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT FROM FREEZING TO AVOID
COAGULATION.
BREATHING SPRAY MISTS OR HEATED VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED
- IF NOT, USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL).
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV: 1.01-1.02 (H2O=1).
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:AS WATER
Solubility in Water:DISPERSIBLE
Appearance and Odor:MILKY WHITE LIQUID EMULSION; WITH SLIGHT STYRENE
ODOR.
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NON-REACTIVE, MAY COAGULATE IF FROZEN AT
32F.
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE INCINERATED OR DISPOSED OF IN SANITARY
LANDFILL I/A/W PROCEDURES USED WITH LATEX PRODUCTS AND WITH LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SANI-CLOR 6% BLEACH (1 GAL)
Preparer's Name:DONALD L. GREEN
CAGE:FO373
CAGE:0E7P7
CAGE:FO373
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYPOCHLORITE (SARA III)
CAS:7681-52-9
RTECS #:NH3486300
Fraction by Wt: 6%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:
CORROSIVE/IRRITATION/BURN/BLISTER/ ECZEMA. EYE: DAMAGE/IRRITATION.
INGESTION: MUCOUS MEMBRANE CORROSION/ ESOPHAGUS & STOMACH
PERFORATION/LARYNGEAL EDEMA/CONVULSION/COMA/DEATH/LUNG IRRITATION.
IN HALATION: COUGH/DIFFICULT BREATHING/STOMATITIS/NAUSEA/ PULMONARY
EDEMA/CIRCULATORY COLLAPSE/DELIRIUM/BRONCHIAL IRRITATIO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: CORROSIVE/IRRITATION/BURN/BLISTER/
ECZEMA. EYE: DAMAGE/IRRITATION. INGESTION: MUCOUS MEMBRANE
CORROSION/ ESOPHAGUS & STOMACH PERFORATION/LARYNGEAL
EDEMA/CONVULSION/COMA/DEATH/LUNG IRRITATION. IN HALATION:
COUGH/DIFFICULT BREATHING/STOMATITIS/NAUSEA/ PULMONARY
EDEMA/CIRCULATORY COLLAPSE/DELIRIUM/BRONCHIAL IRRITATIO
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINS. SKIN: FLUSH W/LARGE
AMOUNTS OF WATER OR WASH W/SOAP & WATER. TREAT BURNS AS NEEDED.
INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK A LARGE QUANTITY
OF MILK , GELATIN SOLUTION, OR WATER. DON'T GIVE VINEGAR OR THEIR
ACIDS. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE APPROPRIATE MEDIA FOR SURROUNDING FIRE & WATER
SPRAY.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING. USE WATER SPRAY TO KEEP FIRE-EXPOSED
CONTAINERS COOL, TO DILUTE LIQUID, & TO CONTROL VAPORS.
Unusual Fire/Explosion Hazard:REMOVE CONTAINERS TO PREVENT PRESSURE
RUPTURE. VIGOROUS REACTIONS CAN OCCUR W/OXIDIZABLE MATERIALS.
CORROSIVE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. CONTAIN/PICK UP
WHEN POSSIBLE FOR RECOVERY/DISPOSAL. DON'T USE COMBUSTIBLE
ABSORBENTS SUCH AS SAWDUST. FLUSH TO A SUITABLE HOLDING AREA &
W/HIGH DILUTION TO THE SEWER. KEEPOUT OF LAKE/STREAM/POND/PUBLIC
WATERWAYS/SEWERS.
Neutralizing Agent:WEAK REDUCING AGENTS
======================Handling and Storage ======================
Handling and Storage Precautions:MIX W/WATER ACCORDING TO LABEL
DIRECTIONS. AVOID INHALATION OF MISTS/FUMES, & CONTACT W/SKIN/EYE.
STORE IN CLOSED/ VENTED CONTAINERS IN COOL/DRY PLACE
Other Precautions:DON'T CONTAMINATE FOOD/FEED BY STORAGE/DISPOSAL/
CLEANING OF EQUIPMENT. KEEP OUT OF LAKE/STREAM/POND/SEWER/PUBLIC
WATERWAY. STORE <85F AWAY FROM SUNLIGHT/HEAT/INCOMPATIBLE
MATERIAL/PHYSICAL DAMAGE. KE EP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE CANISTER-TYPE RESPIRATORS SUITABLE FOR
CHLORINE W/MIST FILTERS.
Ventilation:PROVIDE ADEQUATE GENERAL/LOCAL EXHAUST VENTILATION TO
MAINTAIN FUMES & MISTS AT A MINIMUM.
Other Protective Equipment:EYEWASH FOUNTAINS, WASHING FACILITIES,
SAFETY SHOWERS, APRON, & OTHER PROTECTIVE EQUIPMENT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
RATE OF DECOMPOSITION INCREASES W/ CONCENTRATION & W/TEMPERATURE.
HYPOCHLORITE CAN BE HARMFUL TO AQUATIC LIFE. THIS PRODUCT IS TOXIC
TO FISH.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Pres:17.5
Spec Gravity:1.0875
pH:12.4
Solubility in Water:COMPLETE
Appearance and Odor:PALE YELLOW LIQUID W/CHLORINE ODOR TYPICAL OF
HOUSEHOLD BLEACH.
Percent Volatiles by Volume:90%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS/AMMONIA/UREA/OXIDIZABLE MATERIALS/METALS SUCH AS
NICKEL/COPPER/TIN/MANGANESE/IRON/ORGANICS/ACIDIC CLEANING AGENTS
Stability Condition to Avoid:HEAT, DIRECT SUNLIGHT, TEMPERATURES >90F,
& PHYSICAL DAMAGE
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CORROSIVE FUMES,
CHLORINE GASES, & OXYGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE HYPOCHLORITE W/WEAK REDUCING AGENTS, &
THEN WASTE LANDFILL. FOLLOW FEDERAL, STATE, & LOCAL REGULATIONS.
CORROSIVE LIQUID. DOT UN1791.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ALKYD WOOD STAINS, 744-4359 OLD WORLD MAHOGANY
CAGE:MART2
CAGE:MART2
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP:
2.0
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 65%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL
SPIRITS 140-FLASH). VP 0.5
CAS:64742-88-7
Fraction by Wt: 10%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:TOLUENE (SARA 313) (CERCLA). VP: 22.0
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:EFTS OF OVEREXP: ASSOCIATED REPEATED & PROLONGED
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WASTE DISP METHOD: DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN.
INTENTIONAL MUSED BY DELIBERATELY CONC & INHALING (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: THE CONTENTS CAN BE HARMFUL.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: BY NIOSH FOR DUST WHICH MAY BE GENERATED FROM
THIS PRODUCT, UNDERLYING PAINT, OR THE ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:VENT: REFER TO OSHA STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOLUENE APPEARS ON THE NAVY LISTING OF
OCCUP CHEM REPROD HAZ. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO . ACUTE: IRRIT OF EYES, S KIN & RESP SYS. MAY CAUSE NERVOUS
SYS DEPRESS. SIGNS & SYMPS OF OVEREXP: HDCH, DIZZ, NAUSEA, & LOSS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: OF COORDINATION ARE INDICATIONS OF
EXCESSIVE EXPOSURE TO VAPS/SPRAY MISTS. REDNESS & ITCHING/BURNING
SENSATION MAY INDICATE EYE/EXCESSIVE SKIN EXPOS. CHRONIC: PRLNG
OVEREXP TO SOLV INGREDS I N SECTION 2 MAY CAUSE ADVERSE EFTS TO
LIVER, URINARY, BLOOD FORMING, & CARDIO-VASCULAR SYS. RPTS HAVE
(ING 4)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM AND
QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES: FLUSH
WITH LAR GE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION. INGEST: NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. DO NOT INDUCE VOMITING. GIVE SEVERAL GLASSES OF WATER. SEEK
MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:95.0F,35.0C
Lower Limits:0.9%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFFECTIVE. IF H*2O IS USED, FOG NOZZLES ARE
PREF. H*2O MAY BE USED TO COOL CLOSED (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS, & OPEN FLAME. CLSD CNTNRS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT. (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTETS ARE FLAMMABLE. KEEP AWAY FROM
HEAT, SPARKS, AND OPEN FLAM. DURING USE AND UNTIL ALL VAPORS ARE
GONE: KEEP AREA VENT DO NOT SMOKE.
Other Precautions:EXTING ALL FLAMES, PILOT LIGHTS, & HEATERS - TURN OFF
STOVES, ELEC TOOLS & APPLIANCES, & ANY OTHER SOURCES OF IGNIT. KEEP
CNTNR CLSD WHEN NOT IN USE. TRANSFER ONLY TO APPRVD CNTNRS
W/COMPLETE & APPROP LABELING. DO NOT TAKE (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMS BY VENT, WEAR A PROPERLY FITTED ORG VAP/PARTICULATE RESP
APPRVD BY NIOSH/FOR PROT AGAINST MATLS IN SECTION 2. WHEN
SANDING/ABRADING DRIED FILM, WEA R A DUST/MIST RESP APPROVED (ING
8)
Ventilation:LOC EXHST PREF. GEN EXST ACCEPTABLE IF EXPOS TO MATLS IN
SECTION 2 IS MAINTAINED BELOW APPLICABLE EXPOS LIMITS. (ING 9)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: CNTNRS TO PVNT PRESS BUILD-UP & POSS
AUTOIGNITION/EXPLOSION WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ:
APPLICATION TO HOT SURFACES REQUIRES SPECIAL PERCAUTIONS. DURING
EMER CNDTNS OVERE XP TO DECOMP PROD MAY CAUSE HLTH HAZ. SYMPS MAY
NOT BE IMMEDLY APPARENT. OBTAIN MED ATTENTION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>222F,>106C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.85
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PRODUCT MAY BE HAZARDOUS AS
DEFINED UNDER THE RCRA 40 CFR 261. WASTE MUST BE TESTED FOR
IGNITABILITY TO DETERMINE THE APPLICABLE EPA HAZARDOUS WASTE
NUMBERS. INCINERATE IN APPROVED FAC ILITY. DO NOT INCINERATE CLOSED
CNTNR. (ING 5)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ALL TRW CARBIDE GRADES EXCEPT: NI-14 & UC-
CAGE:TRWCA
CAGE:TRWCA
============= Composition/Information on Ingredients =============
Ingred Name:TUNGSTEN CARBIDE (41-97%)
CAS:11107-01-0
RTECS #:YO7350000
Fraction by Wt: 97%
ACGIH TLV:5 MG/CUM
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 30%
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:TANTALUM CARBIDE (0-52%)
Fraction by Wt: 52%
ACGIH TLV:5 MG/CUM
Ingred Name:CHROMIUM CARBIDE (0-5.1%)
Fraction by Wt: 5.1%
ACGIH TLV:0.5 MG/CUM
Ingred Name:CHROMIUM ION (CR 3+)
CAS:16065-83-1
RTECS #:GB6261000
Fraction by Wt: 4.5%
OSHA PEL:0.5 MG/M3 (CR)
ACGIH TLV:0.5 MG/M3 (CR); 8990
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION: DUST FROM GRINGDING CAN CAUSE NOSE
& THROAT IRRITATION AND SKIN AND EYE IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE & SEEK MED ATT. SKIN
CONTACT: WASH W/SOAP & WATER. SEEK MED ATT. EYE CONTACT: FLUSH WITH
WATER. IF IRRITATION PERSISTS. SEEK MED ATT. INGESTION: IF
SWALLOWED, DRINK WA TER, INDUCE VOMITING AND SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOR POWDER FIRES USE DRY SAND, DRY DOLOMITE.
Fire Fighting Procedures:USE A RESPIRATOR APPROVED FOR TOXIC DUST &
FUMES. USE SCBA.
Unusual Fire/Explosion Hazard:DUSTS MAY PRESENT A FIRE UNDER RARE
FAVORING CONDITIONS OF SIZE, DISPERSION & STRONG IGNITION SOURCE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF SPILL. CLEAN UP USING
METHODS WHICH AVOID DUST GENERATION SUCH AS CUUM. WET DUST MOP OR
WET CLEAN UP. IF AIRBORNE DUST IS GENERATED, USE AAPPROPRIATE NIOSH
APPROVED RESPIRATOR.
======================Handling and Storage ======================
Handling and Storage Precautions:MAINTAIN GOOD HOUSEKEEPING PROCEDURES
TO PREVENT DUST ACCUMULATION DURING GRINDING. AVOID DUSTNHALATION &
DIRECT SKIN CONTACT WITH DUST.
Other Precautions:WASH HANDS BEFORE EATING OR SMOKING. WASH EXPOSED
SKIN. DON'T SHAKE CLOTHING TO REMOVE DUST. REMOVE DUST BY WASHING
OR VACUUNG. PERIODIC MED EXAMINATIONS RECOMMENDED IF REGULARLY
EXPOSED
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF AIRBORNE DUST CONCENTRATIONS EXCEED THE PEL
OR TLV.
Ventilation:USE LOCAL EXHAUST VENTILATION WHICH IS ADEQUATE.
CONTACT W/DUST & MIST.
Supplemental Safety and Health
MSDS DATE: 11/25/85
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NONE
Spec Gravity:15.5
Evaporation Rate & Reference:NONE
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK GRAY METAL/NO ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACID
Stability Condition to Avoid:DUST WITH STRONG OXIDIZERS MAY CAUSE
EXPLOSION.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPROPRIATE
GOVERNMENT REGULATIONS. MAY BE SOLD AS SCRAP FOR RECLAIM.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:IBM,RIBBON,BLACK NYLON,GENERAL PURPOSE
CAGE:30874
CAGE:30874
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION IN SENSITIVE
INDIVIDUALS.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER FOR
15 MINS. INGESTION: SEEK MEDICAL ATTENTION. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, DRY CHEMICAL, CO2, FOAM
Fire Fighting Procedures:WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXCESSIVE TEMPERATURES DURING
STORAGE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:NYLON FABRIC IMPREGNATED W/BLACK INK, WOUND AROUND
TUBULAR SPINDLES W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Hazardous Decomposition Products:CARBON, CO, CO2, NITROGEN OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS. SINGLE RIBBONS/CARTRIDGES MAY BE DISPOSED OF AS
ROUTINE OFFICE TRASH. LARGE: DISPOSE BY INCINERATION OR IN A SECURE
LANDFILL IS RECOMMEND ED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LIQUID CHLORINE BLEACH
CAGE:MO186
CAGE:MO186
CAGE:0VL27
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYPOCHLORITE (SARA III)
CAS:7681-52-9
RTECS #:NH3486300
Fraction by Wt: 5.25%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD 50 ORAL RAT= 5800 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CAUSES SEVERE TEMPORARY
IRRITATION. SKIN:MAY IRRITATE SENSITIVE SKIN. INGEST:MAY CAUSE GI
IRRITATION. INHAL:MAY IRRITATE NOSE,THROAT AND LUNGS.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:INGEST:NAUSEA,VOMITING.
Medical Cond Aggravated by Exposure:MAY AGGRIVATE CHRONIC RESPIRATORY
PROBLEMS(E.G. ASTHMA).
======================= First Aid Measures =======================
First Aid:IN ALL CASES,CALL A PHYSICIAN FOR PERSISTING SYMPTOMS.
EYE:FLUSH WITH RUNNING WATER. SKIN:REMOVE CONTAMINATED CLOTHING,
WASH WITH RUNNING WATER. INHAL:REMOVE TO FRESH AIR. INGEST:IF
CONSCIOUS, DRINK A GLASSFUL OF TAP WATER.CALL THE POISONCONTROL
CENTER AT 800-282-3171.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT. COOL FIRE EXPOSED CONTAINERS WITH WATER
SPRAY.
Unusual Fire/Explosion Hazard:TOXIC FUMES ARE PRODUCED IN FIRE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL AMOUNTS CAN BE FLUSHED DOWN THE DRAIN
WITH TAP WATER. FOR LARGE AMOUNTS, DILUTE WITH WATER; SOAK UP WITH
AN INERT ABSORBANT; PLACE IN AN APPROPRIATE CONTAINER FOR DISPOSAL.
Neutralizing Agent:DILUTE WITH WATER THE REDUCE THE OXIDIZING EFFECTS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. DO NOT MIX
WITH ANY OTHER CHEMICALS. KEEP OUT OF REACH OF CHILDREN. DO NOT GET
ON SKIN OR IN EYES.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. DO NOT REUSE EMPTY
CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN EMERGENCY SITUATIONS, WHERE ENVIRONMENTAL
CONTROLS ARE LACKING OR IN ENCLOSED SPACES USE A SELF-CONTAINED
BREATHING APPARATUS.
Ventilation:USE WITH GOOD VENTILATION. LOCAL VENTILATION AT THE
WORKSITE; MECHANICAL(GENERAL) VENTILATION TO MAINTAIN TLV/PEL.
Other Protective Equipment:EY WASH STATION,QUICK DRENCH
SHOWER.IMPERVIOUS CLOTHING ...AS NEEDED.
Work Hygienic Practices:WASH HANDS. SEPERATE WORK CLOTHES FROM STREET
CLOTHES. LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE
WORK AREA.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:>100.C, 212.F
Melt/Freeze Pt:=-9.C, 15.8F
Vapor Density:19.2
Spec Gravity:1.08-1.2
pH:10-12
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID,CLEAR; LIGHT YELLOW TO GREEN; CHARACTERISTIC
CHLORINE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAMES.
Hazardous Decomposition Products:VARIOUS HAZARDOUS CHLORINATED GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LN-603 LIQUID NAILS, 0600301
CAGE:MACCO
CAGE:01PD6
CAGE:MACCO
============= Composition/Information on Ingredients =============
Ingred Name:STEAM-CRACKED, POLYMERS W/LIGHT STEAM-CRACKED PETROLEUM
NAPHTHA
CAS:68410-16-2
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BUTADIENE, STYRENE, DIVINYLBENZENE POLYMER
CAS:26471-45-4
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:CONSIDERED LIMITED FOR CARCINOGENICITY. CRYSTALLINE
SILICA IS ALSO A KNOWN CAUSE OF SILICOSIS, A NON (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:CANCEROUS LUNG DISEASE, NTP HAS CLASSIFIED
CRYSTALLINE SILICA A REASONABLY ANTIC HUMAN CARCINOGEN.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:INGEST:IF SWALLOWED, OBTAIN MEDICAL
TREATMENT IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:SPILLS-SHUT OFF LEAK IF SAFE TO DO SO. DIKE &
CONTAIN SPILL. PUMP TO STORAGE/SALVAGE VESSELS. USE (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:ABSORB TO PICK UP EXCESS RESIDUE. KEEP SALVAGEABLE
MATL & RINSE WATER OUT OF SEWERS & WATER COURSES. (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:SM SPILLS-USE ABSORBENT TO PICK UP RESIDUE & DISPOSE
OF PROPERLY.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:AVOIDED, USE APPROP RESP PROT AS DIRECTED UNDER
SPEC PROT INFO. EMPTY CNTNRS MAY CONTAIN HAZARDOUS (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:RESIDUES. GROUND EQUIP WHEN TRANSFERRING TO PREVENT
ACCUMULATION OF STATIC CHARGE.
RTECS #:9999999ZZ
Ingred Name:STYRENE POLYMER WITH 1,3-BUTADIENE; (BUTADIENE-STYRENE
POLYMER) (RUBBER)
CAS:9003-55-8
RTECS #:WL6478000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1); (CALCIUM CARBONATE)
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY (KAOLIN); (KAOLIN)
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 30-40%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:VM & P NAPHTHA
CAS:64742-89-8
Fraction by Wt: 30-40%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.1-1%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:CYCLOHEXANE (SARA 313) (CERCLA)
CAS:110-82-7
RTECS #:GU6300000
Fraction by Wt: 1-5%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
HEAVY NAPHTHENIC
CAS:64742-52-5
RTECS #:PY8035001
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF RESP TRACT.
PRLNGD INHAL MAY LEAD TO FATG, DIZZ &/OR LT HEAD, HDCH, NAUS,
VOMIT, CNS DEPRESS, RESP PROBS, LOSS OF CONSCIOUSNESS, DEATH.
SKIN:IRRIT. PRLNGD/RPTD CONT CAN CAUSE DERM , DEFAT. EYE:IRRIT.
PRLNGD/RPTD CONT CAN CAUSE CONJ, TEARING OF EYES, REDNESS.
INGEST:MAY CAUSE LUNG (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC MONO,
VOL 68, 1997:GROUP 1. NTP 7TH ANNUAL RPT ON CARCIN, 1994:ANTIC TO
BE CARCIN.
Effects of Overexposure:HLTH HAZ:INFLAMM & DMG DUE TO ASPIR OF MATL
INTO LUNGS, HDCH, NAUS, VOMIT, DIARR, GI DISTURB, CNS DEPRESS. SUPP
HLTH INFO:OTHER EFTS OF OVEREXP MAY INCL TOX TO LUNGS. CONTAINS
CRYSTALLINE SILICA WHICH IS CONSIDERED HAZ BY INHAL, IARC HAS
CLASSIFIED CRYSTALLINE SILICA AS PROBABLY CARCIN FOR HUMANS (2A.
THIS (SUPDAT)
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMER MED ATTN. HAVE TRAINED PERSON GIVE OXYG IF NEC. GET MED
HELP FOR ANY BRTHG DFCLTY. SKIN:FLUSH W/WATER, THEN WASH THORO
W/SOAP & W ATER. REMOVE CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE
RE-USE. EYE:FLUSH IMMED W/LG AMTS OF WATER, ESPECIALLY UNDER LIDS
FOR @ LST 15 MINS. IF IRRIT/OTHER EFTS PERSIST, OBTAIN MED
TREATMENT. (ING 12)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:23.0F,-5.0C
Lower Limits:1.2%
Upper Limits:8.4%
Extinguishing Media:DRY CHEMICAL OR FOAM, WATER FOG, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL & PORTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT/FIRE. VAPS MAY IGNITE EXPLOSIVELY @ AMBIENT TEMPS.
VAPS ARE HVR/AIR & MAY TRAVEL LONG DIST TO A (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLIC HLTH & ENVIR REGS. ELIM
ALL SOURCES OF IGNIT. VENTILATE AREA W/EXPLO-PROOF EQUIP. USE
NON-SPK TOOLS. EVAC ALL UNNEC PERS. PLACE COLLECTED MATL IMPROPER
CNTNR. COMPLETE PERSONAL PRO T EQUIP MUST BE USED DURING CLEANUP.
LG(ING 13)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <80F. KEEP AWAY FROM HEAT, SPKS
& OPEN FLAME. USE ONLY W/ADEQ VENT. DO NOT TAKE INTERNALLY. KEEP
OUT OF REACH OF CHILDREN.
Other Precautions:AVOID CONT W/SKIN & EYES, & BRTHG OF VAPS. KEEP
CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE. AVOID CNDTNS WHICH
RSLT IN FORMATION OF INHALABLE PARTICLES SUCH AS
SPRAYING/ABRADING(SANDING) PAINTED SU RFS. IF SUCH CNDTNS CANNOT BE
(ING 16)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARS. WHERE RESPIRTORY PROTECTION IS REQUIRED, USE
ONLY NIOSH APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29
VFR 1910.134.
Ventilation:PROVIDE DILUTION VENT/LOC EXHAUST TO PVNT BUILD-UP OF VAPS.
USE EXPLOSION-PROOF EQUIP. USE NON-SPARKING EQUIP.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
IMPERVIOUS CLOTHING, APRON, BOOTS.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING,
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
EXPLO HAZ:SOURCE OF IGNIT & FLASH BACK. VAPS CAN FORM EXPLOSIVE MIX IN
AIR @ ELEVATED TEMPS. MAY DECOMPOSE UNDER FIRE CNDTNS IN AIR @
ELEVATED TOX GASES. EFTS OF OVEREXP:CLASSIFICATION IS BASED ON FIN
DINGS OF LAB ANIMAL STUDIES THAT WERE CONSIDERED SUFFICIENT & DATA
FROM EPIDEMIOLOGICAL STUDIES THAT WERE (ING 10)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:179F,82C
Spec Gravity:1.125
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:TAN PASTE.
Percent Volatiles by Volume:51.67
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONT W/OXIDIZING AGENT, STORAGE NEAR ACIDS, SPARKS, OPEN FLAME.
IGNITION SOURCES.
Stability Condition to Avoid:ELEVATED TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE & LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL
WATERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:1430 ODOR BLANKET
CAGE:GO127
CAGE:0CPMS
CAGE:GO127
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXENE, 1-METHYL-4-(1-METHYLETHENYL)-, (R)-; (CITRUS
TERPENE)
CAS:5989-27-5
RTECS #:GW6360000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:HEADACHE, NAUSEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. EYES:FLUSH W/WATER FOR AT LEAST 15
MINUTES, GET MEDICAL ATTENTION. SKIN:WASH IMMEDIATELY W/SOAP &
WATER. INGEST:CONSULT MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:115F,46C
Lower Limits:0.7%
Upper Limits:6.1%
Extinguishing Media:DRY POWDER, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . CLASS B FIRE PROCEDURES.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. KEEP AWAY FROM HEAT,
SPARKS & OPEN FLAMES.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS SHOULD BE ABSORBED BY DIRT, SAND
OR OTHER SUITABLE ABSORBENTS FOR DISPOSAL. LARGE SPILLS CAN BE
DIKED W/DIRT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. ALL HANDLING EQUIPMENT
SHOULD BE ELECTRICALLY GROUNDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED, IF VAPOR IS TOO HIGH USE
NIOSH/MSHA APPROVED SELF-CONTAINED MASK.
Ventilation:LOCAL EXHAUST & MECHANICAL (GENERAL).
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . USUALLY NOT NEEDED.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:310F,154C
Vapor Pres:1 @ 20C
Vapor Density:4.69
Spec Gravity:0.837 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:ORANGE LIQUID W/CITRUSY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE & CARBON DIOXIDE.
Conditions to Avoid Polymerization:POLYMERIZATION CATALYSTS SUCH AS
ALUMINUM CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN APPROVED LANDFILL, AWAY FROM WATER
SUPPLIES. BURING IS AN ALTERNATE METHOD. OBSERVE LOCAL, STATE OR
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:P1117 FREON TA
CAGE:GO055
CAGE:GO055
CAGE:87664
============= Composition/Information on Ingredients =============
Ingred Name:FREON 113, 1,1,2,-TRICHLORO-1,2,2,-TRIFLUOROETHANE,
TRICHLOROTRIFLUROETHANE
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 89%
Other REC Limits:1000 PPM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ozone Depleting Chemical:1
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 11%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. PROLONGED/REPEATED
EXPOSURE BY INHALATION CAUSES CARDIAC IRREGULARITIES & DEATH.
VAPORS ARE HEAVIER THAN AIR & CAN CAUSE SUFFOCATION BY REDUCING
OXYGEN AVAILABLE FOR BREATHING. SKIN: IRRITATION AFTER PROLONGED
CONTACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:LIGHT HEADEDNESS, GIDDINESS, SHORTNESS OF
BREATH, NARCOSIS, UNCONSCIOUSNESS, SUFFOCATION, NAUSEA, VOMITING,
IRRITATION.
Medical Cond Aggravated by Exposure:CARDIOVASCULAR DISEASE
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NECESSARY. EYES:
FLUSH W/PLENTY OF WATER FOR 15 MINUTES. SKIN: WASH W/PLENTY OF SOAP
& WATER. INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS, GIVE
PLENTY O F WATER/MILK. DON'T GIVE ANYTHING BY MOUTH TO UNCONSCIOUS
PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES. (SEE SUPPLEMENTAL
DATA)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING. USE
WATER SPRAY TO COOL NEARBY CONTAINERS & STRUCTURES EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:WATER WILL EXTRACT A FLAMMABLE CO-SOLVENT
WHICH WILL FORM A FLAMMABLE SUPERNATANT LAYER.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH IGNITION SOURCES. SMALL: MOP/WIPE
UP/DISPOSE OF IN DOT-APPROVED WASTE CONTAINER. LARGE: CONTAIN/DIKE
W/SOIL/OTHER NON-COMBUSTIBLE ABSORBENT MATERIAL. PLACE
ABSORBENT/RESIDUE IN DOT-APPROVED WASTE CONTAINER. KEEP OUT OF
WATERWAYS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY WELL VENTILATED
PLACE. STORE AWAY FROM IGNITION SOURCES. KEEP CONTAINER TIGHTLY
CLOSED WHEN NOT IN USE. DON'T GET INTO EYES.
Other Precautions:DON'T USE PRESSURE TO EMPTY CONTAINERS. DON'T GET ON
CLOTHING/SKIN. DON'T HEAT CLOSED CONTAINERS >125F. DON'T
CUT/GRIND/WELD/DRILL/NEAR THIS CONTAINER. DON'T WEAR CONTACT
LENSES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED SCBA IN PRESSURE DEMAND MODE,
SUPPLIED AIR RESPIRATOR
Ventilation:LOCAL MECHANICAL EXHAUST
Other Protective Equipment:LONG SLEEVED SHIRT, TROUSERS, SAFETY SHOES,
RUBBER APRON, EYEWASH, SAFETY SHOWER
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NOTE TO PHYSICIAN: RISK OF ELICITING CARDIAC DYSRYTHMIAS/CATECHOLAMINE
DRUGS/SUCH AS EPINEPHRINE/SHOULD BE CONSIDERED ONLY AS LAST RESORT
IN LIFE THREATENING EMERGENCIES. VAPORS ARE HEAVIER THAN AIR/W ILL
COLLECT IN LOW PLACES. DON'T ENTER PLACES WHERE VAPORS ARE AT
UNLESS WEARING PROTECTIVE EQUIPMENT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:110.5F
Melt/Freeze Pt:M.P/F.P Text:-150F
Vapor Pres:380
Vapor Density:2.6
Spec Gravity:1.41
Evaporation Rate & Reference:(BU AC =1): >1
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID W/FAINT SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIS, OXIDIZING MATERIALS, WATER, MOIST AIR, ALKALINE EARTH METALS,
POWERED ALUMINUM, ZINC.
Stability Condition to Avoid:OPEN FLAMES, WELDING ARCS, HIGH
TEMPERATURES, TEMP >125F & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, HYDROGEN CHLORIDE, CHLORINE,
PHOSGENE, HYDROGEN FLOURIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CONTAMINATED PRODUCT & MATERIALS USED
IN CLEANING UP SPILLS/LEAKS. EMPTY CONTAINERS CAN HAVE RESIDUES,
GASES, MISTS & AREA SUBJECT TO PROPER WASTE DISPOSAL. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:156 6553,BLEACH,PROC E-6,PART A(SEE SUPPL)
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM FERRIC ETHLYENEDIAMINETETRAACETIC ACID
CAS:21265-50-9
Fraction by Wt: 15-20%
Other REC Limits:NONE SPECIFIED
Ingred Name:AMMONIUM BROMIDE
CAS:12124-97-9
RTECS #:BO9170000
Fraction by Wt: 10-15%
Other REC Limits:NONE SPECIFIED
Ingred Name:HYDROGEN BROMIDE
CAS:10035-10-6
RTECS #:MW3850000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:C 3 PPM
ACGIH TLV:C 3 PPM; 9192
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85-90%
Other REC Limits:NONE SPECIFIED
Ingred Name:POTASSIUM NITRATE
CAS:7757-79-1
RTECS #:TT3700000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO SPECIFIC HAZARDS KNOWN TO EASTMAN
KODAK COMPANY.
Effects of Overexposure:MSDS FM MFR STATES THAT EFFECTS OF OVEREXPOSURE
ARE OF LOW HAZARD FOR USUAL INDUSTRIAL HANDLING. HOWEVER, ANY
MATERIAL THAT CONTACTS THE EYES MAY BE IRRITATING.MAY CAUSE SKIN
ALLERGIC REACTION ON REPE ATED AND/OR PROLONGED CONTACT WIT SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY THE MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.GET
MEDICAL HELP IF IRRITATION PERSISTS; SKIN:FLUSH WITH WATER.GET MED
ATTN IF NEEDED OR SYMPTOMS PERSIST. IF WALLOWED, DRINK 1-2 GLASSES
OF WA TER.SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE, ALCOHOL
FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN & EYES.
Unusual Fire/Explosion Hazard:COMBUSTION WILL PRODUCE CARBON MONOXIDE,
CARBON DIOXIDE, HYDROGEN BROMIDE GAS, AMMONIA, AND OXIDES OF
NITROGEN.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.USE PROTECTIVE
CLOTHNG/SAFETY GLASSES.STOP LEAK W/O RISK.PROVIDE VENT.DIKE LARGE
SPILL & PUMP INTO COVRED DRUMS;ABSORB/CONTAIN SMALL SPILL IN
CONTAINER;MFGR RECOMMENDS,FLU SH TO SEWER W/LG AMT OF WATER I/A/W
EXISTING LAWS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA.KEEP CONTNRS TIGHTLY CLOSED.PROTECT CONTNRS FROM PHYSICAL
DAMAGE.
Other Precautions:AVOID PROLONGED/REPEATED CONTACT WITH PRODUCT.REMOVE
& WASH CONTAMINATED CLOTHING.WASH HANDS AFTER USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED IN NORMAL CONDITIONS.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:AS NEEDED BY LOCAL AUTHORITIES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING PRODUCT.
Supplemental Safety and Health
ITEM WAS 9 PARTS KIT CONSISTED OF:DEVL(PART A&B),BLEACH(PART A&B),FIRST
DEVL,FIXER,CONDITIONER,REVERSAL BATH AND STABILIZER;EFF 12/27/82
CAT #156 6553 CHNGD TO 101 7599 WHICH WAS AGAIN CHNGD TO 181 50 34
DURING 1985;SAME FORMULA #4100;THE DATA IS OF BLEACH,PART-A;MSDS OF
CAT #156 2461 WAS USED TO UPDATE DATA;KEY1:C1
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:>212F(100C)
Vapor Pres:17MMHG@20C
Vapor Density:0.6
Spec Gravity:1.26
pH:5.4
Solubility in Water:COMPLETE
Appearance and Odor:REDDISH BROWN SOLUTION;SLIGHT AMMONIACAL ODOR
Percent Volatiles by Volume:58%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:FIRE OR EXCESS HEAT
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON
MONOXIDE, CARBON DIOXIDE, HYDROGEN BROMIDE GAS, AMMONIA, AND OXIDES
OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED CONTAINERS PENDING
DISPOSAL.HANDLE/DISPOSE IN FULL COMPLIANCE WITH ALL FED,STATE,AND
LOCAL REGS;MANUFACTURER RECOMMENDS TO FLUSH WASTE TO SEWER WITH
LARGE AMOUNT OF WATER I/A/W FED,STA TE, AND LOCAL EFFLUENT LAWS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NATURAL COE LOR LIQUID
Preparer's Name:FS MORRISON
CAGE:GO295
CAGE:13373
CAGE:GO295
============= Composition/Information on Ingredients =============
Ingred Name:METHACRYLIC ACID, METHYL ESTER; (METHYL METHACRYLATE) (SARA
313) (CERCLA). LD50: (ORAL RAT) 5.5 MG/KG.
CAS:80-62-6
RTECS #:OZ5075000
Fraction by Wt: 60-100%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACRYLONITRILE, 3,3-DICYCLOPROPYL-2-(ETHOXYCARBONYL)-;
(ETHYL-2-CYANO-3,3, DIPHENYLACRYLATE)
CAS:5232-99-5
RTECS #:AT6200000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:10 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:5.5 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: MAY CAUSE NOSE & THROAT IRRIT,
CNS DEPRESS. RPTS HAVE ASSOC RPTD/PLNGD OVER EXP TO BRAIN DMG & CNS
DMG. MAY CAUSE IRRIT/BURNING OF EYES, SKIN & MUC MEMBS. RPTD EXPOS
MAY CAUSE SKIN BURNS, ALLER GIC RXNS, ABNORM LIVER & KIDNEY
FUNCTION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:PROGRESSIVE STEPS OF INHALATION OVEREXPOSURE:
HEADACHE, DIZINESS, NAUSEA, STAGGERING GAIT, CONFUSION,
UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR, IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. SEEK MEDICAL
ATTENTION. INGEST: DO NOT INDUCE VOMITING. GIVE ONE OR TWO GLASSES
OF WA TER & SEEK MEDICAL ATTENTION. SKIN: WASH SKIN WITH SOAP &
WATER. WASH CLOTHES PRIOR TO REUSE. EYES: IMMEDIATELY FLUSH EYES
WITH WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:230F,110C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT, WITH FACE SHIELD
AND SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:WHEN HEATED >FLASH PT, EMITS VAPS, WHICH
WHEN MIXED W/AIR, CAN BURN/BE EXPLOS. FINE MISTS/SPRAYS MAY BE
FLAMM AT TEMPS <FLASH PT. SEALED CNTRS EXPOSED (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCE OF IGNITION. WEAR SKIN, EYE,
RESPIRATORY PROTECTION. CONTAIN SPILL & KEEP OUT OF SEWERS. USE
ABSORBENT TO SOAK UP LIQUID. USE NON-SPARKING EQUIPMENT & SHOVEL
INTO WASTE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, FLAME,
DIRECT SUNLIGHT AND ELEVATED TEMPERATURES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF NEEDED USE MSHA-NIOSH APPROVED RESPIRATOR FOR
ORGANIC VAPORS.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
Work Hygienic Practices:OBSERVE GOOD HYGIENIC PRACTICES.
Supplemental Safety and Health
EXPLO HAZ: TO ELEVATED TEMPERATURES MAY RUPTURE EXPLOSIVELY DUE TO
POLYMERIZATION. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL TO
IGNITION SOURCE. EYE PROT: AND FULL FACE SHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:214F,101C
Vapor Pres:50 @ 30C
Vapor Density:3.5
Spec Gravity:0.939 (H*20=1)
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS LIQUID WITH SWEET SHARP ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
REDUCING AND OXIDIZING AGENTS. MATERIAL HAS STRONG SOLVENT PROPERTIES
AND CAN SOFTEN PAINT OR RUBBER.
Stability Condition to Avoid:HEAT AND IGNITION SOURCES.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL IS A HAZARDOUS WASTE, NO. U162. DISPOSE
OF WASTE IN FACILITY PERMITTED FOR HAZARDOUS WASTE IN ACCORDANCE
WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.